Cateye Velo 7 [CC-VL520] User manual

Brand: Cateye

Model: Velo 7 [CC-VL520]

Category: Bicycle accessories

Type: User manual

This manual is also suitable for

Velo 9 [CC-VL820]

VELO 9 / VELO 7 ENG 1

Before using the computer, please thoroughly read this

manual and keep it for future reference.

Warning / Caution

• Donotconcentrateonthecomputerwhileriding.

Ridesafely!

• Installthemagnet,sensor,andbracketsecurely.

Checktheseperiodically.

• Ifachildswallowsabattery,consultadoctorimmediately.

• Donotleavethecomputerindirectsunlightforalongperiodoftime.

• Donotdisassemblethecomputer.

• Donotdropthecomputertoavoidmalfunctionordamage.

• Whencleaningthecomputer,bracketandsensor,donotusethinners,

benzene,oralcohol.

• Riskofexplosionifbatteryisreplacedbyanincorrecttype.

Disposeofusedbatteriesaccordingtolocalregulations.

• LCDscreenmaybedistortedwhenviewedthroughpolarizedsunglass

lenses.

CATEYE

VELO 9 / VELO 7

CYCLOCOMPUTER

CC-VL820 / CC-VL520

Maintenance

• Tocleanthecomputeroraccessories,usedilutedneutraldetergent

onasoftcloth,andwipeitoffwithadrycloth.

• Ifthegapsbetweenthebuttonsandtheunitgetcloggedwithmudor

sand,washthemawaywithwater.

Replacing the battery

Whenthedisplaybecomesdim,replacethe

battery.Installanewlithiumbattery(CR2032)

withthe(+)sidefacingupward.

*Afterreplacingthebattery,besuretosetthe

unitagainaccordingtotheprocedurespeci-

edin“Preparingthecomputer”(page3).

Troubleshooting

No display.

Isbatteryinthecomputerrundown?

Replacewithnewbatteriesaccordingtotheprocedurespecied

inthesection“Replacingthebattery”.

Incorrect data appear.

Followtheproceduredescribed“Preparingthecomputer”(page3).

Current speed does not appear.

(First,short-circuitthecontactofthecomputerafewtimeswithapiece

ofmetal.Ifcurrentspeedappears,thecomputerisworkingneandthe

causeshouldbeattributedtothebracketorthesensor.)

Isthewirebroken?

Eveniftheoutsideofthewirelooksnormal,therecouldbe

damage.Replacethebracketsensorkitwithanewone.

Istheclearancebetweenthesensorandthemagnettoolarge?

Arethemagnet’scenterandthesensor’smarkinglinealigned?

Re-adjustthepositionsofthemagnetandthesensor.

(Theclearanceshouldbelessthan5mm.)

Isthereanythingstickingonthecontactofthecomputerorthe

bracket?

Cleanthecontactwithacloth.

COIN

CR2032

Open

Speciﬁcation

Battery/Batterylife

Lithiumbattery(CR2032)x1/Approx.3year

*Thefactory-loadedbatterylifemightbeshorterthantheabove-mentionedspecication.

Controller 4bit,1-chipmicrocomputer(Crystalcontrolledoscillator)

Display Liquidcrystaldisplay

Sensor Nocontactmagneticsensor

Tiresizetobe

selected

26”,700c,27”,16”,18”,20”,22”and24”,ortirecircumferenceof

100cm-299cm(initialvalue:26inch)

Working

temperature

32°F-104°F(0°C-40°C)(Thisproductwillnotdisplayappropri-

atelywhenexceedingtheWorkingTemperaturerange.Slowresponse

orblackLCDatlowerorhighertemperaturemayhappenrespectively.)

Dimensions/weight

2-3/16”x1-15/32”x5/32”(55.5x37.5x18.5mm)/1.06oz(30g)

*Thespecicationsanddesignaresubjecttochangewithoutnotice.

Limited warranty

2-Year: Computer only

(Accessories/Bracket sensor and Battery Consumption excluded)

CatEyecyclecomputersarewarrantedtobefreeofdefectsfrommaterialsandworkmanship

foraperiodoftwoyearsfromoriginalpurchase.Iftheproductfailstoworkduringnormal

use,CatEyewillrepairorreplacethedefectatnocharge.ServicemustbeperformedbyCat-

Eyeoranauthorizedretailer.Toreturntheproduct,packitcarefullyandenclosethewarranty

certicate(proofofpurchase)withinstructionforrepair.Pleasewriteortypeyournameand

addressclearlyonthewarrantycerticate.Insurance,handlingandtransportationchargesto

CatEyeshallbebornebypersondesiringservice.ForUKandREPUBLICOFIRELANDcon-

sumers,pleasereturntotheplaceofpurchase.Thisdoesnotaffectyourstatutoryrights.

PleaseregisteryourCatEyeproductonthewebsite.

http://www.cateye.com/en/support/regist/

2-8-25,Kuwazu,HigashiSumiyoshi-ku,Osaka546-0041Japan

Attn:CATEYECustomerServiceSection

Phone :(06)6719-6863 Fax :(06)6719-6033

E-mail :[email protected] URL :http://www.cateye.com

[For US Customers]

CATEYE AMERICA, INC.

2825WildernessPlaceSuite1200,BoulderCO80301-5494USA

Phone :303.443.4595 TollFree :800.5.CATEYE

Fax :303.473.0006 E-mail :[email protected]

Partskit

Bracket

sensorkit

Wheel

magnet

Lithium

battery

Spare accessories

Standard accessories

1603390

1603391

1603491

1665150

CR2032

1699691N

Optional accessories

Heavydutybracket

sensorkit

In use

U.S.Pat.No.6957926&DesignPatented

CCVL82/52-150206

VELO 9 / VELO 7 ENG 2

How to install the unit on your bicycle

5 mm

WhenattachingtheFlexTight™brackettothestem

Attach the bracket to the stem or handlebar

Install the sensor and magnet

Route the wire

TheFlexTight™bracketcanbeattachedtoeitherthestemorthehandlebar,dependingonhowthebrackettsintothe

bracketband.

Remove/Install

the computer

Sensor

Nylonties

(x7)

Magnet

Nylonties

NylontiesHandlebar

Click

Whilesupportingitbyhand,

Pushitoutasiflifting

thefrontup

Stem

Bracket Wire

Double-sidedtape

Bracket

Double-sidedtape

Pull

securely

Magnet

Spoke

Magnet

SENSOR ZONE

Sensor

Magnet

Sensor

Nylonties

SENSOR

ZONE

Tothe

SENSOR ZONE

WhenattachingtheFlexTight™brackettothehandlebar

Install the sensor and magnet

Themagnetpassesthroughthe

sensorzone.

Theclearancebetweenthesen-

sorandmagnetis5mm(3/16”)

orless.

Nylonties

Magnet

Nylonties

Caution:

Adjust the wire length so that it may not be pulled when the

handle is operated.

*Themagnetmaybein-

stalledanywhereonthe

spokeiftheaboveinstal-

lationconditionsaresatis-

ed.

Pullsecurely

NO!

Cut

(3/16”)

VELO 9 / VELO 7 ENG 3

Operation test

Afterinstalled,checkthatthecomputerdisplaysthespeedbyturning

thefrontwheel.Whenitisnotdisplayed,checktheinstallationcondi-

tions

and again(page2).

Preparing the computer

Performtheclearalldataoperationasshownbelow,whenyouusethe

unitforthersttimeorrestoretheunittotheconditioncheckedatthe

factory.

Clear all data (initialization)

PresstheACbuttononthebackofthecomputer.

Select the speed unit

Select“km/h”or“mph”.

MODE

km/h

↔

mph

SET

setting

Set the tire size

Setthetiresizebyeitheroneofthefollowingmethods.

Simplesetting(selectfromthetiresize)

PressingtheMODEbuttonchanges26”

→

700c

→

27”

→

205[]

→

16”

→

18”

→

20”

→

22”

→

24”

→

26”inorder.Selectthetiresize(inch)of

yourbicycle,andthenpresstheSETbutton.

*Generally,thetiresizeisindicatedontheside

ofthetire.

MODE

Switchingsize

SET

thesetting

MODE

Pressandholdtothe

MODEbuttonwith

“205[]”displayedto

changetothewheel

sizeentryscreen.

Detailedsetting(enterthenumericvalueofthetirecircumference)

*Enteringthetirecircumferenceensuresmoreaccuratemeasure-

ments.

With205[]displayedonthescreen,pressand

holdtheMODEbutton.

PressingtheMODEbuttonincreasesthenu-

mericvalueflashing,whereaspressingand

holdingtheMODEbuttonmovesthedigit.En-

teranyvalueofthecircumferenceincm,and

thenpresstheSETbutton.

*Use“Tirecircumferencereferencetable”asa

guide.

MODE

Increase

thevalue

MODE

Movedigits

(Press&

hold)

SET

setting

Tire circumference

Youcanndthetirecircumference(L)ofyourtiresizeinthechartbe-

low,oractuallymeasurethetirecircumference(L)ofyourbicycle.

• How to measure the tire circumference (L)

Forthemostaccuratemeasurement,doawheelroll

out.Withthetiresunderproperpressure,placethe

valvestematthebottom.Markthespotontheﬂoor

andwiththerider’sweightonthebike,rollexactlyone

wheelrevolutioninastraightline(untilthevalvecomesaroundagainto

thebottom).Markwherethevalvestemisandmeasurethedistance.

• Tire circumference reference table

*Generally,thetiresizeorETRTOisindicatedonthesideofthetire.

L cm

ETRTO Tire size L (cm)

40-254 14x1.50 102

47-254 14x1.75 110

40-305 16x1.50 119

47-305 16x1.75 120

54-305 16x2.00 125

28-349 16x1-1/8 129

37-349 16x1-3/8 130

32-369 17x1-1/4(369) 134

40-355 18x1.50 134

47-355 18x1.75 135

32-406 20x1.25 145

35-406 20x1.35 146

40-406 20x1.50 149

47-406 20x1.75 152

50-406 20x1.95 157

28-451 20x1-1/8 155

37-451 20x1-3/8 1625

37-501 22x1-3/8 177

40-501 22x1-1/2 179

47-507 24x1.75 189

50-507 24x2.00 193

54-507 24x2.125 197

25-520 24x1(520) 175

24x3/4Tubular 179

28-540 24x1-1/8 180

32-540 24x1-1/4 191

25-559 26x1(559) 191

32-559 26x1.25 195

37-559 26x1.40 201

40-559 26x1.50 201

47-559 26x1.75 202

50-559 26x1.95 205

54-559 26x2.10 207

57-559 26x2.125 207

58-559 26x2.35 208

75-559 26x3.00 217

28-590 26x1-1/8 197

ETRTO Tire size L (cm)

37-590 26x1-3/8 207

37-584 26x1-1/2 210

650CTubular

26x7/8

192

20-571 650x20C 194

23-571 650x23C 194

25-571

650x25C

26x1(571)

195

40-590 650x38A 213

40-584 650x38B 211

25-630 27x1(630) 215

28-630 27x1-1/8 216

32-630 27x1-1/4 216

37-630 27x1-3/8 217

40-584 27.5x1.50 208

50-584 27.5x1.95 209

54-584 27.5x2.1 215

57-584 27.5x2.25 218

18-622 700x18C 207

19-622 700x19C 208

20-622 700x20C 209

23-622 700x23C 210

25-622 700x25C 211

28-622 700x28C 214

30-622 700x30C 215

32-622 700x32C 216

700CTubular 213

35-622 700x35C 217

38-622 700x38C 218

40-622 700x40C 220

42-622 700x42C 222

44-622 700x44C 224

45-622 700x45C 224

47-622 700x47C 227

54-622 29x2.1 229

56-622 29x2.2 230

60-622 29x2.3 233

MODE

SET

Batterycasecover

Contact

Set the Clock

PressingandholdingtheMODEbuttonswitchesthe

displayto“Displayformat”,“Hour”,and“Minute”in

order.

MODE

12h

↔

24h,or

increasesthe

value

MODE

Switchthe

screenormove

digits

Press the SET button to complete setting

PresstheSETbuttonwiththecurrentclockdisplayed.Then,theunit

settingiscompleted,andtheunitchangestotheMeasuringscreen.

