DHP DE27693 Operating instructions

Type
Operating instructions
DO NOT RETURN TO THE STORE !
Visit www.dhpfurniture.com/eng/support-home
or call Toll-Free 1-800-267-1739
3236238
B34323623800 - 10125-M
Date of Purchase
Manila Metal Bed
E.L. - 2016-12-28
If parts are missing or damaged, we will gladly ship your
replacement parts free of charge.
Lot Number
Thank you for purchasing from DHP!
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT SAFETY
INFORMATION. PLEASE READ AND KEEP FOR FUTURE REFERENCE.
1
2014 Dorel Home Products All Rights Reserved
Queen
Bronze
Weight Limit: 500 Lb / 227 Kg
TM
Contact Us!
cs@dhpfurniture.com
DHP Consumer Services
12345 Albert Hudon, Suite 100,
Montreal, Quebec, Canada H1G 3L1
Read Before Beginning Assembly
1-800-267-1739
Monday - Friday, 9:00 am - 5:00 pm (Eastern Time)
Warranty Information
2
B34323623800
Caution
DHP warrants this product to be free from defects in material and workmanship and
agrees to remedy any such defect. This warranty covers one year from the date of
original purchase. This is solely limited to the repair or replacement of defective
parts and assembly labor is not included.
This warranty does not apply to any product which has been improperly assembled,
subjected to misuse or abuse or which has been altered or repaired in any way.
Liability for consequential damages is excluded to the extent exclusion is permitted
by law. This warranty gives you specific legal rights and you may also have other
rights which vary from state to state.
To obtain warranty service, purchaser must present original bill of sale. Components
repaired or replaced are warranted through the remainder of the original warranty
period only. The defective components will be repaired or replaced without charge,
subject to the terms and conditions described above.
Visit www.dhpfurniture.com to view the limited warranty valid in the U.S. and
Canada.
Call our toll free number if you need assistance.
Work in a spacious area and near where the unit will be used, preferably on a
carpet, or use a piece of the cardboard packaging to protect your floor and product.
Recommended # of people needed for assembly: 2 (however it is always better
to have an extra hand). Estimated assembly time is 1.5 hours.
Make sure all parts are included. Most parts are labeled or stamped on the raw
edge.
Read each step carefully. It is very important that each step of the instructions is
performed in the correct order. If these steps are not followed in sequence,
assembly difficulties will occur.
This product is designed for home use and not intended for commercial use.
This product contains small components. Please ensure that they are kept away
from small children.
Do not use power tools to assemble your furniture. Power tools may strip or
damage the parts.
For help with assembly, identifying parts, product information or to order parts,
please contact us:
4
Parts
B34323623800
All in 1 big box!
Before you throw the package, please use the
Check Box to identify the parts and ensure that
you have all the parts needed for the assembly.
There are inner box(es) that include components
required to complete this assembly.
Replacement Parts, Visit www.dhpfurniture.com/eng/support-home
A
Post
T943960
X 1
Post
T943970
X 1
Post
T943980
X 1
Post
T943990
X 1
Side Rail
T938250
X 2
Side Rail
T938260
X 2
Brace
T938280
X 1
Brace
T938290
X 2
Brace
T938300
X 2
End Guard Rail
T944510
X 2
Leg
T937730
X 3
Leg
T937740
X 3
Ball
T928370
X 4
Bracket
T938310
X 1
Plastic Plug
T392590
X 28
Slats
T933150
X 14
B
C
D
E
F
G
H
I
T
O1
M
L
S
K
Y
A
B
S
T
S
E
F
Y
K
S
C
T
D
F
E
O1
M
L
G
H
I
5
Hardware Pack
B34323623800
Hardware Pack #: T3247298-02
Please do not completely tighten all the hardware,
until the entire assembly is complete, unless
otherwise indicated in the step-by-step
instructions.
The screw(s), bolt(s) to be used at each step are
shown in actual size in the lower right corner of
the page.
7 8
1/4" X 1 9/16"
X 4
2
5
3
4
1
1/4" X 1 3/16"
X 8
1/4" X 7/8"
X 12
5/16" X 3/4"
X 16
1/4" X 11/16"
X 4
1/4"
X 4
4mm
X 1
Wrench
X 1
6
6
B34323623800
Step
1
Insert T X 2 into A/B and C/D with .
X 8
A
B
D
C
T
T
2
Correct: Part (T) penetrating
through Part (A,B,C & D).
Incorrect: Part (T) NOT penetrating
through Part (A,B,C & D).
7
B34323623800
Step
2
Insert F X 2 into E X 2 with .
X 4
E
F
F
E
5
Holes on the top side.
E
F
8
B34323623800
Step
3
3.1 Attach H X 2 to sub-assembly E/F x 2
from previous step with .
3.2 Attach G to E X 2 with .
X 8
E
F
F
E
H
G
H
F
H
G
E
3.2
3.1
3
9
B34323623800
Step
4
This bed offers you 2 options for the height
of the bed foundation.
To assembly in Higher Position:
From STEP 4 to STEP 9.
To assembly in Lower Position:
From STEP 10 to STEP 15.
Attach M X 2 to G with .
X 4
G
M
M
G
3
F
E
E
F
10
B34323623800
Step
5
Attach sub-assembly E/F from previous
step to A, B, C and D with .
X 16
A
B
F
E
E
F
C
D
A
F
4
11
B34323623800
Step
6
6.1 Insert one end of both I into the slot on
G as illustrated.
6.2 Attach the other end of both I to H with
and .
X 2
H
G
I
I
I
I
G
I
H
1
6
6.2
6.1
X 2
1
6
12
B34323623800
Step
7
Attach M&K to G with with and .
M
G
K
M
6
6
G
K
1
X 2
X 2
1
6
13
B34323623800
Step
8
Insert O1 into E&F as illustrated, then lock
O1 into place with Y.
F
E
E
F
2
1
2
3
3
1
Y
O1
E
O1
E
O1
A
14
B34323623800
Step
9
Attach S X 4 to A, B, C & D.
S
S
S
A
B
C
D
S
B
15
B34323623800
Step
10
X 4
To assembly in Lower Position:
From STEP 10 to STEP 15.
Attach L X 2 to G with .
G
L
G
L
3
B
16
B34323623800
Step
11
X 16
Attach sub-assembly E/F from previous
step to A, B, C and D with .
A
B
D
C
F
E
E
F
F
A
4
17
B34323623800
Step
12
X 2
12.1 Insert one end of both I into the slot
on G as illustrated.
12.2 Attach the other end of both I to H
with and .
H
G
I
I
G
I
I
H
I
1
6
12.2
12.1
X 2
1
6
18
B34323623800
Step
13
X 2
Attach L&K to G with and .
G
L
K
K
G
6
6
L
1
1
X 2
6
19
B34323623800
Step
14
Insert O1 into E&F as illustrated, then lock
O1 into place with Y.
E
O1
O1
E
Y
2
1
2
3
3
1
E
F
F
E
O1
C
20
B34323623800
Step
15
Attach S X 4 to A, B, C & D.
B
S
S
S
S
D
A
B
C
21
Helpful Hints
B34323623800
Move your new furniture carefully, with two
people lifting and carrying the unit to its new
location.
Your DHP furniture can be disassembled and
reassembled to move.
Some parts have been pre-assembled for this
item. They are illustrated on this page and available
for replacement.
WARNINGS:
For safety reasons and to prevent injuries:
This bed is not intended for use by children under 4
years old.
Prohibit jumping and horseplay on this bed.
Only use a mattress which is 79" - 80" long and 59"
- 60" wide.
Do not use risers under this bed.
Helpful Hints
Weight Limit: 500 Lb / 227 Kg
End Cap
T392480
X 4
End Cap
T392520
X 6
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27

DHP DE27693 Operating instructions

Type
Operating instructions

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages