Jeep Wrangler Owner's manual

Wrangler

OWNER’S MANUAL

2016 Wrangler

Seventh Edition

Printed in U.S.A.

16JK72-126-AG

Jeep is a registered trademark of FCA US LLC.

2016

STICK WITH THE SPECIALISTS

®

VEHICLES SOLD IN CANADA

With respect to any Vehicles Sold in Canada, the name FCA

US LLC shall be deemed to be deleted and the name FCA

Canada Inc. used in substitution therefore.

DRIVING AND ALCOHOL

Drunken driving is one of the most frequent causes of

accidents.

Your driving ability can be seriously impaired with blood

alcohol levels far below the legal minimum. If you are

drinking, don’t drive. Ride with a designated non-

drinking driver, call a cab, a friend, or use public trans-

portation.

WARNING!

Driving after drinking can lead to an accident.

Your perceptions are less sharp, your reflexes are

slower, and your judgment is impaired when you

have been drinking. Never drink and then drive.

This manual illustrates and describes the operation of

features and equipment that are either standard or op-

tional on this vehicle. This manual may also include a

description of features and equipment that are no longer

available or were not ordered on this vehicle. Please

disregard any features and equipment described in this

manual that are not on this vehicle.

FCA US LLC reserves the right to make changes in design

and specifications, and/or make additions to or improve-

ments to its products without imposing any obligation

upon itself to install them on products previously manu-

factured.

TABLE OF CONTENTS

SECTION PAGE

1

INTRODUCTION . ..............................................................3

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE .................................11

3

UNDERSTANDING THE FEATURES OF YOUR VEHICLE .................................105

4

UNDERSTANDING YOUR INSTRUMENT PANEL ......................................307

5

STARTINGANDOPERATING ....................................................435

6

WHATTODOINEMERGENCIES..................................................579

7

MAINTAININGYOURVEHICLE...................................................601

8

MAINTENANCE SCHEDULES ....................................................675

9

IF YOU NEED CONSUMER ASSISTANCE ............................................685

10

INDEX .....................................................................697

1

2

3

4

5

6

7

8

9

10

INTRODUCTION

CONTENTS

䡵 INTRODUCTION ........................4

䡵 ROLLOVER WARNING ....................5

䡵 HOW TO USE THIS MANUAL ..............6

䡵 WARNINGS AND CAUTIONS ..............8

䡵 VEHICLE IDENTIFICATION NUMBER ........8

䡵 VEHICLE MODIFICATIONS/ALTERATIONS ....9

1

INTRODUCTION

Congratulations on selecting your new FCA US LLC

vehicle. Be assured that it represents precision workman-

ship, distinctive styling, and high quality.

This is a specialized utility vehicle. It can go places and

perform tasks that conventional passenger cars are not

intended. It handles and maneuvers differently from

many passenger cars both on-road and off-road, so take

time to become familiar with your vehicle.

The two-wheel drive version of this vehicle was designed

for on-road use only. It is not intended for off-road

driving or use in other severe conditions suited for a

four-wheel drive vehicle.

Before you start to drive this vehicle, read the Owner’s

Manual. Be sure you are familiar with all vehicle controls,

particularly those used for braking, steering, transmis-

sion, and transfer case shifting. Learn how your vehicle

handles on different road surfaces. Your driving skills

will improve with experience. When driving off-road, or

working the vehicle, don’t overload the vehicle or expect

the vehicle to overcome the natural laws of physics.

Always observe federal, state, provincial and local laws

wherever you drive.

As with other vehicles of this type, failure to operate this

vehicle correctly may result in loss of control or a

collision. Refer to “On-Road/Off-Road Driving Tips” in

“Starting And Operating” for further information.

This Owner’s Manual has been prepared with the assis-

tance of service and engineering specialists to acquaint

you with the operation and maintenance of your vehicle.

It is supplemented by Warranty Information, and various

customer-oriented documents. Please take the time to

read these publications carefully. Following the instruc-

tions and recommendations in this manual will help

assure safe and enjoyable operation of your vehicle.

4 INTRODUCTION

NOTE: After reviewing the owner information, it

should be stored in the vehicle for convenient referenc-

ing and remain with the vehicle when sold.

When it comes to service, remember that your authorized

dealer knows your Jeep® vehicle best, has factory-trained

technicians and genuine MOPAR® parts, and cares about

your satisfaction.

ROLLOVER WARNING

Utility vehicles have a significantly higher rollover rate

than other types of vehicles. This vehicle has a higher

ground clearance and a higher center of gravity than

many passenger cars. It is capable of performing better in

a wide variety of off-road applications. Driven in an

unsafe manner, all vehicles can go out of control. Because

of the higher center of gravity and the narrower track, if

this vehicle is out of control it may roll over when some

other vehicles may not.

Do not attempt sharp turns, abrupt maneuvers, or other

unsafe driving actions that can cause loss of vehicle

control. Failure to operate this vehicle safely may result

in a collision, rollover of the vehicle, and severe or fatal

injury. Drive carefully.

Rollover Warning Label

1

INTRODUCTION 5

Failure to use the driver and passenger seat belts pro-

vided is a major cause of severe or fatal injury. In a

rollover crash, an unbelted person is significantly more

likely to die than a person wearing a seat belt. Always

buckle up.

HOW TO USE THIS MANUAL

Consult the Table of Contents to determine which section

contains the information you desire.

Since the specification of your vehicle depends on the

items of equipment ordered, certain descriptions and

illustrations may differ from your vehicle’s equipment.

The detailed index at the back of this Owner’s Manual

contains a complete listing of all subjects.

Consult the following table for a description of the

symbols that may be used on your vehicle or throughout

this Owner’s Manual:

6 INTRODUCTION

1

INTRODUCTION 7

WARNINGS AND CAUTIONS

This Owner’s Manual contains WARNINGS against

operating procedures that could result in a collision,

bodily injury and/or death. It also contains CAUTIONS

against procedures that could result in damage to your

vehicle. If you do not read this entire Owner’s Manual,

you may miss important information. Observe all Warn-

ings and Cautions.

VEHICLE IDENTIFICATION NUMBER

The Vehicle Identification Number (VIN) is found on the

left front corner of the instrument panel pad, visible from

outside of the vehicle through the windshield. This

number also appears underbody, on the right side of the

frame rail near the center of the vehicle, as well as on the

Automobile Information Disclosure Label affixed to a

window on your vehicle. Save this label for a convenient

record of your vehicle identification number and optional

equipment.

The VIN is also stamped on either right or left hand side

of the engine block.

NOTE: It is illegal to remove or alter the VIN plate.

Vehicle Identification Number

8 INTRODUCTION

VEHICLE MODIFICATIONS/ALTERATIONS

WARNING!

Any modifications or alterations to this vehicle could

seriously affect its roadworthiness and safety and

may lead to a collision resulting in serious injury or

death.

1

INTRODUCTION 9

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

CONTENTS

䡵 A WORD ABOUT YOUR KEYS .............14

▫ Ignition Key Removal ...................14

▫ Key-In-Ignition Reminder ................16

䡵 SENTRY KEY ..........................16

▫ Replacement Key Fobs ..................17

▫ Customer Key Programming ..............18

▫ General Information ....................19

䡵

VEHICLE SECURITY ALARM — IF EQUIPPED . . .20

▫ Rearming The System ...................20

▫ To Arm The System ....................20

▫ To Disarm The System ..................21

䡵 ILLUMINATED ENTRY — IF EQUIPPED ......21

䡵 REMOTE KEYLESS ENTRY — IF EQUIPPED . . .22

▫ To Unlock The Doors And Swing Gate .......23

▫ Remote Key Unlock On First Push ..........23

▫ To Lock The Doors And Swing Gate .........24

▫ Sound Horn On Lock ...................24

▫ Using The Panic Alarm ..................25

▫ To Turn Off Flash Lights With Lock .........25

▫ Programming Additional Key Fobs ..........26

2

▫ Key Fob Battery Replacement .............26

▫ General Information ....................27

䡵 REMOTE STARTING SYSTEM —

IF EQUIPPED ..........................28

▫ How To Use Remote Start ................28

▫ Remote Start Abort Message On Electronic

Vehicle Information Center (EVIC) — If

Equipped ............................29

▫ To Enter Remote Start ...................29

▫ To Exit Remote Start Mode Without Driving

The Vehicle...........................30

▫ To Exit Remote Start Mode And Drive The

Vehicle ..............................31

▫ General Information ....................31

䡵 DOORS ..............................31

▫ Upper Half Door Window Removal —

If Equipped ..........................32

▫ Upper Half Door Window Installation —

If Equipped ..........................32

▫ Front Door Removal ....................32

▫ Rear Door Removal (Four-Door Models) ......34

䡵 DOOR LOCKS .........................37

▫ Manual Door Locks ....................37

▫ Power Door Locks — If Equipped ..........39

▫ Child-Protection Door Lock System —

Rear Doors ..........................42

12 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

䡵 WINDOWS ...........................43

▫ Power Windows — If Equipped ...........43

▫ Wind Buffeting .......................46

䡵 REAR SWING GATE .....................46

䡵 OCCUPANT RESTRAINT SYSTEMS ..........48

▫ Important Safety Precautions ..............48

▫ Seat Belt Systems ......................49

▫ Supplemental Restraint System (SRS) ........63

▫ Child Restraints .......................76

▫ Transporting Pets ......................99

䡵 ENGINE BREAK-IN RECOMMENDATIONS ....99

䡵 SAFETY TIPS .........................100

▫ Transporting Passengers .................100

▫ Exhaust Gas .........................100

▫ Safety Checks You Should Make Inside The

Vehicle .............................101

▫ Periodic Safety Checks You Should Make

Outside The Vehicle ...................104

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 13

A WORD ABOUT YOUR KEYS

The authorized dealer that sold you your new vehicle has

the key code numbers for your vehicle locks. These

numbers can be used to order duplicate keys. Ask your

authorized dealer for these numbers and keep them in a

safe place.

Ignition Key Removal

1. Place the gear selector in PARK (if equipped with an

automatic transmission).

2. Turn the ignition switch to the ACC (Accessory)

position.

3. Push the key and cylinder inward and rotate the key to

the LOCK position.

4. Remove the key from the ignition switch lock cylinder.

Key Fob

14 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

WARNING!

• Before exiting a vehicle, always shift the automatic

transmission into PARK or the manual transmis-

sion into FIRST gear or REVERSE, apply the park-

ing brake, turn the engine OFF, remove the key fob

from the ignition and lock your vehicle.

• Never leave children alone in a vehicle, or with

access to an unlocked vehicle.

• Allowing children to be in a vehicle unattended is

dangerous for a number of reasons. A child or

others could be seriously or fatally injured. Chil-

dren should be warned not to touch the parking

brake, brake pedal or the gear selector.

• Do not leave the key fob in or near the vehicle, or

in a location accessible to children. A child could

operate power windows, other controls, or move

the vehicle.

(Continued)

Ignition Switch Positions

1 — LOCK

2 — ACC (ACCESSORY)

3 — ON/RUN

4 — START

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 15

WARNING! (Continued)

• Do not leave children or animals inside parked

vehicles in hot weather. Interior heat build-up may

cause serious injury or death.

CAUTION!

An unlocked vehicle is an invitation. Always remove

the key from the ignition and lock all doors when

leaving the vehicle unattended.

Key-In-Ignition Reminder

Opening the driver’s door when the key is in the ignition

sounds a signal to remind you to remove the key.

NOTE: The Key-In-Ignition reminder only sounds when

the ignition key is placed in the LOCK or ACC position.

SENTRY KEY

The Sentry Key Immobilizer System prevents unauthor-

ized vehicle operation by disabling the engine. The

system does not need to be armed or activated. Operation

is automatic, regardless of whether the vehicle is locked

or unlocked.

The system uses key fobs that have an embedded elec-

tronic chip (transponder) to prevent unauthorized ve-

hicle operation. Therefore, only key fobs that are pro-

grammed to the vehicle can be used to start and operate

the vehicle. The system will shut the engine off in two

seconds if someone uses an invalid key to try to start the

engine.

16 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

NOTE: A key fob that has not been programmed is also

considered an invalid key, even if it is cut to fit the

ignition or lock cylinder for that vehicle.

During normal operation, after placing the ignition in the

on position, the Vehicle Security Light will turn on for

three seconds for a bulb check. If the light remains on

after the bulb check, it indicates that there is a problem

with the electronics. In addition, if the Vehicle Security

Light begins to flash after the bulb check, it indicates that

someone used an invalid key to try to start the engine.

Either of these conditions will result in the engine being

shut off after two seconds.

If the Vehicle Security Light turns on during normal

vehicle operation (vehicle running for longer than 10

seconds), it indicates that there is a fault in the electron-

ics. Should this occur, have the vehicle serviced as soon

as possible by an authorized dealer.

CAUTION!

The Sentry Key Immobilizer system is not compat-

ible with some aftermarket remote starting systems.

Use of these systems may result in vehicle starting

problems and loss of security protection.

All of the key fobs provided with your new vehicle have

been programmed to the vehicle electronics.

Replacement Key Fobs

NOTE: Only key fobs that are programmed to the ve-

hicle electronics can be used to start and operate the

vehicle. Once a key fob is programmed to a vehicle, it

cannot be programmed to any other vehicle.

2

THINGS TO KNOW BEFORE STARTING YOUR VEHICLE 17

CAUTION!

Always remove the Sentry Keys from the vehicle and

lock all doors when leaving the vehicle unattended.

Duplication of key fobs may be performed at an autho-

rized dealer or by following the customer key program-

ming procedure. This procedure consists of program-

ming a blank key fob to the vehicle electronics. A blank

key fob is one that has never been programmed.

NOTE: When having the Sentry Key Immobilizer Sys-

tem serviced, bring all vehicle key fobs with you to an

authorized dealer.

Customer Key Programming

If you have two valid key fobs, you can program new key

fobs to the Sentry Key Immobilizer system by performing

the following procedure:

1. Cut the additional Key(s) to match the ignition and

lock cylinder key code.

2. Insert the first valid key into the ignition. Place the

ignition in the ON/RUN position for at least three

seconds, but no longer than 15 seconds. Then, place

the ignition in the LOCK position and remove the first

key.

3. Insert the second valid key into the ignition. Place the

ignition in the ON/RUN position within 15 seconds.

After 10 seconds, a chime will sound. In addition, the

Vehicle Security Light will begin to flash. Place the

ignition in the LOCK position and remove the second

key.

4. Insert a blank key into the ignition. Place the ignition

in the ON/RUN position within 60 seconds. After

10 seconds, a single chime will sound. In addition, the

Vehicle Security Light will stop flashing. To indicate

18 THINGS TO KNOW BEFORE STARTING YOUR VEHICLE

Page is loading ...

Jeep Wrangler, 2016, 2016 Wrangler, 2016 Wrangler Unlimited, Wrangler Unlimited Owner's manual

Related papers

Other documents