Sony CFD-G555CPK User manual

Sony
Brand
Sony
Model
CFD-G555CPK
Category
Cassette players
Type
User manual

This manual is also suitable for

SERVICE MANUAL
Sony Corporation
Personal Audio Division
Published by Sony Techno Create Corporation
Canadian Model
CFD-G555CPK
E Model
Australian Model
CFD-G555CP
Mexican Model
CFD-G555CPK
CD RADIO CASSETTE-CORDER
9-887-100-02
2006D16-1
© 2006.04
Ver. 1.1 2006.04
SPECIFICATIONS
CFD-G555CP/G555CPK
Model Name Using Similar Mechanism CFD-G550CP
CD CD Mechanism Type KSM-213CDP/C2NP
Section Optical Pick-up Type KSS-213C
TAPE Model Name Using Similar Mechanism CFD-G500/G550
Section Tape Transport Mechanism Type MF-G500
CD player section
System
Compact disc digital audio system
Laser diode properties
Emission duration: Continuous
Laser output: Less than 44.6 µW
(This output is the value measured at a
distance of about 200 mm from the objective
lens surface on the optical pick-up block with
7 mm aperture.)
Number of channels
2
Frequency response
20 - 20 000 Hz +1/–2 dB
Wow and flutter
Below measurable limit
Radio section
Frequency range
FM: 87.5 - 108 MHz
AM:531 - 1 611 kHz (9 kHz step)(G555CP)
530 - 1 610 kHz (10 kHz step)(G555CP)
530 - 1 710 kHz (G555CPK)
Antennas
FM: Telescopic antenna
AM: Built-in ferrite bar antenna
Cassette-corder section
Recording system
4-track 2 channel stereo
Fast winding time
Approx. 120 s (sec.) with Sony cassette C-60
Frequency response
TYPE I (normal): 70 - 13 000 Hz
General
Speaker
Full range: 10 cm dia., 3.2 Ω, cone type (2)
Woofer: 10 cm dia., 4 Ω, cone type (1)
Outputs
Headphones jack (stereo minijack)
For 16 - 68 Ω impedance headphones
Power output
4 W + 4 W (at 3.2 Ω, 10% harmonic
distortion)
Woofer:
12 W (at 4 Ω, 10% harmonic distortion)
Power requirements
For CD radio cassette-corder:
230 V AC, 50 Hz (G555CP: SP, E41, AUS)
120 V AC, 60 Hz (G555CP: E92/G555CPK)
12 V DC, 8 R20 (size D) batteries
For remote control:
3 V DC, 2 R03 (size AAA) batteries
Power consumption
AC 30 W
Battery life
For CD radio cassette-corder:
FM recording
Sony R20P: approx. 6 h
Sony alkaline LR20: approx. 18 h
Tape playback
Sony R20P: approx. 1.5 h
Sony alkaline LR20: approx. 6 h
CD playback
Sony R20P: approx. 1 h
Sony alkaline LR20: approx. 4 h
Dimensions
Approx. 530 × 241 × 369 mm (w/h/d)
(incl. projecting parts)
Mass
Approx. 8.0 kg (incl. batteries)
Supplied accessories
AC power cord (1)
Remote control (1)
•Abbreviation
AUS: Australian model
E41 : AC 230V area in E model
E92 : AC 120V area in E model
MX : Mexican model
SP : Singapore model
Design and specifications are subject to change
without notice.
Photo : CFD-G555CP
2
CFD-G555CP/G555CPK
TABLE OF CONTENTS
1. SERVICING NOTES ............................................... 3
2. GENERAL ................................................................... 4
3. DISASSEMBLY
3-1. Disassembly Flow ........................................................... 8
3-2. Cabinet (Upper) (1) Section ............................................ 9
3-3. Cabinet (Upper) (2) Section ............................................ 9
3-4. Cabinet (Front) Section ................................................... 10
3-5. TUNER KEY Board, VOL KEY Board .......................... 10
3-6. LCD Panel Assy .............................................................. 11
3-7. LED Board ...................................................................... 12
3-8. LCD Board ...................................................................... 13
3-9. POWER Board, TRANS Board....................................... 14
3-10. CD KEY Board (CFD-G555CPK) .................................. 14
3-11. MIC Board, POWER KEY Board,
H/P Board (CFD-G555CPK)........................................... 15
3-12. CD KEY Board (CFD-G555CP)..................................... 15
3-13. TUNER Board (CFD-G555CPK) ................................... 16
3-14. H/P Board, TUNER Board (CFD-G555CP) ................... 16
3-15. MAIN Board.................................................................... 17
3-16. CD Block Section ............................................................ 17
3-17. Optical Pick-up (KSS-213C)........................................... 18
3-18. Tape Mechanism Deck .................................................... 18
3-19. TC Board ......................................................................... 19
3-20. Main Belt, Sub Belt ......................................................... 19
4. MECHANICAL ADJUSTMENTS......................... 20
5. ELECTRICAL ADJUSTMENTS .......................... 20
6. DIAGRAMS
6-1. Block Diagram – CD/MP3 Section – ............................. 24
6-2. Block Diagram – MAIN Section –................................. 25
6-3. Printed Wiring Board – CD Section – ............................ 26
6-4. Schematic Diagram – CD Section –............................... 27
6-5. Printed Wiring Board – TUNER Section – .................... 28
6-6. Schematic Diagram – TUNER Section – ....................... 29
6-7. Printed Wiring Board – TC Section –............................. 30
6-8. Schematic Diagram – TC Section – ............................... 31
6-9. Printed Wiring Boards – MAIN Section (G555CP) – .... 32
6-10. Printed Wiring Boards – MAIN Section (G555CPK) – . 33
6-11. Schematic Diagram – MAIN Section (1/3) – ................. 34
6-12. Schematic Diagram – MAIN Section (2/3) – ................. 35
6-13. Schematic Diagram
– MAIN (3/3), CONTROL Section – .............................. 36
6-14. Printed Wiring Boards
– CONTROL Section (G555CP) – .................................. 37
6-15. Printed Wiring Boards
– CONTROL Section (G555CPK) – ............................... 38
6-16. Printed Wiring Board – POWER Section (G555CP) – .. 39
6-17. Printed Wiring Board – POWER Section (G555CPK) – 40
6-18. Schematic Diagram – POWER Section – ...................... 41
7. EXPLODED VIEWS
7-1. Overall Section ................................................................ 49
7-2. Cabinet (Front) Section ................................................... 50
7-3. Cabinet (Rear) Section .................................................... 51
7-4. Cabinet (Upper) (1) Section (CFD-G555CPK)............... 52
7-5. Cabinet (Upper) (1) Section (CFD-G555CP).................. 53
7-6. Cabinet (Upper) (2) Section ............................................ 54
7-7. Tape Mechanism Deck Section ....................................... 55
7-8. Optical Pick-up Section (KSM-213CDP/C2NP) ............ 56
8. ELECTRICAL PARTS LIST .................................. 57
Notes on chip component replacement
•Never reuse a disconnected chip component.
•Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
•Keep the temperature of soldering iron around 270˚C during
repairing.
•Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
•Be careful not to apply force on the conductor when soldering
or unsoldering.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead-
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
•Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
•Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
•Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COM- POSANTS
QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT
DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS
PUBLIÉS PAR SONY.
Ver. 1.1
3
CFD-G555CP/G555CPK
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission,
observe more than 30 cm away from the objective lens.
CHUCK PLATE JIG ON REPAIRING
On repairing CD section, playing a disc without the CD lid, use
Chuck Plate Jig.
•Code number of Chuck Plate Jig : X-4918-255-1
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
1. Turn ON the [OPERATE] button and press [CD] button to CD
position.
2. Open the CD lid.
3. Turn on S801 with screwdriver, etc. as following figure.
4. Press the u (CD) button.
5. Confirm the laser diode emission while observing the objecting
lens. When there is no emission, Auto Power Control circuit
or Optical Pick-up is broken.
Objective lens moves up and down three times for focus search.
S801
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2 V AC range are suitable. (See
Fig. A)
Fig. A. Using an AC voltmeter to check AC leakage.
1.5 k
Ω
0.15
µ
FAC
voltmete
r
(0.75 V)
To Exposed Metal
Parts on Set
Earth Ground
Ver. 1.1
4
CFD-G555CP/G555CPK SECTION 2
GENERAL This section is extracted
from instruction manual.
"ASIC/PERATIONS
6/,
ȱ
ā
Ȯ
à
ȩ
AND
Ⱥ
ONTHEREMOTEHAVEATACTILE
DOT
"EFOREUSINGTHEUNIT
4OTURNONOFFTHEPOWER
0RESS0/7%2
ȷ
4OADJUSTTHEVOLUME
0RESS6/,n
ȱ
4OLISTENTHROUGHHEADPHONES
#ONNECTTHEHEADPHONESTOTHEHEADPHONESJACKȸ
4OSELECTTHESOUNDCHARACTERISTIC
0RESS3/5.$
Ȱ
REPEATEDLYTOSELECTTHEAUDIO
EMPHASISYOUWANT
#HOOSE 4OGET
0OWERFULCLEANSOUNDSEMPHASIZING
LOWANDHIGHRANGEAUDIO
,IGHTBRIGHTSOUNDSEMPHASIZINGHIGH
ANDMIDDLERANGEAUDIO
0ERCUSSIVESOUNDSEMPHASIZINGBASS
AUDIO
4HEPRESENCEOFVOCALSSTRESSING
MIDDLERANGEAUDIO
4HEWHOLEDYNAMICRANGEFORMUSIC
SUCHASCLASSICALMUSIC
4OREINFORCETHEBASSSOUND
0RESS0/7%2$2)6%7//&%27//&%2ON
THEREMOTE
ȫ
TOSELECT OR ON
THEDISPLAY ISMOREEFFECTIVE7HENTHE
7//&%2FUNCTIONWORKSTHERINGONTHEFRONTPANEL
LIGHTSUP
4ORETURNTONORMALSOUNDPRESSTHEBUTTONREPEATEDLY
UNTILTHEINDICATIONDISAPPEARSFROMTHEDISPLAY
.OTES
s7HILETHESLEEPINGTIMERISONTHERINGDOESNOTLIGHTEVENIFTHE
7//&%2FUNCTIONISUSED
s7HENYOUUSETHEHEADPHONESTHE7//&%2FUNCTIONDOESNOT
WORK
0LAYINGA#$-0DISC
 0RESSì053(/0%.#,/3%
ȯ
ONTHEUNIT
ANDPLACEADISCWITHTHELABELSIDEUPONTHE#$
COMPARTMENT
4OCLOSETHE#$COMPARTMENTPRESSì053(/0%.
#,/3%
ȯ
ONTHEUNIT
 0RESS
ā
ONTHEUNIT
à
ONTHEREMOTE
Ȯ
4HEUNITPLAYSALLTHETRACKS-0lLESONCE
7HENYOUPLACE-0DISCSh-0vAPPEARSINTHE
DISPLAYAFTERTHEUNITREADSTHElLEINFORMATION
!UDIO#$
4RACK
NUMBER
0LAYING
TIME
-0DISC
-0lLE
NUMBER
!FTERTHElLENAMEIS
DISPLAYEDTHEPLAYING
TIMEWILLAPPEAR
4O 0RESS
0AUSEPLAYBACK
ā
ONTHEUNIT
ê
ONTHEREMOTE
Ȯ
4ORESUMEPLAYPRESSITAGAIN
3TOPPLAYBACK
Ą
Ȯ
'OTOTHENEXT
TRACK-0lLE
Ñ
ȭ
'OBACKTOTHE
PREVIOUSTRACK
-0lLE
Ã
ȭ
3ELECTAFOLDERON
AN-0DISC
&/,$%2TOGOFORWARDAND
&/,$%2nTOGOBACKWARD
Ȭ
,OCATEAPOINT
WHILELISTENINGTO
THESOUND
Ñ
FORWARDOR
Ã
BACKWARD
ȭ
WHILEPLAYINGANDHOLDITUNTIL
YOUlNDTHEPOINT
,OCATEAPOINT
WHILEOBSERVING
THEDISPLAY
Ñ
FORWARDOR
Ã
BACKWARD
ȭ
INPAUSEANDHOLDITUNTILYOU
lNDTHEPOINT
,OCATEASPECIlC
TRACK-0lLE
DIRECTLY
4HENUMBERBUTTON
Ⱥ
OFTHETRACK
-0lLEONTHEREMOTE
2EMOVETHE#$
ì
053(/0%.#,/3%
ȯ
4IPS
s0LAYBACKSTARTSFROMTHETRACK-0lLEYOULASTSTOPPEDPLAYING
2ESUMEPLAY$URINGSTOPTHETRACK-0lLENUMBERTOBEPLAYED
ISDISPLAYED
s4OCANCELTHERESUMEPLAYTOSTARTPLAYFROMTHEBEGINNINGOFTHE
lRSTTRACK-0lLEPRESS
Ą
Ȯ
WHILETHE#$ISSTOPPED7HENYOU
OPENTHE#$COMPARTMENTORTURNOFFTHEUNITTHERESUMEPLAYIS
ALSOCANCELED
s7HENYOULOCATEATRACK-0lLENUMBEREDOVERPRESS
Ⱥ
ONTHEREMOTElRSTTHENTHECORRESPONDINGNUMBERBUTTONS
Ⱥ
ON
THEREMOTE
%XAMPLE4OPLAYTRACK-0lLENUMBERPRESSlRSTTHEN
AND
s4OSELECTATRACK-0lLENUMBEREDORMOREPRESS
Ⱥ
ON
THEREMOTETWICETHENTHECORRESPONDINGNUMBERBUTTONS
Ⱥ
ONTHE
REMOTE
.OTE
9OUCANNOTLOCATEASPECIlCTRACK-0lLEIFh3(5&vORh0'-vIS
LITINTHEDISPLAY4URNOFFTHEINDICATIONBYPRESSING
Ą
Ȯ
%XAMPLEOFFOLDERSTRUCTUREANDPLAYING
ORDER
4HEPLAYINGORDEROFTHEFOLDERSANDlLESISASFOLLOWS
&OLDER
-0lLE
.OTESON-0DISCS
s7HENTHEDISCISINSERTEDTHEUNITREADSALLTHElLESONTHATDISC
$URINGTHISTIMEh2%!$).'vISDISPLAYED)FTHEREAREMANY
FOLDERSORNON-0lLESONTHEDISCITMAYTAKEALONGTIMEFORPLAY
TOBEGINORFORTHENEXT-0lLETOSTARTPLAY
7ERECOMMENDTHATYOUDONOTSAVEUNNECESSARYFOLDERSORlLES
OTHERTHAN-0ONESINTHEDISCTOBEUSEDFOR-0LISTENING
s,OCATINGASPECIlC-0lLEUSINGTHENUMBERBUTTONS
Ⱥ
ONTHE
REMOTEISONLYAVAILABLEFORTHE-0lLESINTHESELECTEDFOLDER
s!FOLDERTHATDOESNOTINCLUDEAN-0lLEISSKIPPED
s-AXIMUMNUMBEROFFOLDERS
-AXIMUMNUMBEROFlLES
-AXIMUMDIRECTORYLEVELS
s&OLDERNAMESANDlLENAMESCANBEDISPLAYEDWITHUPTO
CHARACTERSINCLUDINGQUOTATIONMARKSANDACHARACTEREXTENSION
CODE
s4HECHARACTERS!:AZAND?CANBEDISPLAYEDONTHISUNIT
/THERCHARACTERSAREDISPLAYEDAShv
s4HISUNITCONFORMSTO6ERSIONOFTHE)$TAGFORMAT)FTHElLE
HASTHE)$TAGINFORMATIONhSONGTITLEvhARTISTNAMEvANDhALBUM
NAMEvCANBEDISPLAYED
s7HENNAMINGBESURETOADDTHElLEEXTENSIONhMPvTOTHElLE
NAME
s)FYOUPUTTHEEXTENSIONhMPvTOAlLEOTHERTHANAN-0lLETHE
UNITCANNOTRECOGNIZETHElLEPROPERLYANDWILLGENERATERANDOM
NOISETHATCOULDDAMAGEYOURSPEAKERS
s4HElLENAMEDOESNOTCORRESPONDTOTHE)$TAG
,ISTENINGTOTHERADIO
 0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNIT"!.$
Ȼ
ONTHEREMOTEREPEATEDLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
h&-vh!-v
 (OLDDOWN45.%ORn
Ȫ
UNTILTHEFREQUENCY
DIGITSBEGINTOCHANGEINTHEDISPLAY
4HEUNITAUTOMATICALLYSCANSTHERADIOFREQUENCIES
ANDSTOPSWHENITlNDSACLEARSTATION
)FYOUCANNOTTUNEINASTATIONPRESS45.%ORn
Ȫ
REPEATEDLYTOCHANGETHEFREQUENCYSTEPBYSTEP
7HENAN&-STEREOBROADCASTISRECEIVEDh34v
APPEARS
4IP
)FTHE&-BROADCASTISNOISYPRESS-/$%
ȵ
UNTILh-ONOvAPPEARS
INTHEDISPLAYANDTHERADIOWILLPLAYINMONAURAL
#HANGINGTHE!-TUNINGINTERVAL
%XCEPTFORTHE!USTRALIANMODEL
)FYOUNEEDTOCHANGETHE!-TUNINGINTERVALDOTHE
FOLLOWING
 0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITUNTILh!-vISDISPLAYED
 0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNITFORSECONDS
 0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITFORSECONDS
h!-vORh!-vmASHES
 0RESS02%3%4ORn
ȭ
ONTHEUNITTOSELECT
h!-vFORK(ZINTERVALORh!-vFORK(Z
INTERVAL
 0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNIT
!FTERCHANGINGTHETUNINGINTERVALYOUNEEDTORESETYOUR
PRESET!-RADIOSTATIONS
0LAYINGATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION
 0RESSĄì
ȩ
ONTHEUNITANDINSERTTHETAPEINTO
THETAPECOMPARTMENTWITHTHESIDEYOUWANTTO
PLAYFACINGUPWARD5SE490%)NORMALTAPE
ONLY#LOSETHECOMPARTMENT
-AKESURETHEREISNOSLACKINTHETAPETOAVOID
DAMAGINGTHETAPEORTHEUNIT
 0RESSà
ȩ
ONTHEUNIT
4HEUNITSTARTSPLAYING
4O 0RESS
0AUSEPLAYBACK
ê
ȩ
ONTHEUNIT4ORESUMEPLAY
PRESSITAGAIN
3TOPPLAYBACK
Ąì
ȩ
ONTHEUNIT
&ASTFORWARDOR
REWIND
ß
OR
ù
FASTFORWARDOR
REWIND
ȩ
ONTHEUNIT
%JECTTHECASSETTE
Ąì
ȩ
ONTHEUNIT
2ECORDINGONATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION

0RESSĄì
ȩ
ONTHEUNITTOOPENTHETAPE
COMPARTMENTANDINSERTABLANKTAPEWITHTHESIDE
YOUWANTTORECORDONFACINGUPWARD5SE490%)
NORMALTAPEONLY#LOSETHECOMPARTMENT
 3ELECTTHEPROGRAMSOURCEYOUWANTTORECORD
4ORECORDFROMTHE#$PLAYERPRESSĄ
Ȯ
ONTHEUNIT
ANDPLACEA#$
4ORECORDFROMTHERADIOTUNEINTHESTATIONYOUWANT
SEEh,ISTENINGTOTHERADIOv
 0RESSĆ
ȩ
ONTHEUNITTOSTARTRECORDINGàIS
DEPRESSEDAUTOMATICALLY
4O 0RESS
0AUSERECORDING
ê
ȩ
ONTHEUNIT
0RESSTHEBUTTONAGAINTO
RESUMERECORDING
3TOPRECORDING
Ąì
ȩ
ONTHEUNIT
4IPS
s!DJUSTINGTHEVOLUMEORTHEAUDIOEMPHASISWILLNOTAFFECTTHE
RECORDINGLEVEL
s&ORTHEBESTRESULTSUSETHE!#POWERASAPOWERSOURCEFOR
RECORDING
s4OERASEARECORDINGPROCEEDASFOLLOWS
)NSERTTHETAPEWHOSERECORDINGYOUWANTTOERASE
-AKESURETHATh4!0%vISDISPLAYED)Fh4!0%vISNOTDISPLAYED
PRESSà
ȩ
ONTHEUNITORPRESS&5.#4)/.
ȹ
ONTHEREMOTE
UNTILITAPPEARSINTHEDISPLAY
0RESSĆ
ȩ
ONTHEUNIT
CFD-G555CP (1/2)
5
CFD-G555CP/G555CPK
5SINGTHEDISPLAY
9OUCANCHECKINFORMATIONABOUTTHE#$USINGTHE
DISPLAY
#HECKINGTHEINFORMATIONOFANAUDIO
#$
4OCHECKTHETOTALTRACKNUMBERANDPLAYING
TIMEOFTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALTRACKNUMBER
4OTALPLAYINGTIME
4OCHECKTHEREMAININGTIME
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
WHILEPLAYINGA#$4HEDISPLAYCHANGESASFOLLOWS
4HECURRENTTRACKNUMBERANDPLAYINGTIME
Ô
4HECURRENTTRACKNUMBERANDTHEREMAINING
TIMEOFTHECURRENTTRACK
4HENUMBEROFTRACKSLEFTANDTHETIME
REMAININGONTHE#$
#HECKINGTHEINFORMATIONOFAN-0
DISC
4OCHECKTHETOTALFOLDERNUMBERANDTOTAL
lLENUMBERONTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALFOLDER
NUMBER 4OTALlLENUMBER
4OCHECKlLEINFORMATION
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
WHILEPLAYINGAN-0DISC4HEDISPLAYCHANGESAS
FOLLOWS
4HECURRENTlLENUMBERANDPLAYINGTIME
Ô
4HECURRENTlLENUMBERANDTHElLENAME
4HEFOLDERNUMBERANDTHEFOLDERNAME
4HECURRENTlLENUMBERAND)$THESONG
TITLETHEARTISTNAMETHEALBUMNAME
 )FTHEFOLDERDOESNOTHAVEAFOLDERNAMEh2//4vAPPEARSINSTEAD
OFAFOLDERNAME
)FTHElLEDOESNOTHAVE)$INFORMATIONh./4)4,%vh./
!24)34vORh./!,"5-vAPPEARSINTHEDISPLAY
0LAYINGTRACKS-0lLES
REPEATEDLY2EPEAT0LAY
9OUCANPLAYTRACKS-0lLESREPEATEDLYINNORMAL
3HUFmEOR0ROGRAMPLAYMODES

0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY

0ROCEEDASFOLLOWS
4OREPEAT $OTHIS
!SINGLE
TRACK-0
lLE
 0RESS2%0%!4
Ȳ
UNTILh2%0vAPPEARS
 0RESS
Ã
OR
Ñ
ȭ
TOSELECTTHETRACK
-0lLETHATYOUWANTTOREPEAT
 0RESS
ā
Ȯ
ONTHEUNIT
!LLTRACKS
-0lLES
ONTHE#$
 0RESS2%0%!4
Ȳ
UNTILh2%0!,,v
APPEARS
 0RESS
ā
Ȯ
ONTHEUNIT
!SELECTED
FOLDER
-0DISC
ONLY
 0RESS2%0%!4
Ȳ
UNTILh2%0vAND
h&,$2vAPPEAR
 3ELECTTHEFOLDERBYPRESSING&/,$%2
OR&/,$%2n
Ȭ
 0RESS
ā
Ȯ
ONTHEUNIT
4RACKS
-0lLES
INRANDOM
ORDER
 3ELECT3HUFmE0LAYSEEh0LAYINGTRACKS
-0lLESINRANDOMORDERv
 0RESS2%0%!4
Ȳ
UNTILh3(5&vAND
h2%0vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
0ROGRAMED
TRACKS
-0lLES
 0ROGRAMTRACKS-0lLESSEEh#REATING
YOUROWNPROGRAMv
 0RESS2%0%!4
Ȳ
UNTILh2%0vAND
h0'-vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
0ROGRAMED
FOLDERS
-0DISC
ONLY
 0ROGRAMFOLDERSSEEh#REATINGYOUROWN
PROGRAMv
 0RESS2%0%!4
Ȳ
UNTILh2%0vh0'-v
ANDh&,$2vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
/NTHEREMOTE
s5SE
à
Ȯ
INSTEADOF
ā
Ȯ
s!FTERYOUHAVESELECTEDh2%0vPRESSTHENUMBER
BUTTONS
Ⱥ
TOSELECTTHETRACK-0lLE
/THER/PERATIONS
4OCANCEL2EPEAT0LAY
0RESS2%0%!4
Ȳ
UNTILh2%0vDISAPPEARSFROMTHE
DISPLAY
0LAYINGTRACKS-0lLESIN
RANDOMORDER3HUFmE0LAY
9OUCANPLAYTRACKS-0lLESINRANDOMORDER

0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY

0RESS-/$%
ȵ
UNTILh3(5&vAPPEARSINTHE
DISPLAY

0RESSā
Ȯ
ONTHEUNITTOSTART3HUFmE0LAY
/NTHEREMOTE
5SE
à
Ȯ
INSTEADOF
ā
Ȯ
4OCANCEL3HUFmE0LAY
3TOPPLAYINGlRST4HENPRESS-/$%
ȵ
UNTILh3(5&v
DISAPPEARSFROMTHEDISPLAY
4IPS
s$URING3HUFmE0LAYYOUCANNOTSELECTTHEPREVIOUSTRACK-0lLE
BYPRESSING
Ã
ȭ
s4HERESUMEFUNCTIONDOESNOTWORKDURING3HUFmE0LAY
#REATINGYOUROWNPROGRAM
0ROGRAM0LAY
9OUCANARRANGETHEPLAYINGORDEROFUPTOTRACKS
-0lLESONA#$7HENPLAYINGAN-0DISCYOUCAN
ALSOPROGRAMUPTOFOLDERS0ROGRAM&OLDER0LAY

0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY

0RESS-/$%
ȵ
UNTILh0'-vmASHESINTHE
DISPLAY
7HENYOUSELECT0ROGRAM&OLDER0LAY-0DISC
ONLYPRESS-/$%
ȵ
UNTILh0'-vANDh&,$2v
APPEARINTHEDISPLAY

0RESS
Ã
OR
Ñ
ȭ
THENPRESS$)30,!9s
%.4%2s-%-/29
ȴ
ONTHEUNITFORTHETRACKS
-0lLESYOUWANTTOPROGRAMINTHEORDERYOU
WANT
5SE&/,$%2ORn
Ȭ
TOSELECTFOLDERSFOR0ROGRAM
&OLDER0LAY
!UDIO#$0ROGRAM0LAY
0LAYINGORDER
0ROGRAMEDTRACK
NUMBER
-0DISC0ROGRAM0LAY
0LAYINGORDER
0ROGRAMEDlLENAME
-0DISC0ROGRAM&OLDER0LAY
0LAYINGORDER
0ROGRAMEDFOLDER
NAME

0RESS
ā
Ȯ
ONTHEUNITTOSTART0ROGRAM0LAY
/NTHEREMOTE
s5SE
à
Ȯ
INSTEADOF
ā
Ȯ
s!FTERYOUHAVESELECTEDh0'-vPRESSTHENUMBER
BUTTONS
Ⱥ
FORTHETRACKS-0lLESYOUWANTTO
PROGRAMINTHEORDERYOUWANT
4OCANCEL0ROGRAM0LAY
3TOPPLAYINGlRST4HENPRESS-/$%
ȵ
UNTILh0'-v
DISAPPEARSFROMTHEDISPLAY
4OCHECKTHEORDEROFTRACKS-0lLES
BEFOREPLAY
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
%VERYTIMEYOUPRESSTHEBUTTONTHETRACKNUMBER-0
lLENAMEORFOLDERNAMEAPPEARSINTHEPROGRAMEDORDER
4OCHANGETHECURRENTPROGRAM
0RESSĄ
Ȯ
ONCEIFTHE#$ISSTOPPEDANDTWICEIFTHE
#$ISPLAYING4HECURRENTPROGRAMWILLBEERASED
4HENCREATEANEWPROGRAMFOLLOWINGTHEPROGRAMING
PROCEDURE
4IPS
s9OUCANPLAYTHESAMEPROGRAMAGAINSINCETHEPROGRAMISSAVED
UNTILYOUOPENTHE#$COMPARTMENT
s9OUCANRECORDYOUROWNPROGRAM!FTERYOUHAVECREATEDTHE
PROGRAMINSERTABLANKTAPEANDPRESSĆ
ȩ
ONTHEUNITTOSTART
RECORDING
s4HERESUMEFUNCTIONDOESNOTWORKDURING0ROGRAM0LAY
0RESETTINGRADIOSTATIONS
9OUCANSTORERADIOSTATIONSINTOTHEUNITSMEMORY9OU
CANPRESETUPTORADIOSTATIONSFOR&-ANDFOR
!-INANYORDER

0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITTOSELECTTHEBAND

(OLDDOWN2!$)/"!.$s!54/02%3%4
ȳ
ON
THEUNITFORSECONDSUNTILh!54/vmASHESINTHE
DISPLAY

0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNIT
4HESTATIONSARESTOREDINMEMORYFROMTHELOWER
FREQUENCIESTOTHEHIGHERONES
)FASTATIONCANNOTBEPRESETAUTOMATICALLY
9OUNEEDTOPRESETASTATIONWITHAWEAKSIGNALMANUALLY

0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITTOSELECTTHEBAND

4U NEINASTATIONYOUWANT

(OLDDOWN$)30,!9s%.4%2s-%-/29
ȴ
ON
THEUNITFORSECONDSUNTILTHEPRESETNUMBER
mASHESINTHEDISPLAY

0RESS02%3%4ORn
ȭ
ONTHEUNITUNTILTHE
PRESETNUMBERYOUWANTFORTHESTATIONmASHESIN
THEDISPLAY

0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNIT
4HENEWSTATIONREPLACESTHEOLDONE
/NTHEREMOTE

0RESS"!.$
Ȼ
UNTILTHEBANDYOUWANTAPPEARS
INTHEDISPLAY

4U NEINASTATIONYOUWANT

(OLDDOWNTHENUMBERBUTTONS
Ⱥ
THATYOUWANT
TOPRESETTHENEWSTATIONONFORABOUTSECONDS
4OSELECTTHEPRESETNUMBEROVERPRESS
Ⱥ
lRSTTHENTHECORRESPONDINGNUMBERBUTTONS
Ⱥ
9OUNEEDTOHOLDDOWNTHELASTNUMBERBUTTONTOENTER
FORABOUTSECONDS
%XAMPLE4OSELECTPRESSANDlRSTTHEN
HOLDDOWNFORABOUTSECONDS
4IP
4HEPRESETRADIOSTATIONSREMAININMEMORYEVENIFYOUUNPLUGTHE
!#POWERCORDORREMOVETHEBATTERIES
0LAYINGPRESETRADIOSTATIONS

0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITTOSELECTTHEBAND

0RESS02%3%4ORn
ȭ
ONTHEUNITTOTUNEIN
THESTOREDSTATION
/NTHEREMOTE

0RESS"!.$
Ȼ

0RESSTHENUMBERBUTTONS
Ⱥ
TOTUNEINTHE
STOREDSTATION
4OTUNEINAPRESETSTATIONOVERPRESS
Ⱥ
lRST
THENCORRESPONDINGNUMBERBUTTONS
Ⱥ

%XAMPLE4OTUNEINAPRESETSTATIONPRESS
ANDlRSTANDTHENPRESS
&ALLINGASLEEPTOMUSIC

0LAYTHEMUSICSOURCEYOUWANT

0RESS3,%%0
ȶ
TODISPLAYh3,%%0v

0RESS3,%%0
ȶ
TOSELECTTHEMINUTESUNTILTHE
UNITGOESOFFAUTOMATICALLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
hvhvhvh/&&vhvhv
hv
)FSECONDSHAVEPASSEDAFTERYOUPRESSED3,%%0
ȶ

THEMINUTESINTHEDISPLAYAREENTERED
7HENTHEPRESETTIMEHASPASSEDTHEUNITGOESOFF
AUTOMATICALLY
4OCANCELTHESLEEPFUNCTION
0RESS0/7%2
ȷ
TOTURNOFFTHEPOWER
.OTE
7HENYOUAREPLAYINGATAPEUSINGTHISFUNCTION
)FTHETAPELENGTHOFONESIDEISLONGERTHANTHESETTIMETHEUNITWILL
NOTGOOFFUNTILTHETAPEREACHESTHEEND
CFD-G555CP (2/2)
6
CFD-G555CP/G555CPK
"ASIC/PERATIONS
6/,
ȱ
ā
Ȯ
à
ȩ
AND
Ȼ
ONTHEREMOTEHAVEATACTILE
DOT
"EFOREUSINGTHEUNIT
4OTURNONOFFTHEPOWER
0RESS0/7%2
ȷ
4OADJUSTTHEVOLUME
0RESS6/,n
ȱ
4OLISTENTHROUGHHEADPHONES
#ONNECTTHEHEADPHONESTOTHEHEADPHONESJACKȸ
4OSELECTTHESOUNDCHARACTERISTIC
0RESS3/5.$
Ȱ
REPEATEDLYTOSELECTTHEAUDIO
EMPHASISYOUWANT
#HOOSE 4OGET
0OWERFULCLEANSOUNDSEMPHASIZING
LOWANDHIGHRANGEAUDIO
,IGHTBRIGHTSOUNDSEMPHASIZINGHIGH
ANDMIDDLERANGEAUDIO
0ERCUSSIVESOUNDSEMPHASIZINGBASS
AUDIO
4HEPRESENCEOFVOCALSSTRESSING
MIDDLERANGEAUDIO
4HEWHOLEDYNAMICRANGEFORMUSIC
SUCHASCLASSICALMUSIC
4OREINFORCETHEBASSSOUND
0RESS0/7%2$2)6%7//&%27//&%2ON
THEREMOTE
ȫ
TOSELECT OR ON
THEDISPLAY ISMOREEFFECTIVE7HENTHE
7//&%2FUNCTIONWORKSTHERINGONTHEFRONTPANEL
LIGHTSUP
4ORETURNTONORMALSOUNDPRESSTHEBUTTONREPEATEDLY
UNTILTHEINDICATIONDISAPPEARSFROMTHEDISPLAY
.OTES
s7HILETHESLEEPINGTIMERISONTHERINGDOESNOTLIGHTEVENIFTHE
7//&%2FUNCTIONISUSED
s7HENYOUUSETHEHEADPHONESTHE7//&%2FUNCTIONDOESNOT
WORK
0LAYINGA#$-0DISC

0RESSì053(/0%.#,/3%
ȯ
ONTHEUNIT
ANDPLACEADISCWITHTHELABELSIDEUPONTHE#$
COMPARTMENT
4OCLOSETHE#$COMPARTMENTPRESSì053(/0%.
#,/3%
ȯ
ONTHEUNIT

0RESS
ā
ONTHEUNIT
à
ONTHEREMOTE
Ȯ
4HEUNITPLAYSALLTHETRACKS-0lLESONCE
7HENYOUPLACE-0DISCSh-0vAPPEARSINTHE
DISPLAYAFTERTHEUNITREADSTHElLEINFORMATION
!UDIO#$
4RACK
NUMBER
0LAYING
TIME
-0DISC
-0lLE
NUMBER
!FTERTHElLENAMEIS
DISPLAYEDTHEPLAYING
TIMEWILLAPPEAR
4O 0RESS
0AUSEPLAYBACK
ā
ONTHEUNIT
ê
ONTHEREMOTE
Ȯ
4ORESUMEPLAYPRESSITAGAIN
3TOPPLAYBACK
Ą
Ȯ
'OTOTHENEXT
TRACK-0lLE
Ñ
ȭ
'OBACKTOTHE
PREVIOUSTRACK
-0lLE
Ã
ȭ
3ELECTAFOLDERON
AN-0DISC
&/,$%2TOGOFORWARDAND
&/,$%2nTOGOBACKWARD
Ȭ
,OCATEAPOINT
WHILELISTENINGTO
THESOUND
Ñ
FORWARDOR
Ã
BACKWARD
ȭ
WHILEPLAYINGANDHOLDITUNTIL
YOUlNDTHEPOINT
,OCATEAPOINT
WHILEOBSERVING
THEDISPLAY
Ñ
FORWARDOR
Ã
BACKWARD
ȭ
INPAUSEANDHOLDITUNTILYOU
lNDTHEPOINT
,OCATEASPECIlC
TRACK-0lLE
DIRECTLY
4HENUMBERBUTTON
Ȼ
OFTHETRACK
-0lLEONTHEREMOTE
2EMOVETHE#$
ì
053(/0%.#,/3%
ȯ
4IPS
s0LAYBACKSTARTSFROMTHETRACK-0lLEYOULASTSTOPPEDPLAYING
2ESUMEPLAY$URINGSTOPTHETRACK-0lLENUMBERTOBEPLAYED
ISDISPLAYED
s4OCANCELTHERESUMEPLAYTOSTARTPLAYFROMTHEBEGINNINGOFTHE
lRSTTRACK-0lLEPRESS
Ą
Ȯ
WHILETHE#$ISSTOPPED7HENYOU
OPENTHE#$COMPARTMENTORTURNOFFTHEUNITTHERESUMEPLAYIS
ALSOCANCELED
s7HENYOULOCATEATRACK-0lLENUMBEREDOVERPRESS
Ȼ
ONTHEREMOTElRSTTHENTHECORRESPONDINGNUMBERBUTTONS
Ȼ
ON
THEREMOTE
%XAMPLE4OPLAYTRACK-0lLENUMBERPRESSlRSTTHEN
AND
s4OSELECTATRACK-0lLENUMBEREDORMOREPRESS
Ȼ
ON
THEREMOTETWICETHENTHECORRESPONDINGNUMBERBUTTONS
Ȼ
ONTHE
REMOTE
.OTE
9OUCANNOTLOCATEASPECIlCTRACK-0lLEIFh3(5&vORh0'-vIS
LITINTHEDISPLAY4URNOFFTHEINDICATIONBYPRESSING
Ą
Ȯ
%XAMPLEOFFOLDERSTRUCTUREANDPLAYING
ORDER
4HEPLAYINGORDEROFTHEFOLDERSANDlLESISASFOLLOWS
&OLDER
-0lLE
.OTESON-0DISCS
s7HENTHEDISCISINSERTEDTHEUNITREADSALLTHElLESONTHATDISC
$URINGTHISTIMEh2%!$).'vISDISPLAYED)FTHEREAREMANY
FOLDERSORNON-0lLESONTHEDISCITMAYTAKEALONGTIMEFORPLAY
TOBEGINORFORTHENEXT-0lLETOSTARTPLAY
7ERECOMMENDTHATYOUDONOTSAVEUNNECESSARYFOLDERSORlLES
OTHERTHAN-0ONESINTHEDISCTOBEUSEDFOR-0LISTENING
s,OCATINGASPECIlC-0lLEUSINGTHENUMBERBUTTONS
Ȼ
ONTHE
REMOTEISONLYAVAILABLEFORTHE-0lLESINTHESELECTEDFOLDER
s!FOLDERTHATDOESNOTINCLUDEAN-0lLEISSKIPPED
s-AXIMUMNUMBEROFFOLDERS
-AXIMUMNUMBEROFlLES
-AXIMUMDIRECTORYLEVELS
s&OLDERNAMESANDlLENAMESCANBEDISPLAYEDWITHUPTO
CHARACTERSINCLUDINGQUOTATIONMARKSANDACHARACTEREXTENSION
CODE
s4HECHARACTERS!:AZAND?CANBEDISPLAYEDONTHISUNIT
/THERCHARACTERSAREDISPLAYEDAShv
s4HISUNITCONFORMSTO6ERSIONOFTHE)$TAGFORMAT)FTHElLE
HASTHE)$TAGINFORMATIONhSONGTITLEvhARTISTNAMEvANDhALBUM
NAMEvCANBEDISPLAYED
s7HENNAMINGBESURETOADDTHElLEEXTENSIONhMPvTOTHElLE
NAME
s)FYOUPUTTHEEXTENSIONhMPvTOAlLEOTHERTHANAN-0lLETHE
UNITCANNOTRECOGNIZETHElLEPROPERLYANDWILLGENERATERANDOM
NOISETHATCOULDDAMAGEYOURSPEAKERS
s4HElLENAMEDOESNOTCORRESPONDTOTHE)$TAG
,ISTENINGTOTHERADIO

0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNIT"!.$
ȼ
ONTHEREMOTEREPEATEDLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
h&-vh!-v

(OLDDOWN45.%ORn
Ȫ
UNTILTHEFREQUENCY
DIGITSBEGINTOCHANGEINTHEDISPLAY
4HEUNITAUTOMATICALLYSCANSTHERADIOFREQUENCIES
ANDSTOPSWHENITlNDSACLEARSTATION
)FYOUCANNOTTUNEINASTATIONPRESS45.%ORn
Ȫ
REPEATEDLYTOCHANGETHEFREQUENCYSTEPBYSTEP
7HENAN&-STEREOBROADCASTISRECEIVEDh34v
APPEARS
4IP
)FTHE&-BROADCASTISNOISYPRESS-/$%
ȶ
UNTILh-ONOvAPPEARS
INTHEDISPLAYANDTHERADIOWILLPLAYINMONAURAL
0LAYINGATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION

0RESSĄì
ȩ
ONTHEUNITANDINSERTTHETAPEINTO
THETAPECOMPARTMENTWITHTHESIDEYOUWANTTO
PLAYFACINGUPWARD5SE490%)NORMALTAPE
ONLY#LOSETHECOMPARTMENT
-AKESURETHEREISNOSLACKINTHETAPETOAVOID
DAMAGINGTHETAPEORTHEUNIT

0RESSà
ȩ
ONTHEUNIT
4HEUNITSTARTSPLAYING
4O 0RESS
0AUSEPLAYBACK
ê
ȩ
ONTHEUNIT4ORESUMEPLAY
PRESSITAGAIN
3TOPPLAYBACK
Ąì
ȩ
ONTHEUNIT
&ASTFORWARDOR
REWIND
ß
OR
ù
FASTFORWARDOR
REWIND
ȩ
ONTHEUNIT
%JECTTHECASSETTE
Ąì
ȩ
ONTHEUNIT
2ECORDINGONATAPE
5SEBUTTONSONTHEUNITFORTHEOPERATION

0RESSĄì
ȩ
ONTHEUNITTOOPENTHETAPE
COMPARTMENTANDINSERTABLANKTAPEWITHTHESIDE
YOUWANTTORECORDONFACINGUPWARD5SE490%)
NORMALTAPEONLY#LOSETHECOMPARTMENT

3ELECTTHEPROGRAMSOURCEYOUWANTTORECORD
4ORECORDFROMTHE#$PLAYERPRESSĄ
Ȯ
ONTHEUNIT
ANDPLACEA#$
4ORECORDFROMTHERADIOTUNEINTHESTATIONYOUWANT
SEEh,ISTENINGTOTHERADIOv

0RESSĆ
ȩ
ONTHEUNITTOSTARTRECORDING
à
IS
DEPRESSEDAUTOMATICALLY
4O 0RESS
0AUSERECORDING
ê
ȩ
ONTHEUNIT
0RESSTHEBUTTONAGAINTO
RESUMERECORDING
3TOPRECORDING
Ąì
ȩ
ONTHEUNIT
4IPS
s!DJUSTINGTHEVOLUMEORTHEAUDIOEMPHASISWILLNOTAFFECTTHE
RECORDINGLEVEL
s&ORTHEBESTRESULTSUSETHE!#POWERASAPOWERSOURCEFOR
RECORDING
s4OERASEARECORDINGPROCEEDASFOLLOWS
)NSERTTHETAPEWHOSERECORDINGYOUWANTTOERASE
-AKESURETHATh4!0%vISDISPLAYED)Fh4!0%vISNOTDISPLAYED
PRESSà
ȩ
ONTHEUNITORPRESS&5.#4)/.
ȹ
ONTHEREMOTE
UNTILITAPPEARSINTHEDISPLAY
0RESSĆ
ȩ
ONTHEUNIT
CFD-G555CPK (1/2)
7
CFD-G555CP/G555CPK
5SINGTHEDISPLAY
9OUCANCHECKINFORMATIONABOUTTHE#$USINGTHE
DISPLAY
#HECKINGTHEINFORMATIONOFANAUDIO
#$
4OCHECKTHETOTALTRACKNUMBERANDPLAYING
TIMEOFTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALTRACKNUMBER
4OTALPLAYINGTIME
4OCHECKTHEREMAININGTIME
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
WHILEPLAYINGA#$4HEDISPLAYCHANGESASFOLLOWS
4HECURRENTTRACKNUMBERANDPLAYINGTIME
Ô
4HECURRENTTRACKNUMBERANDTHEREMAINING
TIMEOFTHECURRENTTRACK
4HENUMBEROFTRACKSLEFTANDTHETIME
REMAININGONTHE#$
#HECKINGTHEINFORMATIONOFAN-0
DISC
4OCHECKTHETOTALFOLDERNUMBERANDTOTAL
lLENUMBERONTHE#$
0RESSĄȮWHILETHE#$ISSTOPPEDANDYOUCANCHECK
THEMINTHEDISPLAY
4OTALFOLDER
NUMBER 4OTALlLENUMBER
4OCHECKlLEINFORMATION
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
WHILEPLAYINGAN-0DISC4HEDISPLAYCHANGESAS
FOLLOWS
4HECURRENTlLENUMBERANDPLAYINGTIME
Ô
4HECURRENTlLENUMBERANDTHElLENAME
4HEFOLDERNUMBERANDTHEFOLDERNAME
4HECURRENTlLENUMBERAND)$THESONG
TITLETHEARTISTNAMETHEALBUMNAME
 )FTHEFOLDERDOESNOTHAVEAFOLDERNAMEh2//4vAPPEARSINSTEAD
OFAFOLDERNAME
)FTHElLEDOESNOTHAVE)$INFORMATIONh./4)4,%vh./
!24)34vORh./!,"5-vAPPEARSINTHEDISPLAY
0LAYINGTRACKS-0lLES
REPEATEDLY
2EPEAT0LAY
9OUCANPLAYTRACKS-0lLESREPEATEDLYINNORMAL
3HUFmEOR0ROGRAMPLAYMODES
 0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY
 0ROCEEDASFOLLOWS
4OREPEAT $OTHIS
!SINGLE
TRACK-0
lLE
 0RESS2%0%!4
Ȳ
UNTILh2%0v
APPEARS
 0RESS
Ã
OR
Ñ
ȭ
TOSELECTTHETRACK
-0lLETHATYOUWANTTOREPEAT
 0RESS
ā
Ȯ
ONTHEUNIT
!LLTRACKS
-0lLES
ONTHE#$
 0RESS2%0%!4
Ȳ
UNTILh2%0!,,v
APPEARS
 0RESS
ā
Ȯ
ONTHEUNIT
!SELECTED
FOLDER
-0DISC
ONLY
 0RESS2%0%!4
Ȳ
UNTILh2%0vAND
h&,$2vAPPEAR
 3ELECTTHEFOLDERBYPRESSING&/,$%2
OR&/,$%2n
Ȭ
 0RESS
ā
Ȯ
ONTHEUNIT
4RACKS
-0lLES
INRANDOM
ORDER
 3ELECT3HUFmE0LAYSEEh0LAYINGTRACKS
-0lLESINRANDOMORDERv
 0RESS2%0%!4
Ȳ
UNTILh3(5&vAND
h2%0vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
0ROGRAMED
TRACKS-0
lLES
 0ROGRAMTRACKS-0lLESSEEh#REATING
YOUROWNPROGRAMv
 0RESS2%0%!4
Ȳ
UNTILh2%0vAND
h0'-vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
0ROGRAMED
FOLDERS
-0DISC
ONLY
 0ROGRAMFOLDERSSEEh#REATINGYOUROWN
PROGRAMv
 0RESS2%0%!4
Ȳ
UNTILh2%0vh0'-v
ANDh&,$2vAPPEAR
 0RESS
ā
Ȯ
ONTHEUNIT
/NTHEREMOTE
s5SE
à
Ȯ
INSTEADOF
ā
Ȯ
s!FTERYOUHAVESELECTEDh2%0vPRESSTHENUMBER
BUTTONS
Ȼ
TOSELECTTHETRACK-0lLE
/THER/PERATIONS
4OCANCEL2EPEAT0LAY
0RESS2%0%!4
Ȳ
UNTILh2%0vDISAPPEARSFROMTHE
DISPLAY
0LAYINGTRACKS-0lLESIN
RANDOMORDER
3HUFmE0LAY
9OUCANPLAYTRACKS-0lLESINRANDOMORDER
 0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY
 0RESS-/$%
ȶ
UNTILh3(5&vAPPEARSINTHE
DISPLAY
 0RESSā
Ȯ
ONTHEUNITTOSTART3HUFmE0LAY
/NTHEREMOTE
5SE
à
Ȯ
INSTEADOF
ā
Ȯ
4OCANCEL3HUFmE0LAY
3TOPPLAYINGlRST4HENPRESS-/$%
ȶ
UNTILh3(5&v
DISAPPEARSFROMTHEDISPLAY
4IPS
s$URING3HUFmE0LAYYOUCANNOTSELECTTHEPREVIOUSTRACK-0lLE
BYPRESSING
Ã
ȭ
s4HERESUMEFUNCTIONDOESNOTWORKDURING3HUFmE0LAY
#REATINGYOUROWNPROGRAM
0ROGRAM0LAY
9OUCANARRANGETHEPLAYINGORDEROFUPTOTRACKS
-0lLESONA#$7HENPLAYINGAN-0DISCYOUCAN
ALSOPROGRAMUPTOFOLDERS0ROGRAM&OLDER0LAY
 0RESSĄ
Ȯ
h#$vAPPEARSINTHEDISPLAY
 0RESS-/$%
ȶ
UNTILh0'-vmASHESINTHE
DISPLAY
7HENYOUSELECT0ROGRAM&OLDER0LAY-0DISC
ONLYPRESS-/$%
ȶ
UNTILh0'-vANDh&,$2v
APPEARINTHEDISPLAY
 0RESS
Ã
OR
Ñ
ȭ
THENPRESS$)30,!9s
%.4%2s-%-/29
ȴ
ONTHEUNITFORTHETRACKS
-0lLESYOUWANTTOPROGRAMINTHEORDERYOU
WANT
5SE&/,$%2ORn
Ȭ
TOSELECTFOLDERSFOR0ROGRAM
&OLDER0LAY
!UDIO#$0ROGRAM0LAY
0LAYINGORDER
0ROGRAMEDTRACK
NUMBER
-0DISC0ROGRAM0LAY
0LAYINGORDER
0ROGRAMEDlLENAME
-0DISC0ROGRAM&OLDER0LAY
0LAYINGORDER
0ROGRAMEDFOLDER
NAME
 0RESS
ā
Ȯ
ONTHEUNITTOSTART0ROGRAM0LAY
/NTHEREMOTE
s5SE
à
Ȯ
INSTEADOF
ā
Ȯ
s!FTERYOUHAVESELECTEDh0'-vPRESSTHENUMBER
BUTTONS
Ȼ
FORTHETRACKS-0lLESYOUWANTTO
PROGRAMINTHEORDERYOUWANT
4OCANCEL0ROGRAM0LAY
3TOPPLAYINGlRST4HENPRESS-/$%
ȶ
UNTILh0'-v
DISAPPEARSFROMTHEDISPLAY
4OCHECKTHEORDEROFTRACKS-0lLES
BEFOREPLAY
0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHEUNIT
%VERYTIMEYOUPRESSTHEBUTTONTHETRACKNUMBER-0
lLENAMEORFOLDERNAMEAPPEARSINTHEPROGRAMEDORDER
4OCHANGETHECURRENTPROGRAM
0RESSĄ
Ȯ
ONCEIFTHE#$ISSTOPPEDANDTWICEIFTHE
#$ISPLAYING4HECURRENTPROGRAMWILLBEERASED
4HENCREATEANEWPROGRAMFOLLOWINGTHEPROGRAMING
PROCEDURE
4IPS
s9OUCANPLAYTHESAMEPROGRAMAGAINSINCETHEPROGRAMISSAVED
UNTILYOUOPENTHE#$COMPARTMENT
s9OUCANRECORDYOUROWNPROGRAM!FTERYOUHAVECREATEDTHE
PROGRAMINSERTABLANKTAPEANDPRESSĆ
ȩ
ONTHEUNITTOSTART
RECORDING
s4HERESUMEFUNCTIONDOESNOTWORKDURING0ROGRAM0LAY
0RESETTINGRADIOSTATIONS
9OUCANSTORERADIOSTATIONSINTOTHEUNITSMEMORY9OU
CANPRESETUPTORADIOSTATIONSFOR&-ANDFOR
!-INANYORDER
 0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITTOSELECTTHEBAND
 (OLDDOWN2!$)/"!.$s!54/02%3%4
ȳ
ON
THEUNITFORSECONDSUNTILh!54/vmASHESINTHE
DISPLAY
 0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNIT
4HESTATIONSARESTOREDINMEMORYFROMTHELOWER
FREQUENCIESTOTHEHIGHERONES
)FASTATIONCANNOTBEPRESETAUTOMATICALLY
9OUNEEDTOPRESETASTATIONWITHAWEAKSIGNALMANUALLY
 0RESS2!$)/"!.$s!54/02%3%4
ȳ
ONTHE
UNITTOSELECTTHEBAND
 4UNEINASTATIONYOUWANT
 (OLDDOWN$)30,!9s%.4%2s-%-/29
ȴ
ON
THEUNITFORSECONDSUNTILTHEPRESETNUMBER
mASHESINTHEDISPLAY
 0RESS02%3%4ORn
ȭ
ONTHEUNITUNTILTHE
PRESETNUMBERYOUWANTFORTHESTATIONmASHESIN
THEDISPLAY
 0RESS$)30,!9s%.4%2s-%-/29
ȴ
ONTHE
UNIT
4HENEWSTATIONREPLACESTHEOLDONE
/NTHEREMOTE
 0RESS"!.$
ȼ
UNTILTHEBANDYOUWANTAPPEARS
INTHEDISPLAY
 4UNEINASTATIONYOUWANT
 (OLDDOWNTHENUMBERBUTTONS
Ȼ
THATYOUWANT
TOPRESETTHENEWSTATIONONFORABOUTSECONDS
4OSELECTTHEPRESETNUMBEROVERPRESS
Ȼ
lRSTTHENTHECORRESPONDINGNUMBERBUTTONS
Ȼ
9OUNEEDTOHOLDDOWNTHELASTNUMBERBUTTONTOENTER
FORABOUTSECONDS
%XAMPLE4OSELECTPRESSANDlRSTTHEN
HOLDDOWNFORABOUTSECONDS
4IP
4HEPRESETRADIOSTATIONSREMAININMEMORYEVENIFYOUUNPLUGTHE
!#POWERCORDORREMOVETHEBATTERIES
0LAYINGPRESETRADIOSTATIONS
 0RESS2!$)/"!.$s!54/02%3%4ȳONTHE
UNITTOSELECTTHEBAND
 0RESS02%3%4ORn
ȭ
ONTHEUNITTOTUNEIN
THESTOREDSTATION
/NTHEREMOTE
 0RESS"!.$
ȼ
 0RESSTHENUMBERBUTTONS
Ȼ
TOTUNEINTHE
STOREDSTATION
4OTUNEINAPRESETSTATIONOVERPRESS
Ȼ
lRST
THENCORRESPONDINGNUMBERBUTTONS
Ȼ

