Verona VEFSGG304NSS Installation guide

Brand: Verona

Model: VEFSGG304NSS

Category: Cookers

Type: Installation guide

This manual is also suitable for

Verona VEFSGG304NSS is a gas range for residential use only. It comes with a range of features that make cooking easier and more efficient. The range has four burners with different BTU outputs, so you can choose the right amount of heat for your cooking needs. The oven has a large capacity, so you can cook multiple dishes at once. The range also has a self-cleaning feature, so you can keep it clean without having to scrub it by hand.

THIS RANGE IS FOR RESIDENTIAL USE ONLY

FOR INSTALLER ONLY

GAS RANGE

for residential use only

Models: VEFSGG 304 ..

INSTALLATION INSTRUCTIONS

IMPORTANT - PLEASE READ AND FOLLOW

• Beforebeginning,pleasereadtheseinstructionscompletelyandcarefully.

• Donotremovepermanentlyafxedlabels,warnings,orplatesfromtheproduct.Thismay

voidthewarranty.

• Pleaseobservealllocalandnationalcodesandordinances.

• Pleaseensurethatthisproductisproperlygrounded.

• Theelectricalplugshouldalwaysbeaccessible.

• The installer should leave these instructions with the consumer who should retain

for local inspector’s use and for future reference.

Installationmustconformwithlocalcodesorintheabsenceofcodes,theNationalFuelGas

CodeANSIZ223.1/NFPA54-Iatestedition.Electricalinstallationmustbeinaccordancewith

theNationalElectricalCode,ANSI/NFPA70-latesteditionand/orlocalcodes.

INCANADA:InstallationmustbeinaccordancewiththecurrentCAN/CGA-B149.1National

GasInstallationCodeorCAN/CGA-B149.2,PropaneInstallationCodeand/orlocalcodes.

ElectricalinstallationmustbeinaccordancewiththecurrentCSAC22.1CanadianElectrical

CodesPart1and/orlocalcodes.

INSTALLATIONINMANUFACTURED(MOBILE)HOME:Theinstallationmustconformwith

theManufacturedHomeConstructionandSafetyStandard,Title24CFR,Part3280[formerly

theFederalStandardforMobileHomeConstructionandSafety,Title24,HUD(Part280)]

or,whensuchstandardisnotapplicable,theStandardforManufacturedHomeInstallations,

ANSI/NCSBCSA225.1,orwithlocalcodeswhereapplicable.

INSTALLATIONINRECREATIONALPARKTRAILERS:Theinstallationmustconformwith

stateorothercodesor,intheabsenceofsuchcodes,withtheStandardforRecreationalPark

Trailers,ANSIA119.5.

Installationofanygas-redequipmentshouldbemadebyalicensedplumber.Amanualshut-

offvalvemustbeinstalledinanaccessiblelocationinthegaslineexternaltotheappliance

forthepurposeofturningonorshuttingoffgastotheappliance(InMassachusettssuchshu-

toffdevicesshouldbeapprovedbytheBoardofStateExaminersofPlumbers&GasFitters).

Ifanexternalelectricalsourceisutilized,theappliance,wheninstalled,mustbeelectrically

groundedinaccordancewithlocalcodesor,intheabsenceoflocalcodes,withthenational

ElectricalCode,ANSI/NFPA70.

Some models are supplied with a protective lm on steel and aluminium

parts.Thislmmustberemovedbeforeinstalling/usingtheappliance.

WARNING !

Toreducetheriskoftippingtheappliance,

theappliancemustbesecuredbyproperly

installed anti-tip device packed with the

appliance.

• ALL RANGES CAN TIP

• INJURY TO PERSONS COULD RESULT

• INSTALL ANTI-TIP DEVICE PACKED

WITH RANGE

• SEE INSTALLATION INSTRUCTIONS

– Donotstoreorusegasolineorotherammablevaporsand

liquids in the vicinity of this or any other appliance.

– NEVER use this appliance as a space heater to heat or warm

theroom.Doingsomayresultincarbonmonoxidepoiso-

ningandoverheatingoftheappliance.

– WHAT TO DO IF YOU SMELL GAS:

• Donottrytolightanyappliance.

• Do not touch any electrical switch.

• Donotuseanyphoneinyourbuilding.

• lmmediately call your gas supplier from a neighbor’s

phone.Followthegassupplier’sinstructions.

• lfyoucannotreachyourgassupplier,calltheredepart-

ment.

