andrews Correx kit BUFFER GL500 & 1000 Fitting Instructions

Brand: andrews

Model: Correx kit BUFFER GL500 & 1000

Type: Fitting Instructions

FITTING INSTRUCTIONS

BUFFER GL500-8, GL500-10-2”, GL800-8, GL800-10-2.5” & GL1000-8

Fitting instructions

7783006 - 400mm CORREX POWERED ANODE KIT

THE INTRODUCTION OF THIS KIT HAS THREE MAIN ADVANTAGES TO BE CONSIDERED:

• LowMaintenanceCosts(Correxisnon-sacricial,thereforenoanodemaintenanceisneeded)

• LowRunningCosts(Lessthan35kWHperyear)

• Increasedprotection(particularlyinareasoflowelectricalconductivity).

MainselectricalsupplywiringtothewaterheatermustbeinstalledinaccordancewiththecurrentBuildingRegulationsinforceandBS7671

-RequirementsforElectricalInstallations.

iskitisdesignedtousea220/240V1ph50Hzpermanentsupply.efuseratingis3Amp.

emethodofconnectiontothemainselectricalsupplyshouldfacilitatecompleteelectricalisolationoftheCorrexkitandtheappliance.

epointofconnectiontothemainsshouldbereadilyaccessibleandadjacenttotheappliance.

Andrews. Built to perform.

Please read and understand these instructions before commencing installation and leave this manual with the customer for future reference.

INSTALLATION AND SERVICE MANUAL

Cylinders and Buffers

Stainless Steel 316 Storage Cylinders, Twin and Single Coil

STOR-SS300-8-S, STOR-SS500-8-S, STOR-SS800-8-S, STOR-SS1000-8-S,

STOR-SS300-8-T, STOR-SS500-8-T, STOR-SS800-8-T, STOR-SS1000-8-T

FIG 1

Correxanodereplaces

magnesiumanode

Potentiostat

&bracket

240V

permanent

supply

Outputlead

anode

connection

EarthM10

ringterminal

connection

Step 1

To install the Correx kit (refer to Fig1 diagram)

1. Draindownthebuffertank.

2. Removetheexistingmagnesiumanode.

3. Fitthecorrexanodeintotheconnection.

4. Fixthepotentiostattothebuffertankcasingusing

theretainingbracketprovided.

5. Connectthepotentiostatoutputleadontothe

anodeconnection.Achievethisbycuttingthe

leadtothedesiredlengthandusingthecrimp

typefemaleconnectorprovided.

6. Accessthetopconnectionofthetankbylifting

topcovertorevealM10nuts.RemoveoneM10nut

andconnecttheearthreturnatthispoint,bycut-

tingtheleadtothedesiredlengthandusingthe

crimptypeM10ringterminalconnectorprovided.

Replaceandre-tightentheM10nut.

7. Connectthepotentiostatmainscabletoaperma-

nent220/240V1ph50Hzelectricalsupplyviaan

unswitchedspuroutlet(fuserating3A).

Step 2

Test the installation

1. Rellthebuffertankandcheckforleaks.

2. Switchontheelectricalsupplytothepotentiostat.

3. egreenlamponthepotentiostatindicatesthat

theinstallationisfunctioningcorrectly.

4. eredlamponthepotentiostatindicatesafault.

Switchofftheelectricalsupplybeforeanyworkis

carriedout.

e installation is now complete.

7783006–400mmCorrexPoweredAnodeKitPackContents

Qty Part

17783007–400mmCorrexPoweredAnode

1 C995 – Potentiostat

1E049–EarthStrap

1Packofaccessories

• REMEHA – ENGINEERING EFFICIENCY SINCE 1935

Reliably engineering high-performance and high-efciency heating solutions.

• ANDREWS WATER HEATERS – BUILT TO PERFORM

UK’s No. 1 commercial water heaters of choice for quality and reliability.

• POTTERTON COMMERCIAL – TOTALLY DEPENDABLE

Heating solutions that customers can rely on and services they can trust.

• PACKAGED PLANT SOLUTIONS – INGENUITY BOXED

Leading specialists in prefabricated plant rooms from concept to completion.

BAXI HEATING COMMERCIAL BRANDS

BAXI HEATING HAS A PORTFOLIO OF SOME OF THE BEST KNOWN AND

MOST RESPECTED COMMERCIAL BRANDS IN THE HEATING INDUSTRY

ACROSS THE UK AND IRELAND: • REMEHA, • ANDREWS WATER HEATERS,

• POTTERTON COMMERCIAL AND • PACKAGED PLANT SOLUTIONS.

ALL TOGETHER BETTER

Andrews. Built to perform.

Registered ofce address: Baxi Heating UK, Brooks House, Coventry Road, Warwick CV34 4LL June 2020

Sales 0345 070 1055

Technical 0345 070 1057

Web andrewswaterheaters.co.uk

linkedin.com/company/andrews-water-heaters

@AndrewsWH

M10249 RevA

January2021

andrews Correx kit BUFFER GL500 & 1000 Fitting Instructions

andrews Correx kit BUFFER GL500 & 1000 Fitting Instructions

andrews Correx kit BUFFER GL500 & 1000 Fitting Instructions

Related papers

Other documents