%XAMPLE4OTUNEINAPRESETSTATIONPRESS
ANDlRSTANDTHENPRESS
&ALLINGASLEEPTOMUSIC
5SEBUTTONSONTHEREMOTEFORTHEOPERATION
 0LAYTHEMUSICSOURCEYOUWANT
 0RESS3,%%0
ȹ
ONTHEREMOTETODISPLAY
h3,%%0v
 0RESS3,%%0
ȹ
ONTHEREMOTETOSELECTTHE
MINUTESUNTILTHEUNITGOESOFFAUTOMATICALLY
%ACHTIMEYOUPRESSTHEBUTTONTHEINDICATIONCHANGES
ASFOLLOWS
hvhvhvh/&&vhvhv
hv
)FSECONDSHAVEPASSEDAFTERYOUPRESSED3,%%0
ȹ

THEMINUTESINTHEDISPLAYAREENTERED
7HENTHEPRESETTIMEHASPASSEDTHEUNITGOESOFF
AUTOMATICALLY
4OCANCELTHESLEEPFUNCTION
0RESS0/7%2
ȷ
TOTURNOFFTHEPOWER
.OTE
7HENYOUAREPLAYINGATAPEUSINGTHISFUNCTION
)FTHETAPELENGTHOFONESIDEISLONGERTHANTHESETTIMETHEUNITWILL
NOTGOOFFUNTILTHETAPEREACHESTHEEND
5SINGTHE+ARAOKEFUNCTION
+!2!/+%0/.
4HISFUNCTIONREDUCESTHEVOCALCOMPONENTOFTHESOUND
SOURCESOTHATYOUCANENJOY+ARAOKEWITHYOUR#$S
4APESORRADIOPROGRAMS
5SEBUTTONSONTHEUNITFORTHEOPERATION
 #ONNECTAMICROPHONENOTSUPPLIEDTOTHE-)#
-)8
ȵ
JACKONTHEUNIT
)FTHEMICROPHONEHASAPOWERSWITCHSETTHESWITCH
TO/.
 0RESS0/7%2
ȷ
TOTURNONTHEUNIT
 0RESS+!2!/+%0/.
ȵ
ONTHEUNIT
4HEINDICATORBESIDETHE+!2!/+%0/.BUTTON
ȵ
LIGHTSUP
 0LAYTHESOUNDSOURCE
 4U R N-)#,%6%,
ȵ
ONTHEUNITTOADJUSTTHE
MICROPHONEVOLUME
4OCANCELTHE+ARAOKEFUNCTION
0RESS+!2!/+%0/.
ȵ
ORPRESS0/7%2
ȷ
TOTURN
OFFTHEUNIT
.OTES
s-ICROPHONESWITHABUILTINECHOFUNCTIONCANCAUSEAHOWLING
SOUND+EEPTHEVOLUMEOFTHEMICROPHONELOWWITHTHE-)#
,%6%,CONTROL
ȵ
s7HENTHEHOWLINGOCCURSTURNTHEHEADOFTHEMICROPHONEAWAY
FROMTHESPEAKERS
s7HENRECORDINGFROM#$SORRADIOPROGRAMSWITHTHE+ARAOKE
FUNCTIONISONONLYTHEORIGINALSOUNDWITHTHEVOCALCOMPONENT
WILLBERECORDEDONTHETAPE
s)NPUTFROMAMICROPHONECONNECTEDTOTHE-)#-)8̠JACKCANNOT
BERECORDED
s%VENWHENTHE+ARAOKEFUNCTIONISONTHEVOCALCOMPONENTMAY
NOTBEREDUCEDORADEQUATELYREDUCEDFORSOMESOUNDSOURCES
CFD-G555CPK (2/2)
8
CFD-G555CP/G555CPK SECTION 3
DISASSEMBLY
3-1. DISASSEMBLY FLOW
•This set can be disassembled in the order shown below.
3-2. CABINET (UPPER) (1) SECTION
(Page 9)
3-3. CABINET (UPPER) (2) SECTION
(Page 9)
SET
3-4. CABINET (FRONT) SECTION
(Page 10)
3-10. CD KEY BOARD
(Page 14)
3-18. TAPE MECHANISM DECK
(Page 18)
3-19. TC BOARD
(Page 19) 3-20. MAIN BELT,
SUB BELT
(Page 19)
3-14. H/P BOARD,
TUNER BOARD
(Page 16)
3-11. MIC BOARD,
POWER KEY BOARD,
H/P BOARD
(Page 15)
3-12. CD KEY BOARD
(Page 15)
CFD-G555CP modelCFD-G555CPK model
CFD-G555CP modelCFD-G555CPK model
3-15. MAIN BOARD
(Page 17)
3-16. CD BLOCK SECTION
(Page 17)
3-17. OPTICAL PICK-UP (KSS-213C)
(Page 18)
3-5. TUNER KEY BOARD,
VOL KEY BOARD
(Page 10)
3-6. LCD PANEL ASSY
(Page 11)
3-8. LCD BOARD
(Page 13)
3-13. TUNER BOARD
(Page 16)
3-7. LED BOARD
(Page 12)
3-9. POWER BOARD,
TRANS BOARD
(Page 14)
9
CFD-G555CP/G555CPK
Note: Follow the disassembly procedure in the numerical order given.
3-2. CABINET (UPPER) (1) SECTION
3-3. CABINET (UPPER) (2) SECTION
1
Open the handle in the
direction of the arrow.
3
Open the cassette lid.
5
Open the CD lid.
2
seven
screws
(+
BV tapping (B3)
)
4
two
screws
(+
BV tapping (B3)
)
6
two
screws
(+
BV tapping (B3)
)
two claws
4
3
1
Close the cassette lid.
qa
handle
2
Close the CD lid.
7
CNP393 (4P)
8
CNP392 (4P)
9
CNP301 (5P)
0
cabinet (upper) section
5
CNP804 (2P)
6
flexible flat cable
(11 core) (CNP801)
10
CFD-G555CP/G555CPK
3-4. CABINET (FRONT) SECTION
3-5. TUNER KEY BOARD, VOL KEY BOARD
5
6
cabinet (front) section
1
battery lid
2
four
screws
(+
BV tapping (B3)
)
3
four
screws
(+
BV tapping (B3)
)
4
four
screws
(+
BV tapping (B3)
)
7
button (volume)
2
button (function)
9
VOL KEY board
5
TUNER KEY board
1
two
screws
(+
BV tapping (B2.6)
)
6
three
screws
(+
BV tapping (B2.6)
)
3
three
screws
(+
P tapping (B2.6)
)
8
three
screws
(+
P tapping (B2.6)
)
4
three
screws
(+
P tapping (B2.6)
)
11
CFD-G555CP/G555CPK
3-6. LCD PANEL ASSY
5
LCD panel assy
3
woofer speaker
1
two
screws
(+
BV tapping (B3)
)
4
five
screws
(+
BV tapping (B3)
)
2
two
screws
(+
BV tapping (B3)
)
12
CFD-G555CP/G555CPK
3-7. LED BOARD
1
two
claws
claw
light guide LED plate
claw
claw
claw
5
LED 1 board
harnesses
harnesses
6
LED 2 board
7
LED 3 board
8
LED 4 board
3
4
2
two
claws
Route the harnesses as shown below.
13
CFD-G555CP/G555CPK
3-8. LCD BOARD
1
two
screws
(+
BV tapping (B3)
)
7
three
screws
(+
BV tapping (B3)
)
8
screw
(+
BV tapping (B3)
)
qa
two
screws
(+
BV tapping (B2.6)
)
qs
LCD board
2
two
LED holders (R)
9
rear cover
6
woofer cover
5
alignment ring
0
4
two
LED holders (L)
3
two
screws
(+
BV tapping (B3)
)
Remove the harnesses.
notch harnesses
harnesses
Pass the harnesses through
the notch.
14
CFD-G555CP/G555CPK
3-9. POWER BOARD, TRANS BOARD
3-10. CD KEY BOARD (CFD-G555CPK)
