Outdoor Charcoal Barbecue Grill
Model No. CBT916LC/0297995
Manufactured in China for:
Blue Rhino Global Sourcing, Inc
Winston-Salem, NC USA
1.800.762.1142, www.bluerhino.com
© 2010 Blue Rhino Global Sourcing, Inc. All Rights Reserved
Blue Rhino
®
is a Registered Trademark of Ferrellgas, L.P. All Rights Reserved. CBT916LC-OM-101 EF
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury or death.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
Table of Contents
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
First Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cooking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Flare-Ups . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Tips. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Save these instructions for future reference. If you are assembling this unit for
someone else, give this manual to him or her to read and save for future reference.
OWNER’S MANUAL
Made from 70% Bagasse
(Environmentally Friendly Sugar
Cane Pulp By-product)
Outdoor Charcoal Barbecue Grill Model No. CBT916LC/0297995
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
This grill is for outdoor use only, and shall not be used in a building,
garage or any other enclosed area.
This grill is safety certified for use in the United States and/or Canada
only. Do not modify for use in any other location. Modification will result
in a safety hazard and will void the warranty.
Do NOT operate, light or use this appliance within 8 feet of walls,
structures or buildings.
Keep all combustible items and surfaces at least 36 inches (91 cm) away
from the grill at all times. DO NOT use this grill under any overhead or
near any unprotected combustible constructions.
This grill is NOT for commercial use.
Do not use grill for indoor cooking or heating. Toxic carbon monoxide
fumes can accumulate and cause asphyxiation.
Do not use gasoline, kerosene or alcohol for lighting.
Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
Do not store or use gasoline or other flammable liquids or vapors within
25 feet (7.62 m) of this appliance.
Never use charcoal that has been pre-treated with lighter fluid. Use only
a high grade plain charcoal, charcoal/wood mixture, lump charcoal or
cooking wood.
Do not alter grill in any manner. This will void the warranty.
Do not use the grill unless it is completely assembled and all parts are
securely fastened and tightened.
This grill should be thoroughly cleaned and inspected on a regular basis.
Use only Blue Rhino Global Sourcing, Inc. factory authorized parts. The
use of any part that is not factory authorized can be dangerous. This will
also void your warranty.
Do not use this appliance without reading “Operating Instructions” in
this manual.
Do not touch metal parts of grill until it has completely cooled (about
45 min.) to avoid burns, unless you are wearing protective gear (pot
holders, gloves, BBQ mittens, etc.).
Never touch grates (charcoal or cooking), ashes or coals to see if they
are hot.
Do not use on wooden decks, wooden furniture or other combustible
surfaces.
Do not use in or on boats or recreational vehicles.
Position grill so wind can not carry ashes to combustible surfaces.
Do not use in high winds.
Never lean over the grill when lighting.
Do not leave a lit grill unattended. Keep children and pets away from grill
at all times.
Do not attempt to move grill when in use. Allow the grill to cool (about
45 min.) before moving or storing.
When cooking, fire extinguishing materials shall be readily accessible.
In the event of an oil/grease fire, do not attempt to extinguish with water.
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
baking soda.
Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
Never add lighting fluid to hot or even warm coals as flashback may
occur causing serious injury or damage to property.
Always place your grill on a hard, non combustible, level surface. An
asphalt or blacktop surface may not be acceptable for this purpose.
Do not remove the ashes until they are completely and fully
extinguished.
Live hot briquettes and coals can create a fire hazard.
Always empty the ash catcher and grill after each use.
Do not place fuel (charcoal briquets, wood or lump charcoal) directly into
bottom of grill. Place fuel only on the charcoal pan/grid.
Do not allow charcoal to rest on the walls of grill. Doing so will greatly
reduce the life of the metal and finish of your grill.
Check to make sure the air vents are free of debris and ash before using
the grill.
Make sure ash catcher is securely and completely in place before using
the grill.
Extinguished coals and ashes should be placed a safe distance from all
structures and combustible materials.
With a garden hose, completely wet the surface beneath and around grill
to extinguish any ashes, coals or embers which may have fallen during
the cooking or cleaning process.
Always wear protective gloves when adding fuel (charcoal briquets,
wood or lump charcoal) to retain desired heat level.
Keep all electrical cords away from a hot grill.
Always use a meat thermometer to ensure food is cooked to a safe
temperature.
Never cover entire cooking area with aluminum foil.
Use protective gloves when assembling this product.
Do not force parts together as this can result in personal injury or
damage to the product.
Death, serious injury or damage to property may occur if the above is not
followed exactly.
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
3
Parts List
1
Lid Handle
55-09-098
2
Lid Air Vent
55-08-367
3
Lid
55-09-097
4
Cooking Grid
55-09-095
5
Charcoal Grid
55-09-094
6
Top HInge (2)
55-08-323
7
Bottom Hinge (2)
55-08-325
8
Bottom Bowl
55-09-093
9
Bottom Bowl Air Vent
55-08-366
10
Leg (4)
55-09-097
Exploded View
5
9
2
8
Hardware
A
Screw
M4x12 Zinc Plated Phillips Truss Head
2 pcs
B
Screw
M5x12 Zinc Plated Phillips Truss Head
11 pcs
C
Wing Nut
M4 Steel Plated
2 pcs
D
Wing Nut
M5 Steel Plated
13 pcs
E
Washer
ø6.4 Heat Resistant
2 pcs
F
Lock Washer
ø5.3 Zinc Plated
6 pcs
G
Pin
ø5 x 30 Black Coated
2 pcs
H
Cotter Pin 2 pcs
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver
10
1
4 3
7
6
Outdoor Charcoal Barbecue Grill Model No. CBT916LC/0297995
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
Assembly Instructions
1
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.762.1142 toll free. Please have
your owner’s manual and model number available for
reference.
For Easiest Assembly:
• To avoid losing any small components or hardware, assemble
your product on a hard level surface that does not have cracks
or openings.
• Clear an area large enough to layout all components and
hardware.
• When applicable, tighten all hardware connections by hand
first. Once the step is completed go back and fully tighten all
hardware.
• Follow all steps in order to properly assemble your product.
Typical assembly: approximately 30 minutes.
4
Attach Legs
B
x 4
D
x 4
3
Attach Bottom Bowl Air Vent and Bottom Hinges
A
x 2
B
x 4
C
x 2
D
x 4
F
x 4
2
Attach Lid Handle, Top Hinges and Air Vent Set
B
x 3
D
x 5
E
x 2
F
x 2
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
5
Assembly Instructions
5
Attach Lid
G
x 2
H
x 2
6
Insert Chrcoal Grid and Cooking Grid
7
Locking Lid
Unlocking Lid
8
Fold Legs
Unfold Legs
Outdoor Charcoal Barbecue Grill Model No. CBT916LC/0297995
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
CAUTION: Never use charcoal that has been pre-treated with lighter
fluid. Use only a high grade plain charcoal, charcoal/wood mixture,
lump charcoal or cooking wood.
First Use
1. Make sure all labels, packaging and protective films have been removed from the grill.
2. Remove manufacturing oils before cooking on this grill for the first time, by operating the
grill for at least 15 minutes with the lid closed. This will “heat clean” the internal parts and
dissipate odors.
Lighting
Check to make sure the air vents are free of debris and ash before
using the grill.
1. Open lid and vents.
2. Remove cooking grid.
3. Arrange charcoal briquettes or other fuel on the charcoal grid.
4. Light per instructions on fuel package.
5. Allow fuel time to ash into glowing coals before cooking.
CAUTION: When using a liquid starter always check before lighting.
Fluid can collect in the bottom bowl and could ignite resulting in a fire
in the bowl.
CAUTION: Never add lighting fluid to hot or even warm coals as
flashback may occur causing serious injury or damage to property.
Direct Cooking
Cooking directly over hot coals is ideal for searing in juices and grilling food requiring less than
25 minutes of grilling time, such as steaks, hamburgers, hot dogs, chicken parts, vegetables
and fruit.
1. Open lid and remove cooking grid.
2. Load and light charcoal per charcoal manufacturer’s instructions. Leave lid open.
3. While wearing protective gloves, carefully spread hot coals evenly across charcoal grid with a
long handle tool.
4. While wearing protective gloves replace cooking grid, close lid and allow grill to preheat.
5. While wearing protective gloves open lid and place food onto cooking grids above the hot
coals with long handle tongs.
6. With lid open or closed, cook until desired internal food temperatures are achieved.
Note: If additional briquettes are needed, remove food from cooking grid and while wearing
protective gloves remove the cooking grid and place additional briquettes without disturbing the
hot coals. Carefully replace cooking grid and food.
7. Allow charcoal to burn out by closing lid and all vents. Except in the case of an emergency,
do NOT pour water on hot coals.
Indirect Cooking
Not cooking directly over hot coals is ideal for slow cooking and grilling foods requiring more
than 25 minutes such as most roasts, loins, chops, whole chickens, turkey, fish and baked
goods.
1. Open lid and remove cooking grid.
2. Load and light charcoal per charcoal manufacturer’s instructions. Leave lid open.
3. While wearing protective gloves, carefully spread hot coals to the outsides of charcoal grid
with a long handle tool.
4. While wearing protective gloves replace cooking grid, close lid and allow grill to preheat.
5. Wear protective gloves to open lid. Use long handled tools to place food onto cooking grids
above the areas without hot coals.
6. With lid closed, cook until desired internal food temperatures are achieved.
Note: If additional briquettes are needed, remove food from cooking grid and while wearing
protective gloves remove the cooking grid and place additional briquettes without disturbing the
hot coals. Carefully replace cooking grid and food.
7. Allow charcoal to burn out by closing lid and all vents. Except in the case of an emergency,
do NOT pour water on hot coals.
For more tips on indirect cooking please see “Tips for Better Cookouts and Longer Grill Life”.
Operating Instructions
Controlling Flare-ups:
Caution: Do not use water on a grease fire. This can cause the grease
to splatter and could result in serious burns, bodily harm or other
damage.
Caution: Do not leave grill unattended while preheating or burning off
food residue. If grill has not been regularly cleaned, a grease fire can
occur that may damage the product.
WARNING: When cooking, fire extinguishing materials shall be
readily accessible. In the event of an oil/grease fire, do not attempt to
extinguish with water. Use type BC dry chemical fire extinguisher or
smother with dirt, sand or baking soda.
Flare-ups are a part of cooking meats on a grill and adds to the unique flavor of grilling.
Excessive flare-ups can over-cook your food and cause a dangerous situation for you and your
grill.
Excessive flare-ups result from the build-up of grease in the bottom of your grill.
If excessive flare-ups occur, DO NOT pour water onto the flames.
If grease fire occurs, close the lid until the grease burns out. Use caution when opening the lid
as sudden flare-ups may occur.
Minimize Flare-ups:
1. Trim excess fat from meats prior to cooking.
2. Cook high fat contents meats on “LOW” setting or indirectly.
3. Ensure that your grill is on hard level non combustible surface.
Tips for Better Cookouts and Longer Grill Life
1. For great recipes and tips visit recipes.uniflame.com.
2. To reduce flare-up keep grill clean, use lean cuts of meat (or trim fat) and avoid cooking on
very high temperatures.
3. Place delicate foods like fish and vegetables in aluminum foil pouches and indirect cook or
place on upper cooking levels (warming rack).
4. To avoid losing natural juices, use long handled tongs or spatulas instead of forks and turn
foods over just once during cooking.
5. When indirect cooking roasts and larger cuts of meat, place meat onto a roasting rack inside
a heavy gauge metal pan.
6. Try water pans to reduce flare-ups and cook juicer meats. Before starting coals remove
cooking grids and place a heavy duty shallow pan directly on charcoal grid. Fill half way
with water, fruit juices or other flavored liquids. Place coals around grid, per “Lighting
Instructions”, replace cooking grids and position food over the loaded pan.
7. Enhance food flavors by using wood chips in smoker boxes or aluminum foil pouches. Follow
the wood manufacturer’s instructions.
8. Rotisseries, grill baskets, vertical poultry holders and other accessories can enhance your
experiences, reduce cooking times and aid in clean-up.
9. Clean cooking grids and racks after every use with a quality grill bush designed for your grid
material. Wear protective gloves and gently remove the build-up while grids are hot.
10. Allow grill to fully cool after every use. Then protect clean cooking grids with a light coat of
cooking oil, clean out all ashes, wipe outside surfaces with a suitable kitchen cleaner and
protect surfaces with a quality cover that is properly fits your grill.
11. Watch barbecue themed TV shows or purchase related barbecue cookbooks to learn
helpful and interesting tips.
Cleaning and Care
CAUTION: All cleaning and maintenance should be done when grill is
cool (about 45 minutes) and with the fuel supply removed.
CAUTION: DO NOT clean any grill part in a self cleaning oven. The
extreme heat will damage the finish.
Notices:
1. Abrasive cleaners will damage this product.
2. Never use oven cleaner to clean any part of grill.
3. Do not clean any grill part in a self cleaning oven. The extreme heat will damage the
finish.
Cleaning Surfaces:
1. Wipe surfaces clean with mild dishwashing detergent or baking soda.
2. For stubborn surfaces use a citrus based degreaser and a nylon scrubbing brush.
3. Rinse clean with water.
Tips:
1. To help prevent rust keep grill covered when not in use.
2. Applying a light coat of vegetable oil or vegetable oil spray to the interior surface can help
prevent rust. Do NOT coat charcoal grate.
Contact 1.800.762.1142 for assistance. Do not return to place of purchase.
page no.
7
Product Registration
For faster warranty service, register your product immediately at www.bluerhino.com or call
1.800.762.1142.
Limited Warranty
Blue Rhino Global Sourcing, Inc (“Vendor”) warrants to the original retail purchaser of this
product, and to no other person, that if this product is assembled and operated in accordance
with the printed instructions accompanying it, then for a period of one (1) year from the date
of purchase, all parts in such product shall be free from defects in material and workmanship.
Vendor may require reasonable proof of your date of purchase. Therefore, you should retain
your sales slip or invoice. This Limited Warranty shall be limited to the repair or replacement of
parts, which prove defective under normal use and service and which Vendor shall determine
in its reasonable discretion upon examination to be defective. Before returning any parts, you
should contact Vendor’s Customer Service Department using the contact information listed
below. If Vendor confirms, after examination, a defect covered by this Limited Warranty in any
returned part, and if Vendor approves the claim, Vendor will replace such defective part without
charge. If you return defective parts, transportation charges must be prepaid by you. Vendor will
return replacement parts to the original retail purchaser, freight or postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident,
abuse, misuse, alteration, misapplication, improper installation or improper maintenance or
service by you or any third party, or failure to perform normal and routine maintenance on
the product as set out in this owner’s manual. In addition, the Limited Warranty does not cover
damage to the finish, such as scratches, dents, discoloration, rust or other weather damage,
after purchase.
This Limited Warranty is in lieu of all other express warranties. Vendor disclaims all warranties
for products that are purchased from sellers other than authorized retailers or distributors,
including the warranty of merchantability or the warranty of fitness for a particular purpose.
VENDOR ALSO DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING WITHOUT
LIMITATION THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE. VENDOR SHALL HAVE NO LIABILITY TO PURCHASER OR ANY THIRD PARTY FOR ANY
SPECIAL, INDIRECT, PUNITIVE, INCIDENTAL, OR CONSEQUENTIAL DAMAGES. Vendor further
disclaims any implied or express warranty of, and assumes no responsibility for, defects in
workmanship caused by third parties.
This Limited Warranty gives the purchaser specific legal rights; a purchaser may have other
rights depending upon where he or she lives. Some jurisdictions do not allow the exclusion or
limitation of special, incidental or consequential damages, or limitations on how long a warranty
lasts, so the above exclusion and limitations may not apply to everyone.
Vendor does not authorize any person or company to assume for it any other obligation or
liability in connection with the sale, installation, use, removal, return, or replacement of its
equipment, and no such representations are binding on Vendor.
Blue Rhino Global Sourcing, Inc
Winston-Salem, North Carolina USA
(800) 762-1142
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
/
