Intex 28062E Owner's manual

Brand: Intex

Model: 28062E

Category: Above ground pool accessories

Type: Owner's manual

Intex 28062E is a sturdy 2-section pool ladder designed for Intex pools with a wall height of 48 inches. It features a U-shaped top rail for added stability, and its non-skid steps ensure safe climbing in and out of the pool. With a maximum load capacity of 300 lbs, it can accommodate adults and children alike.

91PO

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

OWNER’S MANUAL

Pool Ladder

Owner’s Manual For:

48in (122 cm) model

IMPORTANT

SAFETY RULES

Read, understand, and follow

all instructions carefully before

installing and using this product.

Don’t forget to try these other fine Intex products: Pools, Pool

Accessories, Inflatable Pools and In-Home Toys, Airbeds and

Boats available at fine retailers or visit our website.

Due to a policy of continuous product improvement, Intex

reserves the right to change specifications and appearance,

which may result in updates to the instruction manual, without

notice.

For illustrative purposes only. Pool is not provided.

IMPORTANT!

DO NOT RETURN PRODUCT TO STORE

To purchase parts and accessories or to obtain non-technical assistance, Visit

www.intexcorp.com

For technical assistance and missing parts call us toll-free (for U.S. and Canadian Residents):

1-800-234-6839

Monday through Friday, 8:30am to 5:00pm Pacific Time

091-*PO-R0-1404

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 2

Warnings.......................................................................................... 3

Parts References............................................................................. 4

Setup Instructions........................................................................... 5-7

General Aquatic Safety................................................................... 8

Pool Safety Sign.............................................................................. 9

TABLE OF CONTENTS

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 3

IMPORTANT SAFETY RULES

Read, Understand and Follow All Instructions Carefully Before Installing and Using this Product.

• Supervisechildrenandthosewithdisabilitiesatalltimes.

• Alwaysassistchildrenwhentheyusetheladdertoavoidfallsand/orserious

injury.

• Neverdiveorjumpfromthisladder.

• Locatetheladderonalevel,solidbase.

• Onepersononthisladderatatime.

• Maximumload:300lbs(136kg).ComplieswithNFP90-317strength

 requirements.

• Facetheladderatalltimesforentry/exitofpool.

• Removeandsecureladderwhenpoolisnotoccupied.

• Donotswimunder,throughorbehindladder.

• Checkallnutsandboltsregularlytoensureladderstayssturdy.

• Ifswimmingatnightuseartificiallightingtoilluminateallsafetysigns,

 ladders,poolfloorandwalkways.

• Assemblyanddisassemblybyadultsonly.

• Thisladderisdesignedandmanufacturedforaspecificpoolwallheight

 and/ordeckofthepool.

• Thenon-respectofthemaintenanceinstructionmayresultinhugeriskfor

 health,particularlyforchildren.

• Onlyusethisladderforthepurposesdescribedinthismanual.

FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN BROKEN

BONES, ENTRAPMENT, PARALYSIS, DROWNING OR OTHER SERIOUS

INJURY.

Theseproductwarnings,instructionsandsafetyrulesprovidedwiththeproduct

representsomecommonrisksofwaterrecreationdevicesanddonotcoverall

instancesofriskanddanger.Pleaseusecommonsenseandgoodjudgment

whenenjoyinganywateractivity.

WARNING

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 4

PARTS REFERENCE

Beforeassemblingyourproduct,pleasetakeafewminutestocheckthecontents

andbecomefamiliarwithalltheparts.

NOTE:Drawingsforillustrationpurposeonly.Actualproductmayvary.Nottoscale.

REF.

NO.

DESCRIPTION QUANTITY

SPARE PART NO.

