Waeco SI100 Operating instructions

PocketPower SI100

D 4 Wechselrichter

Bedienungsanleitung

GB 10 Inverter

Operating Manual

F16Onduleur

Notice d’emploi

E22Inversor

Instrucciones d’uso

I28Invertitore

Istruzioni d’uso

NL 34 Inverter

Gebruiksaanwijzing

DK 40 Vekselretter

Betjeningsvejledning

S 46 Växelriktare

Bruksanvisning

N 52 Vekselretter

Bruksanvisning

FIN 58 Vaihtomuunnin

Käyttöohje

MSI-100.book Seite 1 Mittwoch, 6. September 2006 3:58 15

D

Fordern Sie weitere Informationen zur umfangreichen Produktpalette aus dem

Hause WAECO an. Bestellen Sie einfach unsere Kataloge kostenlos und unver-

bindlich unter der Internetadresse: www.waeco.de

GB

We will be happy to provide you with further information about WAECO products.

Please order our free catalogue with no obligation to buy on our homepage:

www.waeco.com

F

Demandez d’autres informations relatives à la large gamme de produits de la

maison WAECO. Commandez tout simplement notre catalogue gratuitement et

sans engagement à l’adresse internet suivante : www.waeco.com

E

Solicite más información sobre la amplia gama de productos de la empresa

WAECO. Solicite simplemente nuestros catálogos de forma gratuita y sin

compromiso en la dirección de Internet: www.waeco.com

I

Per ottenere maggiori informazioni sull’ampia gamma di prodotti WAECO è possi-

bile ordinare una copia gratuita e non vincolante del nostro Catalogo all’indirizzo

Internet: www.waeco.com

NL

Maak kennis met het omvangrijke productscala van de firma WAECO. Bestel onze

catalogus gratis en vrijblijvend onder het internetadres: www.waeco.com

DK

Bestil yderligere information om det omfattende produktudvalg fra WAECO.

Bestil vores katalog gratis og uforpligtende på internetadressen: www.waeco.com

S

Inhämta mer information om den omfattande produktpaletten från WAECO:

Beställ våra kataloger gratis och utan förpliktelser under vår Internetadress:

www.waeco.com

N

Be om mer informasjon om det rikholdige produktutvalget fra WAECO. Bestill vår

katalog gratis uforbindtlig på Internettadressen: www.waeco.com

FIN

Pyytäkää lisää tietoja WAECOn kattavista tuotevalikoimista. Tilatkaa tuotekuvas-

tomme maksutta ja sitoumuksetta internet-osoitteesta: www.waeco.com

MSI-100.book Seite 2 Mittwoch, 6. September 2006 3:58 15

Page is loading ...

Contents PocketPower SI100

10

Please read this instruction manual carefully before starting the machine. Keep it

in a safe place for future reference. If the device is resold, this instruction manual

must be handed over to the purchaser along with the device.

Contents

1 Notes on using the instruction manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

4 Proper use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

6 Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

7 Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

8 Cleaning and care. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

9 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

10 Troubleshooting checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

11 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

1 Notes on using the instruction manual

The following symbols are used in this instruction manual:

Caution!

Safety instruction, failure to observe this instruction can cause injury or

damage the device.

Caution!

Safety instruction relating to a danger from electrical current or voltage. Fail-

ure to observe this instruction can damage the device and/or impair its function

and cause injury.

Note

Supplementary information for operating the device.

➤ Action: this symbol indicates that you need to do something. The required action is

described step-by-step.

✓ This symbol indicates the result of an action.

Please observe the following safety instructions.

MSI-100.book Seite 10 Mittwoch, 6. September 2006 3:58 15

PocketPower SI100 Safety instructions

11

2 Safety instructions

2.1 General safety

z Only connect the device using the connection cable to the 12 V cigarette lighter or

the 12 V on-board socket of the vehicle.

z Do not connect the 230 V output of the inverter to a different 230 V source.

z Always disconnect the power supply when working on the inverter.

z Note that even after the fuse triggers, parts of the inverter remain live.

z Do not pull the plug out of the cigarette lighter by the cable.

z If the cable is damaged, it must be replaced to prevent possible electrical hazards.

z Do not operate the device if it is visibly damaged.

z This device may only be repaired by specialist personnel. Inadequate repairs can

lead to considerable hazards.

Should your device need to be repaired, please contact WAECO customer services.

z Pull out the plug:

– Before cleaning and care

– After use

z Ensure that the ventilation slots are not covered.

z Keep the inverter out of the reach of children.

