Acrosser Technology AR-R6000 Owner's manual

Brand: Acrosser Technology

Model: AR-R6000

Category: Networking

Type: Owner's manual

Revision: 1.1

AR-R6000D41 & AR-R6000D51

System Guide

Revision: 1.1

Contents

1. ................4 Introduction to AR-R6000D41 & AR-R6000D51

1.1 ...............................................................................4 Specifications

1.2

..................................................................................4 Packing List

1.3

........................................................................5 System Dissection

2. ...............................7 Procedure of Assembly/Disassembly

2.1. ...........7 Installing the 2.5”Hard Disk Drive (HDD) and CF card

2.2.

.................................. 11 Installing mini PCI Card and SO-DIMM

2.3.

.................................................12 Installing Extension PCI Card

3. .....................................................14 AR-B6000 Board Guide

3.1. ..............................................................................14 Introduction

3.1.1. ...............................................................................................14 Features

3.1.2.

........................................................................................15 Specification

3.1.3.

...............................................................................16 Package Contents

3.1.4.

.....................................................................................17 Block Diagram

3.2. ..............................................................18 Hardware Information

3.2.1. ...............................................................................................18 Location

3.2.1.1. ...........................................................................................................18 Top Side

3.2.1.2. .....................................................................................................19 Bottom Side

3.2.2. ..................................20 Connector, Header and Jumper Setting Table

3.2.2.1. ...........................................................................21 Pin definition for Connector

3.2.2.2. ................................................................................22 Pin definition for Header

3.2.2.3. .................................................................23 Jumper Setting and Pin definition

3.3. .............................................................................24 BIOS Setting

3.3.1. .....................................................................24 Main (System Overview)

3.3.2.

.........................................................24 Advanced (Advanced Settings)

Revision: 1.1

3.3.3. ..........................................................................25 Power (ACPI Setting)

3.3.4.

...........................................................................25 Boot (Boot Settings)

3.3.5.

...............................................................................26 Exit (Exit Options)

3.4. ...................................................................................27 Appendix

3.4.1. .............................................27 Appendix A - RJ45 LAN LED definition

3.4.2.

...................................28 Appendix B- Front Panel LAN LED definition

3.4.3.

...........................................29 Appendix C- Front Panel LED definition

3.4.4.

.........................................................29 Appendix D- AR-LCM definition

3.4.5.

........................................................30 Appendix E- AR-LCM Demo API

Revision: 1.1

1. Introduction to AR-R6000D41 & AR-R6000D51

Acrosser's Rackmount Networking device AR-R6000 is a cost-effective and entry-level solution,

which is suitable for small office. Base on Intel ATOM D410 (single core & 512K cache) or D510

(dual cores & 1M cache) 1.66GHz CPU, the AR-R6000 consumes very low power to save the total

costs. We also put a quiet fan to keep the low noise, which will not cause uncomfortable voice. By

four 10/100/1000Mbps LANs, the AR-R6000 is sufficient for the small business security hardware

solution.

Key features:

1. Intel ATOM D410 or D510 CPU

2. Intel ICH8M Chipsets.

3. DDRII 667/800 SO-DIMM x 1, up to 2GB memory

4. Intel 82574L 10/100/1000Mbps x 4

5. For R6000D51 system, LAN1 and LAN2 support bypass feature

6. CF socket, 2.5”/3.5” HDD bay x 1, SATA II interface with power x 2

7. Console, VGA (pinhead), USB 2.0 x 4 (2 x connectors, 2 x pin head)

8. Support boot from LAN, console redirection

9. Support mini-PCI and PCI card for feature expansion

10. With LCM module, users can easily program R6000 system

1.1 Specifications

Item Description

System AR-R6000D41 & AR-R6000D51

CPU Board AR-B6000D41 & AR-B6000D51

System Dimensions 442.4×340.5×44 (mm)

1.2 Packing List

Description Q’ty

AR-R6000D41 & AR-R6000D51 1

Console Cable 1

Quick user manual 1

CD with Driver and Manual 1

HDD bracket 2

SATA cable 1

SATA power cable 1

Rack bracket 2

Rubber for HDD bracket 4

Revision: 1.1

1.3 System Dissection

(1) Dimensions

(2) Front Panel

LCM Module Window

LCM Keypad

Revision: 1.1

(3) System Configuration

Item Part No. Description Remark

1 170010963-G TOP COVER 1

2 170010962-G BOTTOM 1

3 170010964-G BOTTOM BRACKET 1

4 170010965-G & 170010966-G HDD BRACKET(FOR 2.5” & 3.5”) 1

5 020010024 OR 020010025 AR-B6000D41 OR AR-B6000D51 1

6 010080650 AR-RS18 1

7 - PCI CARD 1

8 150010098-G POWER 1

9 140060026-G FAN 2

10 150010098-G POWER SWITCH 1

11 150010098-G POWER CORE 1

12 180070084-G

銘板

13 010020235-03 LCM Module 1

14 170010967-G Mounting Bracket 2

Revision: 1.1

2. Procedure of Assembly/Disassembly

2.1. Installing the 2.5”Hard Disk Drive (HDD) and CF card

The following are step-by-step installation

1. Remove the power cord out from the AR-R6000

2. Unscrew the two screws to release top cover of AR-R6000, as shown in Fig-01.

Push(Open) Push(Open)

Unscrew

Fig- 01

Remove the top cover

3. Install HDD into HDD bracket and lock HDD body and bracket by screws (3.5”HDD : 6pcs ,

2.5”HDD : 4pcs), as shown in Fig-02-1 & Fig-02-2

Fig-02-1 HDD bracket with HDD body Fig-02-2 HDD bracket with HDD body

Revision: 1.1

4. Paste rubbers on the HDD bracket, as shown in Fig-02-3.

plaser the rubbers on the HDD bracket.

Fig-0

2-3 paste the rubbers with HDD bracket

5. Connect SATA cable to HDD module (HDD+HDD bracket) , as Fig-03.

Fig-03 connect SATA cable to HDD module

Revision: 1.1

6. Place HDD module back to the case and lock HDD module to the chassis by four screws as

Fig-04-1,04-2 and connect SATA cable to mainboard, as Fig-04-3.

Fig-04-1 Fig-04-2

ig-04-3 Install SATA power cable and SATA cable

Revision: 1.1

7. Installing CF card as shown in Fig-05

The direction for

installing the CF card

Fig-06 The direction for installing the CF card

8. Lock top cover of AR-R6000 by two screws, as shown in Fig-06.

Fig-06 Lock the top cover

Push(Close) Push (Close)

Locked up Locked up

Revision: 1.1

2.2. Installing mini PCI Card and SO-DIMM

The following are step-by-step installation

1. Take off the bottom_bracket by removing the 2 screws, as shown in Fig-07

Fig-07-1 Remove the extending doors by removing the 2 screws.

Unscrew

The direction for installing the

Mini-PCIE card installs for

The direction for installing the SO-DIMM

Fig-0

7-2 Install the cards in the chassis

Revision: 1.1

2.3. Installing Extension PCI Card

The following are instructions for PCI card installation.

1. AR-R6000 can be extended with a PCI card.

2. Unscrew the two screws to release top cover of AR-R6000, as Fig-01.

3. Release the dummy bracket by unscrewing the screws as shown in Fig-08.

Fig-08. unlock the screws for PCI card

Unlocked the screws

4. Takes off PCI bracket, then assembles the PCI card and PCI bracket as shown in Fig-09.

Fig-09-1 Unlock the bracket

unlock

Revision: 1.1

Lock up

Fig-09-2 Lock PCI card

5. Plug the extension PCI card into riser card and adjust the card into the holder as shown in

Fig-10.

1.)Plug in the PCI card

2.)Locked the screws

Fig-10 Install the PCI card

Revision: 1.1

3. AR-B6000 Board Guide

3.1. Introduction

Welcome to the AR-B6000 series Computer. The AR-B6000 series is a Networking board for

Micro-box and Rack-mount with four sets of GbE LAN. Intel Atom (Pineview-D) D410/D510

+ICH8M.

 AR-B6000D41 is a networking board for micro-box and Rack-mount Platform with Intel Atom

D410 +ICH8M, 4*10/100/1000 LAN.

 AR-B6000D51 is a Networking board for micro-box and Rack-mount Platform with Intel Atom

D510 +ICH8M, 4*10/100/1000 LAN with by-pass.

3.1.1. Features

 Processor:

AR-B6000D41: Intel® Atom™ Processor D410 (Single Core, 512K L2 Cache, 1.66 GHz)

AR-B6000D51: Intel® Atom™ Processor D510 (Dual Core, 2X 512K L2 Cache, 1.66 GHz)

 Chipsets: Intel® ICH8M

 Memory: DDR2 667/800MHz SO-DIMM, Maximum 2GB

 Display: VGA

 Storage: 1x CF, 2x SATA II,

 Communication: 4x Gbps Ethernet, 7x USB 2.0, 3x RS-232, 1x RS-232/422/485

 General: Watchdog timer, 8-bit GPIO, and PCI-104 expansion slot.

Revision: 1.1

3.1.2. Specification

System

CPU AR-B6000D41 Intel® Atom™ Processor D410 (512K L2 Cache, 1.66 GHz)

AR-B6000D51 Intel® Atom™ Processor D510 (2X 512K L2 Cache, 1.66 GHz)

Memory One SO-DIMM socket support 667/800 MHz DDR2 SDRAM up to 2GB

Graphic

Controller

Intel® GMA 3150

Gen3.5+ GFX Core, GFX Render Core Frequency @ 200MHz (400MHz), DX9

Video Memory DVMT 4.0, Maximum 256MB shared

Intel® Dynamic Video Memory Technology support 4.0

Video Interface 1 x VGA port (DB15)

Chipset Intel® ICH8M

Thermal

solution

FAN connector for CPU FAN

Fan connector for system FAN*2

BIOS 1. support console redirection(default enable)

2. support bypass setting(default disable)

3. support boot from LAN

Super I/O W83627DHC

Network Interface

Ethernet 4 *RJ45 JACK with LED (Refer to Appendix A)

Intel 82574L (10/100/1000Mbps) (L1~L4),

LAN by-Pass LAN1 and LAN2 support by-pass function

Reserve 1*3 pin Jumper for Hardware select bypass status.

AR-B6000D51 only

I/O

Front panel From left to right:

1. LAN1/ LAN2/ LAN3/ LAN4 LED: 1000, 10/100, Act. (Refer to Appendix B)

2. Power LED/HDD/Bypass: Green/Green/Yellow (Refer to Appendix C)

Rear panel From left to right:

Power Inlet

2 * USB (use standby power)

COM port (DB9)

LAN4/ LAN3/ LAN2

Reset Button

LAN1

Internal I/O

1. 4 x USB 2.0(2.54 pitch)

Mini-PCI

PCI slot

GPIO:

Use super I/O game port as GPIO

2x5 pin 2.0mm Pin Head

8-bit GPIO, 1 x GND, 1 x 3.3V/5V jumper selectable

LCM pin head( 7-pin pinhead 2.54mm)

Power input (Mini Fit 4 pin Co-lay with power inlet)

1*8 pin 2.54mm reserve for CPLD update

VGA pin head(2*5pin, 2.0mm

Panel connector(2*4pin, 2.54mm)

Storage

Revision: 1.1

CF 1 x Compact Flash socket, Type-II Socket

(Master mode) Support UDMA

SATA 2 x SATAII interface with power(JST 4 pin)

Others

Watchdog Timer Software programmable 1~255 Seconds,

Battery Lithium Battery, 3V 220mAH (CR2032)

Hardware

monitoring

CPU voltage

CPU and System Temperature

OS support Win XP/XP Embedded, Fedora 10(2.6.27)

Mechanical

Dimension 218 x 146mm

Operating

Temperature

0~60°C (32~140°F)

Storage

Temperature

-20~80°C (-4~176°F)

Relative

Humidity

0 to 90% @ 40°C, non-condensing (95% @ 40°C, Non-Condensing by request)

Power Supply N/A

Power

Requirements

12V Single Voltage Input

ATX circuit as AT mode

EMC & Safety

EMC CE, FCC Class B

Safety N/A

3.1.3. Package Contents

Model Name Part Lists QTY Remark

AR-B6000 series 1

AR-B6000

series

Revision: 1.1

3.1.4. Block Diagram

Revision: 1.1

3.2. Hardware Information

This chapter describes the installation of AR-B6000. At first, it shows the Function diagram and

the layout of AR-B6000. It then describes the unpacking information that you should read carefully,

as well as the jumper/switch settings for the AR-B6000 configuration.

3.2.1. Location

3.2.1.1. Top Side

Revision: 1.1

3.2.1.2. Bottom Side

Revision: 1.0

3.2.2. Connector, Header and Jumper Setting Table

Page is loading ...

Acrosser Technology AR-R6000 Owner's manual

Brand: Acrosser Technology

Model: AR-R6000

Category: Networking

Type: Owner's manual

Download PDF

report

Acrosser Technology AR-R6000 Owner's manual

Acrosser Technology AR-R6000 Owner's manual

Related papers

Other documents