Wagan 2020 User manual

Page is loading ...

www.wagan.com

1

Quick Flow

™

Compact Air Compressor by Wagan Tech

®

Wagan Tech and wagan.com are trademarks used by Wagan Corporation.

Thank you for purchasing the Quick Flow

™

Compact Air Compressor by

Wagan Tech

®

. With normal care and proper treatment, it will provide

years of reliable service. It is important to read and understand all

operating instructions and warnings before use.

(Off)

(Light) (Compressor)

Power Switch

Worklight

Power Switch

Air Hose Nozzle

Adapter Tip

Sport Ball Needle

Air Pressure Gauge

DC Plug

www.wagan.com

Wagan Tech and wagan.com are trademarks used by Wagan Corporation.

2

User’s Manual—Read before using this equipment

SPECIFICATIONS

• Pressure Reader: 150 PSI GAUGE

• Air Hose: 18 inches

• 12V DC Cord: 10 feet

• Accessories: 2 nozzle adapters, 1 sports needle

• Power Required: 12V 13A DC

AIR COMPRESSOR OPERATION

WARNING: Do not overheat the unit! If the compressor is not pumping

a steady stream of air and appears sluggish or if metal ﬁttings get too

warm to the touch, these are indicators that the compressor has been in

operation for too long. Immediately turn off the compressor and allow it

to cool for approximately 30 minutes before resuming operation. Never

leave compressor unattended while in use.

Do not over inﬂate items beyond their needs. Most car tires will inﬂate

properly between 30 and 35 psi depending upon the tire. Some racing

bicycle tires require pressure in excess of 75 psi. Other bicycle tires may

require substantially lower pressures. This unit is not ﬁtted for high-

pressure tires such as those used on large commercial trucks.

Keep out of reach of children.

1. To achieve optimal performance, your vehicle’s engine should be

running when operating your air compressor.

2. Unwind power cord from the storage compartment of the unit and

insert the DC plug into the 12 Volt cigarette lighter socket of your

vehicle.

www.wagan.com

3

Quick Flow

™

Compact Air Compressor by Wagan Tech

®

Wagan Tech and wagan.com are trademarks used by Wagan Corporation.

3. Pull out hose from compartment.

4. For vehicle tires: Place chuck over valve stem of tire with thumb

latch open in the vertical position.

For other inﬂatable items: Select the appropriate adaptor and

insert it into the hose nozzle. Make sure adapter and hose are

sealed tightly. Tip: When inﬂating athletic balls, moisten needle

before inserting it into the ball valve.

5. Push down ﬁrmly and lock into place by pressing thumb lever to

horizontal position.

Lock valve stem connector

Thumb Latch

Chuck

Air Hose

Unlock

Lock

6. Turn compressor’s switch on to the "||" position and

monitor pressure using the built-in pressure gauge. DO NOT

OVERINFLATE PRODUCTS BEYOND THE MANUFACTURER’S

RECOMMENDATIONS.

NOTE: If your vehicle tire is completely deﬂated, it is possible that

the seal between the tire and the rim is broken, allowing air to

leak out when trying to inﬂate. In the event this situation occurs,

you will need to jack up your car prior to inﬂating the tire.

www.wagan.com

Wagan Tech and wagan.com are trademarks used by Wagan Corporation.

4

User’s Manual—Read before using this equipment

7. When desired pressure is reached, turn off compressor and

disconnect hose.

8. Unplug the power cord from 12 Volt socket and store the hose and

cord back into the unit.

NEVER LEAVE COMPRESSOR UNATTENDED WHILE IN USE.

WORK LIGHT

The Quick Flow

™

Compact Air Compressor comes with a built-in work

light.

1. Unwind power cord from the storage compartment of the unit and

insert the DC plug into the 12 Volt cigarette lighter socket of your

vehicle.

2. Turn the power switch to "|" position to turn on the work light.

3. When ﬁnished, turn off the work light before unplugging the DC

power cord from your vehicle.

TROUBLE SHOOTING

COMPRESSOR DOES NOT START/BLOWS FUSES

1. Push the power plug ﬁrmly into the DC socket and twist it back

and forth to ensure clean contact.

2. Check DC socket for dirt and particles. Use a non-conductive

probe to clean the DC socket. Do not use your ﬁngers or metal.

www.wagan.com

5

Quick Flow

™

Compact Air Compressor by Wagan Tech

®

3. Check vehicle lighter fuse; should be 15 amps minimum.

4. Disconnect the connector and feel for air coming out of connector.

COMPRESSOR RUNS BUT DOES NOT INFLATE

1. Be sure the connector always touches the core of the valve stem.

2. Check article for leaks.

3. Check hose for breaks and leaks at ﬁttings.

COMPRESSOR RUNS SLOWLY

1. Overheated from excessive use. Shut it off and let it cool for 30

minutes.

2. Voltage too low. Check condition of battery.

www.wagan.com

The WAGAN Corp. warranty is limited to products sold only in the United States.

All Wagan Tech products must be registered within (30) days of purchase to activate its

warranty. To register your product, please visit http://tinyurl.com/waganwarranty. Be

sure to keep the original receipt as it will be required when returning a product under

the warranty.

Warranty Duration: This product is warranted to the original purchaser for a period

of one (1) year from the original purchase date, to be free of defects in material and

workmanship. WAGAN Corporation disclaims any liability for consequential damages.

In no event will WAGAN Corporation be responsible for any amount of damages beyond

the amount paid for the product at retail.

Warranty Performance: During the above one (1) year warranty period, a product with

a defect will be replaced with a comparable model when the product is returned to

WAGAN Corporation with an original store receipt. The replacement product will be in

warranty for the balance of the original one (1) year warranty period.

To return a defective item, please contact WAGAN Corporation at (800) 231-5806 to

obtain a Returned Merchandise Authorization number (RMA#), and return instructions.

Each item returned will require a separate RMA#. After you have received the RMA#

and the return instructions from WAGAN Corporation, please follow the instructions and

send the item with PREPAID SHIPPING, along with all of the required documentation, a

complete explanation of the problem, your name, address and daytime phone number.

WAGAN Corporation will, at its option, replace or repair the defective part.

A Returned Merchandise Authorization number (RMA#) is REQUIRED when sending

in any defective item. WAGAN Corporation is not responsible for any item(s) returned

without an ofﬁcial Returned Merchandise Authorization number. The item(s) must

be returned with prepaid shipping. WAGAN Corporation is not responsible for any

shipping charges incurred in returning the item(s) back to the company for repair or

replacement. This warranty is void if the product has been damaged by accident, in

shipment, unreasonable use, misuse, neglect, improper service, commercial use, repairs

by unauthorized personnel or other causes not arising out of defects in materials or

workmanship. This warranty does not extend to any units which have been used in

violation of written instructions furnished.

Warranty Disclaimers: This warranty is in lieu of all warranties expressed or implied and

no representative or person is authorized to assume any other liability in connection with

the sale of our products. There shall be no claims for defects or failure of performance

or product failure under any theory of tort, contract or commercial law including, but not

limited to negligence, gross negligence, strict liability, breach of warranty and breach

of contract.

WAGAN Corp. Limited Warranty

Page is loading ...

31088 San Clemente Street

Hayward, CA 94544, U.S.A.

Tel: + 1.510.471.9221

U.S. & Canada Toll Free: 1.800.231.5806

customerservice@wagan.com

www.wagan.com

Wagan Tech and wagan.com are trademarks used by Wagan Corporation

Wagan Tech y wagan.com son marcas registradas de la Corporación Wagan

Wagan Tech et wagan.com sont des marques de commerce utilisées par Wagan Corporation

REV20130408-ESF

Wagan 2020 User manual

This manual is also suitable for

Wagan 2020 User manual

in other languages

Related papers

Other documents