– Installationandservice must be performed by a qualied

installer,serviceagency,orthegassupplier.

Iftheinformationinthismanualisnotfollowedexactly,



re



explosion



may



result



causing



property



damage,



personal

injury,ordeath.

WARNING !

Thisapplianceisdesignedandmanufacturedsolelyforthecookingofdomestic(household)food

andinnotsuitableforanynonedomesticapplicationandthereforeshouldnotbeusedinacom-

mercialenvironmement.

Theappliancewarrantywillbevoidiftheapplianceisusedwithinanonedomesticenvironmement

i.e.asemicommercial,commercialorcommunalenvironment.

CONVERSIONLABEL

DATAPLATE

TheGovernorofCaliforniaisrequiredtopublishalistofsubstancesknowntothestateofCalifor-

niatocausecancerorreproductiveharmandrequiresbusinessestowarncustomersofpotential

exposurestosuchsubstances.

WARNING!: Gas appliances contain or produce substances which can cause death or serious

illnessandwhichareknowntotheStateofCaliforniatocausecancer,birthdefectsorotherrepro-

ductiveharm.Toreducetheriskfromsubstancesinfuelorfromfuelcombustion,makesurethis

applianceisinstalled,operated,andmaintainedaccordingtothemanufacturer’sinstructions.

The product data plate is

attachedinsidethebottom

pivotingpanel.

INSTALLATION INSTRUCTIONS

WARNING!

THIS APPLIANCE MUST BE INSTALLED BY A QUALIFIED INSTALLER.

Improperinstallation,adjustment,alteration,services,ormaintenancecancauseinjuryorpropertydamage.Consultaquali-

edinstaller,serviceagent,orthegassupplier.

Screwdriver 2 - Wrench

T-handle

wrench

Tape

measurePencil

Adjustable

pliers

Adjustable

wrench

Suitable protective

gloves

Drill

Hammer

TOOLS NEEDED FOR INSTALLATION (NOT SUPPLIED WITH THE APPLIANCE)

IMPORTANT:Theuseofsuitableprotectiveclothing/glovesis

recommendedwhenhandling,installingofthisappliance.

GENERAL INFORMATION

1. Installation mustconform with local codes or, in the absen-

ceoflocal codes, with the National Fuel Gas Code,ANSI

Z223.1/NFPA54

-LatestEdition,CAN/CGA-B149.1orCAN/

CGA-B149.2.

2. Installationinmanufactured(mobile)home:installationmust

conform with the Manufactured Home Construction and

Safety Standard, Title 24 CFR, Part 3280 [formerly the

FederalStandardforMobileHomeConstructionandSa-

fety, Title 24, HUD (Part 280)] or, when such standard is

notapplicable,theStandardforManufactured Home Instal-

lations,ANSI/NCSBCSA225.1, or with local codes where

applicable.

3. Installation in Recreational Park Trailers: installation must

conformwithstateorothercodesor,intheabsenceofsuch

codes, with the Standard for Recreational Park Trailers,

ANSIA119.5.

4. Toeliminateriskofburnsorrebyreachingoverheatedsur-

face units, cabinet storage located above the surface units

shouldbeavoided.

5. Aircurtainorotheroverheadrangehoods,whichoperateby

blowingadownwardairowontoarange,shallnotbeused

inconjunctionwithgasrangesotherthanwhenthehoodand

rangehavebeendesigned,testedandlistedbyanindepen-

denttestlaboratoryforuseincombination.

6. 

WARNING!!

 Thisapplianceshallnotbeusedforspaceheating.This

informationisbasedonsafetyconsiderations.

7. AlIopeningsinthewallbehindtheapplianceandintheoor

undertheapplianceshallbesealed.

8. Keepapplianceareaclearandfreefromcombustiblemate-

rials,gasoline,andotherammablevapors.

9. Donotobstructtheowofcombustionandventilationair.

10. Disconnecttheelectricalsupplytotheappliancebeforeser-

vicing.

11. Whenremovingapplianceforcleaningand/orservice;

A. Shutoffgasatmainsupply.

B. DisconnectACpowersupply.

C. Disconnectgaslinetotheinletpipe.

D. Carefullyremovetherangebypullingoutward.

 CAUTION:Rangeisheavy;usecareinhandling.

12.

Electrical Requirement

Electrical installation should comply with national and local

codes.

13.

