COMP Cams 102102 Operating instructions

Brand: COMP Cams

Model: 102102

Type: Operating instructions

This manual is also suitable for

152152



ConformstoHazCom2012/UnitedStates



SAFETYDATASHEET

SECTION1:IDENTIFICATION



PRODUCTIDENTIFIER(S)/TRADEMARK(S)

USEDONTHELABEL:

SLIPKOTELiquidAssemblyLube

OTHERMEANSOFIDENTIFICATION:ProductCode‐10632

NSFH‐1REGISTRATIONNUMBER:Notavailable.



MANUFACTURER:SPECIALTYLUBRICANTSCORPORATION

8300CorporateParkDrive

Macedonia,OH44056USA

(P):1‐800‐238‐5823

(F):1‐330‐425‐9637



EMERGENCYTELEPHONENUMBER(WITH

HOURSOFOPERATION):

CHEMTREC,U.S.:1‐800‐424‐9300International:+1‐703‐527‐3877(24/7)



SECTION2:HAZARDSIDENTIFICATION



OSHA/HCSSTATUS:WhilethismaterialisnotconsideredhazardousbytheOSHAHazardCommunicationStandard(29CFR

1910.1200),thisSDScontainsvaluableinformationcriticaltothesafehandlingandproperuseofthe

product.ThisSDSshouldberetainedandavailableforemployeesandotherusersofthisproduct.

CLASSIFICATIONOFTHE

SUBSTANCEORMIXTURE:

Notclassified.

GHSLABELELEMENTS

SIGNALWORD:Nosignalword.

HAZARDSTATEMENTS:Noknownsignificanteffectsorcriticalhazards.

PRECAUTIONARYSTATEMENTS

GENERAL:Readlabelbeforeuse.Keepoutofreachofchildren.Ifmedicaladviceisneeded,haveproduct

containerorlabelathand.

PREVENTION:Notapplicable.

RESPONSE:Notapplicable.

STORAGE:Notapplicable.

DISPOSAL:Notapplicable.

HAZARDSNOTOTHERWISE

CLASSIFIED:

Noneknown.



Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page2of8

SECTION3:COMPOSITION/INFORMATIONONINGREDIENTS



SUBSTANCE/MIXTURE:Mixture.

OTHERMEANSOF

IDENTIFICATION:

Notavailable.

CASNUMBER/OTHERIDENTIFIERS

CASNUMBER:Notapplicable

PRODUCTCODE:57000

Therearenoingredientspresentwhich,withinthecurrentknowledgeofthesupplierandintheconcentrationsapplicable,areclassified

ashazardoustohealthortheenvironmentandhencerequirereportinginthissection.

Occupationalexposurelimits,ifavailable,arelistedinSection8.



SECTION4:FIRSTAIDMEASURES



DESCRIPTIONOFNECESSARYFIRSTAIDMEASURES

EYECONTACT:Immediatelyflusheyeswithplentyofwater,occasionallyliftingtheupperandlowereyelids.Checkfor

andremoveanycontactlenses.Getmedicalattentionifirritationoccurs.

INHALATION:Removevictimtofreshairandkeepatrestinapositioncomfortableforbreathing.Getmedical

attentionifsymptomsoccur.

SKINCONTACT:Flushcontaminatedskinwithplentyofwater.Getmedicalattentionifsymptomsoccur.

INGESTION:Washoutmouthwithwater.Removevictimtofreshairandkeepatrestinapositioncomfortablefor

breathing.Ifmaterialhasbeenswallowedandtheexposedpersonisconscious,givesmallquantities

ofwatertodrink.Donotinducevomitingunlessdirectedtodosobymedicalpersonnel.Getmedical

attentionifsymptomsoccur.

MOSTIMPORTANTSYMPTOMS/EFFECTS(ACUTEANDDELAYED)

POTENTIALACUTEHEALTHEFFECTS

EYECONTACT:Noknownsignificanteffectsorcriticalhazards.

INHALATION:Noknownsignificanteffectsorcriticalhazards.

SKINCONTACT:Noknownsignificanteffectsorcriticalhazards.

INGESTION:Noknownsignificanteffectsorcriticalhazards.

OVER‐EXPOSURESIGNS/SYMPTOMS

EYECONTACT:Noknownsignificanteffectsorcriticalhazards.

INHALATION:Noknownsignificanteffectsorcriticalhazards.

SKINCONTACT:Noknownsignificanteffectsorcriticalhazards.

INGESTION:Noknownsignificanteffectsorcriticalhazards.

INDICATIONOFIMMEDIATEMEDICALATTENTIONANDSPECIALTREATMENTNEEDED,IFNECESSARY

NOTESTOPHYSICIAN:Treatsymptomatically.Contactpoisontreatmentspecialistimmediatelyiflargequantitieshavebeen

ingestedorinhaled.

SPECIFICTREATMENTS:Nospecifictreatment.

PROTECTIONOFFIRST‐

AIDERS:

Noactionshallbetakeninvolvinganypersonalriskorwithoutsuitabletraining.

Seetoxicologicalinformation(Section11)





Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page3of8

SECTION5:FIRE‐FIGHTINGMEASURES



EXTINGUISHINGMEDIA

SUITABLEEXTINGUISHINGMEDIA:Carbondioxide,drychemical,foamandwaterfogorspray.

UNSUITABLEEXTINGUISHINGMEDIA:Noneknown.

SPECIFICHAZARDSARISINGFROMTHECHEMICAL:Nospecificfireorexplosionhazard.

HAZARDOUSTHERMALDECOMPOSITION

PRODUCTS:

Decompositionproductsmayincludethefollowingmaterials:

carbondioxide

carbonmonoxide

SPECIALPROTECTIVEACTIONSFORFIRE‐FIGHTERS:Nospecialmeasuresarerequired.

SPECIALPROTECTIVEEQUIPMENTFORFIRE‐

FIGHTERS:

Fire‐fightersshouldwearappropriateprotectiveequipmentandself‐contained

breathingapparatus(SCBA)withafullface‐pieceoperatedinpositivepressure

mode.



SECTION6:ACCIDENTALRELEASEMEASURES



PERSONALPRECAUTIONS,PROTECTIVEEQUIPMENT,ANDEMERGENCYPROCEDURES

FORNON‐EMERGENCY

PERSONNEL:

Noactionshallbetakeninvolvinganypersonalriskorwithoutsuitabletraining.Keepunnecessaryand

unprotectedpersonnelfromentering.Donottouchorwalkthroughspilledmaterial.Puton

appropriatepersonalprotectiveequipment.

FOREMERGENCY

RESPONDERS:

Ifspecializedclothingisrequiredtodealwiththespillage,takenoteofanyinformationinSection8on

suitableandunsuitablematerials.Seealsotheinformationin"Fornon‐emergencypersonnel".

ENVIRONMENTAL

PRECAUTIONS:

Avoiddispersalofspilledmaterialandrunoffandcontactwithsoil,waterways,drainsandsewers.

Informtherelevantauthoritiesiftheproducthascausedenvironmentalpollution(sewers,waterways,

soilorair).

METHODSANDMATERIALSFORCONTAINMENTANDCLEANINGUP

SMALLSPILL:Stopleakifwithoutrisk.Movecontainersfromspillarea.Dilutewithwaterandmopupifwater‐

soluble.Alternatively,orifwater‐insoluble,absorbwithaninertdrymaterialandplaceinan

appropriatewastedisposalcontainer.Disposeofviaalicensedwastedisposalcontractor.

LARGESPILL:Stopleakifwithoutrisk.Movecontainersfromspillarea.Prevententryintosewers,watercourses,

basementsorconfinedareas.Washspillagesintoaneffluenttreatmentplantorproceedasfollows.

Containandcollectspillagewithnon‐combustible,absorbentmateriale.g.sand,earth,vermiculiteor

diatomaceousearthandplaceincontainerfordisposalaccordingtolocalregulations(seeSection13).

Disposeofviaalicensedwastedisposalcontractor.Note:seeSection1foremergencycontact

informationandSection13forwastedisposal.



SECTION7:HANDLINGANDSTORAGE



PRECAUTIONSFORSAFEHANDLING

PROTECTIVEMEASURES:Putonappropriatepersonalprotectiveequipment(seeSection8).

ADVICEONGENERAL

OCCUPATIONALHYGIENE:

Eating,drinkingandsmokingshouldbeprohibitedinareaswherethismaterialishandled,storedand

processed.Workersshouldwashhandsandfacebeforeeating,drinkingandsmoking.SeealsoSection

8foradditionalinformationonhygienemeasures.

CONDITIONSFORSAFE

STORAGE,INCLUDINGANY

INCOMPATIBILITIES:

Storeinaccordancewithlocalregulations.Storeinoriginalcontainerprotectedfromdirectsunlightin

adry,coolandwell‐ventilatedarea,awayfromincompatiblematerials(seeSection10)andfoodand

drink.Keepcontainertightlyclosedandsealeduntilreadyforuse.Containersthathavebeenopened

mustbecarefullyresealedandkeptuprighttopreventleakage.Donotstoreinunlabeledcontainers.

Useappropriatecontainmenttoavoidenvironmentalcontamination.



Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page4of8

SECTION8:EXPOSURECONTROLS/PERSONALPROTECTION



CONTROLPARAMETERS

OCCUPATIONALEXPOSURELIMITSNone.

APPROPRIATEENGINEERINGCONTROLS:Goodgeneralventilationshouldbesufficienttocontrolworkerexposuretoairborne

contaminants.

ENVIRONMENTALEXPOSURE

CONTROLS:

Emissionsfromventilationorworkprocessequipmentshouldbecheckedtoensurethey

complywiththerequirementsofenvironmentalprotectionlegislation.

INDIVIDUALPROTECTIONMEASURES

HYGIENEMEASURES:Washhands,forearmsandfacethoroughlyafterhandlingchemicalproducts,beforeeating,

smokingandusingthelavatoryandattheendoftheworkingperiod.Appropriate

techniquesshouldbeusedtoremovepotentiallycontaminatedclothing.Wash

contaminatedclothingbeforereusing.Ensurethateyewashstationsandsafetyshowersare

closetotheworkstationlocation.

EYE/FACEPROTECTION:Safetyeyewearcomplyingwithanapprovedstandardshouldbeusedwhenarisk

assessmentindicatesthisisnecessarytoavoidexposuretoliquidsplashes,mists,gasesor

dusts.Ifcontactispossible,thefollowingprotectionshouldbeworn,unlesstheassessment

indicatesahigherdegreeofprotection:safetyglasseswithside‐shields.

SKINPROTECTION

HANDPROTECTION:Chemical‐resistant,imperviousglovescomplyingwithanapprovedstandardshouldbeworn

atalltimeswhenhandlingchemicalproductsifariskassessmentindicatesthisisnecessary.

BODYPROTECTION:Personalprotectiveequipmentforthebodyshouldbeselectedbasedonthetaskbeing

performedandtherisksinvolvedandshouldbeapprovedbyaspecialistbeforehandlingthis

product.

OTHERSKINPROTECTION:Appropriatefootwearandanyadditionalskinprotectionmeasuresshouldbeselectedbased

onthetaskbeingperformedandtherisksinvolvedandshouldbeapprovedbyaspecialist

beforehandlingthisproduct.

RESPIRATORYPROTECTION:Useaproperlyfitted,air‐purifyingorsuppliedairrespiratorcomplyingwithanapproved

standardifariskassessmentindicatesthisisnecessary.Respiratorselectionmustbebased

onknownoranticipatedexposurelevels,thehazardsoftheproductandthesafeworking

limitsoftheselectedrespirator.



SECTION9:PHYSICALANDCHEMICALPROPERTIES



APPEARANCE

PHYSICALSTATE:Liquid.

COLOR:Red.

ODOR:Mildpetroleum.

ODORTHRESHOLD:Notavailable.

pH:Notavailable.

MELTINGPOINT:Notavailable.

BOILINGPOINT:Notavailable.

FLASHPOINT:OpenCup:290.56°C(555°F)[Cleveland.]

BURNINGTIME:Notapplicable.

BURNINGRATE:Notapplicable.

EVAPORATIONRATE:Notavailable.

FLAMMABILITY(SOLID,GAS):Flammableinthepresenceofthefollowingmaterialsorconditions:open

flames,sparksandstaticdischarge.

LOWERANDUPPEREXPLOSIVE(FLAMMABLE)LIMITS:Notavailable.

VAPORPRESSURE: Notavailable.

VAPORDENSITY:Notavailable.

RELATIVEDENSITY:0.92g/ml

Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page5of8

SECTION9:PHYSICALANDCHEMICALPROPERTIES(CONTINUED)



SOLUBILITY:Insolubleinthefollowingmaterials:coldandhotwater

PARTITIONCOEFFICIENT:N‐OCTANOL/WATER:Notavailable.

AUTO‐IGNITIONTEMPERATURE: Notavailable.

DECOMPOSITIONTEMPERATURE:Notavailable.

SADT:Notavailable.

VISCOSITY:Notavailable.



SECTION10:STABILITYANDREACTIVITY



REACTIVITY:Nospecifictestdatarelatedtoreactivityavailableforthisproductoritsingredients.

CHEMICALSTABILITY:Theproductisstable.

POSSIBILITYOFHAZARDOUS

REACTIONS:

Undernormalconditionsofstorageanduse,hazardousreactionswillnotoccur.

CONDITIONSTOAVOID:Donotheataboveflashpoint.

INCOMPATIBLEMATERIALS:Reactiveorincompatiblewiththefollowingmaterials:oxidizingmaterials.

HAZARDOUSDECOMPOSITION

PRODUCTS:

Undernormalconditionsofstorageanduse,hazardousdecompositionproductsshouldnotbe

produced.



SECTION11:TOXICOLOGICALINFORMATION



INFORMATIONONTOXICOLOGICALEFFECTS

ACUTETOXICITY:Thereisnodataavailable.

IRRITATION/CORROSION:Thereisnodataavailable.

SENSITIZATION:Thereisnodataavailable.

MUTAGENICITY:Thereisnodataavailable.

CARCINOGENICITY:Thereisnodataavailable.

REPRODUCTIVETOXICITY:Thereisnodataavailable.

TERATOGENICITY:Thereisnodataavailable.

SPECIFICTARGETORGANTOXICITY(SINGLEEXPOSURE):Thereisnodataavailable.

SPECIFICTARGETORGANTOXICITY(REPEATEDEXPOSURE):Thereisnodataavailable.

ASPIRATIONHAZARD:Thereisnodataavailable.

INFORMATIONONTHELIKELYROUTESOFEXPOSURE:Ingestion.

POTENTIALACUTEHEALTHEFFECTS

EYECONTACT:Noknownsignificanteffectsorcriticalhazards.

INHALATION:Noknownsignificanteffectsorcriticalhazards.

SKINCONTACT:Noknownsignificanteffectsorcriticalhazards.

INGESTION:Noknownsignificanteffectsorcriticalhazards.

SYMPTOMSRELATEDTOTHEPHYSICAL,CHEMICAL,ANDTOXICOLOGICALCHARACTERISTICS

EYECONTACT:Noknownsignificanteffectsorcriticalhazards.

INHALATION:Noknownsignificanteffectsorcriticalhazards.

SKINCONTACT:Noknownsignificanteffectsorcriticalhazards.

INGESTION:Noknownsignificanteffectsorcriticalhazards.

DELAYEDANDIMMEDIATEEFFECTSANDALSOCHRONICEFFECTSFROMSHORT‐ANDLONG‐TERMEXPOSURE

SHORT‐TERMEXPOSURE: 

POTENTIALIMMEDIATEEFFECTS:Noknownsignificanteffectsorcriticalhazards.

POTENTIALDELAYEDEFFECTS:Noknownsignificanteffectsorcriticalhazards.



Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page6of8

SECTION11:TOXICOLOGICALINFORMATION(CONTINUED)



LONG‐TERMEXPOSURE:

POTENTIALIMMEDIATEEFFECTS:Noknownsignificanteffectsorcriticalhazards.

POTENTIALDELAYEDEFFECTS:Noknownsignificanteffectsorcriticalhazards.

POTENTIALCHRONICHEALTHEFFECTS

GENERAL:Noknownsignificanteffectsorcriticalhazards.

CARCINOGENICITY:Noknownsignificanteffectsorcriticalhazards.

MUTAGENICITY:Noknownsignificanteffectsorcriticalhazards.

TERATOGENICITY:Noknownsignificanteffectsorcriticalhazards.

DEVELOPMENTALEFFECTS:Noknownsignificanteffectsorcriticalhazards.

FERTILITYEFFECTS:Noknownsignificanteffectsorcriticalhazards.

NUMERICALMEASURESOFTOXICITY

ACUTETOXICITYESTIMATES:Thereisnodataavailable.



SECTION12:ECOLOGICALINFORMATION



TOXICITY:Thereisnodataavailable.

PERSISTENCEANDDEGRADABILITY:Thereisnodataavailable.

BIOACCUMULATIVEPOTENTIAL:Thereisnodataavailable.

MOBILITYINSOIL:

SOIL/WATERPARTITIONCOEFFICIENT(KOC):Notavailable.

OTHERADVERSEEFFECTS: Noknownsignificanteffectsorcriticalhazards.



SECTION13:DISPOSALCONSIDERATIONS



DISPOSALMETHODS:Thegenerationofwasteshouldbeavoidedorminimizedwhereverpossible.Disposalofthisproduct,

solutionsandanyby‐productsshouldcomplywiththerequirementsofenvironmentalprotectionand

wastedisposallegislationandanyregionallocalauthorityrequirements.Disposeofsurplusandnon‐

recyclableproductsviaalicensedwastedisposalcontractor.Wasteshouldnotbedisposedof

untreatedtothesewerunlessfullycompliantwiththerequirementsofallauthoritieswithjurisdiction.

Wastepackagingshouldberecycled.Incinerationorlandfillshouldonlybeconsideredwhenrecycling

isnotfeasible.Thismaterialanditscontainermustbedisposedofinasafeway.Emptycontainersor

linersmayretainsomeproductresidues.Avoiddispersalofspilledmaterialandrunoffandcontact

withsoil,waterways,drainsandsewers.



SECTION14:TRANSPORTINFORMATION



DOTCLASSIFICATIONIMDGIATA

UNNUMBER:Notregulated.Notregulated.Notregulated.

UNPROPERSHIPPINGNAME: ‐‐‐ ‐‐‐ ‐‐‐

TRANSPORTHAZARDCLASS(ES):‐‐‐ ‐‐‐ ‐‐‐

PACKINGGROUP: ‐‐‐ ‐‐‐ ‐‐‐

ENVIRONMENTALHAZARDS: No.No.No.

ADDITIONALINFORMATION:‐‐‐ ‐‐‐ ‐‐‐



Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page7of8

SECTION14:TRANSPORTINFORMATION(CONTINUED)



AERG:Notapplicable.

SPECIALPRECAUTIONSFORUSER:Transportwithinuser’spremises:alwaystransportinclosedcontainersthatare

uprightandsecure.Ensurethatpersonstransportingtheproductknowwhatto

dointheeventofanaccidentorspillage.

TRANSPORTINBULKACCORDINGTOANNEXIIOF

MARPOL73/78ANDTHEIBCCODE:

Notavailable.



SECTION15:REGULATORYINFORMATION



U.S.FEDERALREGULATIONS:

TSCA8(a)PAIR:ZincAlkyldithiophosphate

TSCA8(a)CDREXEMPT/PARTIALEXEMPTION:Notdetermined.Allcomponentsarelistedorexempted.

