PowerWalker VFD 600 (CEE 7/3) Owner's manual

Brand: PowerWalker

Model: VFD 600 (CEE 7/3)

Category: Uninterruptible power supplies (UPSs)

Type: Owner's manual

This manual is also suitable for

VFD 1000 (CEE 7/3)

PowerWalker VFD 600 (CEE 7/3) is a reliable power backup solution for your sensitive electronic equipment. With a capacity of 600VA/300W, it provides up to 8 minutes of runtime during power outages, giving you enough time to save your work and shut down your system safely. The VFD 600 features automatic voltage regulation (AVR) to protect your equipment from voltage fluctuations and surges. It also includes four surge-protected outlets to safeguard your valuable electronics from damaging power spikes.

ffline(Standby)UPS

PowerWalkerVFD400

PowerWalkerVFD600

PowerWalkerVFD1000

QuickStartGuide

EN



IMPORTANTSAFETYINSTRUCTIONS



SAVETHESEINSTRUCTIONS–Thismanualcontainsimportantinstructionsformodels

PowerWalkerVFD400/600/1000thatshouldbefollowedduringinstallationandmaintenance

oftheUPSandbatteries.



• ThisproductisspeciallydesignedforPCsanditisnotrecommendedforuseinanylife‐

supportingsystemandotherspecificimportantequipment.

• Thisequipmentcanbeoperatedbyanyindividualwithnoprevioustraining.

• DonotplughouseholdappliancessuchashairdryerstoUPSreceptacles.



• Thisunitintendedforinstallationinacontrolledenvironment(temperaturecontrolled,

indoorareafreeofconductivecontaminants).AvoidinstallingtheUPSinlocationswhere

thereisstandingorrunningwater,orexcessivehumidity.

• Risk of electric shock, do not remove cover. No user serviceable parts inside. Refer

servicing

toqualifiedservicepersonnel.

• Theutilitypoweroutletshallbeneartheequipmentandeasilyaccessible.ToisolateUPS

fromACinput,removetheplugfromtheutilitypoweroutlet.

• IfUPSistobestoredforalongtime, it isrecommendedto recharge the batteries(by

connecting

theutilitypowertoUPS,switch“ON”),onceamonthfor24hourstoavoida

fullbatterydischarge.

• PleasedonotusetheUPSinexcessoftheratedloadcapacity.

• The UPS contains one/two large‐capacity batteries. So the shell shall not be opened,

otherwise such

dangers as electric shock will be caused. If any internal overhaul or

replacementofthebatteryisrequired,pleasecontactthedistributor.

• TheinternalshortcircuitingoftheUPSwillleadtodangerssuchaselectricshockorfire,

therefore,nowatercontainers(suchasawaterglass)shallbe

placedonthetopofthe

UPSsoastoavoidsuchdangersaselectricshock.

• Donotdisposeofbatteryorbatteriesinafire.Thebatterymayexplode.

• Donotopenormutilatethebatteryorbatteries.Releasedelectrolyteisharmfultothe

skinandeyes.

Itmaybetoxic.

• IconΦontheratinglabelstandsforphasesymbol.

• A battery can present a risk of electrical shock and high short circuit current. The

followingprecautionsshouldbeobservedwhenworkingonbatteries:

• Removewatches,rings,orothermetalobjectsfromthehand.



• Usetoolswithinsulatedhandles.

EN



• Servicingofbatteriesshouldbeperformedorsupervisedbypersonnelknowledgeableof

batteries and the required precautions.Keep unauthorized personnel away from

batteries.

• Whenreplacingbatteries,replacewiththesametypeandnumberofthesealedlead‐acid

batteries.

• Themaximumambienttemperatureratingis40°C.

• This pluggable type A equipment with battery already installed by the supplier is

operatorinstallableandmaybeoperatedbylaymen.

• Duringtheinstallationofthisequipmentitshouldbeassuredthatthesumoftheleakage

currentsoftheUPSandtheconnectedloadsdoesnotexceed3.5mA.



• Attention, hazardous through electric shock. Also with disconnection of this unit from

the mains, hazardous voltage stillmay beaccessible through supply from battery.The

battery supply should be therefore disconnected in the plus and minus pole of the

batterywhenmaintenanceorserviceworkinsidetheUPSis

necessary.

• ThemainssocketoutletthatsuppliestheUPSshallbeinstalledneartheUPSandshallbe

easilyaccessible.

• In case smoke is found coming out from the device, please cut off the power supply

quicklyandcontactthedistributor.

• Donotkeeporusethisproduct

inanyofthefollowingenvironments:

o Anyareawithcombustiblegas,corrosivesubstanceorheavydust.

o Anyarea with extraordinarily high or low temperature (above 40˚C orbelow

0˚C)andhumidityofmorethan90%.

o Anyareaexposedtodirectsunshineornearanyheating

apparatus.

o Anyareawithseriousvibrations.

o Outdoor.

• Intheeventthatthereisfireoccurringinthevicinity,pleaseusedry‐powerextinguishers.

Theuseofliquidextinguishersmaygiverisetothedangerofelectricshock.



EN

1. SystemDescription



FrontPanel

1. PowerSwitch

2. UPSstatusIndicator–

ACMode:Greenlighting

BatteryMode:Greenflashing

3. FaultLED:Redlighting



VFD400/VFD600Backpanel



VFD1000Packpanel



BackPanel

1. CircuitBreaker

2. ACinput



3. Outputreceptacles

4. Modem/PhoneLineSurge

Protection



EN

2. Installationandoperation



Inspection



RemovetheUPSfromitspackagingandinspectitfordamagethatmayhaveoccurredduring

shipping.Ifanydamageisdiscovered,repacktheunitandreturnittotheplaceofpurchase.