2.2 Operating the device safely

z When using the device in a vehicle, make sure that it does not impair operation of the

vehicle.

z Before starting the device ensure that the power supply line and the plug are dry.

z Never start the device when your hands are wet.

z Only operate the device when you or another person can attend to it.

z Do not operate the device on hot surfaces.

z Do not operate the device near flames or other heat sources (heating, direct sunlight,

gas ovens etc.).

z Do not immerse the device in water.

z Protect the device and the cable against heat and moisture.

z WAECO cannot be held liable for damage resulting from improper usage or incor-

rect operation.

3 Scope of delivery

Quan-

tity

Description

1 SI100 inverter with built-in connection cable for 12 Volt cigarette lighter or 12

Volt on-board socket

1 Operating manual

MSI-100.book Seite 11 Mittwoch, 6. September 2006 3:58 15

Proper use PocketPower SI100

12

4Proper use

The SI100 inverter can be used to generate a 230 Volt output from a 12 Volt power

source. The 230 Volt output can be used to power a 230 Volt consumer unit with a power

consumption of up to 110 watts.

The inverter can be used anywhere where there is a 12 V DC cigarette lighter socket. Due

to the non-sine wave voltage, some devices may heat up. The maximum constant output

is 110 Watts. Devices requiring a higher output may not be connected.

Note when connecting devices with an electrical drive (such as power drills and

refrigerators), that they often need more power than is stated on the type plate.

5 Technical description

The device has a compact design for portable use. The heat generated during operation

is dissipated by a fan inside the device.

5.1 Key to illustration on page 3

6 Connection

The 12 Volt socket and the power supply must be rated to at least 15 Amps.

Do not put in a fuse with a higher rating than 15 Amps.

Make sure the plug is firmly connected in the socket (see fig. 1.4, page 3).

If the connection is not sufficiently firm, the plug may heat up.

Do not operate the device while the vehicle is moving.

If you connect the device to the cigarette lighter, remember that the ignition

must be turned on to supply it with power.

The device has a plug for connection to a 12 V cigarette lighter or a 12 V on-board socket.

Connect the middle pin (see fig. 1.3, page 3) of the plug to the positive wire (+) and the

two side brackets (see fig. 1.2, page 3) to the negative wire (–).

Digits Description

1 Green status LED

2 Negative contact

3 Positive contact

4 230 V AC output

MSI-100.book Seite 12 Mittwoch, 6. September 2006 3:58 15

PocketPower SI100 Operation

13

7 Operation

You can operate the inverter with the engine running or switched off. However,

do not start the engine while the inverter is switched on, since the power sup-

ply to the 12 Volt socket is interrupted during ignition.

The green status LED (see fig. 1.1, page 3) indicates that the inverter is working correctly.

If the battery voltage falls below 10.7 V or the device heats up too much during operation,

the green LED flashes. If the voltage is too low or the device overheats, the inverter

switches itself off.

If the inverter overheats, pull out the connection cable from the socket. After it cools down,

you can plug the inverter back in.

When operating the inverter at high load for lengthy periods, it is advisable to

start the engine in order to recharge the vehicle battery.

8 Cleaning and care

Caution!

Before cleaning the device, pull the cable out of the socket or the cigarette

lighter.

Caution!

Do not clean the device under flowing water or in soapy water.

Caution!

Do not use abrasive cleaning agents or hard objects during cleaning as these

can damage the device.

➤ Clean the exterior of the device with a damp cloth.

9Disposal

➤ Place the packaging material in the appropriate recycling waste bins wherever pos-

sible.

If you need to scrap the device, ask your local recycling centre or specialist deal-

er for details about how to do this in accordance with the applicable disposal reg-

ulations.

MSI-100.book Seite 13 Mittwoch, 6. September 2006 3:58 15

Troubleshooting checklist PocketPower SI100

14

10 Troubleshooting checklist

Feature Possible cause Remedy

The device does not

switch on after connection

to the 12 Volt socket (the

green LED does not light

up).

The cigarette lighter is

switched on via the

ignition.

Switch the vehicle ignition on.

The battery voltage is

less than 10 V.

Charge the vehicle battery

(start the engine).

The device has over-

heated.

Switch off the consumer unit,

let the inverter cool down and

ensure better ventilation.

The fuse (in the inverter

or the vehicle) is defec-

tive.

Have an electrician replace

the fuse.

The green LED flashes

(see fig. 1 E, page 3)

The battery voltage is

below 10.7 V.

Charge the vehicle battery

(start the engine).

There is a poor contact in

the 12 Volt socket.

Clean the contacts.

The device switches on

and off repeatedly.

The constant load is too

high (the consumer unit

has a power consumption

of more than 100 Watts).

Reduce the constant load.

The inverter switches off

when the consumer is

switched on.

The starting current of the

consumer unit is too high.

