Metos Hotmix Pro Gastro XL Owner's manual

Brand: Metos

Model: Hotmix Pro Gastro XL

Category: Food processors

Type: Owner's manual

Installation and User Manual

THERMO CUTTER

Metos Hotmix

GASTRO XL

15.12.2014

MG4163993, MG4163995



2



IMPORTANTNOTICE

“WAIT‐TEMPERATURE”FUNCTION

Whenyougetinformedthatarecipe(orastepofit)hasbeencompletedafterreachingasettemperature,

andyouwishtokeeptheingredients at this steady temperature forawhile,you need to use the “WAIT‐

TEMPERATURE”function. 

HOTMIXPROiscapabletofindandkeepthe

wishedtemperaturefortheprogrammedtime.

Withthisfunction,theinitialtemperatureoftheingredientsisNOTRELEVANT,thereforeyougetthesame

resultsanytime.

HOTMIXPROstartsthetimecountdownwhenthePROGRAMMEDtemperaturehasbeenreached.



ACCESSTOTHEFUNCTION

•Pressthetemperatureiconfor3

seconds,tillyouhearabeep

•Thedisplaywillshow:WAIT‐TEMP,togetherwiththeTemperatureicon

•Setthewishedtemperature

•Pressthetimeicon

•Thedisplaywillshow:WAIT‐TEMP,togetherwiththeTimeicon

•Setthewishedtime





3



CONTENTS

IMPORTANTNOTICE..........................................................................................................................................2

GENERALINFORMATION...................................................................................................................................4

WARNINGSBEFOREUSE....................................................................................................................................5

FREIGHT,PACKAGEANDSTORAGE...................................................................................................................6

INSTRUCTIONSFORUSE....................................................................................................................................6

PRODUCTDESCRIPTION....................................................................................................................................7

MACHINEDEVICES.............................................................................................................................................8

ACCESSORIES...................................................................................................................................................10

CLEANING........................................................................................................................................................12

HOWTOOPERATE...........................................................................................................................................13

HOWTOUSE

THEPRODUCTPROPERLY..........................................................................................................21

RECYCLINGANDWASTEDISPOSAL.................................................................................................................22

TECHNICALSPECIFICATIONS............................................................................................................................22



Pleasereadcarefullythismanualpriortothefirstuseoftheappliance.

Itisfundamentaltogetthebestresultsoutoftheproductandthehighestlevelofsafety.





4



GENERALINFORMATION

Aboutthemanual

Thismanualcontainsinformationoninstallation,ope r ationand maintenanceoftheequipmentandmust

beconsultedasareferenceguide.

Readingthisbookprovidesasafeandproperuseoftheappliance.

Inadditiontotheinformationprovidedwiththismanual,youmustcomplywithlocalregulations.

The

instructionmanualisanintegralpartoftheproduct,andshouldbekeptneartheequipmentandeasily

accessibletoanyonewhomakestheinstallation,careandcleaning.



Symbols

Inthismanual,symbolsareusedtohighlightimportantsafetyinstructionsandanywarning.

Theinstructionsmustbefollowedverycarefully

toavoidanyriskofaccidents,personalinjuryand/or

damagetothingsandpeople.



WARNING!Thissymbolhighlightsthedangersthatmightcauseinjuryand/ordamage.



WARNINGElectricityDanger!

Thissymbolpointsoutpotentialelectricityhazard.



CAUTION!Thissymbolhighlightsinstructionsthatmustbe

followedtoavoidrisks,damage,

malfunction,and/orbreakingoftheappliance.



Thissymbolhighlightstipsandinformationthatmustbefollowedfortheefficientoperationofthe

appliance.



NOTE!

Readtheinstructionmanualcarefullybeforeusingtheappliance.Themanufacturerdisclai msanyliability

resultingfromnon‐compliancewiththeseinstructions

foruse.Theinstructionmanualmustalways bekept

neartheequipmentandeasilyaccessibleforanyonewishingtoconsultit.Wereservetherighttomake

unannouncedchangestoimprovethetechnicalspecificationsand/orthedevelopmentoftheproduct.



ComplianceStatement

Theappliancehasbeenbuiltin

accordancewiththecurrentstandardsandtheinternationalsafety

directives.





5



WARNINGSBEFOREUSE

• Before using the appliance,please check that the voltage of theelectricity grid corresponds to theone

indicatedonthelabelofthedevice.Onlyconnectthemachinetoanoutletthathasaminimumcapacityof

10Aandaneffectiveearthingsystem.

• The  ele ctrical safety of this

 equipment is  guaranteed only if it is connected directly to an AC grounded

socket as required by the applicable electrical safety standards. The manufacturer cannot be held

responsible for any damage caused by a lack of connection to ground the appliance. In case of doubt,

contactaprofessionallyqualifiedtechnician.

•Afteryou’veunwrappedtheequipment,ensuretheintegrityoftheunit.Incaseofdoubt,donotusethe

applianceandcontactqualifiedpersonnelonly.

• We do not recommend the use of adapters, multiple plugs and / or extension cords. If is absolutely

necessary use one of these devices,

 you must only use single or multiple adapters conform to current

safetystandards,beingcarefulnottoexceedthepowerlimitspecifiedintheadapter.

•Theelementsofthepackaging(plasticbags,etc..)shouldbekeptoutofreachofchildren,becausethey

areapotentialsourceofdanger.

• This equipment must be used solely for the use described in this manual. Any other use is considered 

inappropriateandthereforedangerous.

• The manufacturer cannot be held responsible for any  damage caused by the equipment when used

inappropriately,erroneousandirrational,and/orrepairedbyunqualifiedpersonnel.

