Davis Instruments 3160 Owner's manual

Brand: Davis Instruments

Model: 3160

Category: Network antennas

Type: Owner's manual

This manual is also suitable for

WindTrak AV (3160)

Antenna

Whip

Antenna

Body

Reference

Tabs

Bracket

Antenna Cable

#3160

This WindTrak 15" wind direction indicator

easily mounts onto Metz™ or Shakespeare™

VHF or AM/FM whip antennas

Antenna whip must be less than 1/8” (3 mm) in diameter

WindTrak AV features:

• Reducesweight&windagealoftbycombiningtwo

 installationsintoone!

• Sensitiveandaccurateforgreatersailing

 performance

• Aidspowerboaterswhiledocking

 anddriftshing

• Vaneoftough,UVratedengineeringplastic…

 lightandstrong

• Ridesontwolow-frictionTeon

bearings

• Completewithreectivereferencetabs,stainless

 steelarms,andallcomponentsnecessaryfor

 quickandeasyinstallation(antennanotincluded)

• Visiblenightorday

Seeseparate

documentfor

international

languages.

ANTENNA VANE

FOR SAIL & POWER

< 1/8" (3 mm)

Vane length

15" (380 mm)

Components

Completeassembly

instructions

beginnextpage

55°

50°

60°

65°

Use this template to set the angle

of the reference tabs to display

apparent upwind performance

50°

for high performance multi-hulls and foiling boats

55° for race boats with extreme windward performance

60° for normal ocean racers and cruising catamarans

65° for heavy cruising boats

WindTrak AV INSTALLATION

INSTRUCTIONS

FormountingonMetz™andShakespeare™

SquattyBody

antennas.

Adjust reference tabs.

Bendthetabsupportwiretotheproper

angleusingthereferencetabtemplate

includedonthispage.Tabsshouldbe

adjustedbeforeascendingthemast.

For use with whip antennas only.

Antenna diameter must be less

than 1/8" (3 mm).

Remove whip from antenna

body.

Metz

Loosenlocknutsothatwhipmay

beremovedfromantennabody.

Ifyoumustunthreadthenutallthe

way,becarefulnottolosethetiny

compressionferruleinside(see

drawing).

Shakespeare

Models with removable

whip…

Loosensetscrewwithan

Allenwrench.

Shakespeare

Models with permanent

whip…

Donotattempttodetach

whipfromantennabody.

– OR –

Placecapinboilingwater

for60seconds.

Removecap

withpliers.

seconds

Shakespeare

Slide WindTrak AV vane components onto whip.

Installintheordershown:

If you removed the whip, reinsert it into the

antenna body.

Tightenlocknutorsetscrew.

Slide vinyl keeper downsovaneisheldinplaceyetturnsfreely.

Final Assembly.

•Disconnectantennacable.

•Removelocknut

•Unthreadcouplerfrombottomof

 antennabody.

•ReplacetheMetzbushingwithone

 oftwoplasticbushingssupplied

 (trythickerbushingfirst).

•Threadcouplerbackontothe

 antennabody.

•PlaceMetzO-ringinposition.

•Placestainlesssteelwasherunder 

 O-ring.

•Slidethereferencetabsupportwire 

 ontothecoupler.

•InsertcouplerintoMetzbracket.

•Threadlocknutontocoupler.Ifnot 

 enoughthreadsareavailableto  

 securelocknut,removecouplerand 

 replacebushingwiththinnerbushing 

 supplied.Repeatassembly.

•Positionreferencetabarmssothey 

 faceaft,alignedwithcenterlineofboat.

•Tightenlocknut.

•Reconnectantennacable.

Metz antenna:

Refertothedrawing

atright.

Weatherproof coupler

connection.

Squeezeabeadofsilicone

adhesivearoundthegap

wherethereferencetabwire

meetsthebracket.

Shakespeare antenna:

Refertothedrawing

atright.

•Disconnectantennacable.

•Removelocknut.

•Slidereferencetabsupportwire

 ontothecoupler.

•Placestainlesssteelwasheronto

 coupler.

•SlidecouplerintoShakespeare

 bracket.

•Threadlocknutontocoupler.

•Positionreferencetabarmsso

 theyfaceaft,alignedwithcenter-

 lineofboat.

•Tightenlocknut.

•Reconnectantennacable.

Tips for using your WindTrak:

•AlwaysassembleyourWindTrakwith

Locktite

orusesiliconesealonthethreads

toeliminatethepossibilityoftheunit

unscrewinginusefromvibration.

•Priortounsteppingyourmast,takeyour

WindTrakdownfirst.

 Periodicallychecktheassemblyscrewshold-

ingyourWindTraktogether.

•Lubricationisneverneeded,butyearsofsalt

ordirtbuild-upshouldberinsedoffwithfresh

wateroccasionally.

Replacement Parts for WindTrak AV

Sparepartscanbeorderedfromyourlocal

dealerorfromDavis;identifywhichmodelyou

havebeforecalling.

3161 SpareVaneforWindexAV

The Complete WindTrak Line…

WindTrakmodelsareavailableforevery

sailor’sneeds.

3120 WindTrak 10

  10"(25cm)vane,

  forsmallboatsanddinghies 

3150 WindTrak 15

  15"(38cm)vane,

  thechoiceformostsailors

3160 WindTrak AV

  15"(38cm)vane,formounting

  onwhipantennas,combiningtwo

  installationsinone

Davis Instruments

3465 Diablo Avenue, Hayward, CA 94545 U.S.A.

www.davisinstruments.com

03160.026,Rev.ANovember2020

Davis Instruments 3160 Owner's manual

Brand: Davis Instruments

Model: 3160

Category: Network antennas

Type: Owner's manual

This manual is also suitable for

WindTrak AV (3160)

Download PDF

report

Davis Instruments 3160 Owner's manual

This manual is also suitable for

Davis Instruments 3160 Owner's manual

Related papers

Other documents