Air Supply and Ventilation

Theinstallermustreferstolocal/nationalcodes.

14.

Gas Manifold Pressure

Naturalgas-4.0”W.C.P.

LP/Propane-11.0”W.C.P.

15. Themisuseofovendoor(e.g.stepping,sitting,orleaningon

them)canresultinpotentialhazardsand/orinjuries.



WARNING!!

ELECTRICAL GROUNDING INSTRUCTIONS

Therangemustbeelectricallygroundedinaccordancewith

localcodesor,intheabsenceoflocalcodes,withtheNatio-

nalElectricalCode,ANSI/NFPANo.70-latestedition,inCana-

da Canadian Electrical Code.

InstallationshouldbemadebyaIicensedelectrician.

FORPERSONALSAFETY,THISAPPLIANCEMUSTBEPRO-

PERLY GROUNDED.

Ifanexternalelectricalsourceisutilized,theinstallationmustbe

electrically grounded in accordance with local codes or, in the

absenceoflocal codes,withthenationalElectricalCode,ANSI/

NFPA70.

This appliance is equipped with a three-prong grounding plug

(NEMA 5-15P) for your protection against shock hazard and

shouldbepluggeddirectlyintoaproperlygroundedsocket.

Do not under any circumstances cut or remove the third

(ground)prongfromthepowerplug.

REPLACEMENT PARTS

Onlyauthorizedreplacementpartsmaybeusedinperformingser-

viceontherange.Replacementpartsare availablefromfactory

authorizedpartsdistributors.Contactthenearestpartsdistributor

inyourarea.

16. Wheninstallingorremovingtherangeforservice,arollinglift

jackshouldbeused.Donotpushagainstanyoftheedgesof

therangeinanattempttoslideitintooroutoftheinstallation.

Pushingorpullingarange(ratherthanusingaliftjack)also

increases the possibility of bending the leg spindles or the

internalcouplingconnectors.

PROXIMITY TO SIDE CABINETS

1. Thisrangemaybeinstalleddirectlyadjacenttoexisting36”(914mm)

highbasecabinets.

 Rangedimensions:

• width:29”7/8(759mm)

• depth:24”13/64(614.9mm)

• height (without backguard): MIN 35” 21/32 (905.5 mm) - MAX 36”

11/32(923mm)

• backguard(height):3”(76mm)

 Gaslineopening:Wall-37/64”(14.5mm)fromtherightsidetocentre

ofrange;from5”7/16(138mm)to6”1/8(155.5mm)[dependingonfeet

regulation]fromtheoor.

 Grounded outlet:The electric cord with3-prong ground plug (NEMA

5-15P)hasalengthof72”(1830mm).Groundedoutletshouldbeloca-

ted37/64”(14.5mm)fromtheleftsidetocentreofrange;from5”7/16

(138mm)to6”1/8(155.5mm)[dependingonfeetregulation]fromthe

oor.

2. TherangeCANNOTbeinstalleddirectlyadjacenttosidewalls,tallcabi-

nets,tallappliances,orothersideverticalsurfacesabove36”(914mm)

high.

 Theremustbeaminimumof11”13/16(300mm)sideclearancefromthe

rangetosuchcombustiblesurfacesTOTHELEFTorTOTHERIGHT

abovethe36”(914mm)highcountertop.

 IMPORTANT:Oneside(leftorright)abovethe36”(914mm)high

countertopmustalwaysbekeptclear.

 Island installation: Theremustbeaminimumof12”(305mm)clearan-

cefromtherear ofthebackguardto suchcombustiblesurfaceon the

backoftherangeabovethe36”(914mm)highcountertop.

3. Themaximumuppercabinetdepthrecommendedis13”(330mm).Wall

cabinetabovetherangemustbeaminimumof30”(762mm)abovethe

countertopforawidthofminimum30”(762mm):ithastobecentered

withtherange.Sidewallcabinetsabovetherangemustbeaminimum

of18”(457mm)abovethecountertop.

installation

Fig. 1.1

3”

(76mm)

MIN35”21/32(905.5mm)

MAX36”11/32(923mm)

24”

13/64

(614.9

mm)

29”



7/8

(759

mm)

ASSEMBLING THE BACKGUARD

Itismandatorytoinstallthebackguard.

Assemblethebackguardasshowningure1.3:

• Screwthe2screws“A”interposingthespacers.

• Screwthecentralscrew“B”.

Fig. 1.3

GAS AND ELECTRIC CONNECTION

Fig. 1.2

Dottedlineshowingtheposition

oftherangewheninstalled

Areafor

ELECTRICAL

connection

Areafor

GASconnection

Ref. inch mm

A 5”7/16-6”1/8(*) 138-155.5(*)

B 14”3/8 365

C 37/64” 14.5

(*):Dependingonfeetregulation

PROXIMITY TO SIDE CABINETS

STANDARD INSTALLATION

Fig. 1.4b

Fig. 1.4a

OVEN VENT

Ref. inch mm

A 0” 0

B 36” 914

C 11”13/16 300

D 30”minimum 762minimum

E 18”minimum 457minimum

F 13”maximum 330maximum

G 20”minimum 500minimum

OVEN VENT

PROXIMITY TO SIDE CABINETS

ISLAND INSTALLATION

Fig. 1.5b

Fig. 1.5a

OVEN VENT

Ref. inch mm

A 0” 0

B 36” 914

C 11”13/16 300

D 30”minimum 762minimum

E 18”minimum 457minimum

F 13”maximum 330maximum

G 20”minimum 500minimum

H 12”minimum 305minimum

OVEN VENT

YOU MUST USE STABILITY

ANTI TIP BRACKET TO

PREVENT UNIT FROM

TIPPING.

ANTI-TIP STABILITY DEVICE INSTALLATION INSTRUCTIONS

1. Theanti-tipbrackethastobeattachedasshownongurebelow(onlyrearleftside),

ithastobexedontheoorORontherearwallbyno.4(four)suitablescrews(not

supplied).Alternativelytheanti-tipbracketcanalsobexedontheoorANDonthe

rearwallbyno.8(eight)suitablescrews(notsupplied).

2. Afterxingtheanti-tipbracket,sliderangeintoplace.Besuretherearleftfootslides

undertheanti-tipbracketattached.

LEVELLING THE RANGE

Therangeisequippedwith4LEVELLINGFEETandmaybelevelledbyscrewingor

unscrewingthefeet(gs.1.6-1.7).

Itisimportanttoobservethedirectionsofgures1.6,1.8a,1.8b.

Fig. 1.8bFig. 1.8a

Fig. 1.7

Fig. 1.6

Suppliedwiththerange

inaseparatekit

Suppliedwiththerange

inaseparatekit

0”

0mm

+5/16”

+8mm

+5/16”

+8mm

+11/16”

+17.5mm

Fig. 1.9

Dotted line showing the position

oftherangewheninstalled

ANTI-TIPSTABILITY

DEVICEFIXING

Anti-tipstability

device

Rearleft

feetofrange

3”

15/64

(82mm)

INSTALLING THE COOKTOP FRONT GUARD

Toincreasetheclearancebetweenthefrontedgeofthecooktopandtheburnersitispossibletoinstallthecooktopfrontguardsupplied

withtheappliance.

IMPORTANT:Toinstall/removetheguarditisnecessarytoremovethecooktop.

Attemptingtoinstall/removetheguardwithoutdisassemblingthecooktopwillresultinpermanentdamagetotheappliance.

Installthefrontguardasshowningure1.10:

1. Removethebackguard.

2. Removethepansupports,theburnercapsandtheamespreaders.

3. Unscrewcooktopxingscrews(“A”ingurebelow).

4. Removethedualburnerinneramespreader(“B”ingurebelow).

5. Removethecooktop(keepattentionnottodamagethegasketsttedabovetheburnercups-belowthecooktop).

6. Installthefrontguard“C”byinsertingthewireterminalsintotheproperholesabovethecontrolpanel(“D”ingurebelow).

7. Reassemblethecooktopandtheothercomponents(stepsfrom5to1).

 Payspecialattentiontothegasketsttedabovetheburnercups

 (belowthecooktop);iftheyaredamagedtheyshallbereplaced.

Fig. 1.10

gasconnection

2.PressureRegulator:

a. Allheavyduty,commercialtypecookingequipmentmusthaveapressureregulator

ontheincomingservicelineforsafeandefcientoperation,sinceservicepressure

mayuctuatewithlocaldemand.

 Beforeinstallingtheregulatormountthe1/2”NPT(conical)maleconnectortothe

regulator(seepicture2.2).

 Gasketsuppliedhastobeplacedbetween1/2”NPT(conical)connector/extension

pipemalepipetting(seepicture2.3).

 Theregulatorsuppliedwiththisrangemustbeinstalledbeforeanygasconnections

aremade.

 Usesuppliedpressureregulatoronly.

Gas supply line

Shuto valve

“open” position

To range

Explosion Hazard

Use a new CSA or UL approved

gas supply line.

Install a shut-off valve.

Securely tighten all gas connec-

tions.

If connected to LP, have a quali-

fied person make sure gas pres-

sure does not exceed 14" water

column.

Examples of a qualified person

include licensed heating per-

sonnel, authorized gas compa-

ny personnel, and authorized

service personnel.

Failure to do so can result in

death, explosion, or fire.

Fig. 2.1

Allgasconnectionsmustbemadeaccordingtonationalandlocalcodes.Thisgassupply

(service)linemustbethesamesizeorgreaterthantheinletlineoftheappliance.Sea-

lantonallpipejointsmustberesistanttotheactionofLP/Propanegas.

TherangeisequippedfortheusewithNATURALgas.Itisdesign-certiedbyCSAInter-

nationalforNATURALandL.P.gaseswithappropriateconversion.

Themodel/serialratingplate,locatedinsidethebottompivotingpanel,hasinformation

onthetypeofgasthatcanbeused.Ifthisinformationdoesnotagreewiththetypeof

gasavailable, check withthe localgas supplier.See page from16 to21 for L.P.gas

conversioninstructions.

1.ManualShut-offValve(g:2.1):

Amanualshut-offvalvemustbeinstalledinanaccessiblelocationinthegaslineexternal

totheapplianceforthepurposeofturningonorshuttingoffgastotheappliance(InMas-

sachusettssuchshutoffdevicesshouldbeapprovedbytheBoardofStateExaminersof

Plumbers&GasFitters).

Thisvalveshouldbelocatedinthesameroomastherangeandshouldbeinalocation

thatallowseaseofopeningandclosing(inapositionwhereitcanbereachedquicklyin

theeventofanemergency).

Donotblockaccesstotheshutoffvalve.Thevalveisforturningonorshuttingoffgas

totheappliance.

LOCK

Arrow

PRESSURE REGULATOR INSTALLATION

STEP1

Mountthe1/2”NPT(conical)maleconnectortothepressureregulatorand

tightenbyusingawrench.

Donotovertightentheconnector.

Overtighteningmaycrackregulator.

STEP2

Assemblethe1/2”NPTconnector+pressureregulatorgrouptotheextensionpipeinterposingthegasketsupplied.

Theregulatorcovermustbeorientedtowardthefrontsideoftherange.

IMPORTANT:usetwowrenchestotightentheconnection.

Fig. 2.3

Fig. 2.2

Regulatorcover

Gasket

Fig. 2.4

GAS CONNECTION SPEFICICATION

Range

manifold

Manifoldmalepipetting

1/2”Gcylindrical

(ISO228-1)male

1/2”Gcylindrical

(ISO228-1)female

Gasket

Extension

pipe female

pipetting

Torange

1/2”Gcylindrical

(ISO228-1)female

Extension

pipe

1/2”Gcylindrical

(ISO228-1)male

Extension

pipe male

pipetting

Gasket

Connector

1/2”NPT(conical)

male

1/2”NPT

female

Pressure

regulator

1/2”NPT

female

To mains

connection

Arrow

WARNING: Check the right positioning of the gas

regulator.

Thearrowonthebackofthegasregulatormustbe

oriented toward the connector.

b. Anyconversionrequiredmustbeperformedbyyourdealeroraqualiedlicen-

sedtechnicianorgasservicecompany.Pleaseprovidetheservicepersonwith

thismanualbeforeworkisstartedontherange.(Gasconversionsarethere-

sponsibilityofthedealerorenduser.)

c. ThisrangecanbeusedwithNATURALorLP/PROPANEgas.Itisshippedfrom

thefactoryadjustedforusewithNATURALgas.

d. Manifold pressureshould be checked with a manometerandby operating as

belowdetailed:

• Removetheinjectorfromtherearleft(orrearright)burnerandmountthe

proper test point adapter which is available from theAfter-Sales Service

(seesidegureandthe“OPERATIONSTOBEPERFORMEDWHENSUB-

STITUTINGTHEINJECTORSOFTHECOOKTOPBURNERS”chapter).

• Turntherearleft(orrearright)burnercontrolknobtothemaximumposi-

tion.

