Sea Ray 2008 215 WEEKENDER Owner's manual
- Type
- Owner's manual
Specific
Information
Manual
215 Weekender
Manual Part Number: MRP 1902268
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
215 Weekender i
Manual Part Number: MRP 1902268
215 WEEKENDER SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity..........................................................1
2. Passenger Locations ............................................... 1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances ................3
5. Function and Location of Through-Hull Cutouts ...... 4
6. Helm, Gauge & Switch Layout.................................5
7. Deck Layout.............................................................6
8. Mid Deck Layout, Cabin ..........................................7
9. Cleats ......................................................................8
10. Navigation and Anchor Lights ................................8
11. Bilge Layout ...........................................................9
12. Fuel Layout ............................................................ 9
A. Diesel Fuel System (Optional) ........................ 10
12. Fuel System......................................................... 11
13. Canvas ................................................................ 11
14. Entertainment System ......................................... 11
15. Electrical Schematic ............................................ 11
Information in this publication is based upon the latest product specifications available at printing. Sea
Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment,
specifications, materials and prices of all models, or to discontinue models. Should changes in production models
be made, Sea Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of
such changes.
Owner’s Manual
215 Weekender
Printed in the U.S.A. April 2007
© Sea Ray Boats, Inc. • A Brunswick Company
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
215 Weekender i
Manual Part Number: MRP 1902268
215 WEEKENDER SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity..........................................................1
2. Passenger Locations ............................................... 1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances ................ 3
5. Function and Location of Through-Hull Cutouts ...... 4
6. Helm, Gauge & Switch Layout.................................5
7. Deck Layout.............................................................6
8. Mid Deck Layout, Cabin .......................................... 7
9. Cleats ...................................................................... 8
10. Navigation and Anchor Lights ................................8
11. Bilge Layout ...........................................................9
12. Fuel Layout ............................................................ 9
A. Diesel Fuel System (Optional) ........................ 10
12. Fuel System......................................................... 11
13. Canvas ................................................................ 11
14. Entertainment System ......................................... 11
15. Electrical Schematic ............................................ 11
Information in this publication is based upon the latest product specifications available at printing. Sea
Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment,
specifications, materials and prices of all models, or to discontinue models. Should changes in production models
be made, Sea Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of
such changes.
Owner’s Manual
215 Weekender
Printed in the U.S.A. April 2007
© Sea Ray Boats, Inc. • A Brunswick Company
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
1
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
8
Ray
215 WE
Boats
820
kg
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or water
conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near boat,
or on swim platform or ladder.
! DANGER
Rear facing transom seats be used while engine is running
or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting something
in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring, mooring
or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and hold
on to rails or boat structure.
! WARNING
PASSENGER LOCATIONS
(Fig. 1.2)
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGNATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPATION DURING NORMAL
OPERATION)
215 Weekenderii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
1
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
8
Ray
215 WE
Boats
820
kg
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or water
conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near boat,
or on swim platform or ladder.
! DANGER
Rear facing transom seats be used while engine is running
or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting something
in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring, mooring
or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and hold
on to rails or boat structure.
! WARNING
PASSENGER LOCATIONS
(Fig. 1.2)
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGNATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPATION DURING NORMAL
OPERATION)
215 Weekenderii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
3
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
BOAT DIMENSIONS AND CLEARANCES
(Fig. 3.1)
17’ 11.5”
22’ 0”
8’ 6”
7’ 3 5/8”
1’ 5/8”
Length overall......................................22ft./6.71m
Height overall..........................6ft. 8 9/16in./2.05m
Water line to top of windshield....6ft. 7/16in./1.84m
Maximum beam...............................8ft. 6in./2.59m
Bow to transom/keel
intersection...........................20ft. 9.5in./6.34m
Draft (stern drive down).......................37”/94.0cm
(stern drive up)............................20”/50.8cm
Fuel capacity.............................50gal./189.3 Liters
Useable fuel...........................47.5gal./179.8Liters
Dead rise..........................................................19º
34”
FULL LOAD WATER LINE
6’ 8 9/16”
6’ 7/16”
NOTE: DIMENSIONS CAN
VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS
2
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(Fig. 2.1)
THIS TAG REPLACES DOMESTIC
CERTIFICATION TAG WHEN BOAT IS
ORDERED WITH CE INTERNATIONAL
OPTION
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
AVOID SERIOUS INJURY OR DEATH FROM CARBON MONOXIDE
EXHAUST FUMES FROM ENGINES CONTAIN CARBON MONOXIDE GAS
AND MAY COLLECT IN ENCLOSED AREAS
KEEP COCKPIT CABIN AND CABIN AREAS WELL VENTILATED. DO NOT
USE CANVAS, SIDE CURTAINS AND FORWARD VISOR WITHOUT
PROPER VENTILATION.
CO SICKNESS SYMPTIONS INCLUDE HEADACHE, NAUSEA, AND DIZZINESS.
DO NOT MISTAKE FOR SEASICKNESS.
MRP 1369743 SR-246
DANGER
!
!
MRP 811000 SR-102
DANGER
!
TRANSOM DOOR MUST BE
CLOSED AND SECURE WHEN
ENGINE IS RUNNING
MRP 1112879 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR
DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP 852525 SR-111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 852533 SR-119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOSIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
IF SWITCH IS TURNED OFF WHILE
ENGINE IS RUNNING ALTERNATOR
WILL BE DAMAGED.
MRP # 921767 SR-167
ON BATTERY SWITCH PANEL
ON AFT WALL OF PORT STORAGE
CAUTION
!
MAXIMUM CAPACITIES
8 PERSONS OR 1400 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY * COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS * BASIC FLOATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 215WE
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
DO NOT STAND OR WALK ON
TH IS AREA SERIOU S INJURY
COULD RESULT.
MRP # 113562 SR-216
DANGER
!
12VDC-15A MAX
MRP # 324756 SR-47
LEAKING FUEL IS A FIRE AND EXPLO-
SION HAZARD, INSPECT SYSTEM
REGULARY. EXAMINE FUEL TANKS
FOR LEAKS OR CORROSION AT LEAST
ANNUALLY.
MRP 852632 SR-151
WARNING
!
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
!
PREVENT THE DISCHARGE OF POLLUTANTS
DISCHARGE OF OIL OR OILY WASTE INTO NAVIGABLE WATERS IS
PROHIBITED OF SUCH A DISCHARGE CAUSES A FILM, SHEEN OR
A DISCOLORATION OF THE SURFACE, OR CAUSES A SLUDGE
OR EMULSION BENEATH THE SURFACE OF THE WATER.
VIOLATORS ARE SUBJECT TO PENALITIES.
MRP # 934539 SR-166
INSIDE ENGINE BOX
Save Our Seas
(See next page)
MRP # 532820 SR-61
LOCATED UNDER TOP STEP TO CABIN.
LIFT STEP TO ACCESS
AUTOMATIC EXTINGUISHER SYSTEM
LIGHT ON-UNIT CHARGE/LIGHT OFF-UNIT DISCHARGED.
IF SYSTEM DISCHARGED, SHUTDOWN ENGINE, BLOWER, AND ELECTRICAL SYSTEM
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH
BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR GASLINE OR VAPORS. OPERATE
BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION, RUN BLOWER WHEN VESSEL
OPERATING BELOW CRUISING SPEED
! WARNING
(MRP NUMBER LOCATED IN PARTS MANUAL)
MAXIMUM
0609
IMCI
Sea
8
Ray
215 WE
Boats
820
kg
! DANGER
! WARNING
CARBON MONOXIDE CAN BE FATAL In all gasoline powered boats, engine exhaust systems
produce colorless, odorless carbon monoxide gas (’CO’) Direct prolonged exposure can result in
CO poisoning which may be harmful or fatal. to prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through utilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO ‘CO’ CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
Operation at slow speeds or dead in water. Utilization of canvas tops, side curtains or back curtains.
Any blockage of hull exhaust outlets.
Operation with a high bow angle attitude. Operation of engines and/or generator in confined spaces or at dockside.
Contributing climatic conditions, such as headwind.
AVOID RISK OF INJURY OR DEATH. SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”. Visibility can be limited
by high boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
3
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
BOAT DIMENSIONS AND CLEARANCES
(Fig. 3.1)
17’ 11.5”
22’ 0”
8’ 6”
7’ 3 5/8”
1’ 5/8”
Length overall......................................22ft./6.71m
Height overall..........................6ft. 8 9/16in./2.05m
Water line to top of windshield....6ft. 7/16in./1.84m
Maximum beam...............................8ft. 6in./2.59m
Bow to transom/keel
intersection...........................20ft. 9.5in./6.34m
Draft (stern drive down).......................37”/94.0cm
(stern drive up)............................20”/50.8cm
Fuel capacity.............................50gal./189.3 Liters
Useable fuel...........................47.5gal./179.8Liters
Dead rise..........................................................19º
34”
FULL LOAD WATER LINE
6’ 8 9/16”
6’ 7/16”
NOTE: DIMENSIONS CAN
VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS
2
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(Fig. 2.1)
THIS TAG REPLACES DOMESTIC
CERTIFICATION TAG WHEN BOAT IS
ORDERED WITH CE INTERNATIONAL
OPTION
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
AVOID SERIOUS INJURY OR DEATH FROM CARBON MONOXIDE
EXHAUST FUMES FROM ENGINES CONTAIN CARBON MONOXIDE GAS
AND MAY COLLECT IN ENCLOSED AREAS
KEEP COCKPIT CABIN AND CABIN AREAS WELL VENTILATED. DO NOT
USE CANVAS, SIDE CURTAINS AND FORWARD VISOR WITHOUT
PROPER VENTILATION.
CO SICKNESS SYMPTIONS INCLUDE HEADACHE, NAUSEA, AND DIZZINESS.
DO NOT MISTAKE FOR SEASICKNESS.
MRP 1369743 SR-246
DANGER
!
!
MRP 811000 SR-102
DANGER
!
TRANSOM DOOR MUST BE
CLOSED AND SECURE WHEN
ENGINE IS RUNNING
MRP 1112879 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR
DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP 852525 SR-111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 852533 SR-119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOSIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
IF SWITCH IS TURNED OFF WHILE
ENGINE IS RUNNING ALTERNATOR
WILL BE DAMAGED.
MRP # 921767 SR-167
ON BATTERY SWITCH PANEL
ON AFT WALL OF PORT STORAGE
CAUTION
!
MAXIMUM CAPACITIES
8 PERSONS OR 1400 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY * COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS * BASIC FLOATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 215WE
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
DO NOT STAND OR WALK ON
TH IS AREA SERIOU S INJURY
COULD RESULT.
MRP # 113562 SR-216
DANGER
!
12VDC-15A MAX
MRP # 324756 SR-47
LEAKING FUEL IS A FIRE AND EXPLO-
SION HAZARD, INSPECT SYSTEM
REGULARY. EXAMINE FUEL TANKS
FOR LEAKS OR CORROSION AT LEAST
ANNUALLY.
MRP 852632 SR-151
WARNING
!
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
!
PREVENT THE DISCHARGE OF POLLUTANTS
DISCHARGE OF OIL OR OILY WASTE INTO NAVIGABLE WATERS IS
PROHIBITED OF SUCH A DISCHARGE CAUSES A FILM, SHEEN OR
A DISCOLORATION OF THE SURFACE, OR CAUSES A SLUDGE
OR EMULSION BENEATH THE SURFACE OF THE WATER.
VIOLATORS ARE SUBJECT TO PENALITIES.
MRP # 934539 SR-166
INSIDE ENGINE BOX
Save Our Seas
(See next page)
MRP # 532820 SR-61
LOCATED UNDER TOP STEP TO CABIN.
LIFT STEP TO ACCESS
AUTOMATIC EXTINGUISHER SYSTEM
LIGHT ON-UNIT CHARGE/LIGHT OFF-UNIT DISCHARGED.
IF SYSTEM DISCHARGED, SHUTDOWN ENGINE, BLOWER, AND ELECTRICAL SYSTEM
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH
BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR GASLINE OR VAPORS. OPERATE
BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION, RUN BLOWER WHEN VESSEL
OPERATING BELOW CRUISING SPEED
! WARNING
(MRP NUMBER LOCATED IN PARTS MANUAL)
MAXIMUM
0609
IMCI
Sea
8
Ray
215 WE
Boats
820
kg
! DANGER
! WARNING
CARBON MONOXIDE CAN BE FATAL In all gasoline powered boats, engine exhaust systems
produce colorless, odorless carbon monoxide gas (’CO’) Direct prolonged exposure can result in
CO poisoning which may be harmful or fatal. to prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through utilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO ‘CO’ CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
Operation at slow speeds or dead in water. Utilization of canvas tops, side curtains or back curtains.
Any blockage of hull exhaust outlets.
Operation with a high bow angle attitude. Operation of engines and/or generator in confined spaces or at dockside.
Contributing climatic conditions, such as headwind.
AVOID RISK OF INJURY OR DEATH. SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”. Visibility can be limited
by high boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
5
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
HELM GAUGE AND DASH LAYOUT
(Fig. 5.1)
E
F
Fuel
VDC
10
12
14
16
0
20
30
40
50
60
65
MPH
kp/h
0
100
50
20
80
Down
Up
Trim
0
1
2
3
4
5
6
RPM
X1000
0
00
0 0
HOURS
0
80
PS/kps
40
20
60
100
130
140
180
o
F/
o
C
220
170
AUTOMATIC EXTINGUISHING SYSTEM
LIGHT ON - UNIT CHARGED/LIGHT OFF - UNIT DISCHARGED
IF SYSTEM DISCHARGES, SHUT DOWN ENGINE, BLOWER
AND ELECTRICAL SYSTEM.
!
WARNING
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEAT H
BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR
GASOLINE OR VAPORS, OPERATE BLOWER FOR FOUR MINUTES,
AND VERIFY BLOWER OPERATION, RUN BLOWER
WHEN VESSEL IS OPERATING BELOW CRUISING SPEED.
TRIM TAB SWITCH
(OPTION)
GAUGE PANEL
SWITCH PAD
ENGINE MONITOR PANEL
(DIESEL OPTION)
STEREO REMOTE
DEPTH SOUNDER
(OPTION)
IGNITION SWITCH WITH AUTOMATIC FIRE
EXTINGUISHER LIGHT AND INFORMATION
12 VOLT
RECEPTACLE
FUEL
GAUGE
VOLTMETER
SPEEDOMETER
OUTDRIVE
TRIM GAUGE
TACHOMETER
OIL
PRESSURE
WATER
TEMPERATURE
4
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(Fig. 4.1)
PORT THROUGH-HULL CUTOUTS
(Fig. 4.2)
BILGE THROUGH-HULL CUTOUTS
(Fig. 4.3)
TRANSOM THROUGH-HULL CUTOUTS
(Fig. 4.4)
BILGE PUMP
ROPE LOCKER
DRAIN
COOLER DRAIN
TRANSDUCER
(OPTION)
GARBOARD DRAIN
5
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
HELM GAUGE AND DASH LAYOUT
(Fig. 5.1)
E
F
Fuel
VDC
10
12
14
16
0
20
30
40
50
60
65
MPH
kp/h
0
100
50
20
80
Down
Up
Trim
0
1
2
3
4
5
6
RPM
X1000
0
00
0 0
HOURS
0
80
PS/kps
40
20
60
100
130
140
180
o
F/
o
C
220
170
AUTOMATIC EXTINGUISHING SYSTEM
LIGHT ON - UNIT CHARGED/LIGHT OFF - UNIT DISCHARGED
IF SYSTEM DISCHARGES, SHUT DOWN ENGINE, BLOWER
AND ELECTRICAL SYSTEM.
!
WARNING
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEAT H
BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR
GASOLINE OR VAPORS, OPERATE BLOWER FOR FOUR MINUTES,
AND VERIFY BLOWER OPERATION, RUN BLOWER
WHEN VESSEL IS OPERATING BELOW CRUISING SPEED.
TRIM TAB SWITCH
(OPTION)
GAUGE PANEL
SWITCH PAD
ENGINE MONITOR PANEL
(DIESEL OPTION)
STEREO REMOTE
DEPTH SOUNDER
(OPTION)
IGNITION SWITCH WITH AUTOMATIC FIRE
EXTINGUISHER LIGHT AND INFORMATION
12 VOLT
RECEPTACLE
FUEL
GAUGE
VOLTMETER
SPEEDOMETER
OUTDRIVE
TRIM GAUGE
TACHOMETER
OIL
PRESSURE
WATER
TEMPERATURE
4
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(Fig. 4.1)
PORT THROUGH-HULL CUTOUTS
(Fig. 4.2)
BILGE THROUGH-HULL CUTOUTS
(Fig. 4.3)
TRANSOM THROUGH-HULL CUTOUTS
(Fig. 4.4)
BILGE PUMP
ROPE LOCKER
DRAIN
COOLER DRAIN
TRANSDUCER
(OPTION)
GARBOARD DRAIN
7
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
8. MID DECK LAYOUT, CABIN
CABIN LAYOUT
(Fig. 7.1)
STBD NAVIGATION
LIGHT
PORT NAVIGATION
LIGHT
HEAD
(OPTION)
ANCHOR STORAGE
LOCKER
CONVERTIBLE
DINETTE
SLEEPER SOFA
ICE BUCKET
! DANGER
Sleeping on boat requires an operating
Carbon Monoxide detection system in
each sleeping location.
6
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(Fig. 6.1)
STBD NAVIGATION
LIGHT
PORT NAVIGATION
LIGHT
ENGINE BOX
HELM SEAT WITH
FLIP UP THIGH RISE
BOLSTER
ANCHOR STORAGE
LOCKER
LADDER
WASTE PUMPOUT
PLATE
(OPTIONAL)
SLIDING CABIN
DOOR WITH
INTEGRAL STEPS
DECK
HATCH
FORWARD/AFT
FACING
COMPANION SEAT
WALK-THROUGH
WINDSHIELD
FUEL FILL
ACCESS PLATE TO
FUEL TANK SENDING
UNIT
FLOOR STORAGE
SKI TOW
7
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
8. MID DECK LAYOUT, CABIN
CABIN LAYOUT
(Fig. 7.1)
STBD NAVIGATION
LIGHT
PORT NAVIGATION
LIGHT
HEAD
(OPTION)
ANCHOR STORAGE
LOCKER
CONVERTIBLE
DINETTE
SLEEPER SOFA
ICE BUCKET
! DANGER
Sleeping on boat requires an operating
Carbon Monoxide detection system in
each sleeping location.
6
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(Fig. 6.1)
STBD NAVIGATION
LIGHT
PORT NAVIGATION
LIGHT
ENGINE BOX
HELM SEAT WITH
FLIP UP THIGH RISE
BOLSTER
ANCHOR STORAGE
LOCKER
LADDER
WASTE PUMPOUT
PLATE
(OPTIONAL)
SLIDING CABIN
DOOR WITH
INTEGRAL STEPS
DECK
HATCH
FORWARD/AFT
FACING
COMPANION SEAT
WALK-THROUGH
WINDSHIELD
FUEL FILL
ACCESS PLATE TO
FUEL TANK SENDING
UNIT
FLOOR STORAGE
SKI TOW
9
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
11. BILGE LAYOUT
12. FUEL LAYOUT
BILGE LAYOUT
(Fig. 9.1)
A
H
G
F
E
D
C
B
A Trim Tab Pump (Optional)
B Fire Extinguisher (Optional)
C Bilge Blower
D Trim Pump
E Battery (Optional)
F Battery
G Diesel Fuel Filter (Diesel option)
H Fuel Tank
I Bilge Pump and Float Switch
I
STANDARD FUEL SYSTEM
FUEL FILL
HOSE
FUEL TANKFUEL VENT
HOSE
ENGINE FUEL
FEED
FUEL VENT
DANGER
NOTICE
FUEL
FILL CAP
FUEL FILL
(Fig. 9.2)
8
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
9. CLEATS
Cleats must not be used for lifting the boat; they are
intended for docking or mooring use only.
CLEAT LOCATIONS
(Fig. 8.1)
10. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
B
EXTERIOR LIGHTS
A
A
B
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
A
PORT/STBD
NAV. LIGHT
(Fig.8.2)
STERN NAVIGATION/
ANCHOR LIGHT
(REMOVABLE)
9
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
11. BILGE LAYOUT
12. FUEL LAYOUT
BILGE LAYOUT
(Fig. 9.1)
A
H
G
F
E
D
C
B
A Trim Tab Pump (Optional)
B Fire Extinguisher (Optional)
C Bilge Blower
D Trim Pump
E Battery (Optional)
F Battery
G Diesel Fuel Filter (Diesel option)
H Fuel Tank
I Bilge Pump and Float Switch
I
STANDARD FUEL SYSTEM
FUEL FILL
HOSE
FUEL TANKFUEL VENT
HOSE
ENGINE FUEL
FEED
FUEL VENT
DANGER
NOTICE
FUEL
FILL CAP
FUEL FILL
(Fig. 9.2)
8
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
9. CLEATS
Cleats must not be used for lifting the boat; they are
intended for docking or mooring use only.
CLEAT LOCATIONS
(Fig. 8.1)
10. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
B
EXTERIOR LIGHTS
A
A
B
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
A
PORT/STBD
NAV. LIGHT
(Fig.8.2)
STERN NAVIGATION/
ANCHOR LIGHT
(REMOVABLE)
11
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
14. ENTERTAINMENT SYSTEM
The 12 volt AM/FM radio single CD satellite ready
stereo. The system includes four (4) water proof
speakers, an optional digital remote control is
located at the control station.
15. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
®
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
®
dealer for service. Sea Ray
®
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
13. CANVAS
The following canvas pieces are available individually
as options:
• Sunbrella® Bimini Top w/ Boot
• Canvas Cockpit Cover w/ storage Bag
• Canvas Hatch Cover
12. FUEL SYSTEM
The 215 Weekender standard gasoline fuel system
consists of a 50 gallon (189.3 liter) fuel tank, fuel
tank vent, anti-siphon valve, engine fuel supply line
and fuel fill.
10
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
A. DIESEL FUEL SYSTEM (OPTIONAL)
An optional diesel fuel system is available and
consists of a 50 gallon fuel tank, fuel tank vent,
shut-off valve, engine fuel supply and return line,
fuel filter and fuel fil.
FUEL VENT
HOSE
FUEL RETURN
HOSE
FUEL HOSE ROUTING (DIESEL OPTION)
(Fig. 10.1)
FUEL FEED
HOSE
FUEL
FILTER
FUEL
TANK
FUEL
FILL
11
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
14. ENTERTAINMENT SYSTEM
The 12 volt AM/FM radio single CD satellite ready
stereo. The system includes four (4) water proof
speakers, an optional digital remote control is
located at the control station.
15. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
®
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
®
dealer for service. Sea Ray
®
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
13. CANVAS
The following canvas pieces are available individually
as options:
• Sunbrella® Bimini Top w/ Boot
• Canvas Cockpit Cover w/ storage Bag
• Canvas Hatch Cover
12. FUEL SYSTEM
The 215 Weekender standard gasoline fuel system
consists of a 50 gallon (189.3 liter) fuel tank, fuel
tank vent, anti-siphon valve, engine fuel supply line
and fuel fill.
10
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
A. DIESEL FUEL SYSTEM (OPTIONAL)
An optional diesel fuel system is available and
consists of a 50 gallon fuel tank, fuel tank vent,
shut-off valve, engine fuel supply and return line,
fuel filter and fuel fil.
FUEL VENT
HOSE
FUEL RETURN
HOSE
FUEL HOSE ROUTING (DIESEL OPTION)
(Fig. 10.1)
FUEL FEED
HOSE
FUEL
FILTER
FUEL
TANK
FUEL
FILL
215 Weekender 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
1. ELECTRICAL SCHEMATICS
DC WIRING INFORMATION (1 OF 2)
(FIG 13.1)
12
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
215 Weekender 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
1. ELECTRICAL SCHEMATICS
DC WIRING INFORMATION (1 OF 2)
(FIG 13.1)
12
215 WEEKENDER OWNERS MANUAL
215 Weekender
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
215 Weekender 15
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC WIRING DIAGRAM (VOLVO D3)
(FIG. 15.1)
ELECTRICAL SCHEMATICS (CONTINUED)
215 Weekender14
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS (CONTINUED)
DC WIRING DIAGRAM (2 OF 2)
(FIG. 14.1)
215 Weekender 15
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC Wi r i n g Di a g r a m (Vo l V o D3)
(Fi g . 15.1)
El E c t r i c a l Sc h E m a t i c S (co n t i n u E d )
215 Weekender16
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS (CONTINUED)
DC WIRING DIAGRAM (VOLVO D3)
(FIG. 16.1)
Index i215 Weekender
Manual Part Number: MRP 1902268
INDEX
A
Anchor Lights...............................................................8
B
Bilge Layout ................................................................. 9
C
Canvas ...................................................................... 11
Clearances .................................................................. 3
Cleats .......................................................................... 8
D
Deck Layout.................................................................7
Dimensions .................................................................. 3
E
Electrical Schematics ................................................ 11
F
Fuel System............................................................... 11
G
Gauge Layout .............................................................. 5
H
Helm Layout ................................................................ 5
L
Load Capacity..............................................................1
N
Navigation Lights ......................................................... 8
P
Passenger Locations ................................................... 1
R
Rear Facing Lounger ................................................... 9
S
Safety Label Locations ................................................2
Switch Layout ..............................................................5
T
Through-Hull Cutouts .................................................. 4
Page is loading ...
Page is loading ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
Sea Ray 2008 215 WEEKENDER Owner's manual
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Sea Ray 2008 225 WEEKENDER Owner's manual
-
-
-
-
-
-
-
-
-