Page is loading ...
1
1
Qty: 8
Long leg
assembled
B
Correctly assembled legs.
Items to Assemble
1 Long Leg Assembly
1 Short Leg Assembly
8 Screws
A Place bottom shelf on table or grill
container.
B Insert tabs on long leg assembly
into bottom shelf.
C Attach leg assembly with one screw
on each side.
D Repeat step B and C for short leg
assembly.
A
Long leg
left side
A TEN IONT T
LEAVE HIS SLEEVE
T
ON UNTIL E S EL G
AR
ASS MBLED ONTOE
HE GRILLT
OATTENTI N
LEAVE THIS SLEEVE
SON UNTIL LEG ARE
S ONA SEMBLED TO
THE GRILL
Short leg
right side
C
C
Underside
of bottom shelf
D
CAUTION: Ends of screws have sharp points
A
C
D
Hub on wheel faces into grill bottom
Correct position
B
Correct position
of flanged hex nut
Turn cart upside down
Stand cart upright and
remove cardboard sleeves
1
2
Qty: 1
Not to scale
Items to Assemble
2 Leg Extenders
1 U-Nut
1 Cylinder Thumbscrew
2 Wheels
1 Axle Rod
1 Flanged Hex Nut
2 Flat Washers
1 Hitch Pin
A Attach leg extenders. Check to make sure leg is seated all the way into the
leg extender.
B Attach u-nut to tab. See enlargement of u-nut for correct position.
C Thread cylinder thumbscrew into hole and u-nut. Screw flanged hex nut onto
end of cylinder thumbscrew.
D Slide wheel on axle rod. Insert axle rod/wheel into large hole in bottom shelf.
Attach other wheel with two washers and a hitch pin.
tQty: 1
Qty: 1
Not to scale
Qty: 2
Qty: 1
3
Items to Assemble
4 Rails (all identical)
10 Screws
A Overlap rails and hook tabs into slots. Pull rails to latch.
B Attach one screw in center of each rail.
C Attach rail and legs with two screws in each corner.
Qty: 10
B
A
B
C
C
C
C
B
A
C
B
B
B
A
A
4
Items to Assemble
1 Front Panel
2 Push Pins
Qty: 2
A Place tabs on front panel beside leg tabs.
B Insert push pins into front panel and legs.
B
C
A
C
B
C
Casting Seat
Items to Assemble
1 Grill Bottom Assembly
4 Screws
A Angle grill bottom assembly around and under the rails.
CAUTION: Be careful not to dislodge burner tubes.
B Make sure ribs on each side of bottom casting are nestled
into notches on casting seat.
C Attach four screws inside grill bottom and into casting seat.
Qty: 4
6
7001787_463363006 (04-06-06) - 0
Parts List - Model 463363006
Key Qty. Description . . . . . . . . . . . . . . Part #
A 1 Bottom Shelf . . . . . . . . . . . . . . . . 7000870
B 4 Rails . . . . . . . . . . . . . . . . . . . . . . 7000286
C 1 Logo Plate. . . . . . . . . . . . . . . . . . 4157147
D 1 Temperature Gauge w/ Wing Nut 4157171
E 1 Temperature Gauge Bezel . . . . . 4157169
F 1 Top Casting . . . . . . . . . . . . . . . . 7001783
G 1 Bottom Casting . . . . . . . . . . . . . . 7000846
H 3 Burners . . . . . . . . . . . . . . . . . . . . 7000083
I 1 Carryover Tube . . . . . . . . . . . . . . 7000278
J 2 Pal Nuts. . . . . . . . . . . . . . . . . . . . 7000132
K 2 “U” Nuts. . . . . . . . . . . . . . . . . . . . 7001639
L 2 Casting Bumpers. . . . . . . . . . . . . 7000184
M 1 Handle. . . . . . . . . . . . . . . . . . . . . 7000199
N 1 “U” Nuts. . . . . . . . . . . . . . . . . . . . 7001640
O 2 Wheels . . . . . . . . . . . . . . . . . . . . 7000262
P 1 Axle Rod . . . . . . . . . . . . . . . . . . . 7001149
Q 3 Vaporizer Tents . . . . . . . . . . . . . . 7000381
R 1 Grease Tray Assy . . . . . . . . . . . . 7000042
S 1 Grease Pan. . . . . . . . . . . . . . . . . 7000046
T 2 Leg Extenders. . . . . . . . . . . . . . . 7000230
Key Qty. Description . . . . . . . . . . . . . . . . Part #
U 3 Control Knobs. . . . . . . . . . . . . . . . . 7000237
V 1 Electrode w/Nut . . . . . . . . . . . . . . . 7000378
W 1 Thumbscrew. . . . . . . . . . . . . . . . . . 7000355
X 1 Ignitor . . . . . . . . . . . . . . . . . . . . . . . 4153713
Y 2 Shelves. . . . . . . . . . . . . . . . . . . . . . 7000258
Z 1 Front Panel. . . . . . . . . . . . . . . . . . . 7001785
AA 1 Warming Rack . . . . . . . . . . . . . . . . 7000180
BB 2 Cooking Grids. . . . . . . . . . . . . . . . . 7000028
CC 1 Valve/Hose/Regulator Assy . . . . . . 7000064
DD 1 Console Assembly . . . . . . . . . . . . . 7001789
EE 1 Ignitor Wire. . . . . . . . . . . . . . . . . . . 4163196
FF 1 Leg, Long . . . . . . . . . . . . . . . . . . . . 7000522
GG 1 Leg, Short. . . . . . . . . . . . . . . . . . . . 7000523
- - 1 Hardware Bag. . . . . . . . . . . . . . . . . 7001652
A
B
C
D
E
F
G
H
I
J
K
K
L
L
M
O
P
Q
R
S
T
U
V
Y
Y
Z
BB
CC
DD
AA
FF
GG
A LY M UAL SSEMB AN
63 300 4 36 6
THI GRI I
R S LL S FO
TDOOR SE O OU U NLY
CA N: Rea nd lo l afet UTIO d a fol w al s y
s tem nts as em y ns cti ns d u e anta e , s bl i tru o an s d
are rec on bef atte pti to s bl c di ti s ore m ng as em e
nd c
ooka .
INSTALLER A B E/ SSEM L R:
Le e se ns ct ns th c ns er.av the i tru io wi o um
ON ME p ths anu for ure C SU R: Kee i m al fut
fere e.re nc
Fa ure folow al m ufac urer’s i stru ti s il to l l an t n c on
c ul es t i eri us ers al ju an r o d r ul n s o p on in ry d/o
per da agepro ty m .
Som parts ma c tai ha edg - e y on n s rp es
e pecaly a no in e m nua W ar s i l s ted th a l! e
tec v lo es f ne es ary.pro ti e g v i c s
f you av a questi or d sist nc du iI h e ny ons nee as a e rng
as b , p
s call 1-800-24sem ly lea e 1-7548.
i i on he web t:Vs t us t a
ww ch b i . C mw . ar ro l o
CAUTION
!
R NWA NI G
!
n Pri ted in USA
2 0 W C Br de Co , l Righ
ts R serve© 0 6 . . a l y . Al e d
Use the one short u-nit first
r n s
O ie t a shown
A
Items to Assemble:
2 U-Nuts
Close up of right
side of grill bottom.
nd ntI e
5
A Use the two longer u-nuts on bottom casting. Place
u-nut as shown into indent on left and right side of
grill bottom.
Qty: 2 Actual size
X
EE
W
N
/