• Presstheknobandkeepingitpressedcheckthemanifoldpressurewitha

manometer;NATURALgasrequires4.0”W.C.P.andLP/PROPANErequires

11.0”W.C.P.

• Incominglinepressureupstreamfromtheregulatormustbe1”W.C.P.hi-

gherthanthemanifoldpressureinordertochecktheregulator.

• Theregulatorusedonthisrangecanwithstandamaximuminputpressure

of1/2PSI(14.0”W.C.P).Ifthelinepressureisinexcessofthatamount,a

stepdownregulatorwillberequired.

e. Theappliance,itsindividualshut-offvalve,andpressureregulatormustbedi-

sconnectedfrom thegas supplypiping system duringany pressuretesting of

thatsystematpressuresinexcessof1/2PSI(3.5kPa).

f. Theappliancemustbeisolatedfromthegassupplypipingsystembyclosingits

individualmanualshut-offvalveduringanypressuretestingof thegassupply

pipingsystemattestpressureequaltoorlessthan1/2PSI(3.5kPa).

3.FlexibleConnections:

Iflocalcodespermit,CSAorULdesign-certied,exiblemetalapplianceconnector

isrecommendedforconnectingthisrangetothegassupplyline.DoNotkinkorda-

magetheexibleconnectorwhenmovingtherange.Thepressureregulatorhas1/2”

NPTfemalepipethreads.Youwillneedtodeterminethettingsrequired,depending

onthesizeofyourgassupplyline,exiblemetalconnectorandshutoffvalve.

4.RigidPipeConnections:

Ifrigidpipeisusedasagassupplyline,acombinationofpipettingsmustbeusedto

obtainanin-lineconnectiontotherange.Allstrainsmustberemovedfromthesupply

andfuellinessorangewillbelevelandinline.

• Usejointcompoundsandgasketsthatareresistanttoactionofnaturalorpropa-

negasonallmalepipethreads.

• Donotovertightengasttingwhenattachingtopressureregulator.Overtighte-

ningmaycrackregulator.

5.LeakTesting:

IMPORTANT:Leaktestingoftheapplianceshallbeconductedasfollows:

• Afternalgasconnectionismade,turnonmanualgasvalveandtestallcon-

nectionsin gassupplypiping andappliance forgas leakswitha soapywater

solution.Duringthistestallappliancegasvalveshavetobeclosed.

• Inordertoavoidpropertydamageorseriouspersonalinjury,neveruseaIighted

match.Ifaleakispresent,tightenjointorunscrew,applymorejointcompound,

tightenagainandretestconnectionforleak.

Fig. 2.5

TESTPOINTADAPTER

The Test Point adapter is available from the

After-SalesService.

Pressure

regulator

NATURAL GAS

REGULATION

LP/PROPANE

REGULATION

REGULATOR COVER

CONVERSION TOLP/PROPANE GAS (OR CONVERSION BACK TOTHE

ORIGINAL GAS - NATURAL GAS)

Everyrangeisprovidedwithasetofinjectorsforthevarioustypesofgas.

Selecttheinjectorstobereplacedaccordingtothe“INJECTORSTABLE”.

Thenozzlediameters,expressedinhundredthsofamillimetre,aremarkedonthebodyofeachinjector.

CAUTION:Savetheoricesremovedfromtheapplianceforfutureuse.

SETTING THE PRESSURE REGULATOR

Thepressure regulatorisaccessible byopening the pivotingpanel (g.2.6); the pressureregulator is

positionedontherearrightsideoftherange(g.2.7).

Tosetthepressureregulator(g.2.7):

1. Unscrewtheregulatorcover.

2. Unscrewthe“A”component,reverseandscrewitaccordingtotheLP/PROPANE(orNATURALGAS)

regulation.

Fig. 2.6

Fig. 2.7

OPERATIONS TO BE PERFORMED WHEN SUBSTITUTING THE

INJECTORS OF THE COOKTOP BURNERS

• Removethepansupports,theburnercapsandtheamespreaders.

• Dualburneronly(g.2.9):Unscrewtheno.3xingscrews“A”andremovetheinner

crownamespreader“B”;thenunscrewtheno.2xingscrews“C”andremovethe

coverplate“D”.

• Usingawrenchsubstitutethenozzleinjectors“J

”,“J

”and“J

”(gs.2.8,2.9)with

thosemostsuitableforthekindofgasforwhichitistobeused.

• