Chevrolet 2006 HHR Owner's manual

Seats and Restraint Systems

........................... 1-1

Front Seats

............................................... 1-2

Rear Seats

.............................................. 1-10

Safety Belts

............................................. 1-13

Child Restraints

....................................... 1-34

Airbag System

......................................... 1-58

Restraint System Check

............................ 1-74

Features and Controls

..................................... 2-1

Keys

........................................................ 2-3

Doors and Locks

...................................... 2-10

Windows

................................................. 2-16

Theft-Deterrent Systems

............................ 2-18

Starting and Operating Your Vehicle

........... 2-21

Mirrors

.................................................... 2-38

OnStar

®

System

...................................... 2-43

Storage Areas

......................................... 2-45

Sunroof

.................................................. 2-49

Instrument Panel

............................................. 3-1

Instrument Panel Overview

.......................... 3-4

Climate Controls

...................................... 3-19

Warning Lights, Gages, and Indicators

........ 3-24

Driver Information Center (DIC)

.................. 3-40

Audio System(s)

....................................... 3-51

Driving Your Vehicle

....................................... 4-1

Your Driving, the Road, and Your Vehicle

..... 4-2

Towing

................................................... 4-37

Service and Appearance Care

.......................... 5-1

Service

..................................................... 5-3

Fuel

......................................................... 5-5

Checking Things Under the Hood

............... 5-10

Headlamp Aiming

..................................... 5-38

Bulb Replacement

.................................... 5-41

Windshield Wiper Blade Replacement

......... 5-45

Tires

...................................................... 5-46

Appearance Care

..................................... 5-74

Vehicle Identiﬁcation

................................. 5-82

Electrical System

...................................... 5-83

Capacities and Speciﬁcations

..................... 5-88

Maintenance Schedule

..................................... 6-1

Maintenance Schedule

................................ 6-2

Customer Assistance and Information

.............. 7-1

Customer Assistance and Information

........... 7-2

Reporting Safety Defects

........................... 7-13

Index

................................................................ 1

2006 Chevrolet HHR Owner Manual M

GENERAL MOTORS, GM, the GM Emblem,

CHEVROLET, and the CHEVROLET Emblem are

registered trademarks and the name HHR is a

trademark of General Motors Corporation.

This manual includes the latest information at the time it

was printed. We reserve the right to make changes

after that time without further notice. For vehicles ﬁrst

sold in Canada, substitute the name “General Motors of

Canada Limited” for Chevrolet Motor Division whenever

it appears in this manual.

Keep this manual in the vehicle, so it will be there if it is

needed while you are on the road. If the vehicle is

sold, leave this manual in the vehicle.

Canadian Owners

A French language copy of this manual can be obtained

from your dealer or from:

Helm, Incorporated

P.O. Box 07130

Detroit, MI 48207

How to Use This Manual

Many people read the owner manual from beginning to

end when they ﬁrst receive their new vehicle. If this

is done, it can help you learn about the features

and controls for the vehicle. Pictures and words work

together in the owner manual to explain things.

Litho in U.S.A.

Part No. 06HHR B Second Printing

©

ii

Index

A good place to quickly locate information about the

vehicle is the Index in the back of the manual. It is an

alphabetical list of what is in the manual and the

page number where it can be found.

Safety Warnings and Symbols

There are a number of safety cautions in this book.

We use a box and the word CAUTION to tell about

things that could hurt you if you were to ignore

the warning.

{CAUTION:

These mean there is something that could hurt

you or other people.

In the caution area, we tell you what the hazard is.

Then we tell you what to do to help avoid or reduce the

hazard. Please read these cautions. If you do not,

you or others could be hurt.

You will also ﬁnd a circle

with a slash through it in

this book. This safety

symbol means “Do Not,”

“Do Not do this” or “Do Not

let this happen.”

iii

Vehicle Damage Warnings

Also, in this manual you will ﬁnd these notices:

Notice: These mean there is something that could

damage your vehicle.

A notice tells about something that can damage the

vehicle. Many times, this damage would not be covered

by your vehicle’s warranty, and it could be costly.

But the notice will tell what to do to help avoid the

damage.

When you read other manuals, you might see

CAUTION and NOTICE warnings in different colors

or in different words.

There are also warning labels on the vehicle.

They use the same words, CAUTION or NOTICE.

Vehicle Symbols

The vehicle has components and labels that use

symbols instead of text. Symbols are shown along with

the text describing the operation or information

relating to a speciﬁc component, control, message,

gage, or indicator.

If you need help ﬁguring out a speciﬁc name of a

component, gage, or indicator, reference the following

topics:

• Seats and Restraint Systems in Section 1

• Features and Controls in Section 2

• Instrument Panel Overview in Section 3

• Climate Controls in Section 3

• Warning Lights, Gages, and Indicators in Section 3

• Audio System(s) in Section 3

• Engine Compartment Overview in Section 5

iv

These are some examples of symbols that may be found on the vehicle:

v

✍ NOTES

vi

Front Seats ......................................................1-2

Manual Seats ................................................1-2

Driver Seat Height Adjuster ..............................1-3

Six-Way Power Driver Seat ..............................1-3

Power Lumbar ...............................................1-4

Heated Seats .................................................1-4

Reclining Seatbacks ........................................1-5

Head Restraints .............................................1-7

Passenger Folding Seatback ............................1-8

Rear Seats .....................................................1-10

Split Folding Rear Seat .................................1-10

Safety Belts ...................................................1-13

Safety Belts: They Are for Everyone ................1-13

Questions and Answers About Safety Belts ......1-17

How to Wear Safety Belts Properly .................1-18

Driver Position ..............................................1-18

Shoulder Belt Height Adjustment .....................1-26

Safety Belt Use During Pregnancy ..................1-27

Right Front Passenger Position .......................1-27

Rear Seat Passengers ..................................1-27

Rear Safety Belt Comfort Guides ....................1-30

Safety Belt Pretensioners ...............................1-33

Safety Belt Extender .....................................1-33

Child Restraints .............................................1-34

Older Children ..............................................1-34

Infants and Young Children ............................1-36

Child Restraint Systems .................................1-39

Where to Put the Restraint .............................1-43

Lower Anchors and Tethers for

Children (LATCH) ......................................1-45

Securing a Child Restraint in a Rear

Seat Position ............................................1-52

Securing a Child Restraint in the Right

Front Seat Position ....................................1-54

Airbag System ...............................................1-58

Where Are the Airbags? ................................1-61

When Should an Airbag Inﬂate? .....................1-64

What Makes an Airbag Inﬂate? .......................1-65

How Does an Airbag Restrain? .......................1-65

What Will You See After an Airbag Inﬂates? .....1-66

Passenger Sensing System ............................1-67

Servicing Your Airbag-Equipped Vehicle ...........1-72

Adding Equipment to Your Airbag-Equipped

Vehicle ....................................................1-73

Restraint System Check ..................................1-74

Checking the Restraint Systems ......................1-74

Replacing Restraint System Parts

After a Crash ............................................1-74

Section 1 Seats and Restraint Systems

1-1

Front Seats

Manual Seats

{CAUTION:

You can lose control of the vehicle if you try to

adjust a manual driver’s seat while the vehicle

is moving. The sudden movement could startle

and confuse you, or make you push a pedal

when you do not want to. Adjust the driver’s

seat only when the vehicle is not moving.

Lift the bar located under the front of the seat to unlock

it. Slide the seat to where you want it and release

the bar. Try to move the seat with your body to be sure

the seat is locked in place.

1-2

Driver Seat Height Adjuster

If your vehicle has this feature, the driver’s seat height

adjuster is located on the outboard side of the seat.

To raise the seat, move the lever upward repeatedly

until the seat is at the desired height. To lower the seat,

move the lever downward repeatedly until the seat is

at the desired height.

Six-Way Power Driver Seat

If your vehicle has this feature, the power seat control is

located on the outboard side of the driver’s seat.

To adjust the seat, do the following:

• Move the seat forward or rearward by pushing the

control toward the front or rear of the vehicle.

• Tilt the front of the seat cushion up or down by

holding the front of the control up or down.

• Raise or lower the entire seat by holding the rear of

the control up or down.

Driver’s Seat with 6-way Power Seat Control and

Power Lumbar shown

1-3

Power Lumbar

If your vehicle has this feature, the control is located on

the outboard side of the driver’s seat cushion.

To increase support, press and hold the front of the

control. To decrease support, press and hold the rear of

the control. Keep in mind that as your seating position

changes, as it may during long trips, so should the

position of your lumbar support. Adjust the seat

as needed.

Heated Seats

If your vehicle has this

feature, the driver’s and

passenger’s heated

seat buttons are located

on the climate control

panel below the fan switch.

Press the button once to turn the heated seat to the

high setting. Both lights below the heated seat symbol

will come on. Press the button a second time and

the heated seat will go to the low setting. The bottom

light will come on to indicate that the setting is on

low. Press the button a third time to turn the heated

seat off.

The heated seat feature will need to be turned on each

time the ignition is turned off and back on again.

Driver’s side button

shown, Passenger’s

side button similar

1-4

Reclining Seatbacks

{CAUTION:

You can lose control of the vehicle if you try to

adjust a manual driver’s seat while the vehicle

is moving. The sudden movement could startle

and confuse you, or make you push a pedal

when you do not want to. Adjust the driver’s

seat only when the vehicle is not moving.

{CAUTION:

If the seatback is not locked, it could move

forward in a sudden stop or crash. That could

cause injury to the person sitting there. Always

push and pull on the seatback to be sure it is

locked.

The seats have reclining seatbacks. The lever used to

operate them is located on the outboard side of the

seats. Lift the lever to release the seatback. Move the

seatback to where you want it and release the lever

to lock the seatback in place. Press rearward on

the seatback to be sure it is locked into place.

Passenger’s Side Reclining Lever shown, Driver’s

Side similar

1-5

{CAUTION:

Sitting in a reclined position when your vehicle

is in motion can be dangerous. Even if you

buckle up, your safety belts cannot do their

job when you are reclined like this.

The shoulder belt cannot do its job because it

will not be against your body. Instead, it will be

in front of you. In a crash, you could go into it,

receiving neck or other injuries.

The lap belt cannot do its job either. In a

crash, the belt could go up over your

abdomen. The belt forces would be there, not

at your pelvic bones. This could cause serious

internal injuries.

For proper protection when the vehicle is in

motion, have the seatback upright. Then sit

well back in the seat and wear your safety belt

properly.

Do not have a seatback reclined if your vehicle is

moving.

1-6

Head Restraints

Adjust the head restraint so that the top of the restraint

is at the same height as the occupant’s head. This

position reduces the chance of a neck injury in a crash.

Pull the head restraint up

to raise it. To lower the

head restraint, press

the button, located on the

top of the seatback,

and push the restraint

down. Only the front head

restraints are adjustable.

Both the front and rear head restraints can be removed.

Press the button, located on the top of the seatback,

and pull the restraint out from the seatback. Do not

remove the head restraint if someone will be sitting in

that seat while the vehicle is moving.

1-7

Passenger Folding Seatback

Your vehicle has a front passenger seat that folds ﬂat.

{CAUTION:

If you fold the seatback forward to carry longer

objects, such as skis, be sure any such cargo

is not near an airbag. In a crash, an inﬂating

airbag might force that object toward a person.

This could cause severe injury or even death.

Secure objects away from the area in which an

airbag would inﬂate. For more information,

see Where Are the Airbags? on page 1-61 and

Loading Your Vehicle on page 4-32.

{CAUTION:

Things you put on this seatback can strike

and injure people in a sudden stop or turn, or

in a crash. Remove or secure all items before

driving.

To fold the seatback, do the following:

1. Move the front passenger seat rearward to ensure

there is enough room to fold the seatback forward.

See Manual Seats on page 1-2 for more

information. The head restraint may need to be

removed if the seat is not able to be moved

fully rearward. If removing the head restraint,

store it so that it will not move while the vehicle is

in motion.

2. Make sure that the seatback is in an upright

position. Use the recliner lever located on the

outboard side of the seat to move the seatback to

the upright position.

1-8

3. Use one of two levers to fold the seat ﬂat.

The levers are located on the rear of the seat near

the bottom of either side of the seat. Pull up on

either lever and fold the seat forward until the

seatback disengages. This can most easily be down

from the rear seats.

4. Continue to fold the seat forward until it locks in the

folded position. Pull up on the seatback to be sure

it is locked.

1-9

To raise the seatback to an upright position, do the

following:

1. Pull up on one of the two levers located on the

rear of the seat near the bottom of either side of

the seat.

2. Push the seatback up until it is in a locked position.

{CAUTION:

If the seatback is not locked, it could move

forward in a sudden stop or crash. That could

cause injury to the person sitting there. Always

push and pull on the seatback to be sure it is

locked.

3. Push and pull on the seatback to make sure it is

locked.

Rear Seats

Split Folding Rear Seat

The seatbacks can be folded ﬂat so that they are at the

same level as the rear cargo area. This allows more

cargo space.

To lower the rear seatback(s), do the following:

1. Move the front seat forward and/or put the front

seatback in an upright position so it does not

interfere with folding the rear seatback forward.

2. Open the rear door while the vehicle is parked.

3. The rear head restraint may need to be removed to

ensure that it does not interfere with the front seat

when the front seat is moved back in place.

If removed, store the head restraint where it cannot

move while the vehicle is in motion.

Notice: Folding a rear seat with the safety belts

still fastened may cause damage to the seat or the

safety belts. Always unbuckle the safety belts

and return them to their normal stowed position

before folding a rear seat.

1-10

4. Move the safety belt out of the way before lowering

the seatback. Do not let the safety belt get caught

between the seatback and seat cushion as the

seatback is folded.

5. Pull up on the knob

located on the top

of the seatback on

the outboard side to

release the seatback.

With your other hand,

pull the seatback

forward.

6. Keep folding the seatback forward until it lies ﬂat.

1-11

To raise the rear seatback(s), do the following:

{CAUTION:

A safety belt that is improperly routed, not

properly attached, or twisted will not provide

the protection needed in a crash. The person

wearing the belt could be seriously injured.

After raising the rear seatback, always check

to be sure that the safety belts are properly

routed and attached, and are not twisted.

1. Lift the seatback up and push rearward until you

hear a click. Make sure the safety belt has not

gotten twisted or lodged between the seat and the

inside panel of the vehicle.

The release knob on the top of the seatback has a

red ring. If the seatback is not fully latched this

ring will be visible. Push on the seatback until the

ring is not visible.

{CAUTION:

If the seatback is not locked, it could move

forward in a sudden stop or crash. That could

cause injury to the person sitting there. Always

pull forward on the top of the seatback at the

area of the latch to be sure it is locked.

2. Push and pull on the seatback to make sure it is

locked in place.

1-12

Safety Belts

Safety Belts: They Are for Everyone

This part of the manual tells you how to use safety

belts properly. It also tells you some things you should

not do with safety belts.

{CAUTION:

Do not let anyone ride where he or she cannot

wear a safety belt properly. If you are in a

crash and you are not wearing a safety belt,

your injuries can be much worse. You can hit

things inside the vehicle or be ejected from it.

You can be seriously injured or killed. In the

same crash, you might not be, if you are

buckled up. Always fasten your safety belt,

and check that your passengers’ belts are

fastened properly too.

{CAUTION:

It is extremely dangerous to ride in a cargo

area, inside or outside of a vehicle. In a

collision, people riding in these areas are more

likely to be seriously injured or killed. Do not

allow people to ride in any area of your vehicle

that is not equipped with seats and safety

belts. Be sure everyone in your vehicle is in a

seat and using a safety belt properly.

Your vehicle has indicators to remind you and your

passengers to buckle your safety belts. See Safety Belt

Reminder Light on page 3-27 and Passenger Safety

Belt Reminder Light on page 3-27.

1-13

In most states and in all Canadian provinces, the law

says to wear safety belts. Here is why: They work.

You never know if you will be in a crash. If you do have

a crash, you do not know if it will be a bad one.

A few crashes are mild, and some crashes can be so

serious that even buckled up, a person would not

survive. But most crashes are in between. In many of

them, people who buckle up can survive and sometimes

walk away. Without belts they could have been badly

hurt or killed.

After more than 30 years of safety belts in vehicles,

the facts are clear. In most crashes buckling up

does matter...a lot!

Why Safety Belts Work

When you ride in or on anything, you go as fast as

it goes.

Take the simplest vehicle. Suppose it is just a seat on

wheels.

1-14