Compare the device power

with the maximum power of

the inverter.

MSI-100.book Seite 14 Mittwoch, 6. September 2006 3:58 15

PocketPower SI100 Technical data

15

11 Technical data

This device conforms to the following EC guidelines:

z “Low Voltage Electrical Equipment Directive” 73/23/EEC issued 19/2/1973 including

the modified guideline 93/68/EEC

Versions, technical modifications and delivery options reserved.

Rated input voltage: 12 V DC

Constant output power: 110 W

Peak output power: 200 W

Output frequency: 50 Hz +/-2 Hz

Idle current consumption: 0.1 A

Input voltage range: 10 V - 15 V

Low voltage shutdown: 10 V

Maximum ambient temperature: 50 °C +/-5 C°

Heat dissipation: Fan

Dimensions (HxWxD, mm): 42x70x130

Weight: 340 g

Testing/certification:

MSI-100.book Seite 15 Mittwoch, 6. September 2006 3:58 15

Page is loading ...

Europe

WAECO Schweiz AG

Riedackerstrasse 7a

CH-8153 Rümlang (Zürich)

℡ +41 44 8187171

 +41 44 8187191

Mail: info@waeco.ch

WAECO Danmark A/S

Tværvej 2

DK-6640 Lunderskov

℡ +45 75585966

 +45 75586307

Mail: [email protected]k

WAECO Ibérica S.A.

Camí del Mig, 106

Poligono Industrial Les Corts

E-08349 Cabrera de Mar

(Barcelona)

℡ +34 93 7502277

 +34 93 7500552

Mail: info@waeco.es

WAECO Distribution SARL

ZAC 2 · Les Portes de L‘Oise

Rue Isaac Newton

F-60230 Chambly (Paris)

℡ +33 1 30282020

 +33 1 30282010

Mail: info@waeco.fr

WAECO Finland OY

Mestarintie 4

FIN-01730 Vantaa

℡ +358 20 7413220

 +358 9 7593700

Mail: [email protected]

WAECO Italcold SRL

Via dell’Industria 4/0

I-40012 Calderara di Reno (BO)

℡ +39 051 727094

 +39 051 727687

Mail: [email protected]t

WAECO Norge AS

Leif Weldingsvei 16

N-3208 Sandefjord

℡ +47 33428450

 +47 33428459

Mail: firmapost@waeco.no

WAECO Benelux B.V.

Ecustraat 3

NL-4879 NP Etten-Leur

℡ +31 76 5029000

 +31 76 5029090

Mail: [email protected]

WAECO Svenska AB

Gustaf Melins gata 7

S-42131 Västra Frölunda

(Göteborg)

℡ +46 31 7341100

 +46 31 7341101

Mail: [email protected]

WAECO UK Ltd.

Dorset DT2 8LY · Unit G

Roman Hill Business Park

UK-Broadmayne

℡ +44 1305 854000

 +44 1305 854288

Mail: [email protected]k

CH

DK

E

F

FIN

I

N

NL

S

UK

Overseas + Middle East

WAECO Pacific Pty. Ltd.

1 John Duncan Court

Varsity Lakes QLD 4227

℡ +61 7 55076000

 +61 7 55076001

Mail: sales@waeco.com.au

WAECO Impex Ltd.

Suites 3210-12 · 32/F · Tower 2

The Gateway · 25 Canton Road,

Tsim Sha Tsui, Kowloon

Hong Kong

℡ +852 24632750

 +852 24639067

Mail: info@waeco.com.hk

WAECO Impex Ltd.

Taipei Office

2 FL-3 · No. 56 Tunhua South Rd, Sec 2

Taipei 106, Taiwan

℡ +886 2 27014090

 +886 2 27060119

Mail: marketing@waeco.com.tw

WAECO Middle East FZCO

R/A 8, SD 6

Jebel Ali, Dubai

℡ +971 4 8833858

 +971 4 8833868

Mail: waeco@emirates.net.ae

WAECO USA, Inc.

8 Heritage Park Road

Clinton, CT 06413

℡ +1 860 6644911

 +1 860 6644912

Mail: customer[email protected]om

AUS

HK

ROC

UAE

USA

Headquarters

WAECO International GmbH · Hollefeldstraße 63 · D-48282 Emsdetten

℡ +49 2572 879-195 ·  +49-2572 879-322 · Mail: [email protected] · Internet: www.waeco.de

D

www.waeco.com

3.03.18.01248 09/2006

MSI-100.book Seite 184 Mittwoch, 6. September 2006 3:58 15

Waeco SI100 Operating instructions

This manual is also suitable for

Waeco SI100 Operating instructions

in other languages

Related papers

Other documents