SET

(Finish)

Displayformat

Hour Minute

Displayformat

VELO 9 / VELO 7 ENG 4

Calorie Consumption(VL820)*2

Thiscomputermeasuresthecalorieconsumptionbyintegratingthevalue

calculatedfromthespeedineverysecond.Checkitasareferencevalue.

Speed 10km/h[mph] 20km/h[mph] 30km/h[mph]

Kcalperhour

67.3kcal

[155.2kcal]

244.5kcal

[768.2kcal]

641.6kcal

[2297.2kcal]

How to calculate the Carbon offset(VL820)*3

TheCarbonoffsetarecalculatedasfollows.

Tripdistance(km)x0.15=Carbonoffset(kg)

*Thisfactorof0.15isdeterminedbyapplyingtheaveragevalueoftheover-

allgasoline-poweredpassengercarsin2008totheequationofthe“Carbon

offsetfrom1kmdriveofagasoline-poweredcar”describedontheweb-

siteoftheMinistryofLand,InfrastructureandTransportandTourism.

Operating the computer [Measuring screen]

Switching computer function

PressingtheMODEbuttonswitchesthemeasurementdataatthebottom

intheordershowninthefollowinggure.

*1: WhenTMexceedsabout27hours,orDSTexceeds999.99km,

.Ewillappear.

Resetthedata.

*2,*3: TobedisplayedonlywithVL820.

Current speed

0.0(4.0)–199.9km/h

[0.0(3.0)–124.9mph]

Pace arrow

Indicatesifthecurrentspeedisfasteror

slowerthantheaveragespeed.

(

Faster, Slower)

Speed unit

VELO 7 VELO 9

How to change tire size

DisplaytheTotalDistance(ODO)andpress

theSETbuttontochangethetiresize.

Thesettingmethodisthesameasfor“Pre-

paringthecomputer-3”(page3).

How to set clock

Intheclockmode,pressSETbuttononthe

back,andthedisplayentersclocksetting

mode.

Thesettingmethodisthesameasfor“Pre-

paringthecomputer-4”(page3).

ElapsedTime

0:00.00–9:59.59

DST

TripDistance

0.00–999.99km[mile]

AverageSpeed

(*1)

0.0–199.9km

[0.0–124.9mph]

MaximumSpeed

0.0–199.9km/h

[0.0–124.9mph]

CAL



CalorieConsump-

tion

(*2)

0–99999kcal

CO2

Carbonoffset

(*3)

0.00–999.99kg

ODO

TotalDistance

0–99999km[mile]

Clock

0:00–23:59

[1:00–12:59]

SET

Starting/Stopping measurement

Measurementsstartautomaticallywhenthebicycleisinmotion.

Duringmeasurement,km/hormphﬂashes.

START STOP

Resetting data

PressingandholdingMODEonthemeasuringscreen

returnsthemeasurementdatato0.

*Thetotaldistance(ODO)isnotreset.

Power-saving function

Ifthecomputerhasnotreceivedasignalfor10minutes,power-saving

screenwillactivateandonlytheclockwillbedisplayed.Whenthecom-

puterreceivesasensorsignal,themeasuringscreenreappears.

MODE

Startmeasurement Stopmeasurement

MODE

(Press&hold)

Measuring screen Power-saving screen

10minutes

How to change the total distance

DisplayDST,andthenpresstheSETbutton

toswitchtothetotaldistancemanualinput

screen.PresstheMODEbuttontoincrease

thevalue.PressandholdtheMODEbutton

tomovetothenextdigit.

PresstheSETbuttontoconrmthevalue.

*Onlywholenumberscanbeentered.(0–99999km[miles])

SET

Cateye Velo 7 [CC-VL520] User manual

Brand: Cateye

Model: Velo 7 [CC-VL520]

Category: Bicycle accessories

Type: User manual

This manual is also suitable for

Velo 9 [CC-VL820]

Download PDF

report

Cateye Velo 7 [CC-VL520] User manual

This manual is also suitable for

Cateye Velo 7 [CC-VL520] User manual

Related papers

Other documents