Jacuzzi HP55845 Installation guide

 www.jacuzzi.com Page1

HC08000A            06/2011

English

Overow Drain Kit

Installation Instructions

Thisdrainkithasa26”exposedcableandisdesignedtotbaths17”to22”inheight.

Required Tools

Level Hacksaw

YardstickorTapeMeasure StandardScrewdriver

PlumbersPutty 3/32"AllenWrench

Sandpaper AdjustableWrench

Installation Instructions

1. DrymounttheOverowAssemblyand

 DrainShoeontotubasshown.Referto

 bathspecicationsheetforrecommended

 dimensions.



 Note: DO NOT detach Drain Shoe cable

for any reason. Cut Overow Assembly

Tube and Drain Shoe Tube ends as

necessary to achieve t. Remove rough

edges with sandpaper prior to assembly.

2. InstallDrainShoe(D)usingsuppliedbrass

 DrainBolt(A),Strainer(B)andGasket(C)

 asillustrated.TightenDrainBolt(A)to

 secure.DonotovertightenorDrainShoe

 assemblymaybedamaged!



 Note: The top tub lip MUST be level. Verify

top and bottom tub oor sealing surface is

clean, at and smooth prior to assembly.

D

A

B

C

OverowandDrain

ShoeTubemustextend

1"-1.5"intodraintee

ends.

Overow

Assembly.

Drain

Tee

TubWall

DrainShoe

BrassDrainBolt

Verifystraineris

levelandushwith

thetubsurface.

TubFloor

Gasket

PlumbersPuttyrequired

Page2 www.jacuzzi.com

3. InstallOverowAssembly(H)using

 suppliedRoundGasket(E),FlangeRing

 (F)andBrassNut(G).Fingertightenbrass

 nut.



 Note: Brass Nut (G) to be tightened further

upon completion of step 4.

4. VerifyPoly-Vinylwashers(I)areinstalled

 underDrainNuts(beveledsideinward).

 TightenDrainNutstosecureDrainTee.

 Finally,tightenBrassOverowNut(G)with

 anadjustablewrenchtosecureOverow.

 DoNotOvertighten!

5. InstallDrainKnoboverOverowShaft(set

 screwagainstatsurface).Thenadjust

 Knobfora1/16”-1/8”wallgapas

 illustrated.Finally,tightensetscrewto

 secure.



CAUTION!DrainKnobwallgapis

 mandatorytoallowwatertoescape,

 preventingoverows.

H

G

E

F

RoundFlangeRing

BrassNut

RoundGasket

TubWall

I

G

Overow

Assembly

VerifyPoly-Vinyl

Washersareinstalled

underDrainNuts

Drain

Nuts

DrainTee

DrainShoe

TubWall

Mandatorywall

gap1/16"-1/8"

DrainKnob

3/32"Allen

Wrench

English

 www.jacuzzi.com Page3

BrassNut

TubWall

6. AdjustbrassPlungerBoltandLockNut

 fora1/2”-5/8”minimumopening,then

 tightenLockNutagainstPlungerShaftto

 secureheightadjustment.

CAUTION!PlungerLockNutmustbe

 tightenedagainstplungershaftpriorto

 tubuse.

7. TestdrainoperationbyturningOverow

 Handleasfollows:

•

ToOpenDrain:TurnKnob1/8turn

 clockwise(J).

•

ToCloseDrain:TurnKnob1/8turn

 counterclockwise(K).

PlungerAssembly

BrassPlungerBolt

andLockNut

1/2"-5/8"

J

K

DrainKnob

Open

DrainKnob

Closed

1/2"-5/8"

English

Page4 www.jacuzzi.com

90 Day (Parts Only) Limited Warranty On Options And

Accessories

Ourwarrantycoversoptionsandaccessoriesmanufacturedforthecompanybutnotinstalledbythe

factory(e.g.llspoutkits,trimkits,skirts,pillows,etc.)againstdefectsinmaterialorworkmanship.

Warrantycoveragebeginsonthedatetheoptionoraccessorywasoriginallypurchasedbythe

user.ContactourWarrantyDepartmentat1-800-288-4002astowheretosendthedefectivepartto

receiveawarrantyreplacement.Proofofpurchaseisrequiredforwarrantyclaims.

Installation Notes

English

Page is loading ...

Jacuzzi HP55845 Installation guide

This manual is also suitable for

Jacuzzi HP55845 Installation guide

in other languages

Related papers

Other documents