8
qs
POWER board,
TRANS board
Remove the harnesses.
Remove the harnesses.
4
BATTERY1 board
2
CNP902 (4P)
1
sheet trans chassis
3
screw
(+
PWH tapping (B3)
)
5
four
screws
(+
BV tapping (B3)
)
6
screw
(+
BV tapping (B3)
)
9
screw
(+
BV tapping (B3)
)
7
two
screws
(+
BV tapping (B3)
)
0
two
screws
(+
BV tapping (B3)
)
qa
two
screws
(+
BV tapping (B3)
)
5
CD KEY board
7
button (woofer) assy
8
button (CD)
1
CNP804 (4P)
4
KH405 (3P)
3
two
screws
(+
PWH tapping (B2.6)
)
2
six
screws
(+
BV tapping (B2.6)
)
6
screw
(+
BV tapping (B2.6)
)
15
CFD-G555CP/G555CPK
3-11. MIC BOARD, POWER KEY BOARD, H/P BOARD (CFD-G555CPK)
3-12. CD KEY BOARD (CFD-G555CP)
qa
button (power)
9
CNP391 (9P)
3
CNP394 (3P)
1
screw
(+
PWH tapping (B2.6)
)
6
four
screws
(+
BV tapping (B2.6)
)
0
H/P board
7
POWER KEY board
5
MIC board
2
JACK HOLD board
8
screw
(+
PWH tapping (B2.6)
)
4
screw
(+
PWH tapping (B2.6)
)
4
CD KEY board
6
button (woofer) assy
7
button (CD)
8
button (power)
1
CNP804 (3P)
3
two
screws
(+
PWH tapping (B2.6)
)
2
ten
screws
(+
BV tapping (B2.6)
)
5
screw
(+
BV tapping (B2.6)
)
16
CFD-G555CP/G555CPK
3-13. TUNER BOARD (CFD-G555CPK)
3-14. H/P BOARD, TUNER BOARD (CFD-G555CP)
3
Remove the soldering.
4
TUNER board
2
flexible flat cable
(11core) (CNP1)
1
two
screws
(+
BV tapping (B3)
)
6
JACK HOLD board
7
H/P board
8
CNP391 (9P)
3
Remove the soldering.
4
TUNER board
1
two
screws
(+
BV tapping (B3)
)
5
screw
(+
PWH tapping (B2.6)
)
2
flexible flat cable
(11core) (CNP1)
17
CFD-G555CP/G555CPK
3-15. MAIN BOARD
qs
MAIN board
6
3
CNP806 (4P)
4
connector (2P)
2
CNP303 (6P)
5
three
screws
(+
BV tapping (B3)
)
8
Remove the soldering.
0
Remove the soldering.
9
flexible flat cable (11 core)
qa
flexible flat cable (11 core)
1
flexible flat cable
(11 core) (CNJ303)
7
flexible flat cable
(20 core) (CNJ802)
3-16. CD BLOCK SECTION
3
CD block section
2
two
screws
(+
PWH tapping (B2.6)
)
1
two
screws
(+
PWH tapping (B2.6)
)
18
CFD-G555CP/G555CPK
3-17. OPTICAL PICK-UP (KSS-213C)
3-18. TAPE MECHANISM DECK
2
Open the cassette lid.
3
tape mechanism dec
k
1
three
screws
(+
BV tapping (B3)
)
claw
1
gear (A)
2
claw
3
4
sled shaf
t
5
optical pick-up
19
CFD-G555CP/G555CPK
1
screw
4
TC board
2
hook
3
Remove soldering from the four points.
yellow red white
black
TC board
3-19. TC BOARD
3-20. MAIN BELT, SUB BELT
1
two
screws
(
+BIND DT
M2
×
6
)
2
hook
3
motor assy
(M971)
4
main belt (B1)
5
sub belt (B1)
20
CFD-G555CP/G555CPK SECTION 5
ELECTRICAL ADJUSTMENTS
SECTION 4
MECHANICAL ADJUSTMENTS
PRECAUTION
1. Clean the following parts with a denatured-alcohol-moistened
swab :
record/playback head pinch roller
erase head rubber belts
capstan idlers
2. Demagnetize the record/playback head with a head
demagnetizer. (Do not bring the head magnetizer close to the
erase head.)
3. Do not use a magnetized screwdriver for the adjustments.
4. The adjustments should be performed with the rated power
supply voltage (9V) unless otherwise noted.
Torque Measurement
Mode Torque meter Meter reading
2.95 – 6.86 mN • m
FWD CQ-102C (30 – 70 g • cm)
(0.42 – 0.97 oz • inch)
FWD 0.15 – 0.53 mN • m
Back Tension CQ-102C (1.5 – 5.5 g • cm)
(0.021 – 0.076 oz • inch)
more than 5.88 mN • m
FF CQ-201B (more than 60 g • cm)
(more than 0.83 oz • inch)
more than 5.88 mN • m
REW CQ-201B (more than 60 g • cm)
(more than 0.83 oz • inch)
Tape Tension Measurement
Mode Torque meter Meter reading
FWD CQ-403A more than 100 g
(more than 3.53 oz)
i
jack (J391)
set
32
Ω
test tape
WS-48A
(3 kHz, 0 dB)
digital frequenc
y
counter
TAPE SECTION 0 dB = 0.775 V
• Standard Output Level
Output terminal HP OUT
load impedance 32 Ω
output signal level 0.25 V (–10 dB)
• Test Tape
Type Signal Used for
WS-48A 3 kHz, 0 dB tape speed adjustment
Tape Speed Adjustment
Procedure:
Mode: playback
Adjust so that the value on the digital frequency counter is
3,000 Hz.
Specification Value:
Digital frequency counter
2,940 to 3,060 Hz
Adjust so that the frequency at the beginning and that at the end of
tape winding are between 2,970 to 3,030 Hz.
Adjustment Location:
Tape speed adjustment
control inside motor
(M971)
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55
  • Page 56 56
  • Page 57 57
  • Page 58 58
  • Page 59 59
  • Page 60 60
  • Page 61 61
  • Page 62 62
  • Page 63 63
  • Page 64 64
  • Page 65 65
  • Page 66 66
  • Page 67 67
  • Page 68 68
  • Page 69 69
  • Page 70 70

Sony CFD-G555CPK User manual

Sony
Brand
Sony
Model
CFD-G555CPK
Category
Cassette players
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents