Craftsman 360.796800 Owner's manual

Category
Air blowers/dryers
Type
Owner's manual

This manual is also suitable for

SEA/ S I
OWNER'S
MANUAL
MODEL NO.
360.796800
CAUTION:
READ AND FOLLOW
ALL SAFETY RULES
AND INSTRUCTIONS
BEFORE OPERATING
EQUIPMENT
CRRFTSHRN°
4.5 HP, 2 CYCLE
54cc/3.3 cu. in.
229 MPH/589 CFM
BACKPACK AIR BLOWER
• Assembly
Operation
Customer Responsibilities
Service and Adjustments
Repair Parts
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
WARNINGS AND SAFETY INSTRUCTIONS
A
TRAINING:
CAUTION: ALWAYS DISCONNECT SPARK PLUG WIRE AND PLACE WHERE IT CAN- A
NOT CONTACT SPARK PLUG TO PREVENT ACCIDENTAL STARTING WHEN sE'ITING _H_
uP, TRANSPORTING, ADJUSTING OR MAKING REPAIRS,
Read theoperator'smanual carefully• Become familiar
with the controls and know how to operate your air
blower propedy.
Do not allow children to use your air blower. Never
allow adults to use air blower without proper instruc-
tions.
Keep thearea of operationclear of all persons,
especially small children and pets.
Use air blower only as the manufacturer intended
and as described in this manual.
Do not operate air blower if it has been dropped or
damaged in any manner. Always have damage
repaired before using your air blower.
Do not use accessory attachments that are not
recommended by the manufacturer. Use of such
attachments may be hazardous.
PREPARATION:
Always wearsafety glasses or eye shields when
starting andwhileusing your air blower.
Dress properly. Do not operate air blower when
barefoot or weadng open sandals. Wear only solid
shoes with good traction.
Wear long-sleeved clothes that are snug fitting.
Avoid weadng loose clothing.
Wear either tightly cuffed or cuffless pants.
Wear heanng"protection even w_en working for a
short period of time. Rememberk_.hearingdamage is
cumulative.
Wear protective, non-slipglovesfor saferoperation.
Check fuel tankbeforestartingengine.Do notfillfuel
tank indoors,when theengineis runningorwhen the
engine ishot.Allowtheenginetocoolforseveral
minutesb0forefilling thefuel tank. Clear_offany
spilledgasolinebeforestartingtheengine.
Always make edjustments beforestartingyourair
blower.Never attempt todo thiswhilethe engineis
running.
Use onlyin daylightor goodartificiallight.
OPERATION
Keep youreyes and mindo_ yourairblower and the
area being blown. Don't letotherinterestsdistract
yOU.
Always be sure of yourfooting.Use.extracaution in
wet or slippery grass. Walk - Don't Run.
Do not put hands or feet near rotating parts. Keep
clear of the nozzle opening at all times.
Always stop the engine whenever you leave or are
not using your air blower.
Never direct discharge of matedal toward bystand-
ers nor allow anyone near the air blower while you
are operating it.
Before cleaning, inspecting, or repaidng your air
blower, stop the engine and make absolutely sure
all moving parts have stopped. Then disconnect the
wire and keep it away from the spark plug to
prevent accidental starting.
Do not adjust carburetor. Overspeeding, engine
damage or personalinjury may result.
Do not operate your air blower if itvibrates abnor-
mally. Excessive vibration is an indication of
damage; stop the engine, safely check for the
cause of vibration and repair as needed.
Do not run the engine indoors. Exhaust fumes are
dangerous.
Never operate your air blower without proper
guards,tubesor othersafety devices in ;)lace.
WA RN!NGCaliforniaProposition 65 I
The engine exhaust from this product contains I
chemicals known to the State ofCalifornia to cause I
cancer, birth defects or other reproductive harm. I
MAINTENANCE AND STORAGE:
Check the enginemountingbolts oftento be sure
theyaretightenedpropedy.
Check all bolts,nutsand screwsat frequent intervals
for propertightnesstobe sure air blowerisinsafe
workingcondition.
Keep all safetydevicesin placeand working.
To reducefire hazard,keep theenginefree ofdebds
and excessivegrease and oil.
Allowengine tocoolbefore stodnginanyenclosure.
Never storeair blowerwithfuel inthetankinsidea
buildingwherefumes may reach anopenflame or an
ignitionsourcesuch as hotwaterIleater, space
heater, clothesdryer,etc.
I_ LOOK FOR THIS SYMBOL,TO POINT OUT IMPORTANT SAFETY, PRECAUTIONS. 'I
IT MEANS- ATTENTION! I BECOME ALERTIII yOUR SAF_IS INVOLVED. :;i :iii, I
'" " : _: r _!:'_ _" _ _'_.:_ _ ,._ ;'_.,'_*;_ i__'.: "_",'_" L:_:,_:_ _,_'-
CONGRATULATIONS on yourpurchaseofa Sears
BackpackAir Blower.It has been designed, engineered
and manufacturedto giveyouthe best possiblede-
pendabilityand performance.
Shouldyou experienceanyproblemyoucannoteasily
remedy,please contactyournearest SearsService
CenterDepartment.We havecompetentwell-trained
techniciansand the propertoolstoserviceorrepairthis
airblower.
Please read and retain thismanual.The instructionswill
enable you to assemble and maintain your air blower
)ropedy.Always observe the "SAFETY RULES".
MODEL NO. 360.796800
SERIAL NO.
DATE OF PURCHASE:
THE MODEL AND SERIAL NUMBERS WILL BE
FOUND ON A PLATE ON THE BLOWER HOUSING
ABOVE THE AIR FILTER. YOU SHOULD RECORD
BOTH SERIAL NUMBER AND DATEOF PURCHASE
AND KEEP IN A SAFE PLACE FOR FUTURE
REFERENCE.
MAINTENANCE AGREEMENT
A Searsmaintenanceagreementisavailableonthisair
blower.Contactyourneareststorefor details.
CUSTOMER RESPONSIBILITIES
= Read and observethe safety rules.
Follow a regular schedule in maintaining, caring and
using your air blower.
Follow the instructions under =CustomerResponsi-
bilities" and "Storage" sections of this manual.
PRODUCT SPECIFICATIONS
HORSEPOWER:
FUEL/OIL MIX CAPACITY:
FUEL/OIL MIX:
SPARK PLUG
(GAP .020 IN)
AIR VELOCITY:
AIR VOLUME:
MAXIMUM RPM:
DRY WEIGHT:
4.5
1.05 U.S. AT.
40:1
BOSCH WSR6F.
CHAMPION
RCJ-6Y
229 MPH
589 CFM
7300 RPM
17 LBS
WARNING: For userson U.S. ForestLandand in some
states, including California (Public Resources Codes
4442 and 4443), Idaho, Maine, Minnesota, New Jersey,
Oregon, and Washington: Certain internal combusi0n
engines operatedon forest,brush,and/or grass -
covered land in the above areas are required to be
equipped with a spark arrestor, maintained forthe
prevention of fire..Che_k with your state or local
authorities for regulations pertaining to these require-
ments. Failure to follow these requirements is a viola-
tion of the law. This unit is notfactory-equipped with a
spark arrestor; however; a spark arrestor is available
as an optional part. If a spark arrestor is required in
your area, contact your Sears Service Center or Parts
Department for Spark Arrestor #2048360. The spark
arrestor, blower tubes, and nozzles must be assembled
to the unit to be in full compliance with the regulations.
LIMITED ONE YEAR WARRAI_
For one (1) year fromtheclareof._urchaseiftheBackpackAirBlowerismaintained, lubdsatedand tunedup
accordingtothe instructionsin tl'_'owner'smanual,Sears willrepairor replace,free ofcharge,any partsfound to
be defectivein matedalor workmanship.Ifthisproductis usedcommercially,thiswarrantyonlyappliesfor90
days.
This Warranty does not cover:
Expendable items which become wom dudng normal use, suchas spark plugsand air filters.
Repairs necessarybecause of operator abuse, negligence, improper storage, accidentor the failure
to maintainthe equ pment according to the instructions contained in the owner's manual.
WARRANTY SERVICE ISAVAILABLE BY RETURNING THE AIR BLOWER TO THE NEAREST SEARS SER-
VICE CENTER IN THE UNITED STATES.
This warranty gives you specific legal rights, and you may also have other rightswhich may vary from state to
state.
SEARS, ROEBUCK AND CO., D/817 WA, HOFFMAN ESTATES, IL,60179
ACCESSORIES
These accessoriesand attachmentswereavadablewhen the unitwas originallypurchased.They are alsoavad-
able at mostSears retailoutletsand serv=cecenters MostSears storescanorderthese itemsforyou whenyou
providethe modelnumberofyourunit.
SPARK PLUG
GLOVES
2-CYCLE
AIR-COOLED
ENGINE OIL
SAFETY
GOGGLES
AIR FILTER
HEARING
PROTECTION
FUEL
STABILIZER
GAS CAN
CONTENTS OF CARTON
_,_1
Backpack Air Blower (1)
Straight Tube (1)
(Long With Felt) Straight Tube (1)
(Long)
Straight Tube (1)
(Short) Curved Nozzle Tube (1)
Elbow Hose (1)
CONTENTS OF HARDWARE PACKAGE
SEARS
OWNERS
MANUAL
MODEL NO.
360.796800
CRRFTSMRN"
4.5 HP_2 CYCLE
_mwu_ 54cr./3.3 ¢u. in.
_'_ _ 229 MP1"1/589 CFM
BACKPACK AIR BLOWER
.C)pmw_n
OWNER'S MANUAL (1)
METAL CLAMP
FOR ATTACHING ELBOW HOSE
TO BLOWER HOUSING (1)
FUEL FUNNEL (1)
PLASTIC CLAMP FOR
ATTACHING THRO'I'I'LE
HANDLE TO TUBE (2)
COMBINATION WRENCH
FOR ASSEMBLY
AND ADJUSTMENTS (1)
ASSEMBLY
READ THESE INSTRUCTIONS AND THE OPERATING MANUAL IN ITS ENTIRETY BEFORE YOU A1-FEMPT
TO ASSEMBLE OR OPERATE YOUR NEW BACKPACK AIR BLOWER.
YOUR NEW BACKPACK AIR BLOWER HAS BEEN ASSEMBLED AT THE FACTORY EXCEPT FOR THE
BLOWER TUBE. ALL NECESSARY CLAMPS TO COMPLETE ASSEMBLY AS WELL AS A COMBINATION
WRENCH ARE INCLUDED INTHE PARTS BAG ENCLOSED WITH THE UNIT.
TO ENSURE SAFE AND PROPER OPERATION OF YOUR BACKPACK AIR BLOWER, ALL CLAMPS THAT
YOU INSTALL MUST BE TIGHTENED SECURELY.
HOW TO ASSEMBLE ._""
1. SlideMetal ClampontotheE!boc_vHose,then slidethe ElbowHose overthe BlowerDischargePort.Movethe
OblongClampagainstthe raisedsectionandtighten.(Fig.1)
Elbow Hose & Clamp Assembly
(Fig. 1)
ASSEMBLY (Cont...)
2. Slidethe twoRound Clampsovertheoutletend ofthe Elbow Hose. The nutsonthe Clamps shouldface away
from the operator. SlidetheStraightTube withthefelt coveredend intothe ElbowHose. PlacetheThrottle
HandleAssemblyon theend ofthe ElbowHose.The ThrottleHandleAssemblyshouldbe placedsuchthatthe
ignitionswitchfaces upand thethrottleleverfaces away from theblower. Move clampsoverthe metalsupport
of theThrottleHandleand tighten.PushtheThrottleCable intothe clipon the ElbowHose. (Fig, 2)
Mounting Throttle On Tube
(Fig. 2)
Round
Clamps
\
Straight Tube
(Long W/Felt)
Throttle
Handle
Assembly
a---"
Elbow
Hose
3. AttachCurved NozzleTube to theStraightTube and insert securely,(Fig. 3)
Blower Hose Assembly
(Fig. 3)
Elbow Hose Straight Tube Straight Tube
(With Felt) (ShortOr Long)
Curved Nozzle
Tube
OPERATION
KNOW YOUR BACKPACK AIR BLOWER
READ THIS OWNER'S MANUAL AND SAFETY INSTRUCTIONS BEFORE OPERATING YOUR BACKPACK AIR
BLOWER Compare the tllustratJonwtth your backpack air blower to famdtanze yourself with the location of vanous
controls and adjustments. Save thts manual for future reference.
Know Your Backpack Air Blower
(Fig. 4)
1. On/Off Switch - Turns Motor Off
2. Throttle Lever- Controls Engine Speed
3. Choke Lever -Placed In Down To Start, Up To Run.
4. Fuel Valve -Open (In Line With Fuel Line) To Run,
Closed For Storage & To Run Carburetor Dry,
5. Serial# Data Plate
6. Air Filter
7. Fuel Cap
8. Recoil Starter
9. Spark Plug
10. Muffler
®
r_
F
t Start (I)_Stop (O) I
Ii
LI
Throttle
Handle Throttle & Lever
Choke Lever
(Fig. 5)
OrdO_witch
tA
Idle
Lever
OPERATION CONTINUED
HOW TO USE YOUR BACKPACK AIR BLOWER
To stop engine, move throttle lever to idle position and
turn switch to STOP.
,_ WARNING:
BE SURE TO READ THE FUEL HANDLING INFOR-
MATION IN THE SAFETY RULES SECTION ON
PAGE 2 OF THIS MANUAL BEFORE YOU BEGIN.
IF YOU DO NOT UNDERSTAND THE FUEL HAN-
DLING SECTION DO NOT AI-I'EMPT TO FUEL
YOUR UNIT; SEEK HELP FROM SOMEONE THAT
DOES UNDERSTAND THE FUEL HANDLING
SECTION OR CALL SEARS SERVICE AT 1-800-4-
REPAIR.
GASOLINE MIXTURE
The two-cycle engine on this product requires afuel
mixture of regular unleaded gasoline and a high quality
40:1 2-cycle engine oil (AIR-COOLED) for lubrication of
the bearings and other moving parts. The correct fuel/oil
mixture is 40:1 (see Fuel Mixture Chart). Too littleoil or
the incorrect oil type will cause poor performance and
may cause the engine to overheat and seize.
Gasoline and oil mustbe premixed in a clean approved
fuel container. Always use fresh regular unleaded
gasoline.
This engine iscertified to operate on unleaded gasoline.
IMPORTANT: Experience indicates that alcohol blended
fuels called gasohol (or using ethanol or methanol} can
attract moisture, which leads to oiVgas separationand
formation of acidsduringstorage.
Acidic gascandamage thefuelsystem ofan engine while
in storage. To avoid engine problems, the fuel system
should be emptied before storage for 30 days or longer.
Drain the gas tank, then run the fuel out of the carburetor
and fuel lines by startingtheengine and letting itrununtilit
stops. Use fresh fuel next season.See STORAGE instruc-
tions for additional information. Never use engine or car-
buretor cleaner products inthe fueltank or permanent dam-
age may occur.
FUEL STABILIZER
Fuel stabilizeris an acceptablealternativein minimizing
theformationoffuelgumdepositsduringstorage.Addsta-
bilizertogasolineinfueltankorstoragecontainer.Always
followthe fuel mix ratiofoundon the stabilizercontainer.
Run engine at least 5 minutesafter addingstabilizerto
allowthestabilizertoreachthecarburetor.Youdonothave
to drainthefuel tankfor storageifyouare usingfuelstabi-
lizer.
2-CYCLE OIL
CRAFTSMAN 40:1 2-cycle engine oil (AIR-COOLED) is
speciallyblended with fuel stabilizers.If you do not use
thisSears oil,youcan adda fuel stabilizer(suchas Crafts-
man No. 33500) to yourfuel mix. See =Gasoline and Oil
MixtureInstructions" below.
IfCRAFTSMAN 40:1 2-Cycle engineoil is not available;
usea goodquality40:1 2-cycleengineoil(AIR-COOLED)
that hasa recommendedfuel mix ratioof40:1.
