Craftsman 360.796800 Owner's manual

Brand: Craftsman

Model: 360.796800

Category: Air blowers/dryers

Type: Owner's manual

This manual is also suitable for

360796800

SEA/ S I

OWNER'S

MANUAL

MODEL NO.

360.796800

CAUTION:

READ AND FOLLOW

ALL SAFETY RULES

AND INSTRUCTIONS

BEFORE OPERATING

EQUIPMENT

CRRFTSHRN°

4.5 HP, 2 CYCLE

54cc/3.3 cu. in.

229 MPH/589 CFM

BACKPACK AIR BLOWER

• Assembly

•Operation

•Customer Responsibilities

•Service and Adjustments

•Repair Parts

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

WARNINGS AND SAFETY INSTRUCTIONS

TRAINING:

CAUTION: ALWAYS DISCONNECT SPARK PLUG WIRE AND PLACE WHERE IT CAN- A

NOT CONTACT SPARK PLUG TO PREVENT ACCIDENTAL STARTING WHEN sE'ITING _H_

uP, TRANSPORTING, ADJUSTING OR MAKING REPAIRS,

Read theoperator'smanual carefully• Become familiar

with the controls and know how to operate your air

blower propedy.

•Do not allow children to use your air blower. Never

allow adults to use air blower without proper instruc-

tions.

• Keep thearea of operationclear of all persons,

especially small children and pets.

• Use air blower only as the manufacturer intended

and as described in this manual.

• Do not operate air blower if it has been dropped or

damaged in any manner. Always have damage

repaired before using your air blower.

• Do not use accessory attachments that are not

recommended by the manufacturer. Use of such

attachments may be hazardous.

PREPARATION:

• Always wearsafety glasses or eye shields when

starting andwhileusing your air blower.

• Dress properly. Do not operate air blower when

barefoot or weadng open sandals. Wear only solid

shoes with good traction.

• Wear long-sleeved clothes that are snug fitting.

Avoid weadng loose clothing.

Wear either tightly cuffed or cuffless pants.

Wear heanng"protection even w_en working for a

short period of time. Rememberk_.hearingdamage is

cumulative.

•Wear protective, non-slipglovesfor saferoperation.

•Check fuel tankbeforestartingengine.Do notfillfuel

tank indoors,when theengineis runningorwhen the

engine ishot.Allowtheenginetocoolforseveral

minutesb0forefilling thefuel tank. Clear_offany

spilledgasolinebeforestartingtheengine.

•Always make edjustments beforestartingyourair

blower.Never attempt todo thiswhilethe engineis

running.

•Use onlyin daylightor goodartificiallight.

OPERATION

•Keep youreyes and mindo_ yourairblower and the

area being blown. Don't letotherinterestsdistract

yOU.

• Always be sure of yourfooting.Use.extracaution in

wet or slippery grass. Walk - Don't Run.

• Do not put hands or feet near rotating parts. Keep

clear of the nozzle opening at all times.

• Always stop the engine whenever you leave or are

not using your air blower.

• Never direct discharge of matedal toward bystand-

ers nor allow anyone near the air blower while you

are operating it.

• Before cleaning, inspecting, or repaidng your air

blower, stop the engine and make absolutely sure

all moving parts have stopped. Then disconnect the

wire and keep it away from the spark plug to

prevent accidental starting.

• Do not adjust carburetor. Overspeeding, engine

damage or personalinjury may result.

• Do not operate your air blower if itvibrates abnor-

mally. Excessive vibration is an indication of

damage; stop the engine, safely check for the

cause of vibration and repair as needed.

• Do not run the engine indoors. Exhaust fumes are

dangerous.

• Never operate your air blower without proper

guards,tubesor othersafety devices in ;)lace.

WA RN!NGCaliforniaProposition 65 I

The engine exhaust from this product contains I

chemicals known to the State ofCalifornia to cause I

cancer, birth defects or other reproductive harm. I

MAINTENANCE AND STORAGE:

• Check the enginemountingbolts oftento be sure

theyaretightenedpropedy.

•Check all bolts,nutsand screwsat frequent intervals

for propertightnesstobe sure air blowerisinsafe

workingcondition.

• Keep all safetydevicesin placeand working.

•To reducefire hazard,keep theenginefree ofdebds

and excessivegrease and oil.

•Allowengine tocoolbefore stodnginanyenclosure.

•Never storeair blowerwithfuel inthetankinsidea

buildingwherefumes may reach anopenflame or an

ignitionsourcesuch as hotwaterIleater, space

heater, clothesdryer,etc.

I_ LOOK FOR THIS SYMBOL,TO POINT OUT IMPORTANT SAFETY, PRECAUTIONS. 'I

IT MEANS- ATTENTION! I BECOME ALERTIII yOUR SAF_IS INVOLVED. :;i :iii, I

•'" " : _: r _!:'_ _" _ _'_.:_ _ ,._ ;'_.,'_*;_ i__'.: "_",'_" L:_:,_:_ _,_'-

CONGRATULATIONS on yourpurchaseofa Sears

BackpackAir Blower.It has been designed, engineered

and manufacturedto giveyouthe best possiblede-

pendabilityand performance.

Shouldyou experienceanyproblemyoucannoteasily

remedy,please contactyournearest SearsService

CenterDepartment.We havecompetentwell-trained

techniciansand the propertoolstoserviceorrepairthis

airblower.

Please read and retain thismanual.The instructionswill

enable you to assemble and maintain your air blower

)ropedy.Always observe the "SAFETY RULES".

MODEL NO. 360.796800

SERIAL NO.

DATE OF PURCHASE:

THE MODEL AND SERIAL NUMBERS WILL BE

FOUND ON A PLATE ON THE BLOWER HOUSING

ABOVE THE AIR FILTER. YOU SHOULD RECORD

BOTH SERIAL NUMBER AND DATEOF PURCHASE

AND KEEP IN A SAFE PLACE FOR FUTURE

REFERENCE.

MAINTENANCE AGREEMENT

A Searsmaintenanceagreementisavailableonthisair

blower.Contactyourneareststorefor details.

CUSTOMER RESPONSIBILITIES

= Read and observethe safety rules.

• Follow a regular schedule in maintaining, caring and

using your air blower.

• Follow the instructions under =CustomerResponsi-

bilities" and "Storage" sections of this manual.

PRODUCT SPECIFICATIONS

HORSEPOWER:

FUEL/OIL MIX CAPACITY:

FUEL/OIL MIX:

SPARK PLUG

(GAP .020 IN)

AIR VELOCITY:

AIR VOLUME:

MAXIMUM RPM:

DRY WEIGHT:

4.5

1.05 U.S. AT.

40:1

BOSCH WSR6F.

CHAMPION

RCJ-6Y

229 MPH

589 CFM

7300 RPM

17 LBS

WARNING: For userson U.S. ForestLandand in some

states, including California (Public Resources Codes

4442 and 4443), Idaho, Maine, Minnesota, New Jersey,

Oregon, and Washington: Certain internal combusi0n

engines operatedon forest,brush,and/or grass -

covered land in the above areas are required to be

equipped with a spark arrestor, maintained forthe

prevention of fire..Che_k with your state or local

authorities for regulations pertaining to these require-

ments. Failure to follow these requirements is a viola-

tion of the law. This unit is notfactory-equipped with a

spark arrestor; however; a spark arrestor is available

as an optional part. If a spark arrestor is required in

your area, contact your Sears Service Center or Parts

Department for Spark Arrestor #2048360. The spark

arrestor, blower tubes, and nozzles must be assembled

to the unit to be in full compliance with the regulations.

LIMITED ONE YEAR WARRAI_

For one (1) year fromtheclareof._urchaseiftheBackpackAirBlowerismaintained, lubdsatedand tunedup

accordingtothe instructionsin tl'_'owner'smanual,Sears willrepairor replace,free ofcharge,any partsfound to

be defectivein matedalor workmanship.Ifthisproductis usedcommercially,thiswarrantyonlyappliesfor90

days.

This Warranty does not cover:

• Expendable items which become wom dudng normal use, suchas spark plugsand air filters.

• Repairs necessarybecause of operator abuse, negligence, improper storage, accidentor the failure

to maintainthe equ pment according to the instructions contained in the owner's manual.

WARRANTY SERVICE ISAVAILABLE BY RETURNING THE AIR BLOWER TO THE NEAREST SEARS SER-

VICE CENTER IN THE UNITED STATES.

This warranty gives you specific legal rights, and you may also have other rightswhich may vary from state to

state.

SEARS, ROEBUCK AND CO., D/817 WA, HOFFMAN ESTATES, IL,60179

ACCESSORIES

These accessoriesand attachmentswereavadablewhen the unitwas originallypurchased.They are alsoavad-

able at mostSears retailoutletsand serv=cecenters MostSears storescanorderthese itemsforyou whenyou

providethe modelnumberofyourunit.

SPARK PLUG

GLOVES

2-CYCLE

AIR-COOLED

ENGINE OIL

SAFETY

GOGGLES

AIR FILTER

HEARING

PROTECTION

FUEL

STABILIZER

GAS CAN

CONTENTS OF CARTON

_,_1

Backpack Air Blower (1)

Straight Tube (1)

(Long With Felt) Straight Tube (1)

(Long)

Straight Tube (1)

(Short) Curved Nozzle Tube (1)

Elbow Hose (1)

CONTENTS OF HARDWARE PACKAGE

SEARS

OWNERS

MANUAL

MODEL NO.

360.796800

CRRFTSMRN"

4.5 HP_2 CYCLE

_mwu_ 54cr./3.3 ¢u. in.

_'_ _ 229 MP1"1/589 CFM

BACKPACK AIR BLOWER

.C)pmw_n

OWNER'S MANUAL (1)

METAL CLAMP

FOR ATTACHING ELBOW HOSE

TO BLOWER HOUSING (1)

FUEL FUNNEL (1)

PLASTIC CLAMP FOR

ATTACHING THRO'I'I'LE

HANDLE TO TUBE (2)

COMBINATION WRENCH

FOR ASSEMBLY

• AND ADJUSTMENTS (1)

ASSEMBLY

READ THESE INSTRUCTIONS AND THE OPERATING MANUAL IN ITS ENTIRETY BEFORE YOU A1-FEMPT

TO ASSEMBLE OR OPERATE YOUR NEW BACKPACK AIR BLOWER.

YOUR NEW BACKPACK AIR BLOWER HAS BEEN ASSEMBLED AT THE FACTORY EXCEPT FOR THE

BLOWER TUBE. ALL NECESSARY CLAMPS TO COMPLETE ASSEMBLY AS WELL AS A COMBINATION

WRENCH ARE INCLUDED INTHE PARTS BAG ENCLOSED WITH THE UNIT.

