White Mountain Hearth Madison Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Brand: White Mountain Hearth

Model: Madison Premium Clean-Face Gas Conversion NAT to LP

Type: Owner's manual

This manual is also suitable for

Tahoe Premium Clean-Face Gas Conversion NAT to LP

The White Mountain Hearth Madison Premium Clean-Face Gas Conversion NAT to LP is designed to convert your natural gas fireplace to propane gas. It includes a conversion kit with a new pilot orifice, main burner orifice, LP flue restrictor, and SIT gas valve conversion kit. The conversion process involves removing the natural gas components and replacing them with the propane gas components. It also requires adjusting the air shutter setting and replacing the flue restrictor. Once converted, your fireplace will have a manifold pressure of approximately 10.0" w.c. for maximum input and 4.9" w.c.

37112-1-1019 Page 1Empire Comfort Systems Inc. • Belleville, IL

GAS CONVERSION KIT

INSTALLATION INSTRUCTIONS

FOR CONVERSION TO PROPANE (LP) GAS

WARNING

This conversion kit is to be installed by an Empire Comfort Systems, Inc., distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

a representative is engaged in and is responsible for (a) the installation of gas piping or (b)

the connection, installation repair, or servicing of equipment, who is experienced in such

work, familiar with all precautions required, and has complied with all the requirements of the

authority having jurisdiction.

CHECK SAFETY SHUTDOWN PERFORMANCE

WARNING

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Continuous Ignition Systems (Standing Pilot)

1. Place gas control knob in PILOT position. Main burner should go off and pilot should remain lit.

2. Extinguishpilotame.Pilotgasowshouldstopwithin30seconds.Safetyshut-offofpilotgasprovescomplete

shutdownsincesafetyshut-offvalveblocksowofgastomainburnerandpilot.

3. Relightpilotburnerandoperatesystemthroughonecompletecycletomakesureallcontrolsoperateproperly.

Intermittent Ignition Systems (Intermittent Pilot)

100%Shut-OffIPSecondLockout

DIRECT VENT GAS FIREPLACE CONVERSION KITS

DVCP36(PP,SP)30-1 CONVERSION KIT DVCP36(PP,SP)70-1 CONVERSION KIT

PartNumber35396 PartNumber35398

FOR CONVERSION TO PROPANE GAS

37112-1-1019Page 2 Empire Comfort Systems Inc. • Belleville, IL

PARTS LIST

PART DESCRIPTION CONVERSION KIT - 35396 CONVERSION KIT - 35398 QUANTITY SUPPLIED

PilotOrice R7658 R10426 1

MainBurnerOrice P210 P210 1

LP Flue Restrictor

36008 36008 1

SITGasValveConversionKit

R7657 R11169 1

GasConversionLabel 2139 2139 1

Tools Needed:StandardScrewdriver,1/4"HexDriver,5/16"HexDriver,3/8"and1/2"Wrenches

Gas input for direct vent replace insert converted to Propane Gas:

• DVCP36(PP,SP)3032,000Btuperhour

• DVCP36(PP,SP)7032,000Btuperhour

ThedirectventgasreplacewhenconvertedtoPropaneGaswillhaveamanifoldpressureapproximately10.0"w.c.

(2.49kPa)foramaximuminputor4.9"w.c.(1.220kPa)foraminimuminputatthevalveoutletwiththeinletpressuretothe

valvefromaminimumof11.0"w.c.(2.739kPa)forthepurposeofinputadjustmenttoamaximumof13.0"w.c.(3.235kPa).

INSTRUCTIONS FOR CONVERSION

1. Ifthereplaceinsertisinstalled,turnOFFgasandelectricsupplytoreplacebeforemakinggasconversion.

2. Removeaccesspanelbelowglass;liftandpullawayfromreplace.

3. Releasethetwoglassframespringclampsbeneathoneofthetwoglassframes.

4. Removetheglassframeandscreenframeasanassembly.

5. Removelogsfromburnerassembly.

6. Removethetenscrewsaroundtheburnerperimeter,andremovethefalseoorfromtheburnerassembly.

7. Removethefourscrewsretainingtheburnertotheburnerbase,andremoveburner.

8. RemoveNaturalGasmainburneroricefromoricetting.

9. InstallPropaneGasmainburneroriceintooricetting:

• forDVCP36(PP,SP)30,OriceisMARKED #51

• forDVCP36(PP,SP)70,OriceisMARKED #51

10. Pullupwardonpilothoodtoremoveandgainaccesstopilotinjectororice.

11. RemoveNaturalGaspilotinjectororicefrompilotburnerwith5/32"hex(Allen)wrench.

12. InsertIncludedPropaneGaspilotinjectororiceintopilotburnerusinga5/32"hexwrench.

13. Re-installpilothoodtopilotassembly.Pushdownwardtosnapinplace.

14. ForDVCP36(PP,SP)30only,convertgasvalveasinstructedinS.I.T.PropaneGasValveConversionKit.

15.

ForDVCP36(PP,SP)70only,removeNaturalGasvalvefrommanifoldpipeandreplacewithincludedPropaneGasvalve.

16. Adjustairshuttersettingto3/16”open(1/8”with40ft.verticalvent).

17. Replacetheburnerassemblyontotheburnerbase.

18. Replacethefalseoortotheburner.

19. Forverticallyventedinstallationsonly,replacetheuerestrictorwithincludedPropaneGasuerestrictor.

20. Replacelogset.

21. Replaceglassandscreenframes,andloweraccesspanel.

22.

Theconvertedreplacemustbeconnectedtoasupplyoftheconversiongasandcheckedforleaksatallconnections.

White Mountain Hearth Madison Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Brand: White Mountain Hearth

Model: Madison Premium Clean-Face Gas Conversion NAT to LP

Type: Owner's manual

This manual is also suitable for

Tahoe Premium Clean-Face Gas Conversion NAT to LP

Download PDF

report

White Mountain Hearth Madison Premium Clean-Face Gas Conversion NAT to LP Owner's manual

This manual is also suitable for

White Mountain Hearth Madison Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Related papers

Other documents