Safety, Operation, & Maintenance Manual
WARNING
Warning: If incorrectly used, this machine can
cause severe injury. Those who use and maintain
this machine should be trained in its proper use,
warned of its dangers, and must read the entire
manual before attempting to set up, operate, adjust,
or service the machine.
When Performance Matters.
™
GB
Greens King IV Plus with ROPS
62379G01 – Kubota D722-E4B Engine
4212747-Rev D
2
This manual contains safety and operating instructions
for your new Jacobsen machine. This manual should be
stored with the equipment for reference during operation.
Before you operate your machine, you and each operator
you employ should read the manual carefully in its
entirety. By following the safety, operating, and
maintenance instructions, you will prolong the life of your
equipment, and maintain its maximum efficiency.
If additional information is needed, contact your
Jacobsen Dealer.
The serial plate is attached to the frame, near the battery.
Jacobsen recommends you record these numbers below
for easy reference.
1451 MARVIN GRIFFIN RD, AUGUSTA, GA, U.S.A.
PRODUCT OF THE U.S.A. WWW.JACOBSEN.COM
®
kg kW
1-800-848-1636 (US)
FOREWORD
1 CONTENTS
8-2018
© 2018 Textron Specialized Vehicles
This manual may not re reproduced in whole or in part without the express permission of TSV (Augusta) Technical Communications
Department.
CALIFORNIA PROPOSITION 65
WARNING
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects and other reproductive harm.
!
CONTENTS 1
3
1CONTENTS
2SAFETY
2.1How to Operate Safely ............................................. 4
2.2 Important Safety Notes ........................................ 7
3 SPECIFICATIONS
3.1 Product Identification ........................................... 8
3.2 Engine ................................................................. 8
3.3 Cutting Units ........................................................ 8
3.4 Mower .................................................................. 9
3.5 Weights and Dimensions ..................................... 9
3.6 Accessories & Support Literature ........................ 9
3.7 Declaration of Conformity .................................. 10
3.8 Vibration Level ................................................... 13
4DECALS
4.1 Decals................................................................ 14
5 CONTROLS
5.1 Icons .................................................................. 19
5.2 Control Descriptions .......................................... 21
6 OPERATION
6.1 Daily Inspection ................................................. 22
6.2 Interlock System ................................................ 22
6.3 Operating Procedures ....................................... 23
6.4 Starting .............................................................. 24
6.5 Stopping / Parking ............................................. 24
6.6 To Drive / Transport ........................................... 25
6.7 Hillside Operation .............................................. 25
6.8 Mowing .............................................................. 27
6.9 Towing / Trailering ............................................. 28
6.10 Daily maintenance ............................................. 29
7 MAINTENANCE & LUBRICATION CHARTS
7.1 General.............................................................. 30
7.2 Lubrication Chart ............................................... 30
7.3 Maintenance Charts .......................................... 31
8 MAINTENANCE
8.1 General.............................................................. 32
8.2 Engine ............................................................... 32
8.3 Engine Oil .......................................................... 33
8.4 Diesel Air Filter .................................................. 33
8.5 Fuel .................................................................... 34
8.6 Fuel System ....................................................... 34
8.7 Battery ............................................................... 34
8.8 Jump Starting .................................................... 35
8.9 Charging Battery ................................................ 35
8.10 Hydraulic Hoses ................................................ 36
8.11 Hydraulic Oil ...................................................... 36
8.12 Hydraulic Oil Filters ........................................... 37
8.13 Electrical System ............................................... 37
8.14 Muffler And Exhaust .......................................... 37
8.15 Tires ................................................................... 37
8.16 Wheel Mounting Procedure ............................... 38
8.17 Roll Over Protective Structure (ROPS) ............. 38
8.18 Care And Cleaning ............................................ 38
8.19 Radiator ............................................................. 39
8.20 Backlapping ....................................................... 39
8.21 Grinding Bedknife .............................................. 40
8.22 Storage .............................................................. 40
9 ADJUSTMENTS
9.1 General .............................................................. 41
9.2 Bedknife-To-Reel ............................................... 41
9.3 Bedknife Adjustment .......................................... 42
9.4 Cutting Height .................................................... 42
9.5 Bedknife Adjuster Spring ................................... 43
9.6 Bedknife Adjuster Tension ................................. 43
9.7 Antisway Spring ................................................. 43
9.8 Accelerator Pedal .............................................. 44
9.9 Brake Pedal ....................................................... 44
9.10 Parking Brake .................................................... 44
9.11 Interlock Switches .............................................. 45
9.12 Traction Lever .................................................... 45
9.13 Reel Control ....................................................... 45
9.14 Reel Switches .................................................... 46
9.15 Leveling Procedure ............................................ 46
9.16 Reel Bearing ...................................................... 46
9.17 Fan Belt ............................................................. 47
9.18 Lift Cylinders ...................................................... 47
9.19 Specific Torque Requirements .......................... 47
9.20 Torque Specification .......................................... 49
10 PROBLEM SOLVING
10.1 General .............................................................. 50
11 QUALITY OF CUT
11.1 Quality Of Cut Troubleshooting ......................... 51
11.2 Washboarding .................................................... 51
11.3 Marcelling .......................................................... 52
11.4 Step Cutting ....................................................... 53
11.5 Scalping ............................................................. 54
11.6 Stragglers .......................................................... 55
11.7 Streaks............................................................... 56
11.8 Windrowing ........................................................ 57
11.9 Rifling Or Tramlining .......................................... 58
11.10 Mismatched Cutting Units .................................. 58
12 NOTES
2 SAFETY
4
2 SAFETY
2.1 HOW TO OPERATE SAFELY
SAFE OPERATION
a Read the Operator’s Manual and other training
material. If the operator or technician can not read
this manual, the owner is responsible to describe
this material to the operators and technicians.
Manuals in additional languages may be available
on the Jacobsen or RansomesJacobsen website.
a Read all of the instructions for this mower carefully.
Know the controls and the correct operation of the
equipment.
b Children or persons who do not understand these
instructions must not use the mower. The local
regulations can limit the age of the operator.
c Never use a mower near persons, including
children or animals.
d Remember that the operator or owner is
responsible for accidents or hazards that occur to
other persons or their property.
e Never carry passengers.
f Never allow persons to operate or service the
mower or its attachments without correct
instructions.
g Do not operate equipment while tired, sick or after
you use alcohol or drugs.
PREPARATION
a When you operate the mower, wear correct
clothing, slip resistant work shoes or boots, work
gloves, hard hat, safety glasses and hearing
protection. Long hair, loose clothing or jewelry can
be caught in moving parts.
b Do not operate the equipment with the Interlock
System disconnected or the system does not
operate correctly. Do not disconnect or prevent the
operation of any switch.
c Never operate equipment that is not in correct
order or without decals, guards, shields, deflectors
or other protective devices fastened.
d Inspect the mower before you operate the mower.
Check the tire pressure, engine oil level, the
radiator coolant level and the air cleaner indicator.
Fuel is flammable. Use caution when you add the
fuel to the mower.
e Operate the mower in daylight or in good artificial
light. Use caution when you operate the mower
during bad weather. Never operate the mower with
lightning in the area.
f Inspect the area to select the accessories and
attachments that are needed to correctly and safely
do the job. Only use parts, accessories and
attachments approved by Jacobsen.
g Be careful of holes in the terrain and other hazards
that are not visible.
h Inspect the area where the equipment is operated.
Remove all objects you can find before you
operate. Be careful of obstructions above the
ground (low tree limbs, electrical wires) and also
underground obstacles (sprinklers, pipes, tree
roots). Enter a new area carefully. Look for possible
hazards.
i Inspect the cutting system before you start the
mower. Make sure the blades are free to rotate.
When you rotate one blade, other blades can
rotate.
OPERATION
a Never operate the engine without enough
ventilation or in an enclosed area. The carbon
monoxide in the exhaust fumes can increase to
dangerous levels.
b Never carry passengers. Keep other persons or
animals away from the mower.
c Disengage all drives and engage the parking brake
before you start the engine. Only start the engine
with the operator in the seat. Never start the engine
with persons near the mower.
d Keep your legs, arms and body inside the operator
compartment while the mower is in operation. Keep
your hands and feet away from the cutting units.
e Do not use on the slopes greater than the safe
slope limit for the equipment.
f To guard against over turning or loss of control:
– Operate the mower up and down on the face of
slopes (vertically), but not across the face
(horizontally).
– Do not start or stop suddenly on slopes.
WARNING
EQUIPMENT OPERATED INCORRECTLY OR WITHOUT TRAINING CAN BE DANGEROUS.
Know the location and correct operation of controls. Operators without experience must receive instruction from
another person that knows the correct operation of the equipment before you operate the mower.
Only use parts, accessories and attachments approved by Jacobsen.
!
SAFETY 2
5
– Decrease the speed when you operate on slopes
or when you must turn. Use caution when you
change direction. Turf condition can change the
mower stability.
– Use caution when you operate the mower near
drop-offs, ditches or embankments.
– Be careful of holes in the terrain and other hazards
that are not visible.
g When you drive in the reverse direction, look
behind you and down to make sure the path is
clear. Do not operate the cutting units when you
drive in the reverse direction.
h Use caution when you go near corners, trees or
other objects that can prevent a clear view.
i Equipment must meet the current regulations to be
driven on the public roads.
j Before you move across or operate on the paths or
roads, turn off the PTO switch, lift the mowers and
travel at decreased speed. Look for traffic.
k Stop the blades when the mower is on any surface
that is not grass.
l Do not release the cut grass in the direction of
persons or allow persons near the mower while in
operation.
m Do not operate the mower with damaged guards or
without safety devices in position.
n Do not change the engine governor setting or over-
speed the engine. Never change or tamper with
adjusters that are closed with a seal for the engine
speed control.
o Before you leave the operator compartment, for
any reason:
– Disengage all the drives and lower attachments to
the ground.
– Engage the parking brake.
– Stop the engine and remove the key.
p When you hit an object or mower starts to cause
the vibration that is not normal, inspect the mower
for damage and make repairs.
q Decrease the throttle setting before you stop the
engine.
r Do not use this equipment for uses that the mower
was not made for.
ROPS
a The ROPS is a safety device. Keep the ROPS in
the vertical and locked position. Always use the
seat belt when you operate the mower. Make sure
the seat belt can be released quickly in an
emergency.
b Only operate the mower with the ROPS in the
folded position on flat and level surfaces when
necessary. Do not operate the mower with the
ROPS in the folded position on slopes, near sharp
edges or near water. There is no roll over
protection with the ROPS in the folded position.
c Check for clearance before you drive below
objects. Do not contact tree branches, electrical
wires or other objects with the ROPS.
d Do not use the seat belt with the ROPS in the
folded position.
e Inspect the ROPS for damage. Keep the ROPS
hardware fastened.
f Do not weld, drill, change or bend the ROPS.
Replace a damaged ROPS. Do not try to correct a
damaged ROPS.
g Do not remove the ROPS from the mower.
h Jacobsen must approve any changes to the ROPS.
SAFE HANDLING OF FUELS
a The fuel and the fuel vapors are flammable. Use
caution when you add the fuel to the mower. The
fuel vapors can cause an explosion.
b Never use the containers that are not approved to
keep or transfer fuel.
c Never keep the mower or fuel containers near an
open flame or any device that can cause the
ignition of fuel or fuel vapors.
d Never fill the fuel containers inside a vehicle or on a
truck or trailer with a plastic liner. Always put the
fuel container on the ground away from your
vehicle before you fill the container.
e Refuel the mower before you start the engine.
When the engine is in operation or while the engine
is hot, never remove the fuel cap or add fuel to the
mower.
f Refuel outdoors only and do not smoke when you
add fuel. Extinguish all types of ignition.
g The fuel nozzle must touch the rim of the fuel tank
when you add fuel to the mower. Do not use a
device to lock the fuel nozzle in the open position.
h Do not over fill the fuel tank. Leave at least 1 inch
(2.5 cm) below the filler neck.
i Always tighten the fuel tank cap and container cap
after you add fuel.
2 SAFETY
6
j If the fuel spills on your clothing, change your
clothing immediately.
MAINTENANCE AND STORAGE
a Before you clean, adjust or repair this equipment,
push PTO switch to the OFF position, lower the
cutting unit to the ground, engage the parking
brake, stop the engine and remove the key.
b Make sure the mower is parked on a solid and level
surface.
c Never work on a mower that is lifted only by the
jack. Always use the jack stands.
d Never allow persons to service the mower or its
attachments without correct instructions.
e When the mower is parked, put into storage or left
without an operator, lower the cutting device unless
a positive mechanical lock is used.
f When you put the mower on a trailer or put the
mower in storage, close the fuel valve. Do not keep
fuel near flames or drain the fuel inside a building.
g Disconnect the battery before you service the
mower. Always disconnect the negative battery
cable before the positive battery cable. Always
connect the positive battery cable before the
negative battery cable.
h Charge the battery in an area with good airflow.
The battery can release hydrogen gas that is
explosive. To prevent an explosion, keep any
device that can cause sparks or flames away from
the battery.
i Disconnect the battery charger from the power
supply before you connect or disconnect the
battery charger to the battery. Wear protective
clothing and use insulated tools when you service
the battery.
j Be careful and wear gloves when you check or
service the cutting unit blades. Replace any
damaged blades, do not try to correct a damaged
blade.
k Keep your hands and feet away from parts that
move. Do not adjust the mower with the engine in
operation, unless the adjustment needs the engine
in operation.
l Carefully release the pressure from components
with stored energy.
m To prevent injury from the hot, high pressure oil,
never use your hands to check for oil leaks. Use
the paper or cardboard to find leaks.
n The hydraulic fluid pressure can have enough force
to enter your skin. If hydraulic fluid has entered
your skin, a doctor must remove the hydraulic fluid
surgically within a few hours or gangrene can
occur.
o When you service the hydraulic system, make sure
the hydraulic fittings, tubes and hoses are
tightened to the correct torque. Make sure the
hydraulic system is in good condition before you
start the engine.
p Keep the mower and the engine clean.
q Allow the engine to become cool before storage
and always remove the ignition key.
r Keep all nuts, bolts and screws tight to make sure
the equipment is in safe condition.
s Replace worn or damaged parts for safety.
Replace damaged or worn decals. Only use parts,
accessories and attachments approved by
Jacobsen.
t To decrease the fire hazard, remove materials that
burn from the engine, muffler, battery tray and fuel
tank area.
u Disconnect the battery before you weld on this
mower.
WHEN YOU PUT THE MOWER ON A
TRAILER
a Be careful when you load or unload the mower on
a trailer. Trailer must be wider than the mower and
can carry the weight of the mower.
b Use a full-width ramp to load or unload the mower
on a trailer.
c Use straps, chains, cables or ropes to fasten the
mower to the trailer. Both front and rear straps
must be sent down and toward sides of trailer.
d Make sure that all latches are correctly fastened.
SAFETY 2
7
2.2 IMPORTANT SAFETY NOTES ________________________________________________
This safety alert symbol is used to alert you to potential hazards.
DANGER - Indicates an imminently hazardous situation which, if not avoided, WILL result in death or serious injury.
WARNING - Indicates a potentially hazardous situation which, if not avoided, COULD result in death or serious
injury.
CAUTION - Indicates a potentially hazardous situation which, if not avoided, MAY result in minor or moderate injury
and property damage. It may also be used to alert against unsafe practices.
NOTICE - Indicates a potentially hazardous situation which, if not avoided, MAY result in property damage. It may
also be used to alert against unsafe practices.
For pictorial clarity, some illustrations in this manual may show shields, guards or plates open, or removed. Under no
circumstances should this equipment be operated without these devices securely fastened in place.
By following all instructions in this manual, you will prolong the life of your machine and maintain its maximum
efficiency. Adjustments and maintenance should always be performed by a qualified technician.
If additional information or service is needed, contact your Authorized Jacobsen Dealer who is kept informed of the
latest methods to service this equipment and can provide prompt and efficient service.
WARNING
The Interlock System on this mower prevents the mower from starting unless
the parking brake is engaged, reel levers are off, and traction lever is in
Neutral. The system will stop the engine if the operator leaves the seat
without engaging the parking brake, setting the reel levers to off, and placing
traction lever in Neutral.
NEVER operate mower unless the Interlock System is working.
!
WARNING
1. Before leaving the operator’s position for any reason:
a. Return traction lever to Neutral.
b. Disengage all drives.
c. Lower all implements to the ground.
d. Engage parking brake.
e. Stop engine and remove the ignition key.
2. Keep hands, feet, and clothing away from moving parts. Wait for all
movement to stop before you clean, adjust, or service the machine.
3. Keep the area of operation clear of all bystanders and pets.
4. Never carry passengers.
!
3 SPECIFICATIONS
8
3 SPECIFICATION S
3.1 PRODUCT IDENTIFICATION_________________________________________________
62304.............................. Greens King IV Plus, 17.7 hp
diesel engine, power steering.
Without reels.
62379.............................. Greens King IV Plus, 17.7 hp
diesel engine, power steering.
Without reels.
Serial Number ................ An identification plate, like the one
shown, listing the serial number, is
attached to the frame of the
mower near the battery.
Always provide the serial number of the unit when ordering
replacement parts or requesting service information.
3.2 ENGINE__________________________________________________________________
Make ............................... Kubota
Model .............................. D722-E3B (62304)
Model .............................. D722-E4B (62379)
Horsepower .................... 17.7 hp (13.2 kW) @3200 rpm
Displacement .................. 40.03 cu. In. (719 cc)
Torque ............................ 26 ft. lbs. (35 Nm) @ 2600 rpm
Fuel:
Type.......................... No. 2 Low or Ultra Low Sulfur
Diesel
Rating ....................... Min. Cetane rating 45
Capacity.................... 5 U.S. Gal. (18.9 liters)
Governor......................... Ball Type Governor
Low Idle ................... 1100 RPM
High Idle ................... 3400 RPM
Lubrication:
Capacity.................... 3.4 quarts (3.2 liter) with filter
Type.......................... SAE 20W, SAE 30W
API Classification ..... CD, CE
Air Filter .......................... Dry type with evacuator valve and
service indicator.
Alternator ........................ 14 amp
Cooling System .............. Liquid Cooled
Capacity...................... 3qt. (2.8 l) 50/50 water ethylene
glycol mix
3.3 CUTTING UNITS___________________________________________________________
Reel ................................ 3 Reels, 22 in. (55.9 cm) wide.
Reel Diameter................. 5 in. (12.7 cm)
Blade Options ................. 7, 9 or 11 blades
Cutting Width .................. 62 in. (157.4 cm)
Cutting Frequency:
7 Blade ..................... 0.084 in./mph (0.133 cm/kph)
9 Blade ..................... 0.065 in./mph (0.103 cm/kph)
11 Blade ................... 0.053 in./mph (0.084 cm/kph)
15 Blade ................... 0.039 in./mph (0.061 cm/kph)
Product
EEC Sound
Power
Sound Pressure
Level
Operator Ear
Vibration M/S
2
Arms Body
62379 102 dBa 87 dBa 2.03 0.52
1451 MARVIN GRIFFIN RD, AUGUSTA, GA, U.S.A.
PRODUCT OF THE U.S.A. WWW.JACOBSEN.COM
®
kg kW
1-800-848-1636 (US)
587 13.2 XXXX
62379001651
SPECIFICATIONS 3
9
3.4 MOWER__________________________________________________________________
Tires ................................ 18 x 9.5 - 8 tubeless
Tire Pressure:
Front..........................10-12 psi (0.69-0.83 BAR)
Rear ..........................8-10 psi (0.55-0.69 BAR)
Battery:
Type .......................... 12 Volt Lead/Acid
Group ........................22 GMF
Parking Brake .................Mechanical front drum brakes
Hand lever actuated
Speed:
Mow ......................... 0 - 3.7 mph (5.9 kph)
Transport ................. 0 - 6.6 mph (10.6 kph)
Reverse .................... 0 - 3.5 mph (5.6 kph)
Hydraulic System:
Capacity.......................... 5 U.S. gal. (19 liters) System
Fluid Type ....................... GreensCare 46 Biodegradable
Filter................................ Full Flow 20 micron
Steering ......................... Hydrostatic power steering
Mower Lift ....................... Hydraulic Double Acting Cylinders
3.5 WEIGHTS AND DIMENSIONS ________________________________________________
Dimensions: Inches (cm)
Length - Grass Catchers On ........................ 99.5 (252.6)
Height - Top of ROPS ..................................... 78 (198.1)
Wheel Base.................................................. 52.8 (134.1)
Width - Transport Position .............................. 68 (172.7)
Width - Mowing Position ................................. 70 (177.8)
Width - Wheel .............................................. 50.5 (128.3)
Turning Radius................................................ 18 (457)
Weights: Lbs. (kg)
Working Weight Less Operator
62304 and 62379 ........................................ 1468 (666)
Mower with fuel tank empty
62304 and 62379 ........................................ 1432 (650)
3.6 ACCESSORIES & SUPPORT LITERATURE _____________________________________
Contact your area Jacobsen Dealer for a complete listing of accessories and attachments.
Accessories
Orange Touch-up Paint (12 oz. spray)...................... 554598
Arm Rest ................................................................. 4139431
Grass Catcher............................................................. 67891
Brush, 62 in................................................................. 68623
Fine Bristle Brush........................................................ 68536
Green Sentry II Oil System Monitor ............................ 68669
Light Kit ................................................................... 2811910
Motor / Light / Brush Mounting Kit........................... 2811909
Rear Roller Cleaner .................................................... 68643
Quick Roller (Set of 3)................................................. 68664
Spiker (Set of 3) .......................................................... 68665
Traction Tire (Set of 2) ................................................ 62616
Turf Groomer 1/4 in. Spacing R.H. (2 Required) ........ 67911
Turf Groomer 1/4 in. Spacing L.H. (1 Required) ......... 67912
Turf Groomer 1/2 in. Spacing R.H. (2 Required) ........ 67913
Turf Groomer 1/2 in. Spacing L.H. (1 Required) ......... 67914
Vertical Mower L.H. (1 Required)................................ 68549
Vertical Mower R.H. (2 Required) ............................... 68550
Variable Step Cut........................................................ 68551
High Cut Roller Kit ...................................................... 68634
MAGSystem™ Kit ................................................... 4158083
Reels
7 Blade Reel L.H. (1 Required)....................................62841
7 Blade Reel R.H. (2 Required) ...................................62842
9 Blade Reel L.H. (1 Required)....................................62843
9 Blade Reel R.H. (2 Required) ...................................62844
11 Blade Reel L.H. (1 Required)..................................62845
11 Blade Reel R.H. (2 Required) .................................62846
15 Blade Reel L.H. (1 Required)..................................62847
15 Blade Reel R.H. (2 Required) .................................62848
Rollers
Grooved Front Roller ...................................................68527
Solid Roller .................................................................68530
Segmented Front Roller...............................................68673
Grooved Front Roller (Steel)........................................68613
Grooved Front Roller (Aluminum)................................68614
Grooved Rear Roller....................................................68580
Support Literature
Safety & Operation Manual......................................4212747
Parts & Maintenance Manual...................................4304388
Diesel Engine Parts Catalog....................................4304580
Operator Training Video ..........................................4191631
Service & Repair Manual.........................................4171649
CAUTION
Use of other than Jacobsen authorized parts and accessories may cause personal injury or damage to the
equipment.
!
3 SPECIFICATIONS
10
3.7 DECLARATION OF CONFORMITY ____________________________________________
Textron Specialized Vehicles
1451 Marvin Griffin Rd.
Augusta, GA 30609, USA
62304
62379
Greens King IV Plus Diesel
Lawnmower, Article 12, Item 32
6237901601-6237902500
6237901601-6237902500
Kubota D722-E3B Diesel
Kubota D722-E3B Diesel
13,2 kW @ 3200 RPM
157 cm
2014/30/EU
2006/42/EC
2000/14/EC, 2005/88/EC
2006/66/EC
2006/42/EC Annex VIII
102 dB(A) LWA
102dB(A) LWA
SPECIFICATIONS 3
11
2000/14/EC Annex VI, Part 1
Number: 1088
Sound Research Laboratories Limited
Holbrook House, Little Waldingfield
Sudbury, Suffolk CO10 0TH
87 dB(a) Leq (2006/42/EC)
BS EN ISO 20643
BS EN ISO 5349-1
BS EN ISO 5349-2
BS EN ISO 5395-3
B71.4
ISO 2631-1
ISO 21299
Textron Specialized Vehicles
1451 Marvin Griffin Rd.
Augusta, GA 30609, USA
TBD
3 SPECIFICATIONS
12
2006/42/EC Annex II 1.A.2
Christian D. Clifford
Director of Engineering
Ransomes Jacobsen Limited
West Road, Ransomes Europark,
Ipswich, IP3 9TT, England
2006/42/EC Annex II 1.A.10
Adam Blackford
Vice President of Engineering
Textron Specialized Vehicles
1451 Marvin Griffin Rd.
Augusta, GA 30609, USA
4212747 Rev C
GB
United
Kingdom
BE
Belgium
BG
Bulgaria
CH
Switzerland
CN
China
CY
Cyprus
CZ
Czech
Republic
DE
Germany
DK
Denmark
EE
Estonia
ES
Spain
FI
Finland
FR
France
GR
Greece
HU
Hungary
IS
Iceland
IT
Italy
JP
Japan
KR
Korea
LI
Liechenstein
LT
Lithuania
LV
Latvia
MT
Malta
NL
Netherlands
NO
Norway
PL
Poland
PT
Portugal
RO
Romania
RU
Russia
SE
Sweden
SI
Slovenia
SK
Slovakia
TR
Turkey
UA
Ukrain
SPECIFICATIONS 3
13
3.8 VIBRATION LEVEL_________________________________________________________
The mower was tested for hand and arm vibration levels. The operator was in the normal position to drive the vehicle,
with two hands on the steering mechanism. The engine was in operation and the cutting device was in rotation, while
the mower was not moving.
The Machinery Safety Directive 2006/42/EC
By compliance to:
The Lawnmower Standard BS EN ISO 5395-3
Referenced to Hand/Arm: BS EN ISO20643:2008
Information Supplied for Physical Agents Directive 2002/44/EC
By reference to:
Hand/Arm Standards: BS EN ISO 5349-1 (2001)
BS EN ISO 5349-2 (2001)
The mower was tested for Whole Body vibration levels. The operator was in the normal position to drive the vehicle,
with two hands on the steering mechanism. The cutting device was in rotation with the mower driven in a straight line
at 6 Km/hr on a level and cut lawn.
The Machinery Safety Directive 2006/42/EC
By compliance to:
Whole Body EN1032:2003
Information Supplied for Physical Agents Directive 2002/44/EC
By reference to:
Whole Body Standards BS EN ISO 2631-1 (1997)
Greens King IV Plus
Hand/Arm
Acceleration Level
62304, 62379
Maximum Left Hand or Right Hand Accelerations m/s
2
Mean Value of X, Y, Z Aeq
62304, 62379
1.10 ± 0.6
Greens King IV Plus
Whole Body
Acceleration Level
62304, 62379
Maximum Seat Pad Accelerations m/s
2
Mean Value of X, Y, Z Aeq
62304, 62379
0.343 ± 0.056
4 DECALS
14
4 DECALS
4.1 DECALS _________________________________________________________________
Familiarize yourself with the following decals. They are critical to the safe operation of the
machine. REPLACE DAMAGED DECALS IMMEDIATELY.
4181864
4181865 REV B
Danger
To avoid injury when working with battery:
1. Always connect the black (-) ground last and remove it
first.
2. Keep sparks and flames away, and avoid contact with
acid.
To avoid injury when jumping battery:
1. Connect positive (+) terminal to positive (+) terminal.
2. Connect negative (-) terminal on good battery to frame
of vehicle that has dead battery.
• Read operator's manual. Do not allow untrained
operators to use machine.
• Keep shields in place and hardware securely
fastened.
• Keep hands, feet, and clothing away from moving
parts.
• Before you clean, adjust, or repair this equipment,
disengage all drives, engage parking brake, and stop
engine.
• Never carry passengers.
• Keep bystanders away.
• Do not use on slopes greater than 15°.
4182520
DANGER
To prevent injury, disengage all drives,
engage parking brake and stop engine
before working on machine or emptying
grass catchers.
DECALS 4
15
Familiarize yourself with the following decals. They are critical to the safe operation of the
machine. REPLACE DAMAGED DECALS IMMEDIATELY.
4181863
WARNING
Read manual for service. Torsion
spring under extreme tension.
Clamp may turn suddenly. To avoid
injury, unwind spring by tapping on
clamp while loosening nut. (Located
on lift arms)
WARNING
Read manual for service. To prevent
cuts, do not turn reel by hand. Use
socket wrench or Turf Groomer™
knob to turn reel. (Located on reel
frame)
4181860
WARNING
Read manual. Reels will rotate in
the raised position with reel control
lever(s) set for reverse rotation.
Keep hands and feet away from the
reels to prevent serious injury.
4205183
WARNING
Do not use for towing.
4181862
WARNING
Radiator is under pressure. Remove
cap slowly to avoid personal injury.
4 DECALS
16
Mix equal parts of clean water and a premium quality
ethylene glycol based anti-freeze to maintain the boil
over, rust and corrosion protection.
Drain and disca rd coolant yearly. Read manual for
additional instructions.
THIS RADIATOR CONTAINS
ANTI-FREEZE
PROTECTED TO -26°F (-32°C)
363995
IMPO R T AN T
2811912
This machine us e s Greens Care 46,
a biodeg radable hydraulic fluid.
(Order 5003 105 for 5 g al. pail)
U s e of ATF Dextron II or III
i s an approved alternate fluid.
U s e will compromis e all
biodeg radable properties of
Greens Care 46 hydraulic fluid.
4181861
IMPORTANT
DO NOT USE STARTING ASSIST FLUIDS
Use of starting assist fluids in the air intake
system may be potentially explosive or cause a
“runaway” engine condition. This could result in
serious engine damage.
DECALS 4
17
Familiarize yourself with the following decals. They are critical to the safe operation of the
machine. REPLACE DAMAGED DECALS IMMEDIATELY.
A
B
C
D
2812066
8-12 p.s.i.
(55-83 kPa)
105
dB
L
WA
4141266
3-5
30
3009744
Brake
Reel Switches Wiring
Tire Pressure
Noise Level
Engine Oil
Pressure
Backlap Switch
Ignition Switch
Start
RUN
OFF
Backlap
Operation
Normal
Operation
Glow Plug On
Glow Plug Off
30 Amp Glow
Plug Fuse
Engine
Throttle
Slow
Fast
3002309
D
Diesel Fuel
4 DECALS
18
2
1
N
R
Right ReelCenter ReelLeft Reel
Reel Forward
Rotation
Reel Off
Reel Reverse
Rotation
Parking Brake
Disengaged
Transport
Mow
Neutral
Reverse
Traction Lever
Parking Brake
Engaged
Charging
System Fuse
Interlock
System Fuse
CONTROLS 5
19
5 CONTROLS
5.1 ICONS ___________________________________________________________________
WARNING
Never attempt to drive the mower unless you have read the Safety and Operation Manual
and know how to operate all controls correctly.
Familiarize yourself with the icons shown above and what they represent. Learn the
location and purpose of all of the controls and gauges before operating this mower.
Read Manual
Off Run Start
Engine
Fast
Slow
Engine Throttle
Forward Reverse
Reel Rotation
Fuse
Circuit Breaker
Choke
Headlight
Engaged Disengaged
Parking Brake
Hydraulic Oil Leak
Horn
Service Foot Brake
Hour Meter
Raise
Lower
Enable Disable
Reel Switch
Forward
Reverse
Traction Lever
Transport
Mow
Neutral
Reverse
Mow/Lift Treadle
2
1
N
R
D
Fuel
Diesel
Coolant
Temperature
Glow Plug
Off
On
!
5 CONTROLS
20
3-5
40
P
S
R
2
1
N
R
10
12
14
16
T
U
W
V
X
Y
Z
A
B
C
E
F
G
H
J
K
L
M
N
AA
D
A Reel Control Lever
B Parking Brake Lever
C Traction Lever
D Temperature Gauge (Diesel)
E Volt Meter
F Ignition Switch
G Mechanics (Backlap) Switch
H Light Switch (Optional)
J Lights Fuse (Optional)
K Charging Circuit Fuse
L Interlock System Fuse
M Parking Brake Light
N Oil Pressure Light
P Throttle
R Glow Plug Fuse
S Glow Plug Switch
T Accelerator Pedal
U Brake Pedal
V Tilt Control
W Mow/Lift Pedal
X Hour Meter
Y Seat Control Lever
Z Hydraulic Cap/Dipstick
AA Fuel Cap
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
Ransomes 62379G01 Owner's manual
- Category
- Lawnmowers
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Ransomes 62379 Owner's manual
-
-
-
-
-
-
-
Ransomes 68082 Owner's manual
-
-
Ransomes 67924 Owner's manual
Other documents
-
Jacobsen Greens King IV Plus Safety & Operation Manual
-
Jacobsen 10029628 Maintenance Manual
-
Jacobsen 62306 Maintenance Manual
-
Jacobsen 10029628 Maintenance Manual
-
Jacobsen 62306 Maintenance Manual
-
Jacobsen 10029628 Maintenance Manual
-
Jacobsen 068021-G515 Maintenance Manual
-
Jacobsen 068021-E410E Maintenance Manual
-
Jacobsen 068021-G515 Maintenance Manual
-
Jacobsen 068021-E410E Maintenance Manual
