Weil-McLain Weil Mclain Maxi-Flo Pool Heater WMPH-95 Operating instructions

Weil-McLain
Brand
Weil-McLain
Model
Weil Mclain Maxi-Flo Pool Heater WMPH-95
Type
Operating instructions

This manual is also suitable for

Due to the high temperature at the heat exchanger connections, we recommend
installing a stainless steel nipple (10.00" long) on the pool supply and return lines.
Seal all threaded connections with an appropriate pipe dope. Perform a leak test
to verify all joints.
5
11
8
1
12
15
5
5
13
4
9
10
5
13
6
115V
16
To the pool
Heating
zone
return
Heating zone
supply
7 7
2
3
PVC
Stainless Steel
(minimum
10.00" long)
Stainless Steel
(minimum
10.00" long)
From the Pool
16
PVC
1. Maxi-Flo Heat Exchanger
2. Boiler
3. Boiler Water Circuit
4. Thermostat or Aquastat
5. Gate Valve
6. Check Valve
7. Circulators
8. Pool Water Supply
9. Filtration
10. Pump
11. Relay
12. Flow Switch
13. Thermometer
14. Drain Valve
15. On/Off Switch
16. Flow Control Valve
Due to the high temperature at the heat exchanger connections, we recommend
installing a stainless steel nipple (10.00" long) on the pool supply and return lines.
Seal all threaded connections with an appropriate pipe dope. Perform a leak test
to verify all joints.
MAXI-FLO
SWIMMING POOL HEAT EXCHANGERS
Model WMPH-95
636-000-043/0309
SUGGESTED INSTALLATION
Chlorinators must feed downstream of the heat exchanger and have
an anti-siphoning device to prevent chemical back-up in the heat
exchanger when the pump is shut off.
High chemical concentrations from improperly adjusted feeders
and chlorinators can cause rapid corrosion to the heat exchanger.
We recommend bypassing the heat exchanger while adjusting water
chemistry. Stabilize chemistry to a pH of 7.2 – 7.8, with chlorine
residual at 1.0 to 3.0 ppm.
Damage to the heat exchanger due to improper water chemistry
(including but not limited to salt water or brine applications) is
not covered under the warranty.
WARNING
Automatic chlorinators and chemical feeders
This is only a concept drawing. Engineers must determine whether this system will work in each application and must ensure compliance with code requirements.
14
5
  • Page 1 1

Weil-McLain Weil Mclain Maxi-Flo Pool Heater WMPH-95 Operating instructions

Weil-McLain
Brand
Weil-McLain
Model
Weil Mclain Maxi-Flo Pool Heater WMPH-95
Type
Operating instructions
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents