2. Simplicity
  3. 1695925
1695925

Simplicity 1695925, TRACTOR 42" MOWER DECK Operating instructions

  • Hello! I am an AI chatbot trained to assist you with the Simplicity 1695925 Operating instructions. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
  • Where should I look if the steering wheel is not present in the shipment?
    What should be done before delivering the product to the customer?
    What safety precautions are mentioned in the manual?
    How should I prepare the tires?
    What is the maximum inflation pressure for the tires?
    How should I lift the deck during assembly?
    What is the acceptable difference for side-to-side deck leveling?
    How do I adjust side-to-side leveling if needed?
    What is the acceptable difference for front-to-back deck leveling?
    How do I adjust front-to-back leveling if needed?
1755215_-_
Copyright © 2012 Briggs & Stratton Power Products Group, LLC
Milwaukee, WI, USA. All rights reserved.
BRIGGS & STRATTON POWER PRODUCTS is a registered
trademark of Briggs & Stratton Corporation
A
Note: For shipping purposes, the steering
wheel may be located under the hood of
the tractor.
Setup Instructions
Attention Setup Personnel:
The safety warnings provided in this guide
and in the tractor's operator manual included
with the unit contain important information
that must be followed when assembling,
setting-up, operating, servicing, transporting,
or storing the unit.
This unit should NOT be delivered to a customer until
assembly has been completed according to these
instructions.
These warnings are highlighted by the safety alert
triangle symbol shown above, which signifi es that an
important safety message is being provided.
You must read, understand, and follow these warnings
and instructions, and use safe shop and work practices
at all times while working on or around this unit and all
other outdoor power equipment.
B
.75 x 1.812
.75 x 1.250
A
B
C
D
A
C
D
B
1
2
lb-ft / Nm
15/16
(1X) 9/16, 3/4
(2X) 7/16, 1/2
ANTI-SIEZE LUBRICANT
ANTI-SEIZE
Tra c tor
Roller Bar Deck
42˝
Not for
Reproduction
Note: Apply anti-seize lubricant to rear axle shafts.
Install tire and rotate a few times to spread lubricant.
C D
1
2
3
E
F
B
A
C
D
ANTI-SEIZE
.75 x 1.812
.75 x 1.250
A
F
E
B
C
D
.75 x 1.625
2
3
1/2
1
20 lb-ft
(27 Nm)
2
Not for
Reproduction
3
F
20 lb-ft
(27 Nm)
4
5
2
1
3
ANTI-SEIZE
3
15/16
ANTI-SIEZE LUBRICANT
E
Note: Install steering wheel with center
spoke facing down.
Not for
Reproduction
G
WARNING
Over-inflating tires may cause
them to explode which could
result in serious injury.
DO NOT inflate the tires above the
maximum pressure (stamped on the
sidewall of the tires).
Set the tire pressures to the values shown below.
12-14 psi
(0,82-0,96 bar)
10 psi
(0,68 bar)
H
4
6
5
1
2
3
4
7
2X
Not for
Reproduction
I J
5
2
3
4
5
1
Notes: Lift deck in rear using two boards.
Not for
Reproduction
K
6
1
2
Not for
Reproduction
Mower Leveling
L
WARNING
Careless or improper handling
of blades may result in serious
injury.
DO NOT handle the sharp mower
blades with bare hands.
7
The difference between measurement (A and B)
should be less than 1/8″ (3 mm).
IF AN ADJUSTMENT IS NEEDED:
Tighten nuts (right or left side) as needed to adjust
side to side leveling.
SIDE-to-SIDE LEVELING
5
9/16˝
5
2
4
3
A
B
< 1/8˝
(< 3 mm)
1
Middle
Cut of Height
Not for
Reproduction
8
M
The difference between measurement (C and D)
should be less than 1/8″ (3 mm).
IF AN ADJUSTMENT IS NEEDED:
Locknuts must be turned evenly on both sides to
keep deck le
vel (Side-to-Side).
FRONT-to-BACK LEVELING
4
3
2
D C
C
D
< 1/8˝
(< 3 mm)
1
3/4˝ 3/4˝
4
D
4
D
3/4˝ 3/4˝
Not for
Reproduction
N
9
( )
WARNING
DO NOT REMOVE
COVER
6
7
3
4
5
2
+
+
7/16˝
1
+
WARNING
DO NOT REMOVE
COVER
WARNING
Read and understand any warnings by the
battery manufacturer.
Charge battery according to the instructions
provided by the charger manufacturer.
RISK OF BATTERY EXPLOSION FROM HYDROGEN
GAS MAY RESULT IN SERIOUS INJURY OR DEATH
Battery posts, terminals, and related
accessories contain lead and lead
compounds - chemicals known to the
State of California to cause cancer
and reproductive harm. Wash hands
after handling.
Always remove the ignition key when
disconnecting or connecting any wire harnesses
(engine or equipment).
Never use a battery charger to directly start the
engine. Use only a fully charged battery properly
installed.
Never charge the battery with the NEGATIVE (-)
cables attached to the battery terminal.
WARNING
Charge / Connect Battery
Notice:
1
2
Not for
Reproduction
10
This tractor is equipped with several safety systems
designed to keep the operator safe while using the
tractor. Check the operation of these systems using the
safety systems tests listed in the Operator's Manual.
PO
Not for
Reproduction
/