Williams GN1200BT Installation, Operation & Maintenance Manual

Page1



StainlessSteelCabinet



Installation,Operation&MaintenanceManual



Page2



SafetyTips

z Positiononaflat,stablesurface.

z Aserviceagent/qualifiedtechnicianshouldcarryout

installationandanyrepairsifrequired.Donotremove

anycomponentsorservicepanelsonthisproduct.

z ConsultLocalandNationalStandardstocomplywith

Thefollowing:

·HealthandSafetyatWorkLegislation

BSENCodesofPractice

·FirePrecautions

·IEEWiringRegulations

·BuildingRegulations

z DONOTusejet/pressurewasherstocleanthe

appliance.

z DONOTusetheapplianceoutside.

z DONOTusethisappliancetostoremedicalsupplies.

z DONOTuseelectricalappliancesinsidetheappliance.

(e.g.

heaters,ice‐creammakersetc.)

z DONOTstandorsupportyourselfonthebase,

drawersordoors.

z DONOTallowoilorfattocomeintocontactwiththe

plasticcomponentsordoorseal.Cleanimmediatelyif

contactoccurs.

z Bottlesthatcontainahighpercentageofalcoholmust



besealedandplacedverticallyintherefrigerator.

z Alwayscarry,storeandhandletheapplianceina

verticalpositionandmovebyholdingthebaseofthe

appliance.

z Alwaysswitchoffanddisconnectthepowersupplyto

theunitbeforecleaning.

z Keepallpackingawayfromchildren.

Disposeofthe

packaginginaccordancewiththeregulationsoflocal

authorities.

z Ifthepowercor disdamaged,itmustbereplacedby

anagentorarecommendedqualifiedtechnicianin

ordertoavoidahazard.

Introduction

Pleasetakeafewmomentstocarefullyreadthroughthis

manual.Correctmaintenanceandoperationofthis

machinewillprovidethebestpossibleperformancefrom

yourproduct.

PackContents

·RefrigeratororFreezer

·Shelvesx3(Single)/x6(Double)

·Keysx2



·Instructionmanual

·Shelfguidesx6(Single)/x12(Double)

·Wastewatertray



Weprideourselvesonqualityandservice,ensuringthatat

thetimeofpackingthecontentsaresuppliedfullyfunctional

andfreeofdamage.Shouldyoufindanydamageasaresultof

transit,please

contactyourdealerimmediately.

Installation

Note:Iftheappliancehasnotbeenstoredor

movedinanuprightposition,letitstanduprightfor

approximately12hoursbef or eoperation.Ifindoubt

allowtheappliancetostand.



1. Removetheappliancefromthepackaging.Make

surethatallprotectiveplasticfilmandcoa tings

arethoroughlyremoved

fromallsurfaces.



2.Maintainadistanceof20cm(7inches)between

theunitandwallsorotherobjectsforventilation.

Increasethisdistanceiftheobstacleisaheatsource.



Note:Beforeusingtheapplianceforthefirsttime,

cleantheshelvesandinteriorwithsoapywater.



3.

Setthebrakesonthecastorstokeeptheappliance

inpositionORleveltheappliancebyadjustingthescrewfeet.



RemovingtheCompressorSafetyBand



Thecompressorislocatedonthetopoftheappliance,

andsitsonrubberwashers.Undernormaloperating

conditionsthecompressorisallowedtovibrate.

Toavoiddamagethroughexcessivemotionduring

transit,astainlesssteelsafetybandisplacedoverthe

compressorandscrewedintothetopofthe

appliance.

Thissafetybandandthetwoscrewsfixingittothe

appliancemustberemovedbeforetheappliance is

turnon.



Lock/UnlocktheDoors

Alockisfittedtothedoorstoensurefoodstuffsarekept

securewithinyourappliance.

Usethekeysprovidedtolock/unlockthedoor.



Page3



FittingtheWasteWaterTray

Thewastewatertraycomesreadytofittotheundersideoftheappliance.Slidethetrayintotherunnerssitedunderthe

appliance.

FittingtheShelves

1.Placeonesetofshelfguidesoneithersideofthecabinetatthedesiredheight.

2.Slidetheshelfintoplace.

3.Repeatfortheremainingshelves.



Note:Thisisvitalforensuringcorrectdrainageofcondensation.

Operation

StoringFood

Togetthebestresultfromyourappliance,followtheseinstructions:

·Onlystorefoodstuffsintheappliancewhenithasreachedthecorrectoperatingtemperature.

·Donotplaceuncoveredhotfoodorliquidinsidetheappliance.

·Warporcoverfoodwherepossible.

·Donotobstructthefansinsidethe

appliance.

·Avoidopeningthedoorsforprolongedperiodsoftime.

Turnon

1. Closethedoor(s)oftheappliance.

2. Ensurethepowerswitchissetto[O]andturnonatthesocket.

3. Switchonthepower[l].Thecurrenttemperaturewithintheapplianceisdisplayed.

ManualDefrost

Theappliancewillautomaticallyrunadefrostcycleeverysixhours.

Note:Thecyclestartsfromthetimetheapplianceisinitiallypoweredup.

Tomanuallydefrosttheappliance:

1. PressandholdtheDEFROSTbuttonfor5seconds.

2. ThedefrostcyclewillstartimmediatelyandtheDefrostLETilluminates.Thedefrostwilllastamaximumof30minutes.



Note:Startingamanualdefrostalsoresetstheautomaticdefrosttimer.Thenextautomaticdefrostwillstartsix

hoursafter

themanualdefrosthasfinished.



3. Wastewateriscollectedinthewastewatertray.

Cleaning,Care&Maintenance

·Switchoffanddisconnectfromthepowersupplybeforecleaning.

·Cleantheinterioroftheapplianceasoftenaspossible.

·Donotuseabrasivecleaningagents.Thesecanleaveharmfulresidues.

·Cleanthedoorsealwithwateronly.

·Alwayswipedryaftercleaning.

·Donotallowwaterused

incleaningtorunthroughthedrainholeintotheevaporationpan.

·Takecarewhencleaningtherearoftheappliance.Sharpedgescancut.

·Anagentorqualifiedtechnicianmustcarryoutrepairsifrequired.

CleaningtheCondenser

P eriodicallycleaningthecondensercanextendthelifeoftheappliance.

Werecommendthatouragentorqualifiedtechniciancleanthecondenser.



Page4



Troubleshooting

Ifyourappliancedevelopsafault,pleasecheckthefollowingtablebeforemakingacalltoyourretailer.

Fault  ProbableCause Action

Theapplianceisnotworking

Theunitisnotswitchon Checktheunitispluggedincorrectlyandswitchedon

Plugandleadaredamaged Callyouragentorqualifiedtechnician

Fuseintheplughasblown Replacethefuse

Powersupply Checkpowersupply

Internalwiringfault Callyouragentorqualifiedtechnician

The appliance turns on, but

the temperature is too

high/low

Toomuchiceontheevaporator Defrosttheappliance

Condenserblockedwithdust Callyouragentorqualifiedtechnician

Fault ProbableCause Action

The appliance turns on, but

the temperature is too

high/low

Doorsarenotshutproperly Checkdoorsareshutandsealsarenotdamaged

Appliance isloca ted nearaheat source

or air flow to the condenser is being

interrupted

Movetherefrigeratortoamoresuitablelocation

Ambienttemperatureistoohigh Increaseventilationormoveappliancetoacoolerposition

Unsuitable foodstuffs are being stored

intheappliance

Removeanyexcessivehotfoodstuffsorblockagestothefan

Applianceisoverloaded Reducetheamountoffoodstoredintheappliance

The appliance is leaking

water

Theapplianceisnotproperlylevelled Adjustthescrewfeettoleveltheappliance(Ifapplicable)

Thedischargeoutsideisblocked Clearthedischargeoutlet

Movement of water to the drain is

obstructed

Cleartheflooroftheappliance(ifapplicable)

Thewatercontainerisdamaged Callyouragentorqualifiedtechnician

Thedriptrayisoverflowing Emptythedriptray(ifapplicable)

The appliance is unusually

loud

Loosenut/screw Checkandtightenallnutsandscrews

The appliance hasnotbeeninstalled in

alevelorstableposition

Checkinstallationpositionandchangeifnecessary

ElectricalWiring

Appliancesaresuppliedwitha3pin,moulded,BS1363plugandlead,witha13ampfuseasstandard.Theplugistobe

connectedtoasuitablemainssocket.Appliancesarewiredasfollows:

Livewire(colouredbrown)toterminalmarkedL

Neutralwire(colouredblue)toterminalmarkedN



Earthwire(colouredgreen)toterminalmarkedE

Allappliancesmustbeearthed,usingadedicatedearthingcircuit.

Ifindoubtconsultaqualifiedelectrician.

Electricalisolationpointsmustbekeptclearofanyobstructions.Intheeventofanyemergencydisconnectionbeing

requiredtheymustbereadilyaccessible.

Disposal

EUregulationsrequirerefrigerationproducttobedisposedofbyspecialistcompanieswhoremoveorrecycleallgasses,

metalandplasticcomponents.

Consultyourlocalwastecollectionauthorityregardingdisposalofyourappliance.Localauthoritiesarenotobligedto

disposeofcommercialrefrigerationequipmentbutmaybeabletoofferadvice

onhowtodisposeoftheequipmentlocally.



Compliance

Partshaveundergonestrictproducttestinginordertocomplywithregulatorystandardsandspecificationsetby

international,independent,andfederalauthorities.

Productshavebeenapprovedtocarrythefollowingsymbol:



Williams GN1200BT Installation, Operation & Maintenance Manual

Other documents