Dometic SKL101, SKS101 Installation guide

Dometic
Brand
Dometic
Model
SKL101, SKS101
Category
Cookers
Type
Installation guide

Dometic SKL101, SKS101 is a slide-out kitchen designed to be installed in trailers and mobile homes. It has 3 burners with a total output of 16.9 MJ/h, allowing you to cook meals outdoors. The kitchen features a sink with a tap and flexible water hose, making it easy to wash dishes or prepare food. It also includes a bottle opener, cup holder, cutting board, and serving tray for added convenience. The kitchen is pre-assembled with extendable slides and mounting brackets, and the height can be adjusted to fit your needs.

Dometic SKL101, SKS101 is a slide-out kitchen designed to be installed in trailers and mobile homes. It has 3 burners with a total output of 16.9 MJ/h, allowing you to cook meals outdoors. The kitchen features a sink with a tap and flexible water hose, making it easy to wash dishes or prepare food. It also includes a bottle opener, cup holder, cutting board, and serving tray for added convenience. The kitchen is pre-assembled with extendable slides and mounting brackets, and the height can be adjusted to fit your needs.

SKL101, SKS101
Slide out kitchen
Installation Manual
EN
COOKING
SLIDE OUT KITCHEN
SKL101-I-AUS.book Seite 1 Donnerstag, 18. Oktober 2018 10:50 10
SKL101-I-AUS.book Seite 2 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Explanation of symbols
3
Please read this instruction manual carefully before installation and first
use, and store it in a safe place. If you pass on the product to another
person, hand over this instruction manual along with it.
Table of contents
1 Explanation of symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
2 Safety and installation instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5
4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
5 Preparing the installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
6 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
1 Explanation of symbols
!
!
A
I
WARNING!
Safety instruction: Failure to observe this instruction can cause death
or serious injury.
CAUTION!
Safety instruction: Failure to observe this instruction can lead to injury.
NOTICE!
Failure to observe this instruction can cause material damage and impair
the function of the product.
NOTE
Supplementary information for operating the product.
SKL101-I-AUS.book Seite 3 Donnerstag, 18. Oktober 2018 10:50 10
EN
Safety and installation instructions SKL101, SKS101
4
2 Safety and installation instructions
Please observe the prescribed safety instructions and stipulations from the
vehicle manufacturer and service workshops.
The manufacturer accepts no liability for damage in the following cases:
•
Faulty assembly or connection
•
Damage to the product resulting from mechanical influences
•
Alterations to the product without the express permission of the manufacturer
•
Usage for purposes other than those described in this manual
!
WARNING!
•
If the slide out kitchen has visible damage, contact the manufacturer.
A
NOTICE!
•
Hose and gas lines must not be kinked.
•
Hose lines must be installed in such a way that they are accessible at all
times and that they are not kinked or twisted when being pushed in or
out.
•
Hose lines must be protected from mechanical, chemical and thermal
influences.
2.1 Safety when handling liquefied petroleum gas
!
WARNING!
•
Keep flammable substances away from heating and cooking devices,
and other light and heat sources.
•
Compare the pressure information on the type plate with the pressure
information on the propane gas cylinder.
•
Never store liquefied petroleum gas cylinders in unventilated areas.
•
Keep liquefied petroleum gas cylinders away from direct sunlight.
The temperature may not exceed 50 °C.
•
If you smell gas:
– Do not operate any electrical devices or switches, and avoid using
open flames that can ignite the gas.
– Close the valve on the gas cylinder and keep it closed until the fault
has been rectified.
•
Never attempt to find a gas leak with an open flame.
SKL101-I-AUS.book Seite 4 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Scope of delivery
5
3Scope of delivery
No. in fig. 1 Description
1 Slide out kitchen
2 Bottle opener
3Cup holder
4 Cutting board
5 Serving tray (only SKL101)
6 Accessory adapter
– Tap with flexible water hose
– Installation manual
– Operating manual
– Cooktop manual (MO9923) and sink components
1
2
3
4
5
6
1
SKL101-I-AUS.book Seite 5 Donnerstag, 18. Oktober 2018 10:50 10
EN
Intended use SKL101, SKS101
6
4 Intended use
The slide out kitchen for the outside area is intended for installation in trailers and
mobile homes. It is solely for the preparation of food in the outside area of the trailer
or mobile home.
The slide out kitchen has to be connected to gas via an external gas bottle or a quick
connector on the external wall of the vehicle. The slide out kitchen has to be discon-
nected from gas each time it is stowed. A permanent gas connection to the slide out
kitchen is prohibited!
5Preparing the installation
I
➤ Remove the packing of the slide out kitchen.
➤ Check whether the slide out kitchen has been damaged.
➤ Contact the manufacturer in case of damage.
NOTE
The slide out kitchen is pre-assembled with extendable slides and
delivered with mounting brackets.
The individual elements of the slide out kitchen are covered with a pro-
tective film. This is only to be removed by the end customer.
SKL101-I-AUS.book Seite 6 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Preparing the installation
7
5.1 Installation
➤ Create a drilling template to mark-up and drill holes to suit M8 bolts (fig. 2 to
fig. 3).
8x
2
3
SKL101-I-AUS.book Seite 7 Donnerstag, 18. Oktober 2018 10:50 10
EN
Preparing the installation SKL101, SKS101
8
➤ Mount the device as shown (fig. 4).
➤ Fit M8 bolts with locking washers from underneath (not supplied) (fig. 4). The
length of the bolts should be at least 30 mm longer than the floor thickness.
➤ Adjust the height as needed by using the height adjustment (fig. 5 1).
4
1
5
SKL101-I-AUS.book Seite 8 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Preparing the installation
9
➤ Verify the smooth sliding of the slide out kitchen (fig. 6). Ensure that slider locks
are fully engaged when kitchen is extended and locking release tabs (fig. 6 1)
are releasing the slider locks correctly.
I
NOTE
•
Slider locks are working correctly if the kitchen does not slide back
into cavity when you give it a light push.
•
If the slider locks on one or both sides do not engage, fully extend
the kitchen. Pull it outwards until a click is heard when the slider locks
engage.
•
Ensure the correct disengaging of slider locks as follows:
– Check if the locking release tabs can be pushed down easily with
no resistance.
– Push back the kitchen into the cavity with a light push.
5x
1
6
SKL101-I-AUS.book Seite 9 Donnerstag, 18. Oktober 2018 10:50 10
EN
Preparing the installation SKL101, SKS101
10
5.2 Connecting the gas supply
The gas supply may only be installed by a tested and certified gas plumber.
!
I
➤ Observe the following:
– Use the opening at the rear of the slide out kitchen to route and service all
external plumbing and wiring.
– Connect the slide out kitchen to LPG only.
– Ensure that the connection to the gas supply is serviceable by the user. It must
require detachment before closing the slide out kitchen.
WARNING!
The female gas connection provided can only be connected to a rigid
connection. For use with a flexible hose, install a copper pipe to the base
plate of the slide out kitchen and fix it rigidly (fig. 7, page 10).
NOTE
•
For the gas connection the following additional parts are required:
– male gas adaptor
– copper piping
–pipe mount
– hose fitting
– flexible gas hose at required length, depending on the mounting
application
•
Make sure that the hose line
–is not crushed or kinked
– is a safe distance from the burner.
7
1
2
SKL101-I-AUS.book Seite 10 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Preparing the installation
11
➤ Connect the rigid pipe as shown (fig. 7 1, page 10).
➤ Connect the flexible hose as shown (fig. 7 2, page 10).
5.3 Connecting the water supply
I
fig. 8
➤ Install the tap (4) to the sink using a rubber seal either side.
➤ Attach the flexible water hose (3) to the tap.
➤ Connect an additional extension hose (2) to the flexible water hose using male
fittings (1).
5.4 Connecting to a 12 Vg power supply
For the electrical connection, wires are attached to the inner wall of the slide out
kitchen.
➤ Connect the cooktop igniter wires via a joiner or a plug to a 12 Vg power source.
NOTE
The water supply can be permanently connected.
1
2
3
4
8
SKL101-I-AUS.book Seite 11 Donnerstag, 18. Oktober 2018 10:50 10
EN
Technical data SKL101, SKS101
12
6 Technical data
SKL101 SKS101
Ref. no.: 9600006441 9600019015
Nominal gas consumption: 16 MJ/h
Gas category: Category l
3
, universal LPG
Connection pressure: AT, DE, EE, LT, LV, MT, PL: 30 mbar
BE, CH, ES, FR, GB, GR, IE, IT, LU:
28 – 30/37 mbar
CY, CZ, DK, FI, HU, IS, NL, NO, SE, SI, SK: 28 – 30 mbar
AUS, NZ: 27.5 mbar
Number of burners: 3
Burner output in total: 16.9 MJ/h
Burner 1: 3.8 MJ/h
Burner 2: 5.9 MJ/h
Burner 3: 7.2 MJ/h
Cooking time for 1 l of water: approx. 10 min (depending on the ambient conditions and
pot used)
Dimensions: fig. 9, page 13 fig. 0, page 14
Weight (excluding accesso-
ries):
44 kg 34 kg
Inspection/certification:
SKL101-I-AUS.book Seite 12 Donnerstag, 18. Oktober 2018 10:50 10
EN
SKL101, SKS101 Technical data
13
Dimensions
SKL101
No. in fig. 9 Description
1 Slide out kitchen and sliding fore-rails (inner): 597 mm
Including fixation brackets and nuts: 630 mm
2 Slide out kitchen only: 1515 mm
Including fixation bracket and rails (closed): 1667 mm
Including fixation bracket and rails (extended): 3267 mm
3 Slide out kitchen only: 288 mm
Height adjustments including fixation and bracket:
First height adjustment: 314 mm (A)
Second height adjustment: 334 mm (B)
Third height adjustment: 354 mm (C)
1
3
2
C
B
A
9
SKL101-I-AUS.book Seite 13 Donnerstag, 18. Oktober 2018 10:50 10
EN
Technical data SKL101, SKS101
14
SKS101
SKL101, SKS101
No. in fig. 0 Description
1 Slide out kitchen and sliding fore-rails (inner): 597 mm
Including fixation brackets and nuts: 630 mm
2 Slide out kitchen only: 1075 mm
Including fixation bracket and rails (closed): 1220 mm
Including fixation bracket and rails (extended): 2366 mm
3 Slide out kitchen only: 234 mm
Height adjustments including fixation and bracket:
First height adjustment: 260 mm (A)
Second height adjustment: 280 mm (B)
Third height adjustment: 300 mm (C)
Access doors Door opening
Dometic 658 x 364 mm
Coast2Coast 612 x 346 mm
Thetford 630 x 330 mm
1
3
2
C
B
A
0
SKL101-I-AUS.book Seite 14 Donnerstag, 18. Oktober 2018 10:50 10
SKL101-I-AUS.book Seite 15 Donnerstag, 18. Oktober 2018 10:50 10
YOUR LOCAL
SALES OFFICE
dometic.com/sales-offices
YOUR LOCAL
DEALER
dometic.com/dealer
YOUR LOCAL
SUPPORT
dometic.com/contact
dometic.com
A
complete list of Dometic companies, which comprise the Dometic Group, can be found in the public filings of:
DOMETIC GROUP AB Hemvärnsgatan 15 SE-17154 Solna Sweden
4445102586 11/2019
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

Dometic SKL101, SKS101 Installation guide

Dometic
Brand
Dometic
Model
SKL101, SKS101
Category
Cookers
Type
Installation guide

Dometic SKL101, SKS101 is a slide-out kitchen designed to be installed in trailers and mobile homes. It has 3 burners with a total output of 16.9 MJ/h, allowing you to cook meals outdoors. The kitchen features a sink with a tap and flexible water hose, making it easy to wash dishes or prepare food. It also includes a bottle opener, cup holder, cutting board, and serving tray for added convenience. The kitchen is pre-assembled with extendable slides and mounting brackets, and the height can be adjusted to fit your needs.

Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents