AGES 3+
EN
Please read entire manual before starting assembly.
Keep this manual along with your purchase receipt
for future reference.
OWNER’S MANUAL
Contents, colors and decorations may vary from those shown.
To reduce the risk of injury, adult supervision
is required. Never use on road ways, near
motor vehicles, on or near steep inclines or
steps, swimming pools or other bodies of
water. Always wear shoes, and never allow
more than one rider.
WARNING
Screws contain potentially
hazardous sharp points or
sharp edges. Adult assembly
required.
CAUTION
CHOKING HAZARD-Small parts.
Not for children under 3 yrs.
National Products Ltd.
Room 413- 415, Houst on Centre,
63 Mody Road, Tsim Sha Tsui East,
Kow loon, Hong Kong.
WWW.NPL2.COM
i nf o@ NPL2.c o m
MODEL NO.
0131 0132
0133 0134
0135 0136
0137 0138
0139
(0131-0139)
1-909-594-4000 / 1-877-743-3899
All NPL® vehicles are covered by a ninety day warranty against defects in materials or
workmanship for ninety days from the date of purchase from an authorized retailer.
(The warranty and customer service contact in this manual only apply in the United States and Canada)
12
Important Information
Table of Contents
Limited Warranty
Important Information
Warning
Battery Warning
Battery Charging
Battery Care and Disposal
Parts List
Assembly
2
3
4
5
6
7
8
9-11
.................................................................................................
.......................................................................................................................
..........................................................................................................
...............................
..........................................................................
......................................................................................................................
..............................................................................................................
........................................................................................................
.......................................................................................
Operating your Vehicle
Trouble Shooting
12
13-15
Parts Diagram 16
...................................................................................................
.....................................................................................................
......................................................................................
.............. .....
3
Important Information
1-909-594-4000 / 1-877-743-3899
55 Ibs. (25 kg).
12
vehicle
Warning
To Prevent Serious Injuries
This product is for use by children
3 and up, and is not intended for children under 3
years due to lack of ability to operate safely.
Maximum weight 55 Ibs. ( kg). Maximum 1
rider at a time.
Do not leave children unattended. Adult
supervision required.
This package contains small pa s. Keep away
from the children until assembled.
Read manual for detailed safety information prior
to use.
Inspect product at regular intervals for wear or
loose hardware and tighten as required. Remove
from service if any abnormal conditions such as
cracks or breaks exist.
Check all coverings regularly to make sure
they are in place.
intended ages
of age
25
rt
Batteries can fall out and injure a child if the
vehicle tips over. Always use the battery
cover.
When the temperature falls below
outdoor use of this product is not recommended.
In extreme cold, plastic materials might lose
resilience and may become brittle and crack
upon impact. Store in a warmer and protected
place.
Do not operate the vehicle outdoors if it is
raining. Keep it in a dry area when not in use.
Disconnect the battery power supply when
the vehicle is not in use to prevent the children
driving the vehicle without adult supervision.
Always make sure the seat is securely attached.
The charger and battery are not toys and must
be regularly examined for damage to the cord,
plug, enclosure and other parts.
In the event of damage, the damage or worn
part must not be used until replaced.
Never modify the electrical system. Use of the
wrong type battery or charger could cause a
fire or explosion.
The battery compartment and area under seat
are not storage areas. Storing other articles may
create a fire hazard. Do not store any articles
in or near motor compartment.
0°F(-18°C),
®
NPL Only use the charger specified by .
Safe Driving Rules
Although most children can master the physical
driving skills to control the vehicles, they do not have
the mature judgment skills. Never let a child drive at
any time without adult supervision, and take the time
to carefully evaluate child’s skill levels and abilities
to operate the vehicle safely. Children can not always
recognize the hazards even after instruction. So teach
appropriate safety rules before allowing any child to
operate vehicle, and remember that THERE IS NO
SAFE SUBSTITUTE FOR DIRECT ADULT
SUPERVISON.
Restrict children to safe riding areas:
Teach and learn the safety first:
Always sit on the seat and wear shoes.
Maximum one rider at a time.
Do not operate in the street or near moving vehicles.
Do not operate near bodies of water, obstructions or
drop-offs.
Do not operate on sand, dirt or gravel.
Do not operate in the dark. Unexpected obstacles
could cause an accident.
Do not operate on inclines or steep slopes.
Do not operate near flammable vapors (e.g. gasoline,
paint thinner, acetone, liquid wax, etc.) Using the vehicle
near flammable liquids can or vapors could cause an
explosion or fire.
Do not place anything near moving parts such as
motors, gears or wheels. Rotating parts can snag
hair, fingers, etc., which may cause serious injury.
Away from swimming pools and other bodies of
water to prevent drowning.
Level ground to prevent tipovers and unintended
downhill motion.
Away from steps, hills, driveways, roads and alleys.
ADULT SUPERVISION REQUIRED.
MAKE SURE CHILDREN KNOW AND
FOLLOW
THESE RULES FOR SAFE
DRIVING.
Riding rules:
4
Warning
6
1-909-594-4000 / 1-877-743-3899.
12
55 Ibs. (25 kg)
Plug connectorsPlug connectors
Battery Charging
Non-rechargeable batteries are not to be recharged.
Make sure the charger connector is matching with
the battery connector.
charger are in accordance with the wall outlet.
Make sure the brand, voltage and frequency of the
Batteries are to be inserted with the correct polarity.
The supply terminals are not to be short circuited.
CAUTION
6
Battery Charging
Once the battery is charged, disconnect the battery connector from the charger connector. Un plug the
charger from the wall outlet. The battery is now ready to be installed in your vehicle. Please see the following
Battery Installation Section for detailed instructions on installing your vehicle:
Do not charge or store battery upside down . Charging produces explosive gases. Charge away from flames,
sparks and lit cigarettes. Charge in a well ventilated area.
Recharge the battery for at least 8-10 hours after each use of your vehicle.
Before first-time use, charge the battery for at least 12 hours. Never charge the battery longer than 24 hours.
Note: if power flow to the wall outlet is controlled by a switch , make sure the switch is "ON".
Plug the charger into a standard wal l outlet.
Plug the battery connector into the charger port.
Do not charge the battery longer than 24 hours.
® ®
Only use the NPL 6 volt charger to charge your NPL 6 volt battery.6 v
2
1
Charger
Charge the Battery
The first charge will take about 12 hours.
1. Open the battery charger port cover.
2. Insert the battery charger connector into the charger port.
3. Plug the charger into a standard 120V wall outlet. Note: The charger may feel warm during charging.
This is normal and not a cause for concern.
4. After charging is complete (at least 8 -10 hours, but not more than twenty four hours, with the first charge taking
about 12 hours) unplug the charger from the wall outlet and unplug the battery connector from the charger port.
Battery Replacement
1. Remove the screw on the back of the seat and
lift the seat out.
2. Disconnect the battery connectors.
3. Remove the two screws on the sides of the battery.
4. Carefully lift the battery out of the battery compartment.
Battery
charger
port
Battery
charger
port
6
1-909-594-4000 / 1-877-743-3899.
1-909-594-4000 /
1-877-743-3899.
backrest x 1
Front hubcap x 2 Front wheel x 1
Washer x 2
(Ø10mm)
Pin x 2
Washer x 1
(Ø10mm)
Pin x 1
Screwdriver
Please identify all parts before assembly and save all packaging material until assembly is completed to
ensure that no parts are discarded.
Metal parts have been coated with lubricant for protection during shipment. Wipe all metal parts with a
paper towel to remove any excess lubricant.
Wrench
Parts List
8
Parts List
(Not included)
Tools needed:
For wheels:
Body x 1 Seat x 1
Side mirror (left and right) x 2 (L/R)
Axle sleeve x 2
Rear wheel x 1
Rear drive wheel x 1 Rear hubcap x 2
Handle bar (left & right) 6V Charger x 1 Manual x 1
Manual
Windshield x 1
Front fork x 1 Headlight mount x1
Headlight x 1
Spare parts:
Nut x 1
(8mm)
Nut x 1
(5mm)
Screw x 1
(Ø5 x 30mm)
Screw x 2
(Ø4 x 12mm)
Screw x 1
(Ø3 x 12mm)
Front axle x1
(Ø 10 x 190mm)
Nut x 1
(8mm)
Bolt x 1
(Ø8 x 155mm)
Nut x 1
(8mm)
Nut x 4
(5mm)
Screw x 4
(Ø5 x 30mm)
Screw x 8
(Ø4 x 12mm)
Screw x 4
(Ø3 x 12mm)
Fender x 1
(Ø5x30mm)
Assembly
9
Assembly I
Insert the fender and fasten with 2 screws.
4
Insert the handle bar through the
headlight mount and fasten it with
4 screws and nut.
3
(Ø3x12mm)
(Ø4x12mm) (Ø4x12mm)
Insert the headlight to the headlight
mount and fasten with 3 screws.
Insert the windshield to the headlight
mount and fasten with 3 screws.
WARNING
Children can be harmed by small parts, sharp edges and sharp points in the vehicles
unassembled state, or by electrical items. Care should be taken in unpacking and assembling
the vehicle. Children should not handle parts, including the battery, or help in the assembly
of the vehicle.
2
Headlight
support (Back)
1
(5mm)
Step 1 Step 2 Step 3
37
Slide the rear drive with gear teeth facing
inward onto the rear axle. Assemble all
the parts in sequence as picture shown.
Insert a pin to the hole of the front axle
and make it to “M” shape by a plier.
Insert the hubcap onto the rear drive
wheel.
Rear drive
wheel
1
(Ø4x12mm)
Assembly
10
AssemblyII
36
Align the axle sleeve and hubcap onto the
front wheel on both sides.
Align the bottom part of the handle bar to
the front wheel. Insert the front axle
through the front wheel and fasten it with
bolt and nut.
Insert the front fork to handle bar and
fasten with 1 screw.
5
Front axle
(Ø10x190mm)
(8mm)
Assemble all the parts in sequence as
picture shown. Insert a pin to the hole of
the front axle and make it to “M” shape by
a plier. Insert the hubcap onto the rear
wheel.
Step 1 Step 2 Step 3
Rear wheel
8
(Ø4x12mm)
Assembly
11
Assembly III
Attach seat to slots of main body.
Fasten with 1 screw.
12
9
Insert the backrest to the body.
Fasten with 2 screws.
(Ø3x12mm)
Connect the battery connectors.
(8mm)
Bolt
(Ø8x155mm)
10
Align and fit the body and handle bar.
Insert the bolt through the hole and fasten
it with bolt and nut.
Plug connectorsPlug connectors
11
Operating your Vehicle
12
Operating your Vehicle
Stop
Vehicle will automatically stop after the accelerator is
released.
Sound
Press the button on the dashboard of the body.
Power switch
Switch button ON and OFF.
Forward
Push the shifter in position and press the
accelerator slowly.
upward
position and press the
Push the shifter in downward
accelerator slowly.
Reverse
Safety device
AUTO POWER OFF. If the motor is overloaded for
any reason, including improper usage, an electrical
circuit breaker will automatically cut off the power,
then resume after the parts have cooled!
Maintenance
Clean with a dry, soft cloth only. Do not wash
with water or corrosive agents.
Store vehicle in a dry area when not in use,
since moisture could cause the metal
components and electrical parts to corrode.
Remember to charge the battery monthly while
the vehicle is not in regular use.
Check and tighten all screws and coverings
regularly.
Check all plastic parts for cracks. Replace as
necessary.
ForwardForward
Reverse
Reverse
OnOn
Off
Off
Sound button
Sound button
AcceleratorAccelerator
1-909-594-4000 / 1-877-743-3899
switchesDamaged switch
55 lbs. (25kg)
55 lbs. (25kg)
8-10
13
6
6
55 lbs. (25kg)
8-10
8-10
14
1-909-594-4000 / 1-877-743-3899.
accelerator is
15
Note: Some parts shown are assembled to both sides of the vehicle.
Parts Diagram
Parts Diagram
16
27 26 8
10
11
9
12
13
14
25
1516172021222324
1
2
3
4
5
67
1819
No. Part QuantityNo. Part Quantity
1. Front wheel 1
2. Fender 1
3. Front fork 1
4. Headlight 1
5. Windshield 1
6. Body 1
7. Dashboard 1
8. Seat 1
9. Backrest 1
10. Charger port cover 1
11. Taillight 2
12. Side mirror 2
13. Gearbox cover 1
14. Rear wheel 1
15. Rear axle 1
16. Gearbox 1
17. Handlebar (Left & Right) 2
18. Pedal (Left) 1
No. Part Quantity
19. Oil tank parts 2
20. Pedal (Right) 1
21. Headlight mount 1
22. Axle sleeve 2
23. Front hubcap 2
24. Front axle 1
25. Rear hubcap 2
26. Rear drive wheel 1
27. Battery 1
1-909-594-4000
1-877-743-3899
1-909-869-5945
WE ARE HERE TO HELP
DO NOT RETURN TO STORE
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
Ntional Products 0139 Owner's manual
- Type
- Owner's manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Other documents
-
Chevrolet 818 Owner's manual
-
Hot Wheels MOJAVE 78473 User manual
-
Pacific Cycle Frozen Toddler Quad KT1167 Owner's manual
-
Kawasaki ZX-7 78410 User manual
-
Power Wheels 73690 User manual
-
KID MOTORZ BMW M6 GT3 1208 Owner's manual
-
-
-
-
Kid Trax Toys Doc McStuffins Owner's manual
