2. Navigloo
  3. 3510

Navigloo 3510 Assembly Instructions

  • Hello! I have analyzed the provided user manual for the Navigloo Pontoon Boat 23-24 ft. It contains detailed instructions on assembling the frame, including the vertical support posts, lateral connectors, and self-locking straps. The manual also has information on using foam protectors and installing the tarpaulin. I'm ready to answer any questions you may have regarding the assembly process.
  • Where should the metal pins (K) be installed?
    Where should carabiners (G1) of the straps be installed?
    What is the recommended height for vertical support posts?
    What is the minimum overlap for A and B tubes?
    What to do if the straps (G2) are slipping?
©
NAVIGLOOPONTOONBOATPONTON2324
SUMMARY:KeyPointsofAssemblyInstructions/RÉSUMÉ:Pointsclésdel’assemblage
RÉSUMÉ
!
POINTSCLÉSDEL’ASSEMBLAGE
NAVIGLOOPONTON2324pi
SUMMARY
!
KEYPOINTSOFASSEMBLY
NAVIGLOOPONTOONBOAT2324ft
THE2VERTICALCONNECTORS
WITHOUTBASE
:front&back
LES2EMBRANCHEMENTSVERTICAUX
SANSBASE
:avant&arrière
[10’’24’’]
Leavea10to24inchmaximumoverhangpastthe2verticalsupportposts
withbase(front&back)
sothatthehorizontalbeamremainssecure.
Les2embranchementsverticauxsansbase(avant&arrière)doiventêtre
installésàchacunedesextrémitésdel’armatureàunedistancede10à24
poucesmaximumdespoteauxdesoutienavecbase(avantetarrière)afin
d’assurerlastabilitédelapoutrehorizontale.
Page9
Makesurethateachextremity(frontandback)endsata±90°angle
.
Les2embranchementsverticauxsansbase(avantetarrière)doiventformer
unanglede±90°aveclapoutrehorizontale.
Page10
THE5VERTICALSUPPORTPOSTS
LES5POTEAUXDESOUTIENVERTICAUX
Metalpins(K)mustONLYbeinstalledonthe5verticalsupportposts
.
Lesgoupillesdemétal(K)doiventêtreposéesUNIQUEMENTsurles5poteauxdesoutienverticaux.
Pages6,12
Carabiners(G1)ofthestrapsmustONLYbeinstalledontheCCLIPS(C)securingthe5verticalsupport
posts.
Lesmousquetons(G1)dessanglesdoiventêtresinstallésUNIQUEMENTsurlesCCLIPS(C)des5poteauxde
soutienverticaux.
Pages7,13
Itisimportantthatthehorizontalbeambelevelledasmuchaspossible.Adjusttheverticalposts
accordingly.
Ilestimportantquelapoutrehorizontalesoit,lepluspossible,deniveau.Ajusterlespoteauxverticauxen
conséquence.
Pages6,12

78’’
Theverticalsupportpostsrequireaheightof78inches.Itisrecommendedthatthisheightbemaintained
toensuregreaterframestabilityandachievetheproperpitchtoallowsnowtoslideoff.
Lespoteauxdesoutienverticauxdoiventavoirunehauteurde78pouces.Ilestrecommandédemaintenir
cettehauteurafind’assurerunmaximumderobustesseàl’armatureetd’obtenirlameilleurepente
possiblepourquelaneiges’écoule.
Pages6
Thedistancebetweenthe5verticalsupportpostsmustbemoreorlessequalinordertohavegreater
stability(theyarethe5pillarsoftheframe)
.
L’espaceentreles5poteauxdesoutienverticauxdoitêtrelepluséquilibrépossiblepourassurerunebonne
stabilité(puisqu’ils’agitdes5piliersdel’armature).
Pages12
1
2
[
10’’24’’
]
±90°
±
90°
78’’
K K K K
K
THE5VERTICALSUPPORTPOSTS:THEPILLARSOFTHEFRAME
LES5POTEAUXDESOUTIENVERTICAUX:LESPILIERSDEL’ARMATURE
4
5
3
1/3
©
NAVIGLOOPONTOONBOATPONTON2324
SUMMARY:KeyPointsofAssemblyInstructions/RÉSUMÉ:Pointsclésdel’assemblage
RÉSUMÉ
!
POINTSCLÉSDEL’ASSEMBLAGE
NAVIGLOOPONTON2324pi
SUMMARY
!
KEYPOINTSOFASSEMBLY
NAVIGLOOPONTOONBOAT2324ft
THE7SETSOFLATERALCONNECTORS
LES7PAIRESD’EMBRANCHEMENTSLATÉRAUX
THELATERALCONNECTORS:7SETS
LESEMBRANCHEMENTSLATÉRAUX:7PAIRES
Thespacebetweenthelateralpostsmustbeasequalaspossibletoensuregreaterstabilityandforabetter
weightdistributiononcethetarpaulinison.
L’espaceentrelesembranchementslatérauxdoitêtrelepluséquilibrépossibleafind’assurerunemeilleure
repartitiondeschargeslorsdel’installationdelatoile.
Page16
Foamprotectors(H)mustrestontheedgeofthewatercraftoverhangingtheedgebyabout3inches
.
Lesemboutsdeprotection(H)doivents’appuyersurlereborddel’embarcationetdépasserd’environ
3pouces.
Page17
Foamprotectors(H)mustoverhangtheABpostbyabout2inchesinordertoproperlyprotectthetarpaulin
.
Chaqueemboutdeprotection(H)doitdépasserd’environ2poucesl’embranchementlatéralABpourbien
protégerlatoile.
Page15
Ifallpreviousstepsaretakenintoaccount,theanglefortheslopeshouldbeapproximately50degrees.Itis
preferabletomaintainthisangletohavethebestslopepossibleallowingthesnowtoslideoff.

Enrespectantlesétapesprécédentes,l’angled’inclinaisondesembranchementslatérauxserad’environ
50degrés.Ilestpréférabledemaintenircetangled’inclinaisonafind’assurerlameilleurepentepossiblepour
quelaneiges’écoule.
Page17
OVERLAPINGoftheAandBtubes
CHEVAUCHEMENTdestubesAetB
Foreachofthesesteps,itisimportanttohavea
minimum6inchoverlapoftheAandBtubesin
ordertohavethebestsecuritypossible.
Pourchacunedecesétapes,ilestimportant
d’appliquerunminimumde6poucesde
chevauchementdestubesAetBafind’avoirune
soliditéaccrue.
Pages6,12
Pages10,16 Page9
50°
3’’
K
J
A
A
B
B
J
A
B
2/3
50°
50
°
©
NAVIGLOOPONTOONBOATPONTON2324
SUMMARY:KeyPointsofAssemblyInstructions/RÉSUMÉ:Pointsclésdel’assemblage
RÉSUMÉ
!
POINTSCLÉSDEL’ASSEMBLAGE
NAVIGLOOPONTON2324pi
SUMMARY
!
KEYPOINTSOFASSEMBLY
NAVIGLOOPONTOONBOAT2324ft

EXTRAPROTECTION
PROTECTIONSSUPPLÉMENTAIRES
Werecommendusingextraprotectivemeasuresforfragilesurfacesthatmaycomeintocontactwiththe
bases,thepostsand/orthestraps.Forexample:placeaswatchofcarpetandapieceofplywoodunderthebases
(ortheposts)toprotectthewatercraft’supholstery.
Nousrecommandonsdeprotégertoutesurfacefragilequiseraencontactaveclesbases,lespoteaux
et/oulessangles.Parexemple:déposezunmorceaudetapisetuneplanchedeboissouslesbases(oulespoteaux)
afindebienprotégerlerevêtementdevotreembarcation.
Page5
Page11
DURINGINSTALLATIONOFTARPAULIN:
•ItisyourresponsibilitytopreventtheNaviglootarpaulinfromcomingintodirectcontactwithprotrudingcomponentsthatmay
createfriction,whichcouldpotentiallydamageorperforateit.(i.e.snapsforcanvasorBiminitopanchorpoints)*Damagecausedby
unpaddedcomponentsthatwearorperforatethetarpaulinisnotcoveredundertheconditionsofthelimitedwarranty.
•Takeextraprecautionstopreventthegrommetsonthetarpfromdamagingthehullofyourwatercraft.
LORSDEL’INSTALLATIONDELATOILE:
•Ilestdevotreresponsabilitédevousassurerquelatoilenepuisseêtreencontactavectoutecomposantequipourraitendommagerou
perforerlatoileparfrictioncauséeparleventouautre.(Exemples:lesboutonspressiond’unetoilerapide,lespointsd’ancraged’un
toitBimini,etc.)*Lagarantiesurlatoilenecouvrepaslesdommagescauséspartoutecomposantenonprotégéequipourrait
endommagerouperforerlatoile.
•Assurezvousquelesœilletsdelatoilen’abîmerontpasvotreembarcation.
Itisyourresponsibilitytoaddextraprotectiontoyourwatercraftwhennecessary(Example:motorcover,etc.)
_____ ____ ____________________ ____________________ ___ ____________________ _______________________ _______________
Ilestdevotreresponsabilitéd’apporterlesprotectionssupplémentairesquevousjugerezappropriéesàvotreembarcation.

(Exemple:houssedeprotectionpourmoteurhorsbord,etc.)
THESELFLOCKINGSTRAPS
LESSANGLESAUTOBLOQUANTES
Toensureproperassemblyofstraps:ThreadG2throughtheclipattheendofG1fromthe
bottom,thenpullhardfrombothends.G2shouldnotslip;ifitdoes,removeG2,turnthe
clipattheendofG1oversothattheteethofthecliparefacingupward,thenthreadG2
thoughtheclipfromthebottomagain.Testresistancebypullingstrapfrombothends.

WARNING:Asyoupullonbothendsof thestrap,makesurethatG2doesnotslip!Ifit
does,removeG2,turntheclipattheendofG1oversothattheteethoftheclipare
facingupward,thenthreadG2throughtheclipfromthebottomagain.(seeStep1)
S’assurerquelessanglessoientenfiléesdanslebonsens:lapartieG2 doitêtreenfiléedans
lapartieG1demanièreàcequ’ilyaitunerésistancelorsquevoustirezsurles2extrémités
delasangle(G1 etpartielibrede G2).
ATTENTION:Sivousn’arrivezpasàavoirunerésistanceetquelasangleglisse,enlevezla
partieG2,retournezlaetrecommencezdenouveau.(voirÉtape1)
Pages4,8,14
Thetensionintheselflockingstrapsoneachsideoftheverticalsupportpostsmustremaintightand
equaltoensuremaximumstability.
Latensiondessanglesdoitêtreajustéeuniformémentdechaquecôtédespoteauxdesoutienverticaux
afind’assurerunebonnestabilité.
Pages8,14
Ensurethatgatesonthecarabinersareproperlyclosed.

Assurezvousquelesmousquetonssoientbienenclenchés.
Pages8,14
G1
G2
3/3
/