SERVICE INSTRUCTION
165 Al Mooney Road North
Kerrville, Texas 78028
SERVICE INSTRUCTION SIM20-128
Date: April 9, 2018
MOONEY INTERNATIONAL
CORPORATION
MOONEY INTERNATIONAL CORPORATION -165 Al Mooney Road North, Kerrville, Texas 78028 tel: 830-896-6000 www.mooney.com
Page1of3
SUBJECT: MOONEY ULTRA INTERIOR DOOR PANEL SCREWS
MODELS/ SN M20U OVATION ULTRA 32-0001 AND 32-0004
AFFECTED: M20V ACCLAIM ULTRA 33-0001 THRU 33-0007
TIME OF AS REQUIRED
COMPLIANCE:
INTRODUCTION: Mooney International Corporation has determined the need to add LoctiteSealant 222MS
to interior door panel screws. This sealant prevents any of the screws from backing out, due
to vibrations.
Procedure for adding Loctite222MS to interior mounting screws.
1.1. On Pilot side entrance door, cover wing walk area with protective cover.
NOTE:
Removing the door panel screws “one at a time” will keep from misalignment of holes and
interior panels.
1.2. Open Pilot door, remove interior door panel screws, add a drop of Loctite222MS to
threads of screw and install back into placein upper and lower panels as shown inFigure
SIM20-128-1.
1.3. On Co-Pilot side entrance door, cover wing walk area with protective covering.
1.4. Open Co-Pilot door, remove interior door panel screws, add a drop of Loctite222MS
to threads of screw and install back into place in upper and lower panels as shown in
Figure SIM20-128-1.
1.5. Remove all protective covering from wing walk area.
1.6. Return aircraft to service.
1.7. Procedure complete.
NOTE:
Fill out compliance card and send by MAIL, FAX or EMAIL to Mooney International Corporation
as indicated on the attached Compliance Card (Refer to Figure SIM20-128-2).
WARRANTY: Mooney International Corporation will warrant labor 1 hour when work is completed in accor-
dance with procedures of this Service Instruction for aircraft currently covered under the
Mooney International Corporation factory warranty program.
REFERENCE 1. Applicable Mooney International Service and Maintenance Manual
DATA:
PARTS LIST: Service Instruction Kit SIM20-128
Item P/N Description Qty
1. FLY0155 Loctite222MS AR
SERVICE INSTRUCTION
165 Al Mooney Road North
Kerrville, Texas 78028
SERVICE INSTRUCTION SIM20-128
Date: April 9, 2018
MOONEY INTERNATIONAL
CORPORATION
MOONEY INTERNATIONAL CORPORATION -165 Al Mooney Road North, Kerrville, Texas 78028 tel: 830-896-6000 www.mooney.com
Page2of3
SCREWS
LOWER INTERIOR
PANEL ASSEMBLY
UPPER INTERIOR
PANEL ASSEMBLY
SCREWS
SCREWS SCREWS
SCREWS
SCREWS
SCREWS
SCREWS
SCREWS
PILOT SIDE SHOWN
CO- PILOT OPPOSITE
ADD LOCTITE 222MS
TO ALL INTERIOR DOOR
PANEL SCREWS
NOTE: DIAGRAM SHOWN IS FOR REFERENCE ONLY
SCREW LOCATIONS AND QUANTITY MAY DIFFER
Figure SIM20-128-1 - INTERIOR DOOR PANEL HARDWARE
SERVICE INSTRUCTION
165 Al Mooney Road North
Kerrville, Texas 78028
SERVICE INSTRUCTION SIM20-128
Date: April 9, 2018
MOONEY INTERNATIONAL
CORPORATION
MOONEY INTERNATIONAL CORPORATION -165 Al Mooney Road North, Kerrville, Texas 78028 tel: 830-896-6000 www.mooney.com
Page3of3
MOONEY INTERNATIONAL CORPORATION
KERRVILLE, TEXAS 78028 - FAX 830- 257- 4635
SERVICE (BULLETIN) (INSTRUCTION) NO.________________HAS BEEN COMPLIED
WITH ON AIRCRAFT MODEL _______________ SERIAL NUMBER ________________
Tach. Time:
Owner:
N-Number (Reg. No.)
Date of
Compliance:
Complied
By:
Form 07-0001
Inspection Report:
MOONEY INTERNATIONAL CORPORATION
ATT’N: TECHNICAL PUBLICATIONS DEPT
165 Al Mooney Road, North
Kerrville, Texas 78028
PLACE
STAMP
HERE
SEND TO: Mooney International Corporation
165 Al Mooney Road North
Kerrville, TX 78028
FAX: (830) 257-4635 or EMAIL TO: techpubs@mooney.com
Figure SIM20-128-2 - FILL OUT COMPLIANCE CARD
-
1
-
2
-
3
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Mooney SIM20-130 Owner's manual
-
-
-
-
-
-
-
-
-