TO ENSURE SAFE AND PROPER OPERATION OF YOUR BACKPACK AIR BLOWER, ALL CLAMPS THAT

YOU INSTALL MUST BE TIGHTENED SECURELY.

HOW TO ASSEMBLE ._""

1. SlideMetal ClampontotheE!boc_vHose,then slidethe ElbowHose overthe BlowerDischargePort.Movethe

OblongClampagainstthe raisedsectionandtighten.(Fig.1)

Elbow Hose & Clamp Assembly

(Fig. 1)

ASSEMBLY (Cont...)

2. Slidethe twoRound Clampsovertheoutletend ofthe Elbow Hose. The nutsonthe Clamps shouldface away

from the operator. SlidetheStraightTube withthefelt coveredend intothe ElbowHose. PlacetheThrottle

HandleAssemblyon theend ofthe ElbowHose.The ThrottleHandleAssemblyshouldbe placedsuchthatthe

ignitionswitchfaces upand thethrottleleverfaces away from theblower. Move clampsoverthe metalsupport

of theThrottleHandleand tighten.PushtheThrottleCable intothe clipon the ElbowHose. (Fig, 2)

Mounting Throttle On Tube

(Fig. 2)

Round

Clamps

Straight Tube

(Long W/Felt)

Throttle

Handle

Assembly

a---"

Elbow

Hose

3. AttachCurved NozzleTube to theStraightTube and insert securely,(Fig. 3)

Blower Hose Assembly

(Fig. 3)

Elbow Hose Straight Tube Straight Tube

(With Felt) (ShortOr Long)

Curved Nozzle

Tube

OPERATION

KNOW YOUR BACKPACK AIR BLOWER

READ THIS OWNER'S MANUAL AND SAFETY INSTRUCTIONS BEFORE OPERATING YOUR BACKPACK AIR

BLOWER Compare the tllustratJonwtth your backpack air blower to famdtanze yourself with the location of vanous

controls and adjustments. Save thts manual for future reference.

Know Your Backpack Air Blower

(Fig. 4)

1. On/Off Switch - Turns Motor Off

2. Throttle Lever- Controls Engine Speed

3. Choke Lever -Placed In Down To Start, Up To Run.

4. Fuel Valve -Open (In Line With Fuel Line) To Run,

Closed For Storage & To Run Carburetor Dry,

5. Serial# Data Plate

6. Air Filter

7. Fuel Cap

8. Recoil Starter

9. Spark Plug

10. Muffler

t Start (I)_Stop (O) I

Throttle

Handle Throttle & Lever

Choke Lever

(Fig. 5)

OrdO_witch

Idle

Lever

OPERATION CONTINUED

HOW TO USE YOUR BACKPACK AIR BLOWER

To stop engine, move throttle lever to idle position and

turn switch to STOP.

,_ WARNING:

BE SURE TO READ THE FUEL HANDLING INFOR-

MATION IN THE SAFETY RULES SECTION ON

PAGE 2 OF THIS MANUAL BEFORE YOU BEGIN.

IF YOU DO NOT UNDERSTAND THE FUEL HAN-

DLING SECTION DO NOT AI-I'EMPT TO FUEL

YOUR UNIT; SEEK HELP FROM SOMEONE THAT

DOES UNDERSTAND THE FUEL HANDLING

SECTION OR CALL SEARS SERVICE AT 1-800-4-

REPAIR.

GASOLINE MIXTURE

The two-cycle engine on this product requires afuel

mixture of regular unleaded gasoline and a high quality

40:1 2-cycle engine oil (AIR-COOLED) for lubrication of

the bearings and other moving parts. The correct fuel/oil

mixture is 40:1 (see Fuel Mixture Chart). Too littleoil or

the incorrect oil type will cause poor performance and

may cause the engine to overheat and seize.

Gasoline and oil mustbe premixed in a clean approved

fuel container. Always use fresh regular unleaded

gasoline.

This engine iscertified to operate on unleaded gasoline.

IMPORTANT: Experience indicates that alcohol blended

fuels called gasohol (or using ethanol or methanol} can

attract moisture, which leads to oiVgas separationand

formation of acidsduringstorage.

Acidic gascandamage thefuelsystem ofan engine while

in storage. To avoid engine problems, the fuel system

should be emptied before storage for 30 days or longer.

Drain the gas tank, then run the fuel out of the carburetor

and fuel lines by startingtheengine and letting itrununtilit

stops. Use fresh fuel next season.See STORAGE instruc-

tions for additional information. Never use engine or car-

buretor cleaner products inthe fueltank or permanent dam-

age may occur.

FUEL STABILIZER

Fuel stabilizeris an acceptablealternativein minimizing

theformationoffuelgumdepositsduringstorage.Addsta-

bilizertogasolineinfueltankorstoragecontainer.Always

followthe fuel mix ratiofoundon the stabilizercontainer.

Run engine at least 5 minutesafter addingstabilizerto

allowthestabilizertoreachthecarburetor.Youdonothave

to drainthefuel tankfor storageifyouare usingfuelstabi-

lizer.

2-CYCLE OIL

CRAFTSMAN 40:1 2-cycle engine oil (AIR-COOLED) is

speciallyblended with fuel stabilizers.If you do not use

thisSears oil,youcan adda fuel stabilizer(suchas Crafts-

man No. 33500) to yourfuel mix. See =Gasoline and Oil

MixtureInstructions" below.

IfCRAFTSMAN 40:1 2-Cycle engineoil is not available;

usea goodquality40:1 2-cycleengineoil(AIR-COOLED)

that hasa recommendedfuel mix ratioof40:1.

OPERATION CONTINUED

IMPORTANTI DO NOT USE:

• AUTOMOTIVE OIL

•BOAT OILS (NMMA, BIA. ET,G)_'_.

These oilsdo not haveproperadd_ivesfor2-cycle

(AIR-COOLED) enginesand cah_:_useengine

damage.

GASOLINE AND OIL MIXTURE

MIX GASOLINE AND OIL AS FOLLOWS:

•Consultchartfor correctquantities.

•Do notmixgasolineand oildirectlyinthe fuel

tank.

FOR ONE GALLON:

•Pdur3.2 ouncesofhighquality,2-cycleengineoil

(AIR-COOLED] intoan empty,approved one gallon

gasolinecontainer.

•Addone gallonof regularunleadedgasolinetothe

galloncontainer, thensecurelyreplacethecap.

Shakethecontainermomentarily.

•The mixtureisnow readyfor use. Fuelstabilizer

canbe addedat thistimeifdesired;follow mixing

Instructionsonthe label.

FUEL MIXTURE CHART

I GASOLINE OIL I

1 Gallon 3.2 ounces

2.5 Gallons .8.0 ounces

STARTING COLD

1. Make surethat thefuelvalve isinthe openposition.

(lever inlinewiththe fuelline). (Fig.4)

2. Move switchto the Start(I) position.(Fig.5)

3. Set Throttle between the "to "position.(Fig. 5)

4. AdjustChoketo the Start(upward)position.

5. PullStarterCord slowlyuntilresistanceisfelt. Then

pullforcibly.

6. When enginecranks (attemptsto start)movechoke

leverto the RUN (down)positionand pullstarter.

STARTING -WARM

Followcoldstartinginstructionsbutleavechoke leverin

Rur_(down)position.

STOPPING

To stopengine, adjustThrottleto IDLEand switchto

STOP (0) positions.

CUSTOMER RESPONSIBILITIES

MAINTENANCE SCHEDULE

CHECK FOR LOOSE FASTENERS

SERVICE DATES

CUSTOMER RESPONSIBILITIES CONTINUED

GENERALRECOMMENDATIONS

The warrantyon thisatrblowerdoes notcover items

thathave been subjectedtooperatorabuseor negk-'

gence.To recetvefull value from thewarranty,opera-

tormustmaintainair bloweras inst,tucted mthis

manual

Allttemsin theCustomerRespondibditiessectionof

thtsmanualshouldbecheckedat leastonce each

season

1. Service moreoftenwhen operatmgin dustyor dirty

conditions.

2. Once a yearyou shouldreplacethe sparkplug and

clean or replacetheair filter. A newspark plugand

a clean airfilterassuresproperair-fuelmtxtureand

helpsyourengmerunbetterand lastlonger.

CHECK FOR LOOSE FASTENERS

Check all fasteners, includingnuts, bolts, screwsand

clamps,toinsurethattheyare tightand secure. Ifnot,

make necessaryadjustmentspriortousingatrblower.

AIR FILTER

Yourenginewillnotrun propenyano mayDedam-

aged byusinga dirtyair filter.

Replaceairfilterelement ifdeteriorationoccurs.

Service moreoftenIfyou useyourAirBlowerin very

dustyordirty conditions.

TO CLEAN AIR FILTER

1. Remove theair filter cover

2. Rinseair filter m a mddsoap& watersolutton.

3. Dryatrfilter completelyand otlslightlybyplacinga

small amount of otlon thefilter and kneedinguntd

completelysaturated.Wtpeoffexcessod. Reas-

sembleair filter

4. Replacea=rfilter element tfdeteriorating.

MUFFLER

Inspectand replacecorrodedmuffleras itcouldcreatea

fire hazardand/ordamage.

SPARK PLUG

Change yoursparkplugeach yeartomake yourengine

start easy and runbetter.Set sparkpluggap at .020".

CUSTOMER RESPONSIBILITIES CONTINUED

CARBURETOR ADJUSTMENT

To comply withemission regulations, the carburetor

mixture is pre-set at the factory and can not be ad-

justed The idle speed can be adjusted. The idle speed

set screwtslocated near the throttle cable on top of the

carburetor. To adjust idle speed'

•Loosenthe Iocknuton the idlespeedset screw•

•Starttheblowerand movethrottletoidleposition

•Adjustidlespeed todesiredspeed. (Clockwiseto

increase/counterclockwiseto decrease)

•Shut offblower

T=ghtenIocknut.

CarburetorAdJusmmt

I- FI- "11"="

FUEL FILTER

Clean fuel filter once everyseasontoensure goodfuel

flow to the carburetor. This makes the engine run better.

To clean: emptyfuel tank, remove fuel tank, remove fuel

valve from tank by unscrewing, flush filter in a mild soap

and water solution and dry before reassembly.

ENGINE CYLINDER COOLING FINS

IMPORTANT: For best performance,keepd=rtfrom

accumulatingaroundthe enginecoolingfins. Clogged

coohogfinscause theenginetorunhotterand shortens

its life Coolingfins maybe cleanedusinga toothbrush

or st(ffbristlebrush.

SPARK ARRESTOR SCREEN (If Installed)

1. Remove screen

2. Clean usinga wire brush and reinstall.

3Replace ifdeteriorating.

STORAGE

PrepareyourBackpackAir Blower for storageat the

end ofthe season or ifthe unit willnotbe usedfor 30

days or more

1. Usesoap and waterto wipedownunitpriorto

storage.

2. Besure thatall nuts,bolts,screwS'_ndfasteners are

securelyfastened. Inspectfor d_magedorworn

parts.Replaceif necessary.

3. Touch upall rustedor chippedpaintsurfaces,sand

lightlybefor_painting.

BLOWER TUBE

The straightblowertubescan be removedtoease

storage Use care notto=kink"the throttlecable.

ENGINE

FUEL SYSTEM - Itis importanttopreventgum depos-

itsfrom forming inessentialfuel systempartssuchas

thecarburetor, fuel filter, fuel hoseor tankduring

storage.Also,experienceindicatesthatalcohol blended

fuels (calledgasoholor usingethanolor methanol)can

attractmoisturewhzchleadsto separationand forma-

tionofacids duringstorage•Acidicgascan damage the

fuel systemofan enginewhileinstorage.

To avoidengine problems,thefuel systemshouldbe

emptiedbeforestorageof30 daysor longer.Follow

theseinstructions:

1. Drainthefuel tank.

2. Start engineand let Itrun untilthefuel lines and

ca_urator are empty(enginestops).

3. Usefresh gas nextseason.

4. Ifyou usefuel stabilizer,thegasolinecan be leftin

the tank. Remembertoturnthefuel shut-offvalveto

the offpositionand follow Step#2 above.

CYLINDER

1. Remove sparkplug.

2. Poura few dropsofoilintothe cylinder.

3. Pullstarterhandleslowlytodistributeoil.

4. Replacew_thnewsparkplug.

OTHER

• Do not storegasolinefromone season toanother.2-

cycle mixagesquicklyand cancauseengine

damage.

•Replace yourgasohnecan ifIt startsto rust.Rust

and/ordirtinyourgasolinewillcauseproblems.

•If possible,storeyourunItindoorsand coveritto

give itprotectionfromdustand d_rt.Do notuse

plastic.P.lasticcannot breathwh=chwdlallowcon-

densetionto formandwillcause yourunIttorust.

IMPORTANT: NEVER COVER AIR BLOWER WHILE

ENGINE AND MUFFLER ARE STILL WARM.

,_ CAUTION:

NEVER STORE YOUR AIR BLOWER INSIDE A

BUILDING WITH FUEL IN THE TANK. FUMES

CAN CONCENTRATE AND POSSIBLY REACH

•A SOURCE OF IGNmON. ALLOW ENGINE TO

COOL BEFORE STORAGE. ,-' .,. _

TROUBLE SHOOTING POINTS

PROBLEM CAUSE CORRECTION

ENGINE SMOKES 1. DirtyAir Filter 1. Cleanor ReplaceAirFilter

EXCESSIVELY 2. FuelMixtureIncorrect 2. Venfyyou have40"1 FuelMixture.

3. Carburetorrequires 3. See carburetorAdjustmentunderCustomerResponslbditle=

adjustment

ENGINE HARD TO

START, WILL NOT

START OR STARTS

AND ONLY RUNS A

FEW SECONDS

1. FuelTank Empty.

2. Engine Flooded.

3. Sparkplug notfinng.

4. DirtyAirFilter

5. Carburetorrequires

idle adjustment.

6 Stalefuel mixor water

in fuel mix

7. Spark plugwire

dasconnected

8. Switchin offposition.

f. Filltankwithcorrectfuel mix.

2. Remove andclean spark plug.Withsparkplugremoved

(engine switchedoff), crankengineafew timesto remove

excess fuel from cylinder.Reinstallsparkplug.

3 Check asfollows: Removesparkplugand reattachthe

spark plugtothe spark plugwire.Groundthe tipofthe

sparkplugagainstthe engineand pullstarterrecoilhandle.

A strongwhitespark shouldjumpacrosstheplugtip.If

there is nospark ora weak spark,trythe testwitha new

sparkplug.If a newspark plugdoes notsolvethe problem,

take the unittoa Sears ServiceCenter

4. Clean or replaceairfilter

5. See CarburetorAdjustmentunderCustomerResponsibilities

6. Draintankand refillwithfresh, cleanfuel mix.

7. Connectwire toplug.

8 Move switchtoRun position

ENGINE WILL NOT

ACCELERATE

LACKS POWER, OR

DIES UNDER A LOAD

1. Dirtyair filter. 1.

2. Spark plug fouled. 2.

3. (Optional) Spark 3.

Arrestor Screen Plugged.

4. Carburetor requires 4.

Adjustment.

Clean or replacefilter.

Clean or replacesparkplugand re-gap(0.020).

Clean or replacescreen.

See Carburetor AdjustmentunderCustomer Responsibilities

Sparepartslist

Page is loading ...

----___]

32 35

9Reparat uPsatz- Vergaser

Repair - kit - Carburetor

Kit de rf_paratlon - Carburateur

Juego de reparation - _rburadot

Dtdltsatz - Vergaser

Gasket÷klt-Carb_etor . ,

Pochettedeioir_- _r

160 1:6_I

BdcI.Nr

Pos-No,

Pos-No

100

101

102

103

104

105

106

108

110

111

112

113

114

115

11G

120

121

122

124

127

128

138

' 133

BestelI.Nr

O_der-No

NOdeCde

Ref-Fir

2048369

20O83O8

2500709

0072 140

0028 137

2300 747

2061 495

20 74913

40 35118

00 18338

2061 496

0015291

2100 456

0015158

20 61308

2500708

O018 207

0034100

0021 130

0028137

25 O0710

00 30125

00 72 143

0028100

00 30 125

0034201

00 10 175

23 O0730

0018188

2043 244

0033285

0018346

2048 357

2200812

2031 238F

0055144

2200 T/G

i0052206

;007s100

0031502

0050102

0054256

O018 389

25 00714

0030102

0018334

0084600

0073385

2300487

2300680

0084612

0084537

0072148

00 18328

O028118

0018311

0066441

0018348

4400281

4400211

4074805

4073602

4073601

0034115

00 21233

4400280

0010204

4074382

0018282

4073352

0018274

0064139

0062116

qoderl

ype

4od_le

_odelo

Merge

Quantity

Hombre

Canbde(

Motor/ Engine/ Moteur/ Motor/

Geblise Blower Housing Carterde Turbine Caja del Ventilador

F_ltereinsata filter element filtre&air elementofiltrante

Fitterplatte filterplate plaquedeltltre platadeftJtro

Luftiilter.kompl a_rfilter,compl ftltre,_air,compl flltro dealre,compl

"fellededer5,2x12xO,5DIN2093Aspringwasbor rondelleballevtlle resor_e

SechskantmutterMSDIN980 nut ecrou tuerca

VergaserWYJ-128 carburetorWYK-128 carburateurWYJ-128 carburadorWYJ-128

Vergaserdtchtung0,7mmdick carburetorgasket jomtdecarburateur juntadelcarburador

Vergaserstutzen manrfolri boded'arimtsslon bndadecarburador

Dtstanzrohr10xl,8xlO spacer entretolse tuboespacFador

Zyhnde_hrauboMSx25 screw vrs torntJlo

D_htungZyllnder-Vergaserstutzen_mder gasket jo=utd'admtss[on lunta

SttftschrauboM5x73 screw ws torndlo

Kurbolgeh+Zyhnder045mm,komplcrankcase+cybnder,complcartermoteuraveco/hndre ogGenal+ohndro,compl

SbftachrauboMSx15DIN835 screw ws tormllo

Auspuffdtchtung1,2mmdick mufflergasket jointd'_chappement juntadeescape

Auspuff muffler echappament escape

SechskantschrauboM5x16 screw vts torndio

Schnorrstcborung5 washer rondellecrant_ seguro

SechskantmutterM5 nut ecrou tuerca

SechskantmuttacMSDIN980 nut ecrou tuerca

Auspuffschutz mufflerguard caputprotechon_chappementpmtecc_ndelescape

_helbo 6.4DIN9021 washer rondelle arandela

Spannsicherungsschelbo6DING796A tensionwasher rondelledetension arandela

_.hskantmutter MG nut _crou tuerca

SchetboG,4DIN9021 washer rondelle acandela

S_lerungsr_elbo5 circhp rondelle_lasttque antlloorcltp

Zy[tnderschrauboM5xl0DIN84A screw vts torntllo

ZGndkerzeWSRGF200 sparkplug bougle bupa

SechskantschrauboM5x20 screw vts torntllo

Befestlgungswlnkel I_acket equerredefrxatton angulodefljaoon

Dtstanzst_ck6xlOxT,8 spacer eotretotse espactador

ZylinderschrauboMGx16 screw vts tornlllo

Kolbonnug45xl,5 pntonring segment antllodepiston

KolbonO45 mm piston piston piston

Kolbonbolzen10/6x32 pistonpin axedepiston boulondepiston

Kotbonbolzens_cheruegI0x0,8 pistonpincirchp dipd'axedeprston segurodebulon

Kurbelwelle3-teihg crankshaft vdebrequm ogOenal

Nadelk&fig10x13x14,5 needlebeanng roulement&atgmlles casqudlodeagujas

Scheibonfeder2x3,7DIN6_ woodruffkey clavet_edemvlune chaveta

PaBscheibo26xJTxlDIN988 washer rondelle arandela

RiIlenkugellager15_5xl1DIN6202 ballbearing roulement&brlles cojmetedebolas

Welle_kd_tring15x]5x5 oilseal JOintd'acbre retch

Zyli_dersdlrauboM5x45 screw vis torndlo

Hal_lNinkel angle equerredefixation angu]odefijaoon

Sche=bo5,3DIN9021A washer rondelle arandela

ZyhndersdlrauboM5xl0 screw vts torntllo

Kerzenstecker sparkplugcap capuchondebougm cabaruzabujta

Kontaktfeder contactspring ressortdecontact resortedecontacto

ZOndmodul =gnrttoncod bobmed'ailumage bobma

ZO_modul,kompl Ignittoncod,compl bobmeallumege,compl bobma,compl.

KurzschluBkabol,Spule,rot short-arcuitcable,red c_blecourt-orcult,rouge cablecortoorculto,rojo

Massekabol,schwarz groundcable,_ack c_bledemasse,notr cabledemase,negro

Spannscboibo4DIN67% tensionwasher rondelle d_scodeteost_

ZyhnderschrauboM4x25 s_ew vts torntllo

SechskantrnutterM4DIN980 nut _rou tuerca

Ltn_enschraubo6x14 screw vts torntilo

S_helle12J12 clamp collier abrazadera

ZyhnderschcauboM6x25 screw vts torntllo

GebBsegehEuso,grau blowerhousing,grey carterdeturbine,gns carterdeturbtna,gns

Magnet-LGfterrad,voll_nd=g fan+flywboefassemblyturbme+volantmagn_t_queruedaventdacion

Abde_kung cover re;ouvrement oJbterta

Zw_scbonflansch2,grau spacer2,grey bodemterr_ta=re 2,gns bndamtermedta2,grts

Zwlscbonflansch1,grau spacer1,grey brideintermkhaire1,gns bndaintermedta1,gns

$d_n_rrucborueg8 washer rondellecrant_ seguro

Sechskan_utterM8 nut ,k.rou tuerca

GebBsegeh_uso2,grau blowerhousing2,gr_=y carterdeturbme2,gris carterdeturbtna2,gris

ZyhnderschraubeM5x75DIN84A screw vts tornillo

Deckel,grau co_, grey oouverde,gris tapa,gns

bnsensch_aube5x45 screw ws torndlo

kuftdurchtritt aJrintake grilledeprotection pasodeaire

bnsonsch_auboSx16 screw _tomilln

Schlauch5xl,5 fue_hose .tuyaq :tubo,

O-Pa_9x2 nng .',jointtod_ue :an_lio

45 40 41

414SEARS-d/OT.98.tiff

Bild-Nr,

Pos.-No.

Pos.:No.

Pos,-No.

BestdI-Nn

Order-No.i

No;deCde.

Ref.-Ne

4071281

4065180

40G5173

O060159

0018340

0066399 i

0020160

4400204

O066662

4800187

2063128

0028121

2800338

28O0551

0064415R

O028110

4073644

0084477

6073567

O018356

0018364

0084704

0084703

4800199

Mndell

type

Mod61e

Mndelo

Blasrohr Straight tube Tube de soufflerie Tubo soplador

BlaskrOmmer elbow tubecoud_ codosoplador

Blasrohr60xl,3xSO0 stzaighttube tubedesoufflerie tubesoplador

Blasroh_P_rbindungsstGck60xl,3 straighttubeconnectiontubedesoufflerie conexiondetubo

Fil_ffage 50x195xl,5 feltspacer feutrine apoyodeflelvo

Zyli_j_.erschraubeMSx4O screw vis tomillo

Spah_schelJeGgxl0 clamp collierdeserrage abrazadera

VierkantmutterM5DIN557 nut PJou tuerca

Faltenschlauch pleatedhosew/elbow tuyausouple+coude tuboplegahle

Spannschelle60/80x9 metalclamp cdlierdeserrage abfazadera

Griffrohr22xlx140 handletube supportdepoign6e tube

KabeltQIle4xGRx3i6 grommet passe-ill manguitodecable

SechskantmottarMG nut _rou tuerca

Regulierbebel throttlelever manetted'acc_l_rateur palancadegas

Bewdenzug,Gas throttlecable,gas _ble d'acc61_rataur,gaz cablebowden,gas

Wellschlauch8,5 tube tube tubo

5echskantmuttarM5DIN980 nut _rou tuerca

Griff_lfte, innen griphalf poign_ext_rieure cascara

Kurzschlugschalter shortcircuitbutton interrupteur interruptor

Griffh_lfte,auSen griphalf poign_eext_rieure r._ara

LinsenschraubeM4x2O strew vis tomillo

ZylinderschraubeM5x32 screw vis tornillo

Kurzschlu6kabel,rot short<ircuitcable,red c,iblecourt<ircuitrouge cablecorcodrcuito,rojo

Massekabe],schwarz groundcable,black _ble demasse,noir cabledemasa,negro

Gdff,kompl, grip,compL poign_,compL cascara,€ompt.

Bild-Hr.

Pos.-No.

Pos...Ho.

Pos.,-No.

Bestell-Nr.

Order-No.

No.deCde.

Ref,-Nr.

4300273

4043998

5074562

0018258

0018344

4036414

0096151

4074962

O012161

O033375

O073363

O018311

0028121

O012172

O073363

O018311

0028121

4074833

4300334

Modell

TypeMod leTragegestell Frame Chassis Bastidor

Modelo

Me_e

Quant_

Nombres

_nti_d

Traggeste]l frame chassis bastidor

Haltewinkel topsupport _cluerredemaintien angulosoporte

Gdff,sd_warz handle,black poign_e,noir palanca,negro

.Unf_chraube 5x18 screw vis tornillo

°'_ind_rschraubeM6xl0 screw vis tornillo

._rtbefestigung shouldstrapdip crochetdebretelle fijacion

ROdmkissen backcushion coussindorsal almohadilla

Stopfen6xlTx18 cushionplug bo_'hon tapon

SechskantschraubeM6x2.SDIN933 screw vis tornillo

Distanzrohr12x2,8x10 spacer entretoise tube

DEmpfungsfeder3x22x26 avspring ressortamortisseur resorteamortiguador

t.imenschrau_6x14 screw vis tornirlo

SechskantmutterM6 nut _rou tuerca

SeshskantsdlraubeM6x16DIN933 screw vis tornillo

D&mpfungsfeder3x22x26 avspring ressortamortisseur resorteamostiguador

Unsenschraube6x14 screw vis tomillo

SechskantmutterM6 nut _crou tuerca

Befe_tigungshaken,schwa_ plastichook,black crochet,noir leva,negro

Tragegust,kompl, shoulderstrap,compl, bretelle,compl, cinturonportador,compl.

Bdd-Nr

Pos-No

Fos-No

134

135

140

141

142

143

145

150

155

15G

160

161

BestelI-Nr

Order-No

No deCde

Ref-Nr

O062 144

2700340

0018275

O030 102

0094197

0044285

27 00 180

27 00376

20 73266

O062 127

05 10922

05 10923

Modell

Type

ModUle

Modelo

Menge

Quantity

Nombres

Cantldad

Motor/ Engine/ Moteur/ Motor/

Gebl_se Blower Housing Carter de Turbine Cajadel Ventilador

O-Rtng13x3 ring jointtorlque antllo

Benzinhahn,kompl fuelvalve,compl robtnetd'essence,compl grtfodegasohna,compl

Llnsenschraube5x30 screw vts torntllo

Schetbe5,3D[N9021A washer rondelle arandela

D_mpfungsgumrm7x13,5x7 shockabsorber stlentbloc gomaamorttguadora

Rohrntet8xO.75x7DIN7340A rivet rtvet remache

Tankverschlul3,kompl tankcap.compl bouchond'essence,compl cterrededep/asuto,compl

Benzmtank.kompl fueltank,compl r_servotrd'essence,compl deposrtodecombustible,compl

EmfGIItr[chter funnel entonnotrderemphssage embudodeIlenado

Dtchtrtng95xlO5x12,5 gasket jomtd'_tancMtt_ amllolunta

Reparatursatz-Vergaser repair_lt-carburetor kitder@aratJon-carburateur juegodereparation-carburador

Dtchtsatz-Vergaser gasket-bt-carburetor pochettedejoints-carburateurjuegodejuntas- carb.urador

Btld-Nr

Pos,_o

Pos-No

,22

e_ 2 f._ J-J

/17

Modell Menge

Type Quanttty

.o ,e Nombs Starter Starter Lanceur Arranque

Modelo Canttdad

BestelI-Nr

Order-No

NodeCde

Ref-Nr

0018257

21O0534

O031527

2600256

2074288

0063152

2074403

2074388

6074294

0073364

2600255

2012726

O018338

4O7358O

0072141

Lmsenschraube5x25 screw vts tomtllo

5tartergeh_u_e starterhousing carterdelanceur carterdearranque

Schebe15,8x21,8xO,2xl,6 washer rondelle arandela

ROckzugfederka_et_e recoilspring ressortderappel resoleretroceso

_drofie starterpulley pouhedelanceur rddana

Startersed4x1050 starterrope cordedelanceur cuerdadearranque

Startergnff startergrip potgn6edelanceur empunadura

Kuhs_e template coulis_ cohsa

Starterkhnke starterpawl diquetdelanceur _nquete

Federstecker1,5 safetydip goupTl[e segum

Starter,kompl, starter,compl lanceur,compt, arranque,compl.

Ar,wurfrolle starterpulley podiedelancement rokbna :

ZylmderschraubeM5x25 scsew _ to_nillo'

Zwischenfiansch flange _inte_aaire bidaintennedia

Sd_eibe9,2x18xO,7DIN2093B washer, rondelle arandda

OWNER'S

MANUAL

MODEL NO.

360.796800

IF YOU NEED REPAIR

SERVICE OR PARTS:

REPAIR SERVICE

1-800-4-REPAIR

(1-800-473-7247)

ORDERING PARTS

1-800-FON-PART

(1-800-366-7278)

ERRFTSMRN°

4.5 HI), 2 CYCLE

54cc/3.3 cu. in.

229 MPH/589 CFM

BACKPACK AIR BLOWER

Each Backpack AirBlowerhas its ownsedal number

The modelnumberofthe AirBlowerwillbefoundon the BlowerHousing just

above the air filter The senal number _slocated in the same place.

All parts listedherein may be orderedthroughSears, Roebuckand Co. Service

Centersand mostRetailStores

WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING

INFORMATION:

•PRODUCT-"BACKPACK AIR BLOWER"

•MODEL NUMBER- 360 796800

•SERIAL NUMBER

•PART NUMBER

•PART DESCRIPTION

Your Sears merchandisehas addedvalue whenyou considerthatSears has

servicecenters nationwidestaffedwith Searstrainedtechniciansspecifically

trainedon Sears products,havingthe parts,toolsand equipmenttoinsure that

we meet our pledgeto you,we servicewhatwe sell.

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

Part No. US9414100 Rev. 8/98

Craftsman 360.796800 Owner's manual

Brand: Craftsman

Model: 360.796800

Category: Air blowers/dryers

Type: Owner's manual

This manual is also suitable for

360796800

Download PDF

report

Craftsman 360.796800 Owner's manual

This manual is also suitable for

Craftsman 360.796800 Owner's manual

Related papers

Other documents