FMI BLY36STL Operating instructions
- Category
- Fireplaces
- Type
- Operating instructions
This manual is also suitable for
IMPORTANT: Read entire instruction sheet before install-
ing ledgestone refractory kit.
This ledgestone refractory kit is approved for use with
DVF-36(N, P)(H, L, S)(R, T)-D and DVF-42(N, P)(H, L, S)(R,
T)-D series replaces. Do not use ledgestone refractory
kit in any other replace models.
If any of these parts are missing or damaged, contact dealer where
you purchased this kit. If they cannot supply original replacement
parts, either contact your nearest Parts Central or call FMI PROD-
UCTS, LLC at 1-866-328-4537 for information.
Note: This installation requires the gas supply line to be disconnected
before removing log assembly. Call a qualied service person to
disconnect gas supply from replace.
IMPORTANT: Always handle Ledgestone refractory panels with
two hands.
WARNING: Turn off, unplug, and let replace cool
before installing ledgestone refractories. Only a quali-
ed service person should service and repair replace.
Ledgestone Refractory Panel Kit Installation Instructions
Models: BLY36STL and BLY42STL
Figure 1 - Ledgestone Refractory Kit
Rear
Refractory
Left
Refractory
Left Front
Refractory
Center Front
Refractory
Note: Brick pattern
may look different from
illustration
Right
Refractory
Right Front
Refractory
Retaining
Brackets
Parts included with these kits:
Tools required:
• Phillips Screwdriver
• 5/16" Hex Socket Wrench or Nut Driver
KEY
NO. PART NO. DESCRIPTION QTY.
1 125123-04 Rear Refractory, 42" Ledgestone • 1
125087-04 Rear Refractory, 36" Ledgestone • 1
2 125125-04 Left Refractory, 42" Ledgestone • 1
125089-04 Left Refractory, 36" Ledgestone • 1
3 125127-04 Right Refractory, 42" Ledgestone • 1
125091-04 Right Refractory, 36" Ledgestone • 1
4 125129-04 Left Front Refractory 42" Ledgestone • 1
125093-04 Left Front Refractory 36" Ledgestone • 1
5 125131-04 Center Front Refractory 42" Ledgestone • 1
125095-04 Center Front Refractory 36" Ledgestone • 1
6 125130-04 Right Front Refractory 42" Ledgestone • 1
125094-04 Right Front Refractory 36" Ledgestone • 1
7 120520-01 Retainer, Refractory • • 3
8 11166 Screw 10 x 1/2 HWH LGM ZINC (OXI) • • 6
BLY36STL
BLY42STL
NOTICE: Log set/burner must be removed before install-
ing ledgestone refractories. Refer to log base assembly
in owner's manual.
WARNING: A qualied service person must con-
nect and disconnect replace with gas supply. Follow
all local codes.
2701 S. Harbor Blvd.
Santa Ana, CA 92704
1-866-328-4537
www.fmiproducts.com
126387-01
Rev. A
07/12
Figure 5 - Removing/Installing Burner Base
Log
Assembly
Firebox
Bottom
Burner Base
Screws
Spacers
Mesh Access Door
Figure 2: Removing Access Door
Figure 3 - Removing/Replacing Door
Door Retainer
Glass
Door
Door
Latches
INSTALLATION
1. Remove screen assembly by pushing rod either left or right, then
down and forward to remove screen/rod assembly from rebox.
2. Remove Mesh screen door as shown in Figure 2
3. Unlock 2 door latches on bottom of rebox (see Figure 3).
4. Tilt open glass door 45° from the bottom of rebox and lift up to
release door from rebox top retainer (see Figure 3).
5. Remove grate from slots in burner.
6. Carefully lift and remove 3 hearth refractories from replace.
7. Remove 3 spacers from rebox bottom (see Figure 5).
8. For 36" models only: Remove 3 loose logs from log set (see
Figure 4).
Figure 4 - Loose Logs
Loose Log #3
Loose Log #2
Loose Log #1
Underneath Log #2
9. Remove 9 screws from front and sides of rebox burner base. Lift
entire base from unit by pulling forward to disengage from rear
ange and then lifting up (see Figure 5).
10. Remove existing refractory panels.
11. Center rear refractory up against back of rebox then place
the left and right refractories on each side of the rebox (see
Figure 1).
12. Screw retaining brackets to rebox top as shown in Figure 1.
13. Reinstall log set/burner module. If needed, replace burner gasket
before reinstalling log set/burner module.
14. Reinstall 3 spacers to bottom rebox (see Figure 5).
15. Install bottom refractories included with kit.
16. Reinstall grate, glass door, mesh access door and screen as-
sembly.
-
1
-
2
FMI BLY36STL Operating instructions
- Category
- Fireplaces
- Type
- Operating instructions
- This manual is also suitable for
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
Stovax Riva2 750HL Evoke Steel User Instructions
-
-
Valor 785YN/YP Installation guide
-
-
-
-
-
Enviro C44 Owner's manual
-
Kozyheat Bellingham 52 Owner's manual
-