OPERATION CONTINUED
IMPORTANTI DO NOT USE:
AUTOMOTIVE OIL
BOAT OILS (NMMA, BIA. ET,G)_'_.
These oilsdo not haveproperadd_ivesfor2-cycle
(AIR-COOLED) enginesand cah_:_useengine
damage.
GASOLINE AND OIL MIXTURE
MIX GASOLINE AND OIL AS FOLLOWS:
Consultchartfor correctquantities.
Do notmixgasolineand oildirectlyinthe fuel
tank.
FOR ONE GALLON:
Pdur3.2 ouncesofhighquality,2-cycleengineoil
(AIR-COOLED] intoan empty,approved one gallon
gasolinecontainer.
Addone gallonof regularunleadedgasolinetothe
galloncontainer, thensecurelyreplacethecap.
Shakethecontainermomentarily.
The mixtureisnow readyfor use. Fuelstabilizer
canbe addedat thistimeifdesired;follow mixing
Instructionsonthe label.
FUEL MIXTURE CHART
I GASOLINE OIL I
1 Gallon 3.2 ounces
2.5 Gallons .8.0 ounces
STARTING COLD
1. Make surethat thefuelvalve isinthe openposition.
(lever inlinewiththe fuelline). (Fig.4)
2. Move switchto the Start(I) position.(Fig.5)
3. Set Throttle between the "to "position.(Fig. 5)
4. AdjustChoketo the Start(upward)position.
5. PullStarterCord slowlyuntilresistanceisfelt. Then
pullforcibly.
6. When enginecranks (attemptsto start)movechoke
leverto the RUN (down)positionand pullstarter.
STARTING -WARM
Followcoldstartinginstructionsbutleavechoke leverin
Rur_(down)position.
STOPPING
To stopengine, adjustThrottleto IDLEand switchto
STOP (0) positions.
CUSTOMER RESPONSIBILITIES
MAINTENANCE SCHEDULE
B
L
O
W
E
R
E
N
G
I
N
E
CHECK FOR LOOSE FASTENERS
SERVICE DATES
CUSTOMER RESPONSIBILITIES CONTINUED
GENERALRECOMMENDATIONS
The warrantyon thisatrblowerdoes notcover items
thathave been subjectedtooperatorabuseor negk-'
gence.To recetvefull value from thewarranty,opera-
tormustmaintainair bloweras inst,tucted mthis
manual
Allttemsin theCustomerRespondibditiessectionof
thtsmanualshouldbecheckedat leastonce each
season
1. Service moreoftenwhen operatmgin dustyor dirty
conditions.
2. Once a yearyou shouldreplacethe sparkplug and
clean or replacetheair filter. A newspark plugand
a clean airfilterassuresproperair-fuelmtxtureand
helpsyourengmerunbetterand lastlonger.
CHECK FOR LOOSE FASTENERS
Check all fasteners, includingnuts, bolts, screwsand
clamps,toinsurethattheyare tightand secure. Ifnot,
make necessaryadjustmentspriortousingatrblower.
AIR FILTER
Yourenginewillnotrun propenyano mayDedam-
aged byusinga dirtyair filter.
Replaceairfilterelement ifdeteriorationoccurs.
Service moreoftenIfyou useyourAirBlowerin very
dustyordirty conditions.
TO CLEAN AIR FILTER
1. Remove theair filter cover
2. Rinseair filter m a mddsoap& watersolutton.
3. Dryatrfilter completelyand otlslightlybyplacinga
small amount of otlon thefilter and kneedinguntd
completelysaturated.Wtpeoffexcessod. Reas-
sembleair filter
4. Replacea=rfilter element tfdeteriorating.
MUFFLER
Inspectand replacecorrodedmuffleras itcouldcreatea
fire hazardand/ordamage.
SPARK PLUG
Change yoursparkplugeach yeartomake yourengine
start easy and runbetter.Set sparkpluggap at .020".
CUSTOMER RESPONSIBILITIES CONTINUED
CARBURETOR ADJUSTMENT
To comply withemission regulations, the carburetor
mixture is pre-set at the factory and can not be ad-
justed The idle speed can be adjusted. The idle speed
set screwtslocated near the throttle cable on top of the
carburetor. To adjust idle speed'
Loosenthe Iocknuton the idlespeedset screw•
Starttheblowerand movethrottletoidleposition
Adjustidlespeed todesiredspeed. (Clockwiseto
increase/counterclockwiseto decrease)
Shut offblower
T=ghtenIocknut.
CarburetorAdJusmmt
I- FI- "11"="
FUEL FILTER
Clean fuel filter once everyseasontoensure goodfuel
flow to the carburetor. This makes the engine run better.
To clean: emptyfuel tank, remove fuel tank, remove fuel
valve from tank by unscrewing, flush filter in a mild soap
and water solution and dry before reassembly.
ENGINE CYLINDER COOLING FINS
IMPORTANT: For best performance,keepd=rtfrom
accumulatingaroundthe enginecoolingfins. Clogged
coohogfinscause theenginetorunhotterand shortens
its life Coolingfins maybe cleanedusinga toothbrush
or st(ffbristlebrush.
SPARK ARRESTOR SCREEN (If Installed)
1. Remove screen
2. Clean usinga wire brush and reinstall.
3Replace ifdeteriorating.
STORAGE
PrepareyourBackpackAir Blower for storageat the
end ofthe season or ifthe unit willnotbe usedfor 30
days or more
1. Usesoap and waterto wipedownunitpriorto
storage.
