American Hearth Tahoe Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Brand: American Hearth

Model: Tahoe Premium Clean-Face Gas Conversion NAT to LP

Type: Owner's manual

This manual is also suitable for

Madison Premium Clean-Face Gas Conversion NAT to LP

37112-1-1019 Page 1Empire Comfort Systems Inc. • Belleville, IL

GAS CONVERSION KIT

INSTALLATION INSTRUCTIONS

FOR CONVERSION TO PROPANE (LP) GAS

WARNING

This conversion kit is to be installed by an Empire Comfort Systems, Inc., distributor (or other

qualied agency¹)*in accordance with the manufacturer’s instructions and all codes and

requirements of the authority having jurisdiction. Failure to follow instructions could result

in serious injury or property damage. The qualied agency performing this work assumes

responsibility for this conversion.

1National Fuel Gas Code Z223.1 (Latest Edition)

*The term “qualied individual, rm, corporation or company which either in person or through

a representative is engaged in and is responsible for (a) the installation of gas piping or (b)

the connection, installation repair, or servicing of equipment, who is experienced in such

work, familiar with all precautions required, and has complied with all the requirements of the

authority having jurisdiction.

CHECK SAFETY SHUTDOWN PERFORMANCE

WARNING

Perform the safety shutdown test anytime work is done on a gas system to avoid the possibility

of re or explosion with property damage, personal injury or loss of life.

SAFETY SHUTDOWN SYSTEM

Continuous Ignition Systems (Standing Pilot)

1. Place gas control knob in PILOT position. Main burner should go off and pilot should remain lit.

2. Extinguishpilotame.Pilotgasowshouldstopwithin30seconds.Safetyshut-offofpilotgasprovescomplete

shutdownsincesafetyshut-offvalveblocksowofgastomainburnerandpilot.

3. Relightpilotburnerandoperatesystemthroughonecompletecycletomakesureallcontrolsoperateproperly.

Intermittent Ignition Systems (Intermittent Pilot)

100%Shut-OffIPSecondLockout

DIRECT VENT GAS FIREPLACE CONVERSION KITS

DVCP36(PP,SP)30-1 CONVERSION KIT DVCP36(PP,SP)70-1 CONVERSION KIT

PartNumber35396 PartNumber35398

FOR CONVERSION TO PROPANE GAS

37112-1-1019Page 2 Empire Comfort Systems Inc. • Belleville, IL

PARTS LIST

PART DESCRIPTION CONVERSION KIT - 35396 CONVERSION KIT - 35398 QUANTITY SUPPLIED

PilotOrice R7658 R10426 1

MainBurnerOrice P210 P210 1

LP Flue Restrictor

36008 36008 1

SITGasValveConversionKit

R7657 R11169 1

GasConversionLabel 2139 2139 1

Tools Needed:StandardScrewdriver,1/4"HexDriver,5/16"HexDriver,3/8"and1/2"Wrenches

Gas input for direct vent replace insert converted to Propane Gas:

• DVCP36(PP,SP)3032,000Btuperhour

• DVCP36(PP,SP)7032,000Btuperhour

ThedirectventgasreplacewhenconvertedtoPropaneGaswillhaveamanifoldpressureapproximately10.0"w.c.

(2.49kPa)foramaximuminputor4.9"w.c.(1.220kPa)foraminimuminputatthevalveoutletwiththeinletpressuretothe

valvefromaminimumof11.0"w.c.(2.739kPa)forthepurposeofinputadjustmenttoamaximumof13.0"w.c.(3.235kPa).

INSTRUCTIONS FOR CONVERSION

1. Ifthereplaceinsertisinstalled,turnOFFgasandelectricsupplytoreplacebeforemakinggasconversion.

2. Removeaccesspanelbelowglass;liftandpullawayfromreplace.

3. Releasethetwoglassframespringclampsbeneathoneofthetwoglassframes.

4. Removetheglassframeandscreenframeasanassembly.

5. Removelogsfromburnerassembly.

6. Removethetenscrewsaroundtheburnerperimeter,andremovethefalseoorfromtheburnerassembly.

7. Removethefourscrewsretainingtheburnertotheburnerbase,andremoveburner.

8. RemoveNaturalGasmainburneroricefromoricetting.

9. InstallPropaneGasmainburneroriceintooricetting:

• forDVCP36(PP,SP)30,OriceisMARKED #51

• forDVCP36(PP,SP)70,OriceisMARKED #51

10. Pullupwardonpilothoodtoremoveandgainaccesstopilotinjectororice.

11. RemoveNaturalGaspilotinjectororicefrompilotburnerwith5/32"hex(Allen)wrench.

12. InsertIncludedPropaneGaspilotinjectororiceintopilotburnerusinga5/32"hexwrench.

13. Re-installpilothoodtopilotassembly.Pushdownwardtosnapinplace.

14. ForDVCP36(PP,SP)30only,convertgasvalveasinstructedinS.I.T.PropaneGasValveConversionKit.

15.

ForDVCP36(PP,SP)70only,removeNaturalGasvalvefrommanifoldpipeandreplacewithincludedPropaneGasvalve.

16. Adjustairshuttersettingto3/16”open(1/8”with40ft.verticalvent).

17. Replacetheburnerassemblyontotheburnerbase.

18. Replacethefalseoortotheburner.

19. Forverticallyventedinstallationsonly,replacetheuerestrictorwithincludedPropaneGasuerestrictor.

20. Replacelogset.

21. Replaceglassandscreenframes,andloweraccesspanel.

22.

Theconvertedreplacemustbeconnectedtoasupplyoftheconversiongasandcheckedforleaksatallconnections.

American Hearth Tahoe Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Brand: American Hearth

Model: Tahoe Premium Clean-Face Gas Conversion NAT to LP

Type: Owner's manual

This manual is also suitable for

Madison Premium Clean-Face Gas Conversion NAT to LP

Download PDF

report

American Hearth Tahoe Premium Clean-Face Gas Conversion NAT to LP Owner's manual

This manual is also suitable for

American Hearth Tahoe Premium Clean-Face Gas Conversion NAT to LP Owner's manual

Related papers

Other documents