Charging



Thisunitisshippedfromthefactorywithitsinternalbatteryfullycharged,however,some

chargemaybelostduringshippingandthebatteryshouldberechargedpriortouse.Plug

the unit into an appropriatepowersupply andallowthe UPS tochargefully by leaving it

plugged in for

 at least 10 hours with no load (no electrical devices such as computers,

monitors,etc.)connected.



Placement



InstalltheUPSunitinanyprotectedenvironmentthatprovidesadequateairflowaroundthe

unit,andisfreefromexcessivedust,corrosivefumesandconductivecontaminants.Donot

operateyourUPSinanenvironmentwheretheambienttemperatureorhumidityishigh.



ComputerConnection



PlugtheUPSintoa2‐pole,3‐wiregroundedreceptacle.Thenconnectonecomputer‐related

deviceintoeachofthepowerreceptaclessuppliedonthebackoftheUPS.



Modem/NetworkConnection



Plug incoming internet line into the “In” socket at the back of the UPS. Use one more

InternetlinecableandplugoneendoftheInternetlinecabletothe“Out”socketatthe

backoftheUPS.Plugtheotherendtothemodeminputsocketasshown.



 



Incoming

InternetLine

EN



TurnOn/Off



PresstheswitchoftheUPScontinuouslyfor1secondandtheUPSturnsintoitsnormalstate

(thegreenlightisonandthebeeperisoff)afteritperformsaself‐diagnosis(thebeeperand

theredandgreenindicatorlightsareon)forseveralseconds.Atthis

time,usermayturnonthe

PCandotherloads.PresstheswitchoftheUPScontinuouslyfor1secondtoturnofftheUPS.

Note:

• For the convenience of maintenance, please turn onthe UPS first beforeturning on

thePCandtheotherloads,andturnoffthe

UPSaftertheloadsareturnedoff.

• At ordinary times, we recommend to remain the UPS on with the battery charging

(eveniftheloadsareturnedoff),whichisbenefittothemaintenanceofthebattery.



3. TroubleShooting



Symptom PossibleCause Remedy

1.Missingbattery 1.Chargebatteryupto8hours

2.Batterydefect

2. Replace with the same type

ofbattery

NoLEDdisplay

onthefrontpanel

3.Powerswitchisnotpressed 3.Presspowerswitchagain

1.OverloadoftheUPS 1.Removesomenoncriticalload

2.Batteryvoltageistoolow

2.Chargebattery8hoursor

more

Whenpower

failure,backup

timeisshort.

3.Batterydefectduetohigh

temperatureoperation

environment,orimproper

operationtobattery.

3.Replacewiththesametype

ofbattery

1.Circuitbreakerisbroken. 1.Resetthecircuitbreaker.

Mains normal but

LEDisflashing.

2.Powercordisloose.

2.Reconnectthepowercord

properly.



Ifanyabnormalsituationsoccurthatarenotlistedabove,pleasecallservicepeopleimmediately.

EN

4. Specifications



MODEL 

PowerWalker

VFD400

PowerWalker

VFD600

PowerWalker

VFD1000

CAPACITY VA/W 400VA/200W 600VA/300W 1000VA/600W

INPUT Voltage 110/120VACor220/230/240VAC

 VoltageRange 90‐145VAC/170‐280VAC

OUTPUT Voltage 110/120VACor220/230/240VAC



VoltageRegulation(Batt.

Mode)

±10%

 Frequency 50Hzor60Hz



FrequencyRegulation(Batt.

Mode)

+/‐1Hz

 OutputWaveform ModifiedSinewave

BATTERY BatteryType&Number 12V/4.5Ahx1pc 12V/7Ahx1pc 12V/7.2AH*2



BackupTime(ataPCload

with15"monitor)

5minutes 8minutes 30minutes

 RechargeTime 10hoursto90%aftercompletedischarge

TRANSFERTIME Typical 2‐6ms

ACMode GreenLEDlighting

BatteryMode GreenLEDflashingevery4seconds

LowBatteryatBatteryMode GreenLEDflashingeverysecond

Fault RedLEDlighting

BatteryWeakatACMode RedLEDflashingevery2secondsfor30seconds

INDICATOR

BatteryFaultatACMode RedLEDflashingthreetimesevery2seconds

BatteryMode Soundingevery4seconds

LowBatteryatBatteryMode Soundingeverysecond

Fault Continuouslysounding

BatteryWeakatACMode Soundingevery2secondsfor30seconds

AUDIBLEALARM

BatteryFaultatACMode Soundingthreetimesevery2seconds

PROTECTION FullProtection Discharge,overcharge,andoverloadprotection

Dimension,DXWXH(mm) 231x81x185 312x94x250PHYSICAL

NetWeight(kgs) 3.1 3.8 6.7

OperatingEnvironment 0‐40°C,0‐90%relativehumidity(non‐condensing)ENVIRONMENT

NoiseLevel Lessthan40dB



EN

PowerWalker VFD 600 (CEE 7/3) Owner's manual

Brand: PowerWalker

Model: VFD 600 (CEE 7/3)

Category: Uninterruptible power supplies (UPSs)

Type: Owner's manual

This manual is also suitable for

VFD 1000 (CEE 7/3)

Download PDF

report

PowerWalker VFD 600 (CEE 7/3) Owner's manual

This manual is also suitable for

PowerWalker VFD 600 (CEE 7/3) Owner's manual

Related papers

Other documents