2. Besure thatall nuts,bolts,screwS'_ndfasteners are
securelyfastened. Inspectfor d_magedorworn
parts.Replaceif necessary.
3. Touch upall rustedor chippedpaintsurfaces,sand
lightlybefor_painting.
BLOWER TUBE
The straightblowertubescan be removedtoease
storage Use care notto=kink"the throttlecable.
ENGINE
FUEL SYSTEM - Itis importanttopreventgum depos-
itsfrom forming inessentialfuel systempartssuchas
thecarburetor, fuel filter, fuel hoseor tankduring
storage.Also,experienceindicatesthatalcohol blended
fuels (calledgasoholor usingethanolor methanol)can
attractmoisturewhzchleadsto separationand forma-
tionofacids duringstorage•Acidicgascan damage the
fuel systemofan enginewhileinstorage.
To avoidengine problems,thefuel systemshouldbe
emptiedbeforestorageof30 daysor longer.Follow
theseinstructions:
1. Drainthefuel tank.
2. Start engineand let Itrun untilthefuel lines and
ca_urator are empty(enginestops).
3. Usefresh gas nextseason.
4. Ifyou usefuel stabilizer,thegasolinecan be leftin
the tank. Remembertoturnthefuel shut-offvalveto
the offpositionand follow Step#2 above.
CYLINDER
1. Remove sparkplug.
2. Poura few dropsofoilintothe cylinder.
3. Pullstarterhandleslowlytodistributeoil.
4. Replacew_thnewsparkplug.
OTHER
Do not storegasolinefromone season toanother.2-
cycle mixagesquicklyand cancauseengine
damage.
Replace yourgasohnecan ifIt startsto rust.Rust
and/ordirtinyourgasolinewillcauseproblems.
If possible,storeyourunItindoorsand coveritto
give itprotectionfromdustand d_rt.Do notuse
plastic.P.lasticcannot breathwh=chwdlallowcon-
densetionto formandwillcause yourunIttorust.
IMPORTANT: NEVER COVER AIR BLOWER WHILE
ENGINE AND MUFFLER ARE STILL WARM.
,_ CAUTION:
NEVER STORE YOUR AIR BLOWER INSIDE A
BUILDING WITH FUEL IN THE TANK. FUMES
CAN CONCENTRATE AND POSSIBLY REACH
•A SOURCE OF IGNmON. ALLOW ENGINE TO
COOL BEFORE STORAGE. ,-' .,. _
TROUBLE SHOOTING POINTS
PROBLEM CAUSE CORRECTION
ENGINE SMOKES 1. DirtyAir Filter 1. Cleanor ReplaceAirFilter
EXCESSIVELY 2. FuelMixtureIncorrect 2. Venfyyou have40"1 FuelMixture.
3. Carburetorrequires 3. See carburetorAdjustmentunderCustomerResponslbditle=
adjustment
ENGINE HARD TO
START, WILL NOT
START OR STARTS
AND ONLY RUNS A
FEW SECONDS
1. FuelTank Empty.
2. Engine Flooded.
3. Sparkplug notfinng.
4. DirtyAirFilter
5. Carburetorrequires
idle adjustment.
6 Stalefuel mixor water
in fuel mix
7. Spark plugwire
dasconnected
8. Switchin offposition.
f. Filltankwithcorrectfuel mix.
2. Remove andclean spark plug.Withsparkplugremoved
(engine switchedoff), crankengineafew timesto remove
excess fuel from cylinder.Reinstallsparkplug.
3 Check asfollows: Removesparkplugand reattachthe
spark plugtothe spark plugwire.Groundthe tipofthe
sparkplugagainstthe engineand pullstarterrecoilhandle.
A strongwhitespark shouldjumpacrosstheplugtip.If
there is nospark ora weak spark,trythe testwitha new
sparkplug.If a newspark plugdoes notsolvethe problem,
take the unittoa Sears ServiceCenter
4. Clean or replaceairfilter
5. See CarburetorAdjustmentunderCustomerResponsibilities
6. Draintankand refillwithfresh, cleanfuel mix.
7. Connectwire toplug.
8 Move switchtoRun position
ENGINE WILL NOT
ACCELERATE
LACKS POWER, OR
DIES UNDER A LOAD
1. Dirtyair filter. 1.
2. Spark plug fouled. 2.
3. (Optional) Spark 3.
Arrestor Screen Plugged.
4. Carburetor requires 4.
Adjustment.
Clean or replacefilter.
Clean or replacesparkplugand re-gap(0.020).
Clean or replacescreen.
See Carburetor AdjustmentunderCustomer Responsibilities
Sparepartslist
I
----___]
19
16
20
17
18
t
I
I
26
32 35
30
9Reparat uPsatz- Vergaser
Repair - kit - Carburetor
Kit de rf_paratlon - Carburateur
Juego de reparation - _rburadot
Dtdltsatz - Vergaser
Gasket÷klt-Carb_etor . ,
Pochettedeioir_- _r
I
160 1:6_I
BdcI.Nr
Pos-No,
Pos-No
Pos-No
1
3
5
8
9
12
15
1G
17
18
lg
2O
22
25
26
27
28
3O
32
33
35
37
38
39
40
49
5O
55
57
58
59
6O
64
65
67
G8
7O
72
74
75
7G
77
83
90
91
92
95
96
97
98
100
101
102
103
104
105
106
108
110
111
112
113
114
115
11G
120
121
122
124
127
128
138
' 133
BestelI.Nr
O_der-No
NOdeCde
Ref-Fir
2048369
20O83O8
2500709
0072 140
0028 137
2300 747
2061 495
20 74913
40 35118
00 18338
2061 496
0015291
2100 456
0015158
20 61308
2500708
O018 207
0034100
0021 130
0028137
25 O0710
00 30125
00 72 143
0028100
00 30 125
0034201
00 10 175
23 O0730
0018188
2043 244
0033285
0018346
2048 357
2200812
2031 238F
0055144
2200 T/G
i0052206
;007s100
0031502
0050102
0054256
O018 389
25 00714
0030102
0018334
0084600
0073385
2300487
2300680
0084612
0084537
0072148
00 18328
O028118
0018311
0066441
0018348
4400281
4400211
4074805
4073602
4073601
0034115
00 21233
4400280
0010204
4074382
0018282
4073352
0018274
0064139
0062116
qoderl
ype
4od_le
_odelo
Merge
Quantity
Hombre
Canbde(
2
1
2
2
1
1
1
1
1
I
2
1
2
1
I
1
2
1
1
1
2
2
2
2
1
1
1
2
1
2
1
1
1
1
2
1
t
I
2
2
2
4
2
Motor/ Engine/ Moteur/ Motor/
Geblise Blower Housing Carterde Turbine Caja del Ventilador
F_ltereinsata filter element filtre&air elementofiltrante
Fitterplatte filterplate plaquedeltltre platadeftJtro
Luftiilter.kompl a_rfilter,compl ftltre,_air,compl flltro dealre,compl
"fellededer5,2x12xO,5DIN2093Aspringwasbor rondelleballevtlle resor_e
SechskantmutterMSDIN980 nut ecrou tuerca
VergaserWYJ-128 carburetorWYK-128 carburateurWYJ-128 carburadorWYJ-128
Vergaserdtchtung0,7mmdick carburetorgasket jomtdecarburateur juntadelcarburador
Vergaserstutzen manrfolri boded'arimtsslon bndadecarburador
Dtstanzrohr10xl,8xlO spacer entretolse tuboespacFador
Zyhnde_hrauboMSx25 screw vrs torntJlo
D_htungZyllnder-Vergaserstutzen_mder gasket jo=utd'admtss[on lunta
SttftschrauboM5x73 screw ws torndlo
Kurbolgeh+Zyhnder045mm,komplcrankcase+cybnder,complcartermoteuraveco/hndre ogGenal+ohndro,compl
SbftachrauboMSx15DIN835 screw ws tormllo
Auspuffdtchtung1,2mmdick mufflergasket jointd'_chappement juntadeescape
Auspuff muffler echappament escape
SechskantschrauboM5x16 screw vts torndio
Schnorrstcborung5 washer rondellecrant_ seguro
SechskantmutterM5 nut ecrou tuerca
SechskantmuttacMSDIN980 nut ecrou tuerca
Auspuffschutz mufflerguard caputprotechon_chappementpmtecc_ndelescape
_helbo 6.4DIN9021 washer rondelle arandela
Spannsicherungsschelbo6DING796A tensionwasher rondelledetension arandela
_.hskantmutter MG nut _crou tuerca
SchetboG,4DIN9021 washer rondelle acandela
S_lerungsr_elbo5 circhp rondelle_lasttque antlloorcltp
Zy[tnderschrauboM5xl0DIN84A screw vts torntllo
ZGndkerzeWSRGF200 sparkplug bougle bupa
SechskantschrauboM5x20 screw vts torntllo
Befestlgungswlnkel I_acket equerredefrxatton angulodefljaoon
Dtstanzst_ck6xlOxT,8 spacer eotretotse espactador
ZylinderschrauboMGx16 screw vts tornlllo
Kolbonnug45xl,5 pntonring segment antllodepiston
KolbonO45 mm piston piston piston
Kolbonbolzen10/6x32 pistonpin axedepiston boulondepiston
Kotbonbolzens_cheruegI0x0,8 pistonpincirchp dipd'axedeprston segurodebulon
Kurbelwelle3-teihg crankshaft vdebrequm ogOenal
Nadelk&fig10x13x14,5 needlebeanng roulement&atgmlles casqudlodeagujas
Scheibonfeder2x3,7DIN6_ woodruffkey clavet_edemvlune chaveta
PaBscheibo26xJTxlDIN988 washer rondelle arandela
RiIlenkugellager15_5xl1DIN6202 ballbearing roulement&brlles cojmetedebolas
Welle_kd_tring15x]5x5 oilseal JOintd'acbre retch
Zyli_dersdlrauboM5x45 screw vis torndlo
Hal_lNinkel angle equerredefixation angu]odefijaoon
Sche=bo5,3DIN9021A washer rondelle arandela
ZyhndersdlrauboM5xl0 screw vts torntllo
Kerzenstecker sparkplugcap capuchondebougm cabaruzabujta
Kontaktfeder contactspring ressortdecontact resortedecontacto
ZOndmodul =gnrttoncod bobmed'ailumage bobma
ZO_modul,kompl Ignittoncod,compl bobmeallumege,compl bobma,compl.
KurzschluBkabol,Spule,rot short-arcuitcable,red c_blecourt-orcult,rouge cablecortoorculto,rojo
Massekabol,schwarz groundcable,_ack c_bledemasse,notr cabledemase,negro
Spannscboibo4DIN67% tensionwasher rondelle d_scodeteost_
ZyhnderschrauboM4x25 s_ew vts torntllo
SechskantrnutterM4DIN980 nut _rou tuerca
Ltn_enschraubo6x14 screw vts torntilo
S_helle12J12 clamp collier abrazadera
ZyhnderschcauboM6x25 screw vts torntllo
GebBsegehEuso,grau blowerhousing,grey carterdeturbine,gns carterdeturbtna,gns
Magnet-LGfterrad,voll_nd=g fan+flywboefassemblyturbme+volantmagn_t_queruedaventdacion
Abde_kung cover re;ouvrement oJbterta
Zw_scbonflansch2,grau spacer2,grey bodemterr_ta=re 2,gns bndamtermedta2,grts
Zwlscbonflansch1,grau spacer1,grey brideintermkhaire1,gns bndaintermedta1,gns
$d_n_rrucborueg8 washer rondellecrant_ seguro
Sechskan_utterM8 nut ,k.rou tuerca
GebBsegeh_uso2,grau blowerhousing2,gr_=y carterdeturbme2,gris carterdeturbtna2,gris
ZyhnderschraubeM5x75DIN84A screw vts tornillo
Deckel,grau co_, grey oouverde,gris tapa,gns
bnsensch_aube5x45 screw ws torndlo
kuftdurchtritt aJrintake grilledeprotection pasodeaire
bnsonsch_auboSx16 screw _tomilln
Schlauch5xl,5 fue_hose .tuyaq :tubo,
O-Pa_9x2 nng .',jointtod_ue :an_lio
45 40 41
"4
I
I(
2
414SEARS-d/OT.98.tiff
Bild-Nr,
Pos.-No.
Pos.:No.
Pos,-No.
I
2
3
7
10
11
12
15
17
2O
21
22
25
26
27
30
31
32
33
34
35
4O
41
45
BestdI-Nn
Order-No.i
No;deCde.
Ref.-Ne
4071281
4065180
40G5173
O060159
0018340
0066399 i
0020160
4400204
O066662
4800187
2063128
0028121
2800338
28O0551
0064415R
O028110
4073644
0084477
6073567
O018356
0018364
0084704
0084703
4800199
Mndell
type
Mod61e
Mndelo
1s
Blasrohr Straight tube Tube de soufflerie Tubo soplador
BlaskrOmmer elbow tubecoud_ codosoplador
Blasrohr60xl,3xSO0 stzaighttube tubedesoufflerie tubesoplador
Blasroh_P_rbindungsstGck60xl,3 straighttubeconnectiontubedesoufflerie conexiondetubo
Fil_ffage 50x195xl,5 feltspacer feutrine apoyodeflelvo
Zyli_j_.erschraubeMSx4O screw vis tomillo
Spah_schelJeGgxl0 clamp collierdeserrage abrazadera
VierkantmutterM5DIN557 nut PJou tuerca
Faltenschlauch pleatedhosew/elbow tuyausouple+coude tuboplegahle
Spannschelle60/80x9 metalclamp cdlierdeserrage abfazadera
Griffrohr22xlx140 handletube supportdepoign6e tube
KabeltQIle4xGRx3i6 grommet passe-ill manguitodecable
SechskantmottarMG nut _rou tuerca
Regulierbebel throttlelever manetted'acc_l_rateur palancadegas
Bewdenzug,Gas throttlecable,gas _ble d'acc61_rataur,gaz cablebowden,gas
Wellschlauch8,5 tube tube tubo
5echskantmuttarM5DIN980 nut _rou tuerca
Griff_lfte, innen griphalf poign_ext_rieure cascara
Kurzschlugschalter shortcircuitbutton interrupteur interruptor
Griffh_lfte,auSen griphalf poign_eext_rieure r._ara
LinsenschraubeM4x2O strew vis tomillo
ZylinderschraubeM5x32 screw vis tornillo
Kurzschlu6kabel,rot short<ircuitcable,red c,iblecourt<ircuitrouge cablecorcodrcuito,rojo
Massekabe],schwarz groundcable,black _ble demasse,noir cabledemasa,negro
Gdff,kompl, grip,compL poign_,compL cascara,€ompt.
Bild-Hr.
Pos.-No.
Pos...Ho.
Pos.,-No.
1
23
7
8
9
12
13
15
16
17
18
19
22
23
24
25
28
3O
Bestell-Nr.
Order-No.
No.deCde.
Ref,-Nr.
4300273
4043998
5074562
0018258
0018344
4036414
0096151
4074962
O012161
O033375
O073363
O018311
0028121
O012172
O073363
O018311
0028121
4074833
4300334
Modell
TypeMod leTragegestell Frame Chassis Bastidor
Modelo
Me_e
Quant_
Nombres
_nti_d
1
1
1
2
2
2
1
5
2
2
2
2
2
2
2
2
2
1
2
Traggeste]l frame chassis bastidor
Haltewinkel topsupport _cluerredemaintien angulosoporte
Gdff,sd_warz handle,black poign_e,noir palanca,negro
.Unf_chraube 5x18 screw vis tornillo
°'_ind_rschraubeM6xl0 screw vis tornillo
._rtbefestigung shouldstrapdip crochetdebretelle fijacion
ROdmkissen backcushion coussindorsal almohadilla
Stopfen6xlTx18 cushionplug bo_'hon tapon
SechskantschraubeM6x2.SDIN933 screw vis tornillo
Distanzrohr12x2,8x10 spacer entretoise tube
DEmpfungsfeder3x22x26 avspring ressortamortisseur resorteamortiguador
t.imenschrau_6x14 screw vis tornirlo
SechskantmutterM6 nut _rou tuerca
SeshskantsdlraubeM6x16DIN933 screw vis tornillo
D&mpfungsfeder3x22x26 avspring ressortamortisseur resorteamostiguador
Unsenschraube6x14 screw vis tomillo
SechskantmutterM6 nut _crou tuerca
Befe_tigungshaken,schwa_ plastichook,black crochet,noir leva,negro
Tragegust,kompl, shoulderstrap,compl, bretelle,compl, cinturonportador,compl.
Bdd-Nr
Pos-No
Pos-No
Fos-No
134
135
140
141
142
143
145
150
155
15G
160
161
BestelI-Nr
Order-No
No deCde
Ref-Nr
O062 144
2700340
0018275
O030 102
0094197
0044285
27 00 180
27 00376
20 73266
O062 127
05 10922
05 10923
Modell
Type
ModUle
Modelo
Menge
Quantity
Nombres
Cantldad
1
1
2
2
2
2
1
1
1
1
1
1
Motor/ Engine/ Moteur/ Motor/
Gebl_se Blower Housing Carter de Turbine Cajadel Ventilador
O-Rtng13x3 ring jointtorlque antllo
Benzinhahn,kompl fuelvalve,compl robtnetd'essence,compl grtfodegasohna,compl
Llnsenschraube5x30 screw vts torntllo
Schetbe5,3D[N9021A washer rondelle arandela
D_mpfungsgumrm7x13,5x7 shockabsorber stlentbloc gomaamorttguadora
Rohrntet8xO.75x7DIN7340A rivet rtvet remache
Tankverschlul3,kompl tankcap.compl bouchond'essence,compl cterrededep/asuto,compl
Benzmtank.kompl fueltank,compl r_servotrd'essence,compl deposrtodecombustible,compl
EmfGIItr[chter funnel entonnotrderemphssage embudodeIlenado
Dtchtrtng95xlO5x12,5 gasket jomtd'_tancMtt_ amllolunta
Reparatursatz-Vergaser repair_lt-carburetor kitder@aratJon-carburateur juegodereparation-carburador
Dtchtsatz-Vergaser gasket-bt-carburetor pochettedejoints-carburateurjuegodejuntas- carb.urador
11
Btld-Nr
Pos,_o
Pos-No
Pos-No
1
2
5
6
8
10
11
13
14
15
17
2O
21
,22
23
22
/
e_ 2 f._ J-J
f
/17
Modell Menge
Type Quanttty
.o ,e Nombs Starter Starter Lanceur Arranque
Modelo Canttdad
BestelI-Nr
Order-No
NodeCde
Ref-Nr
0018257
21O0534
O031527
2600256
2074288
0063152
2074403
2074388
6074294
0073364
2600255
2012726
O018338
4O7358O
0072141
Lmsenschraube5x25 screw vts tomtllo
5tartergeh_u_e starterhousing carterdelanceur carterdearranque
Schebe15,8x21,8xO,2xl,6 washer rondelle arandela
ROckzugfederka_et_e recoilspring ressortderappel resoleretroceso
_drofie starterpulley pouhedelanceur rddana
Startersed4x1050 starterrope cordedelanceur cuerdadearranque
Startergnff startergrip potgn6edelanceur empunadura
Kuhs_e template coulis_ cohsa
Starterkhnke starterpawl diquetdelanceur _nquete
Federstecker1,5 safetydip goupTl[e segum
Starter,kompl, starter,compl lanceur,compt, arranque,compl.
Ar,wurfrolle starterpulley podiedelancement rokbna :
ZylmderschraubeM5x25 scsew _ to_nillo'
Zwischenfiansch flange _inte_aaire bidaintennedia
Sd_eibe9,2x18xO,7DIN2093B washer, rondelle arandda
OWNER'S
MANUAL
MODEL NO.
360.796800
IF YOU NEED REPAIR
SERVICE OR PARTS:
REPAIR SERVICE
1-800-4-REPAIR
(1-800-473-7247)
ORDERING PARTS
1-800-FON-PART
(1-800-366-7278)
ERRFTSMRN°
4.5 HI), 2 CYCLE
54cc/3.3 cu. in.
229 MPH/589 CFM
BACKPACK AIR BLOWER
Each Backpack AirBlowerhas its ownsedal number
The modelnumberofthe AirBlowerwillbefoundon the BlowerHousing just
above the air filter The senal number _slocated in the same place.
All parts listedherein may be orderedthroughSears, Roebuckand Co. Service
Centersand mostRetailStores
WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING
INFORMATION:
PRODUCT-"BACKPACK AIR BLOWER"
MODEL NUMBER- 360 796800
SERIAL NUMBER
PART NUMBER
PART DESCRIPTION
Your Sears merchandisehas addedvalue whenyou considerthatSears has
servicecenters nationwidestaffedwith Searstrainedtechniciansspecifically
trainedon Sears products,havingthe parts,toolsand equipmenttoinsure that
we meet our pledgeto you,we servicewhatwe sell.
Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.
Part No. US9414100 Rev. 8/98
1 / 1

Craftsman 360.796800 Owner's manual

Category
Air blowers/dryers
Type
Owner's manual
This manual is also suitable for

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Ask the document