•

Donottouchtheappliancewithhandsand/orfeetifwetordamp.

•Donotremovetheplugfrompullingthepowercord.

•Donotleavetheunitexposedtotheweather(rain,sun,frost,etc.).

• This appliance is not intended for use by people

(including children) with reduced physical or mental

ability,orlackofexperienceandknowledge,unlesstheyhavebeeninstructedontheuseoftheequipment

bypersonnelresponsiblefortheirsecurity.

•Ensurethatchildrendonotplaywiththeappliance.

• Before carrying out any cleaning or maintenance, disconnect the

 appliance from the mains supply by

removingtheplug.

•Neverimmersetheapplianceinthewatertocleanit.

•Nevermountthebladesinthebowlwithoutsealing.

•Useonlythesuppliedspatulatostirthepreparations.

•Donotevercookwiththeemptybowl.

•

Neverplacetheentireunitunderthetaptointroducewaterintothebowl.

•Neverlifttheappliancebyholdingthehandleofthebowl.

•Donotcovertheinletandventilationopeningsontherearoftheunit.

•Incaseofbreakdownormalfunctioning,turnitoff

anddonotopenit.Forrepairs,contactonlyaservice

facilityauthorizedbythemanufacturerandasktheuseoforiginalspareparts.Failuretocomplywiththis

rulemayjeopardizethesafetyoftheappliance.

• When you decide  to permanently delete the device, after removing the plug

from the socket, it is

recommendedthecuttingofthepowercord.

• If the power cord is damaged, it must be replaced only at a service centre authorized by the

manufacturer,soastopreventanyrisk.

• When not using the unit, disconnecttheplug from the mains and

 turn off the switch.Do not leave the

deviceconnectedtothemainsifitisnotnecessary.

• The unit cannot be usedaftera fall or in case of imperfections or losses. Beforereturningto use it will

needtobebroughttoanauthorizedservicecentre.

•

Keepthisinstructionmanual,becauseitmaybenecessarytoconsultitinthefuture.

•ThisdevicecomplieswithEuropeanCommunityrulesinrelationtoelectromagneticcompatibility.



6



FREIGHT,PACKAGEANDSTORAGE

Shippingcontrol

Checkshippingclaimsregardingdamagecausedbytransportimmediatelyafterreceipt.

Incaseofapparentdamage,accepttheshipmentonlyunderreserve.Pleasenotetheextentofthedamage

onthetransportdocument.



Packaging

Donotthrowawaythepackagingofyourappliance,becauseitcouldbeuseful

forstorage,when

transportedorincaseofdamageforthereturntocentre.

Theinnerandouterenvelopemustbecompletelyremovedfromtheequipmentbeforeinstallingit



PLEASENOTE!

Incaseyoushouldbringthemachinebacktoyourdealer,pleaseuseexclusivelytheoriginalpackage,as

any

breakorfaultcausedbytransportdamagesduetolackoftheoriginalpackagecouldbechargedto

you.

Ifyouwanttothrowawaythepackage,pleaseconsidertherecyclingregulationsinyour country.

Checktheequipmentandthepresenceofallcomponents.Incaseofmissingparts,please

contactour

customerserviceimmediately.



Storage

Keepthepackagingclosedtillitwillbeinstalled,takingintoaccountthemarkingonthepackaging.

Thepackagingmustbestored,takingintoconsiderationthefollowing:

‐Donotstoreitoutdoor.

‐Keepinadryplaceawayfromdust.

‐Donotexpose

tocorrosiveelements.

‐Donotexposetodirectsunlight.

‐Avoidmechanicalshockandvibrations.

‐Incaseofprolongedstorage(>3months)makesurethatthestateofthepackageandallitspartsarein

goodcondition.Ifnecessary,renewthepackaging.



INSTRUCTIONSFORUSE

•Beforeusingtheapplianceforthefirsttime,thoroughlycleanalltheaccessoriessuchasbowl,lid,

measuringcap,bladesandspatula,followingtheproceduresdescribedlater.

•Placetheunitonahorizontalworksurface,awayfromedgesandheatsourcesandoutofreachof

children.

•The

maximumcapacityofthebowlmustneverbeexceeded.Introducingexcessivequantitycoul dmean

spillingliquidsand,consequently,alsoirreparabledamagetheunit.Thesefailuresarenotcoveredbythe

warrantyagreement.

•Donotintroducehands(orfingers)intotheholeofthelid,itcouldbeapotential

riskofcutting.

7

PRODUCTDESCRIPTION

1. Liquid Crystal Display

2. Control Panel

3. SD c

ard co

mpartment

4. SD card

5. Measu

ring cap

6. Lid

7. Magnet

8. Flaps for li

d opening and closing

9. Lid gasket

10. Lid hole

11. Flaps fo

r lid opening and closing

12. Powe

r cable

13. Switc

ing ON / OFF

14. Stabilizing feet

15. Stainless steel bo

16. Mixing pa

ddle

17. NT

C prob

18. Heatin

g element

19. Liquid le

aking hole

20. Blades

21. Blades lo

cking ring

22. Spatula

Optional a

ccessories

23. Stainless steel ba

sket for steam

cooking

8

MACHINEDEVICES

CONTROL

PANEL (2)

Menu:toac

cesstotherecipemenu.

+‐:toincreaseordecreaseSpeed,Timeand

Temperatureparameters.When“+”and“‐”

areusedaspulsebuttons,theparameters

increaseordecreasebyonedigit.Ifyoukeep

pressingthebuttons,theparameterswill

quicklyincreaseordecrease,justdep

ending

onhowlongthebuttonswillstaypressed.