CLEANWATERACT(CWA)307:ZincAlkyldithiophosphate

CLEANAIRACTSECTION112(b)HAZARDOUSAIR

POLLUTANTS(HAPs):

Notlisted.

CLEANAIRACTSECTION602CLASSISUBSTANCES:Notlisted.

CLEANAIRACTSECTION602CLASSIISUBSTANCES: Notlisted.

DEALISTICHEMICALS(PRECURSORCHEMICALS):Notlisted.

DEALISTIICHEMICALS(ESSENTIALCHEMICALS):Notlisted.

SARA302/304

COMPOSITION/INFORMATIONONINGREDIENTS:Noproductswerefound.

SARA304RQ:Notapplicable.

SARA311/312

CLASSIFICATION:Notapplicable.

COMPOSITION/INFORMATIONONINGREDIENTS:Noproductswerefound.

STATEREGULATIONS

MASSACHUSETTS:Noneofthecomponentsarelisted.

NEWYORK:Noneofthecomponentsarelisted.

NEWJERSEY:Thefollowingcomponentsarelisted:Residualoils(petroleum),solvent‐dewaxed

PENNSYLVANIA:Noneofthecomponentsarelisted.

CALIFORNIAPROP.65Noproductswerefound.

INTERNATIONALREGULATIONS

CHEMICALWEAPONSCONVENTIONLISTSCHEDULEICHEMICALS:Notlisted.

CHEMICALWEAPONSCONVENTIONLISTSCHEDULEIICHEMICALS:Notlisted.

CHEMICALWEAPONSCONVENTIONLISTSCHEDULEIIICHEMICALS:Notlisted.

PetroleumcomponentscontainedinthisproductmeettheIP346criteriaoflessthan3percentDMSO‐extractablecomponents.



SECTION16:OTHERINFORMATION



HAZARDOUSMATERIALINFORMATIONSYSTEM(U.S.A.)

Health:1Flammability:1PhysicalHazards:1



NATIONALFIREPROTECTIONASSOCIATION(U.S.A.)

Health:1Flammability:1Instability:1



Revised:01/01/14SLIPKOTELiquidAssemblyLube(P/N10632)Page8of8

SECTION16:OTHERINFORMATION



Caution:HMIS®andNFPAratingsarebasedona0‐4ratingscale,with0representingminimalhazardsorrisks,and4representing

significanthazardsorrisks.

ThecustomerisresponsiblefordeterminingthePPEcodeforthismaterial.



HISTORY

DATEISSUE(MM/DD/YYYY):01/01/2014

VERSION:1

REVISEDSECTION(S):Notapplicable.



KEYTOABBREVIATIONS:ATE=AcuteToxicityEstimate

BCF=Bio‐concentrationFactor

GHS=GloballyHarmonizedSystemofClassificationandLabellingofChemicals

IATA=InternationalAirTransportAssociation

IBC=IntermediateBulkContainer

IMDG=InternationalMaritimeDangerousCode

LogPow=logarithmoftheoctanol/waterpartitioncoefficient

MARPOL73/78=InternationalConventionforthePreventionofPollutionfromShips,1973as

modifiedbytheProtocolof1978.(“Marpol”=marinepollution)

UN=UnitedNations



NOTICETOTHEREADER:

Tothebestofourknowledge,theinformationcontainedhereinisaccurate.However,neithertheabove‐namedsupplier,noranyof

itssubsidiaries,assumesanyliabilitywhatsoeverfortheaccuracyorcompletenessoftheinformationcontainedherein.

Finaldeterminationofsuitabilityofanymaterialisthesoleresponsibilityoftheuser.Allmaterialsmaypresentunknownhazards

andshouldbeusedwithcaution.Althoughcertainhazardsaredescribedherein,wecannotguaranteethatthesearetheonly

hazardsthatexist.





COMP Cams 102102 Operating instructions

Brand: COMP Cams

Model: 102102

Type: Operating instructions

This manual is also suitable for

152152

Download PDF

report

COMP Cams 102102 Operating instructions

This manual is also suitable for

COMP Cams 102102 Operating instructions

Other documents