#58974 #10903

U-SHAPEDTOPRAIL 2

11167 11171

2 TOPBRACE 2

11168 11172

SHORTFASTENERFORU-SHAPEDTOPRAIL(WITH1EXTRA)

10810 10810

LONGFASTENERFORTOPBRACE(WITH1EXTRA) 5

10227 10227

STEPMOUNTINGPIN(WITH2EXTRA) 34

10349 10913

STEP 8

10348 10914

UPPERSIDELEG(MARKED“A”) 2

11553A 11555A

UPPERSIDELEG(MARKED“B”) 2

11553B 11555B

LOWERJ-SHAPEDSIDELEG(

MARKED

“A”)

11554A 11556A

LOWERJ-SHAPEDSIDELEG(

MARKED

“B”)

11554B 11556B

48” (122 cm) model

ThisladderisdesignedandmanufacturedforIntexpoolwallheight:

Item # Pool Wall Height

58974(white&blue) 48in(122cm)

10903(silver&white) 48in(122cm)

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 5

LADDER SETUP

TOOLS REQUIRED: One (1) Phillips screwdriver

One (1) pair of pliers or a small adjustable wrench

IMPORTANT: Do not fully tighten fasterners until last assembly operation.

WARNING

ASSEMBLE THE LEGS BEFORE INSTALLING THE LADDER STEPS. FAILURE TO

ASSEMBLE THE LEGS BEFORE INSTALLING THE STEPS MAY ALLOW THE LEGS

TO SEPARATE FROM THE LADDER DURING USE, POSSIBLY RESULTING IN

SERIOUS INJURY OR DEATH.

WARNING

INCORRECTLY CONNECTED PARTS MAY RESULT IN AN UNSTABLE LADDER

OR LADDER FAILURE WHICH CAN CAUSE FALLING AND PERSONAL INJURY

OR DEATH.

1. IDENTIFY PARTS:

Itisveryimportanttolayoutthepartscorrectlyandidentifywhichpartsconnect

 togetherbeforestartingtheassembly.Althoughsomepartslookalike,theyarenot

 alwaysinterchangeable.Refertothepartslist. 

2. LEG ASSEMBLY (refer to figures 1.1 through 1.2):

IMPORTANT: Makesurethelegsaresecurelyconnectedandlocked.Checkthespring

pinshavesnappedoutbeforeproceedingtothenextstep.EnsuretheJ-shapedlegsare

pointingoutwardsbeforeinstallingthesteps.

1.2

Springpin

1.1

Press,

hold and

insert

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 6

LADDER SETUP (continued)

3. STEP INSTALLATION (refertofigures2.1through2.2):

IMPORTANT: Makesureallpinsaresecurelylocked.

4. TOP BRACE INSTALLATION – ONE SIDE AT

A TIME (refertofigure3):

 Identifyhole“A”andhole“B”onthetopbraces

(2),markedaccordinglyateachend.Slidethe

 topbracesoverthelegs,makingsurehole“A”

 ofonebraceslidesoverleg“A”andhole“B”of

 theotherbraceoverleg“B”.Thesmallholeson

 thesideofbracesshouldalignwiththelower

 holesonthelegs.Fasteneachbracetothelegs

 usingthelongerfasteners/screws (4).Donotyet

 attachtheothersideoftheladdertothetop

 braces–thisassemblystepwillfollowlater.

2.1

2.2

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 7

LADDER SETUP (continued)

5. U-SHAPED TOP RAIL INSTALLATION (referto

 figure4):

 InstalltheU-shapedtoprails (1) onto the legs

 abovethetopbrace(2)andfastenthemwith

 theshorterfasteners/screws(3)–seefigure4.

6. INSTALLATON OF THE REMAINING LADDER

SIDE(refertofigure5):

 Withallthetoprailandtopbraceholesin

 alignment,slidetheremainingladdersidefrom

 theundersideintoitsproperposition.Makesure

 the“A”legslidesintohole“A”ofthetopbrace

 andthe“B”legslidesintohole“B”ofthe

 correspondingtopbrace.Fastenallpartsusing

 theappropriatefasteners/screws(4) and (3), as

 describedearlier.

7. BEFORE USE OF LADDER:

 Withallpartsnowinplace,verifythatall

 fasteners/screwsarefullytightenedandapply

 downwardpressuretoeachsteptobesurethey

 arefullyanchoredinplace.Ifyourladdercame

 withaladderbarrier,proceedtoinstructionsfor

 ladderbarrierinstallation,otherwiseproceedto

 placingtheladderoverthesidewallofyour

 pool,withonesideoftheladderlocatedinside

 thepoolandtheothersideoutsideofthepool-

 seefigure6.

Estimatedassemblytime20~45minutes.(Note

 theassemblytimeisonlyapproximateand

 individualassemblyexperiencemayvary.)

WARNING

 • Locateladderonalevel,solidbaseandmakesuretheladderisstableand

safe to climb.

 • Removeandsecureladderawayfromthepoolwhenthepoolisnotinuseto

prevent unauthorized, unintentional or unsupervised pool entry.

 • Checkallnutsandboltsregularlyandbeforeeachusetoensuretheladder

is sturdy. See maintenance instructions.

8. MAINTENANCE:

 Regularlycheckallnuts,bolts,stepmountingfixturesandstepmountingpinsto

 ensureallpartsaresecuredproperlyandtheladderissturdy.Bringtheladderindoors

 andstoreinasafeanddryarea,preferablybetween32degreesFahrenheit(0

 degreesCelsius)and104degreesFahrenheit(40degreesCelsius).

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 8

GENERAL AQUATIC SAFETY

Waterrecreationisbothfunandtherapeutic.However,itinvolvesinherentrisksof

injuryanddeath.Toreduceyourriskofinjury,readandfollowallproduct,packageand

packageinsertwarningsandinstructions.Remember,however,thatproductwarnings,

instructionsandsafetyguidelinescoversomecommonrisksofwaterrecreation,butdo

notcoverallrisksanddangers.

For additional safeguards, also familiarize yourself with the following general guidelines

as well as guidelines provided by nationally recognized Safety Organizations:

• Demandconstantsupervision.Acompetentadultshouldbeappointedasa“lifeguard”or

 waterwatcher,especiallywhenchildrenareinandaroundthepool.

• Learntoswim.

• TakethetimetolearnCPRandfirstaid.

• Instructanyonewhoissupervisingpoolusersaboutpotentialpoolhazardsandabouttheuse

 ofprotectivedevicessuchaslockeddoors,barriers,etc.

• Instructallpoolusers,includingchildrenwhattodoincaseofanemergency.

• Alwaysusecommonsenseandgoodjudgementwhenenjoyinganywateractivity.

• Supervise,supervise,supervise.

For additional information on safety, please visit

•TheAssociationofPoolandSpaProfessionals:TheSensibleWaytoEnjoyYour

Aboveground/Onground Swimming Pool www.nspi.org

• AmericanAcademyofPediatrics:PoolSafetyforChildrenwww.aap.org

• RedCrosswww.redcross.org

• SafeKidswww.safekids.org

• HomeSafetyCouncil:SafetyGuidewww.homesafetycouncil.org

• ToyIndustryAssociation:ToySafetywww.toy-tia.org

SAFETY IN YOUR POOL

Safe swimming depends on constant attention to the rules. The "NO DIVING" sign within

thismanualcanbepostednearyourpooltohelpkeepeveryonealerttothedanger.You

may also wish to copy and laminate the sign for protection from the elements.

SAVE THE CARTON FOR STORAGE AND THE INSTRUCTIONS

FOR RE-ASSEMBLY

91PO

SAVE THESE INSTRUCTIONS

(91PO) 48” 2-SECTIONS POOL LADDER ENGLISH 7.5” X 10.3” PANTONE 295U 04/26/2013

English

Page 9

POST THIS WARNING NEAR YOUR POOL

NO DIVING OR JUMPING

SHALLOW WATER

DIVING MAY RESULT IN PERMANENT INJURY OR DEATH

•BeSafe.Swimwithafriend.

•Childrenmustbeaccompaniedbyanadult.

•Don’tswimwhenusingalcoholordrugs.

•Befamiliarwiththepoolbeforeswimming.

•Norunning,jumping,orhorseplayinoraroundpool.

•Noglassinpoolarea.

TO AVOID SERIOUS INJURY ALL POOL USERS MUST KNOW AND FOLLOW THESE SAFETY RULES.

WARNING

Intex 28062E Owner's manual

Brand: Intex

Model: 28062E

Category: Above ground pool accessories

Type: Owner's manual

Download PDF

report

Intex 28062E Owner's manual

Intex 28062E Owner's manual

Related papers

Other documents