Turbo:Bykeepingtheswitchpressed,itispossibletogofromspeed6asaminimumtothe

maximumspeed(“Turbo”speed),tilltheswitchisbeingreleased.

Pulse:togeta“Pulse”functioningatanyspeed,from1to10(wi

ththeexceptionofspeeds1Eand1F).

Clock:tosettheoperatingtimeuptoamaximumof12hours.

Start/stop:itistheon/offswitchforanyfunction.

Thermometer:tosettheoperatingtemperatureasfrom25°C(77°F)upto190°C(374°F).

Speed:Tosettheoperatingspeed,with12differe

ntoptions.

HEATINGELEMENT(18)

Electricaldeviceforheatingthebowlwhilecooking.

WARNING:donotheatthebowlwhenempty!

WARNING:donottouchit,itcouldcauseburns!

NTCPROBE(17)

Itistheelementenabledtocontrolthetemperatureset.



9



LIQUIDLEAKINGHOLE(19)

Wheneversomeliquidsshouldcomeoutofthebowl,theywillgooutfromtheappliancebase,throughout

thishole!

WARNING:checkthattheholeisnotblockedperiodically!

WARNING:theevenpartialblockageofthisholecouldcauseseriousdamageincaseofliquidleakage

out

ofthebowl.



STABILIZINGFEET(14)

Thefourelasticfeetatthebaseoftheapplianceworkasshockabsorbersandstabilizingelementsofany

oscillationwhentheapplianceisoperating.



WARNING:itmayhappenthat,dependingonthefoodpreparation,theappliancecouldmakevisible

oscillations:thisis

absolutelynormal,andthestabilizerswillabsorbanyoscillation



LCDDISPLAY(1)

Oncetheappliancehasbeenswitchedon,theHotmixPROlogowillappearonthedisplay.

Ifthelidofthebowlis open, the icon of the lidwillswitchonandtheindication “LID OPEN” will

appear.

After closing the lid safely, the icon and the written indication will disappear, while the speed icon will

appearwith“00”digits,togetherwiththeindication“SETSPEED”:atthispoint,theapplianceisreadytobe

programmed.

When temperature is being set, the thermometer icon will  switch on, together

 with the indication “SET

TEMPERATURE” Whenpressingthe“CLOCK” switchtosettime, theclockiconwillswitchonwith“00:00”

digits,andthe“SETTIME”indicationwillappear.Thedisplaywillshowtheremainingtimeslippingby.

In case of severe fault,the spanner will switch on while anything

elsewill switch off. Theappliance must

thenbebroughttoaservicecenter.



MOTORCONTROLTHERMOSTATS

Your appliance is equipped with two thermostats for motor protection: one dynamic and one static. The

dynamicthermostatalwaysintervenesbeforethestatic,whichstopsthemachinepointingEr:01.

The dynamic thermostat,  in

 fact, make an “intelligent” control of the motor temperature, stopping for a

moment,ifnecessary,tocoolthemotordownandfinishtherecipe,beforeinvolvingthestaticthermostat.

Whenthedynamicthermostatisinoperation,theword“PULSE”willbedisplayed,andyoucaneasilyfinish

the preparation. If,

however, an excessive amount of ingredients  or a too  thick preparation takes place

(which can cause a strain upon the appliance, with consequent overheating of the motor),  the static

thermostatcomesintooperation,stoppingthemotorimmed iately.Thedisplayshows“Er:01”.Waitafew

minutes before the appliance cools down,

 and when the motor has reached an acceptable temperature,

the machine is automati cally ready for use again. To do this you have a forced air cooling fan  that  also

workswhenthemachineisoff.



SDcard(4)

ThemachineisequippedwithanSdcard,placedinsideofa

comportmentonthebackofthemachine.To

accessit,unscrewthescrews.InsidetheSDcardthereare:

Folder“DEFAULT”:itcontainsprograms,recipesandspeciallystoredfunctions;

Folder“USER”:itissuitedtostorepersonalrecipes;

Folder“CreatorPRO”:itcontainsthesoftwaretobeinstalledonthe

PCforstoring,modifyinganddeleting

therecipesandinstructionstodoit;

Folder“Recipebook_GastroXL”withthecompleterecipebookofpre‐storedrecipes.



10



ACCESSORIES

COVER(6)

•Mountthecoverbypressingthetwosideflaps(8)andexertingalittlepressure.

Itwillbeveryeasy.

Thelidhasagasket(9),whichmustalwaysbemountedcorrectlytoavoidtheriskofleakingfluids.

WARNING: The incorrect position of the gasket (9) could

 enable the spill of  liquids, or prevent the

startoftheappliance.



• If the lid is not closed properly, the electromagnetic safety device (7) prevents the appliance to start

working,andthedisplayshowstheiconofthebowlwithanopeninglid.

•Toopenthelid,press

withtwofingersonthesideflaps (8)andliftthemup.

WARNING:If therearesomeliquidsinthebowlandthespeedishigh,waitbeforeopeningthelida

fewsecondssotheliquidwillcomebacktotheirordinarylevel,toavoidoverspilling.

CAUTION:Before

youstarttheappliance,pleasealwayscheckthatthetwosideflapsareclosed.

CAUTION:Removethegasketperiodi callyandcleanthedirtbetweenthesealitselfandthecover.

CAUTION:Takecaretocorrectlyreassemblethegasketatitshead,sothatthelidcloseswell.

CAUTION:Neverputthe

lidinthedishwasher!



MEASURINGCAP(5)

Thecaphasadualfunction:whenfitonthecoveritpreventsliquidleakingfromtheliditself,andcanbe

usedasahandymeasuringcupaswell.

CAUTION:Ifboilingliquidsarepresent insidethebowl,pleasewaitawhile

beforeremovingthecap:

itwillpreventanypuffsofsteam.



Equivalencecapacityofmeasuringcap:

Water............................................................................................................g.85

Extra‐virginoil...............................................................................................g.85

Seedoil.........................................................................................................g.75

Wine.............................................................................................................g.85

Milk...............................................................................................................g.85

Flour.............................................................................................................g.55

Semolina.......................................................................................................g.70

Sugar............................................................................................................g.

85

Cocoa...........................................................................................................g.50

Rice..............................................................................................................g.85

Breadcrumbs................................................................................................g.50

Gratedcheese..............................................................................................g.50



CLEANING:Themeasuringcapcanbewashedinthedishwasher.

Bowl(15)

Thebowlshowsthreelinestoindicatethecontentlevel:

3rdline=3litres



11



 CAUTION: when the contents of the bowl arrives to the 3rd line (3lt max) the speed 3 is the

maximumspeedsetting.When, onthecontrary, thecontentofthebowldoesn’texceedthe2nd line(1,5

lt).Themaximumspeedsettingis10.



CAUTION:Themaximumcapacitymust

neverbeexceeded,anditisvitalthatyoutakeitintoaccount

for some foods such as leavened dough (bread, pizza, etc..) During  some  preparations volume increases,

furthermorethehigherspeedstendtoincreasetheliquidlevelbecauseofthecentrifugalforce.



BOWL’SEXTRACTION



Ensurethattheunitisstopped,thenpr essthebuttonstoopenthelid.

CAUTION:Tostoptheengineneveropenthelid.Useonlythe“START/STOP”switch.

CAUTION:Toremovethebowl,pleaseuseonlythehandle.

CAUTION:Thebowlmaybeveryhot,donottouch

itanddonotplaceitondelicatesurfacesasthey

couldevenbeirreparablydamaged.



BOWL’SOPENINGANDINSERTION



Make sure that the appliance is stopped, then press the buttons to open the lid. Opening the lid

automaticallysetsoperationalsafetythatstopstheengineand,consequently,thebladesstopturning.

Insert the bowlmaking sure that soundsperfectly in theirseats, otherwise the safety device will prevent

the

motorstarting.

CAUTION:beforetoinsertthebowlcheckthatthebladesaresecurelylocked. 

CAUTION: Before cleaning the glass, always make sure that the blades are dismantled in order to

avoidtheriskofcutting.

CLEANING:Thebowlcanbewashedinthedishwasher.Consider,however,thatthedetergentsused



indishwashersareveryaggressiveandthat,aftersometime,thegripofthebo wl’shandlecouldbecomea 

littlediscoloured.



BLADES(20)

MOUNTINGTHEBLADES:

Holdthe bladeswithone hand,insertitintotheholeonthebottomofthebowlwiththeotherhandand

carefullytighten

thelockeronthebottomofthebowl,turningitclockwise.

Totakeouttheblades,pleaseturnthelockeranti‐clockwiseandmaketheoppositeoperationtore‐mount

theblades.

WARNING:Thebladeshavesharpsurfaces,becarefulwhilehandling.

CAUTION:Afteryouhavecrushedharshelements(ice,nuts,

carrotsetc.)ALWAYStightenthelocker.

Alwayscheckthatthebladesareequippedwiththegasketandthatthegasketisingoodcondition,

otherwiseitwillbepossiblethatliquidscomeoutthroughthedischargepipeonthebasisoftheappliance.



12



SPATULA(22)

The spatula allows to stir the ingredie nts contained in the bow l even with the blades  in motion in total

security,becauseitsspecialshapemakesitimpossibletogetincontactwiththeblades themselves.Italso

enables,whennecessary,toremoveingredientsfromthewallsofthebowl

inoneprocessingstepandthe

next.

WARNING:DONOTuseothertools(spoonsorwoodenspoons,etc.)withthebladesinmotion.

CLEANING:Thespatulacanbewashedsafelyinthedishwasher.



MIXINGPADDLE(16)

Themixingpaddlehelpsfoodsandliquidstogetproperlyblended.

Toinsertthe

mixingpaddle,pleasematchtheholeatthebottomofthedevicewiththeupperpinlinkedto

theblades,thenpushdowntillyouheara“click”.

Toremovethemixingpaddle,pu llitupwardtoremoveitfromtheblades’pin.

Thetimeofusageofthemixing

paddleislinkedtothedurationofthefoodpreparation.

WARNING:DONOTusethemixingpaddleatspeedshigherthan4oratspeedTURBO.

WARNING:DONOTremovethemixingpaddlewhentheglassisstillhot.Waittillthemixingpaddle

coolsdownbeforeremovingitfromthe

bowl.

CLEANING

Clean the appliance with a damp cloth and neutral detergent, avoid cleaners that result in being too

aggressiveorthatmaketoomuchfoam.

CAUTION:Disconnecttheplugfromtheoutletbeforestartingthecleaningoperations.

CAUTION:Donotcompletelysubmergetheunitinwaterforcleaning.

CAUTION:Donot

cleantheappliancewithajetofwater.

WARNING:periodicallydisassemblethelid’sgasketandremovethedirtthattheremightbebetween

itandthelid.

WARNING:takecaretocorrectlyreassemblethegasketatitshead,sothatthelidclosescorrectly.

Clean the inside of the bowl

with a slightly dampened, non‐abrasive sponge. Do this only and

exclusivelywhenthemachineis offandcold.Before cleaningthebowl,alwaysmake surethattheblades

aredismantled,inordernottoruntheriskofcutting.





13



HOWTOOPERATE

•Placetheapplianceonaflatsurface,sothatitwillbeinastableposition.

•Connecttheequipmenttothemainsvoltage.

•Switchontheappliancebykeepingthemainswitchpressed,thedisplaywillthenswitchonautomatically 

andshowingtheHotmixPROlogo.

Toensuresafetyandrespectofenergysaving,ifyoudonotsetanyparameters,afterabout5minutesthe

unitwillshutdown,settingin“standby”positionand displayingtheHotmixPROlogo.

Justpressanykeytoputthedevicebackintooperation.



SETTINGTHEFUNCTIONS

•Selectthe

iconofthefunction.

•Usethe“+”and“‐”buttonstosetthedigits.

•Setthefunctionsnecessarytomakefoodpreparations,alwaysusethisrecommendedsequence:

1.Temperature

2.Speed

3.Time

4.Start/Stop



WARNING: at the first use,  it is possible  that the

device emit a low noise, due to the internal

stabilizationofthejoints.Thatisnormal,anditwilldisappearinashorttime.



CORRECTIONOFDATASET

Whenworkingyoucanchangetheparametersofspeed,timeandtemperature and, with the “+” and “‐” 

symbols,definethe

newdigits.

Proceedasfollows:

•PresstheSTART/STOPbuttontostoptheappliance

•Pressthebuttoncorrespondingtotheparameterthatyouwanttochan gefor thesetting

•Pressthe“+”and“‐”buttonstosetthenewdigit

•PresstheSTART/STOP

buttontorestarttheunit.

Theunitwillnotstartwithoutanygivensetofparameters.



SPEEDCONTROL

Selectionoftheblades’speedasfollows:

•PresstheSPEEDbutton

•Use“+”and“‐”buttonstoselecttherequiredspeed.Thespeedsetwillappearsonthedisplay.



Theapplianceisequippedwith23differenttypesofspeed:

•Speedfrom0to10

•Speedfrom1to10PULSE

•Speed1Eforcookingmeatwithmixingpaddle

•Speed1Fforcookingdelicatefoodswithmixingpaddle

•Turbo



Thespeed“0”canbedisplayed

andselectedonlybysettingatemperaturefirstasfollows:

•Pressthebuttonwiththeiconofthethermometer

•Selectatemperature

•Usethe“‐”buttontoselectspeed“0”,thatwillappearsonthedisplay

•Settheotherparametersandproceed.



14



TIME

Selectionoftimeduration:

•PresstheTIMEbutton.

•Use“+”and“‐”toselecttheworkingtime.Thevalueoftimesetwillbedisplayed.

•Therangeoftimevariesfrom5secondsto12hours.

•After60minutes,andupto12hours,the

stepswillbe10minutesatatime,unlessyouusethe“+”and“‐

”withsmallshots:inthiscasewecanproceedfromminutetominute.



Stepsoftheclock:

<1min1‐5min.5‐10min.10‐30min.30‐60min.>60min.finoto12hours.

Every5sec.

Every15sec.Every30sec.Every1min.Every5min.Every10min.

Every10min.withoptionofmin.inmin.

Thedisplayshowstheremainingtimeoffoodpreparation.

Theunitstopsautomaticallywhenitreachestheselectedtimeandemitsabeep.



TEMPERATURE

Temperatureselection:

•

PresstheTEMPERATUREbutton

•Use“+”and“‐”buttonstoselecttherequiredtemperature.Thedisplaywillshowthesettemperature.

•Ifyoudonotsetanytemperatureasthemachinehastowork“cold”,thedisplaywillshowtwohorizontal

linestoindicatethatthereis

noheating.



Thetemperaturerangevariesfrom25°C(77°F)to190°C(374°F).

Preparefirstallthosepreparationsthatdonotrequirethetemperaturesetting,soyoudonothave

towaitfortheunittocool downforsubsequen tfoo dprocessing.



EXAMPLESOFWORK



NORMALWORK:



•Afterintroducingtheingredientsintothebowl,closethelidproperly.

•PresstheSPEEDbutton,thenusethebuttons“+”and”“‐”toselecttherequiredspeed.

•PresstheTIMEbuttonandthenusethebuttons“+”and“‐”toselect therequiredtime.

•

Pressthetemperaturebutton(ifnecessary),thenwiththe“+”and“‐”buttonspleaseselecttherequired

temperature.

•Finally,presstheStart/Stopbutton(tooperatetheappliance).



PULSEWORK

(workstopped):

Whentheunitisoperatingwiththetrendoftheregularprogram:

•PressthePULSEbuttonbriefly‐sothejobwillgofromNORMALtotheDISCONTINUED.Theappearance

oftheappropriateicononthedisplaywillindicatethatthefunctionPULSEison‐going.



TURBOWORK:



Whentheunitisoperatingwiththetrendoftheregularprogram:

• Press the button to activate TURBO function. TURBO function remains operational until the button is

pressed.

TheTURBOisactivefromthespeed6throughspeed10.

ThedisplayindicatesthefunctionwiththeflashingiconTURBO

SPEED.



15



MENU

a.RECIPEGUIDE

b.RECIPEMANAGEMENT(modifying,deleting,memorizing) 



InordertoaccesstheRECIPEGUIDE,pleaseinserttheSDcardintheappropriatecompartment,placedon

thebacksideoftheappliance(3).

a.KeepingtheMENUswitchpressed,thepre‐storedrecipes/programswillbeaccessed.

b. Keeping the

 MENU switch pressed for at least 3 seconds, the following functions can be accessed: 

modifying,deleting,storingofone’sownrecipes(onlyforsettingfunctions).

The programs and the pre‐stored recipes have been created by our chefs according to their

personal taste, using ingredients available in our country.It

is possible that different ingredients and a

different personal taste will sort out a different outcome from what expected. To this purpose, the

applianceofferstheopportunitytomodifythestoredrecipesand/orprograms,bysavingacopyinone’s

ownfile(User),ortostoreownrecipes,accordingtothe

personaltasteandtheingredientsavailablein

one’sowncountry.



a.KeeptheMENUbuttonpressedand,byusingthe+and–buttons,selectthefileyouwanttoaccessto:

DEFAULT (pre‐stored recipes and programs) or USER (perso nal recipes). Confirm by pressing the Start

button.



Regardlessof

theselectedfile,pleaseproceedasfollowstocreateaprestoredrecipe/program:



•Byusingthe“+”and“‐“buttons,selectthenumberofthechosenprogram.Forseeingthecompletelist,

pleasegoto:www.hotmixpro.com,atthe“RECIPESANDSPECIALPROGRAMS”section.Theconsultationof

thissectionwill

enableyou:

a)toprintthefulltextofrecipes,includinganyfinalstagesofprocessing;b)toalwaysfindtheupdatedlist,

inrealtime,ofanyrecipeandprogramavailableandpossiblytheirupdatedversion, whichwillbepossible

todownloadonyourSDcard.

•Thenpress

theSTART/STOPbutton:thenumberoftheprogram/recipewillappearontop,withthetitle

flowing“INGREDIENT_OF_”(where000isthefirstingredient, andthenumberafterthebarshowthetotal

quantityofingredients of aspecificrecipe),andthenameandthequantityofthefirstingredient.

Within

someprograms,neithertheingredientsnotthequantitiesarebeingspecified.

•Byusingthe“+”button,alltheingredientsneededforarecipecanbedisplayedonebyone.

• At the end, press again the START/STOP switch to show the first ingredient of the first step to

be

introducedintothebowl.Thedisplayshowsthetotalnumberofthestepsforeachrecipeaswell(e.g.1/3).

•Oncetheingredientsofthefirststephavebeenintroducedintothebowl,pressSTARTandthemachine

willoperate.

•Attheend,followthesameprocedurewith

thesecondstep,tilltherecipewillbecompleted.

Thedisplayshowstheremainingtime,speed,temperatureandtheaccessoryused.

• At any stage of each operations, the icons will appear on the display, thus indicating which function is

working,likewhenthemachineisbeingoperatedmanually.



 the end of the last operating step. The machine will emit a continuous “beep”, like at the end of any

manualpreparation.

When a stored recipe is being created, it is fundamental that the ingredients are being introduced

exactlyinthesameorderaspertheindicationsgivenonthe

displayortherecipeguide.

ATTENTION:Neverletthemachineunattendedwhileworking.



16



b.PresstheMENUbuttonforatleast3seconds.Byusingthe“+”and“‐”buttons,selectthefileasfollows:

DEFAULT (pre‐stored recipes and programs) or USER (perso nal recipes). Confirm by pressing the Start

button.

Thismenuincludesthefollowingactivities:

Storageofarecipe



Modificationofapre‐storedrecipe



Deleteofapre‐storedrecipe



STORAGEOFARECIPE



Therearetwowaystostoreone’sownrecipe:

A. Directly from the machine, into the USER file, it is possible to store number and name of a recipe,

numberofthesteps requiredtocompleteit,andtheoperatingparameters(speed,timeandtemperature).

It is not possible to

write the ingredients and the quantities, if you wish to include these infos please

proceedtopointB.

B.FromthePC,afterinsertingtheSDcardintotheappropriatecardreader,throughtheprogramintothe

CreatorPRO file it is possible to store number and name of the recipe, 

number of the steps required to

complete it, and theoperating parameters (SPEED,TIMEand TEMPERATURE), besides writing ingredients

andrelatedquantities.



A.Tostorearecipedirectlyfromthemachine:

 KeeptheMENUbuttonpressedforatleast3seconds.

 Usethe“+”e“‐”buttons

tolettheMenuwordsflowingtillselecting“STORE”,andpressthe“START”

button.

 Itisnecessarytoselectthenumberoftherecipetobestored,bylettingthenumbersflowingwiththe

“+”and“‐”buttons.ConfirmtheselectednumberwiththeSTARTbutton:incase

theselectednumber

is already assigned, the indication “ATTENTION RECIPE EXISTING” will appear, and it will fade away

after 3 seconds; a “beep” will be then heard, and the display will go back to the previous screen, in

ordertoenabletheselectionofanothernumber.Incasetheselectednumber

willbeavailable,please

confirmwiththeSTARTsw itch,thengoaheadtothesubsequentline.

 Thestorageofarecipeshouldbemadebydividingitintosteps,startingfrom1upwards,usingthe“+”

and“‐”buttons.ThenconfirmwiththeSTARTbutton,andthengo

aheadtothesubsequentscreenof

settingmodes.

 If when storing each step an already assigned number will be chosen, a “beep” will be heard after 3

secondsandthedisplaywillgobackautomaticallytothepreviousscreen,toenabletheinsertionofthe

correctnumber.

 Onceon

thescreenofthesettingmodes,selecttheSPEEDdigitwiththe“+”and“‐”buttons,andthe

PULSEswitchaswellifrequired,thenpressSTARTtoconfirm.

 NowwegototheTIMEsettingmode.Pleaseselectthedigitswiththe“+” and“‐”buttons,

confirmwith

theSTARTbutton, andthengotothenextsettingmode.

 So we get tothe TEMPERATURE setting: please select the digit with the “+” and “‐” buttons, confirm

withtheSTARTbutton,andthengotothenextsettingmode,thatistheselectionofthe

accessoryto

beused.

 Selection of the ACCESSORY: please go the requested accessory by the “+” and “–“ buttons, then

confirmwiththeSTART/STOPbutton.

 All the set data are to be confirmed (or not) with the subsequent screen by using the “+” and “‐”

buttons, to

getpositioned over YES,orNO and then pressing the START/STOP button. If the data are

confirmed, then the subsequent screen will appear, otherwise it will go back to the initial  screen. In

bothcasesthenameoftheaccessorywillflowonthedisplay.

 On the next screen the

 indication “OPERATION COMPLETED” will appear. It will mean that all the

necessaryoperationshavebeenset.Theindicationwillstayonforabout3seconds,thena“beep”will

announcethechangetothenextscreen.



17



 Incasea recipeneedstobepreparedthroughvarioussteps,presstheSTARTbuttontogetbacktothe

screenwherethenumberof thestepto bestoredwillbeselected.Conversely,iftherecipehasbeen

completed,pleaseselecttheindicationENDbyusingthe“+”and

“‐”buttons,andthenpressSTART.

 TogetoutfromtheSTORERECIPEmenuandgobacktotheinitial screenRECIPEMANAGEMENT,press

START if the storage procedure has been completed, or MENU if you decide to exit earlier, therefore

deletingthestorageprocedure.



MODIFICATIONOFA

PRE‐STOREDRECIPE

Tomodifyapre‐storedrecipe:

 PresstheMENUbuttonforatleast3seconds.

 By using the “+” and “‐”  buttons, let the menu words  flowing, till selecting “CHANGE”,and press the

STARTbutton.

 Choosethenumberoftherecipetobemodified,byusing

the“+”and“‐”buttons,thenonceselected

pressSTARTtoconfirm,andpassontothelinebelow.

 Selectionofthesteptobemodified:byusingthe“+”and“‐”buttons,oncethestephasbeenselected

pleasepressSTARTtoconfirm,andthenpasson

tothesettingmodescreen.

 Tosetthenewoperatingspeed:selectthedigitwiththe“+” and “‐” buttons, and possibly the PULSE

function(bypressingthePULSEbutton).OncethewordSPEEDhasbeenselected,choosethenewdigit

with the “+” and “‐” buttons,

then confirm by pressing the START button, and pass  on to the

subsequentscreen.

 Tosetthenewoperatingtime: select thedigitwiththe“+”and“‐”switches.Onceselectedthe word

TIME, choose the new digit with the “+” and “‐” switches and confirm by pressing

 the START switch,

thenpassontothesubsequentscreen.

 Tosetthenewoperatingtemperature:choosethedigitwiththe“+”and“ ‐”buttons.Onceselectedthe

new the wor d TEMPERATURE, choose  the new digit with the “+” and “‐” buttons, and confirm by

pressingthe

STARTbutton,thenpassontothenextscreen.

 Tosetanew accessory,positiononthewordreferredtotheaccessorytobeselectedwiththe“+”and

“‐”buttons,andconfirmbypressingtheSTARTbutton.

 To confirm the new set data, select YES with the

 “+”  and “‐” buttons, and confirm by pressing the

STARTbutton,thenpassontothenextscreen.

 Conversely,ifyoudonotwanttoconfirmthenewsetdata,selectNOwiththe“+”and“‐”buttons,and

confirm bypressing the START button to go

back to the screen that enables to repeat any operation

requiredtochangetheparameters.



DELETEOFAPRE‐STOREDRECIPE



Todeleteapre‐storedrecipe,pleaseproceedasfollows:

 EntertheRECIPEMANAGEMENTmenubykeepingtheMENUbuttonpressedfor3seconds.

 Use the “+” and “‐” buttons to let the menu words flow, then position on DELETE and confirm by

pressingtheSTARTbutton.

 Select the numberof the recipe to be deleted by using the “+” and “‐” buttons, then press START to

confirmandpassontothelinebelow.

 PositiononYESwiththe“+”and“‐”buttonsandconfirmbypressingtheSTARTbutton.

 The display

 will show the indication SURE DELETE, then get positioned on YES with the “+” and “‐”

buttonsandgiveconfirmationbypressingtheSTARTbutton.ThenthesubsequentscreenOPERATION

COMPLETEDwillappear.

 Conversely,byselectingNOtheprogramwillbeexited.



B.Tostorearecipethrough

thePC,writingeveni ngredients andquantities,ortomodifyordeletearecipe

from the SD card through the PC, download from the SD card the software located in the folder

“CreatorPRO”andinstallitfollowingtheinstructions.



18



SPECIALFUNCTIONS



“WAITTEMPERATURE”FUNCTION

Thisfunction,particularlyusefulforpastrypreparations,allowsthemachinetoreachatemperaturethat

hasbeenpre‐determinedbytheuser.Oncereachedthistemperature,therecipehasbeencompleted(e.g.

Custard), but the WAIT  TEMPERATURE function enables to keep mixing the just completed

preparation,

requiringthataTIMEdigitbelow04:00hoursisbeingsetintothemachine.

When one wants to use the preparation, the machine must be stopped MANUALLY, by pressing the

START/STOPbutton.



PERSONALTOUCH:

To facilitate the perfect success of the stored recipes, you can repeat the last sequence of

 processing as

follows:

•Pressthe“clock”

•Youwillhearabeep

•Setatimeofyourchoice

•Pressthe“Start”

Inthiswaytheunitwillrepeatthelastsequencewiththesamespeedandthesametemperature,forthe

timeyouset.It isvery

useful,forexample,togivea finaltouchtofoodprepar ationsthat are nottoyour

liking,withouttheneedtoresetallthedigitsagain.



DELAYEDDEPARTURE 

Thereare3waystooperatethemachinewiththelatedeparture.



MANUALPROGRAMMING



Whenthemachineisturnedon,tosetthecurrenttime,pressandholdthebutton “clock”for5secondstill

youwillhear3beeps.Nowthedisplayshows“‐‐:‐‐”withthefirsttwolinesthatareflashing,theyindicate

thehour,withthe“+”and“‐

”buttonsyoucouldjustsetthetimeformat0‐24.

Once you have chosen the time, you have to store your data by pressing the “start / stop” button: after

flashing,thesecondtwolinesaretoindicatetheminutes:withthesameprocedureyoustoretheminutes.

Then, you

 must set the time you want  the appliance get started, and with the same system you set the

hour.

Once you confirm the inf ormation with the START / STOP button, the display will show the clock icon,

which means that we mustset(againwith the “+” and “‐

”buttons)the time wewantthemachinestarts

working;itmustbeconfirmedbypressing“start/stop”aswell.

Next,thedisplayshowstheiconofthethermometer,ifyouwanttosetatemperature,alwayswiththe“+”

and “‐” buttons, and pressing the “start / stop”

 button to confirm. If you do not want any temperature,

pressthe“startstop”buttonandskipthisstep.

Nowtheblades’iconappearsonthedisplay,andasabove,adjustthespeedwiththe“+”and“‐”buttons,

andstorethedata.Ifyouwantaspeedpulse,

pressthe“pulse”buttonbeforestoringthedata.

Onceyousetthelastdigitofspeed,youwillhear4beeps,themachineisputonstandby,thedisplayshows

thecurrenttimeandtheclockiconisflashing.

Inthisconditionthemachinewaitsforthesettimetoperform

thesetfunctions.

Speedswillbesetonlyupto3,thetemperaturewillbeupto95°andthetimeupto4hours.



COMPLETERECIPEINMEMORY:



Onceselectedarecipethatyouwanttoperformwiththedelayedstart,press  andholdfor 5secondsthe

“clock”buttonandyouwillthenhear3beeps.Nowthedisplayshows“‐‐:‐‐”withthefirsttwolinesthat

areflashing,theyindicatethehour,withthe

“”and“‐”youcouldjustsetthetimeformat0‐24.

Once you have chosen the time, you have to store your data by pressing the button “start / stop”: after

flashingthesecondtwolinesindicatetheminutestothesameproceduretimeyoustoretheminutes.



19



Then, you must set the time when you want the appliance will get started, with the same system with

whichhehadsetthehourearlier.

Once you set the last value, you will  hear 4 beeps, the machine is  put on standby, the display shows the

currenttimeandthe

clockiconisflashing.

Inthisconditionthemachinewaitsforthesettimetoperformthesetfunction.

In this case, the first step of the recipe selection starts, then once finished the machine stops and

waitsforthestartforthenextstep.

CAUTION: Always check that the

ingredients are introduced in the recommended amount from the

display.

WARNING:Failuretomaintainthequantityoffoodcouldcauseseriousdamagetothingsandpeople.

CAUTION:Neverleaveyourapplianceunattendedduringtheoperations.



SINGLESTEPOFARECIPE

Whenyoupickarecipeofwhichyouwantto

makeasinglestepwiththedelayedstart,firstyouneedtodo

theabovestepsintheordinary way, then once the last step is over,andbeforeyougivethestarttothe

nextstep,pressandholdfor5secondsthe“clock”buttonandyouwillhear3

beeps.

Nowthedisplayshows“‐‐:‐‐”withthefirsttwolinesthatareflashing,theyindicatethehour,withthe“+”

and“‐”buttonsyoucould justsetthetimeformat0‐24.

Once you have chosen the time, you have to store your data by pressing

the button “start / stop”: after

flashingthesecondtwolinesindicatetheminutes:withthesameprocedureforstoringthehours,younow

storetheminutes.

Then, you must set the time at which you want the appliance getting started, with the same system by

whichyouhadsetthe

hourearlier.

Inthiscase,thestepbeingpartofthechosenrecipestarts.Attheendofit,themachinestopsand

waitsforthestartofthenextstep,oritbeepswhiletherecipehasbeencompleted.

WARNING:Alwayscheckthattheingredients are being introduced in

therecommended a mount as

perthedisplayindication.

WARNING:Failuretomaintainthequantityoffoodcouldcauseseriousdamagetothingsandpeople.

CAUTION:Neverleaveyourapplianceunattendedduringtheoperations.

Itispossibletocheckifsetdataarecorrectwhenthemachineisinstandby,withthe

clockflashing,

bypressingthestart/stopbutton:setdigitsappearinsequencewiththeappropriateicon.



Whenmakingthisoperation,ifyourealizethatyouhavesetwrongdata,pleasepresstherecipeiconfor5

seconds,thenyouhear4beeps,andalldatasettingswillbe

deletedwiththeexceptionofthecurrenttime.



FOODREHEATING

Forthisfunction,thereistheprogramP00intherecipememory.

AfterpressingtheSTART/STOPbutton,you’llneedtosetthetemperature(rangingfrom25°to65°)with

the“+”and“‐”buttons,thenonce

theselectedtemperatureisconfirmedbypressing“Start/Stop”button.

You should then confirm the time (0‐4 hours), then after pressing “start /  stop”, the robot will start

reheatingthefoodatspeed0atthesettemperatureandtime.



20





Page is loading ...

Metos Hotmix Pro Gastro XL Owner's manual

Brand: Metos

Model: Hotmix Pro Gastro XL

Category: Food processors

Type: Owner's manual

Download PDF

report

Metos Hotmix Pro Gastro XL Owner's manual

Metos Hotmix Pro Gastro XL Owner's manual

Related papers

Other documents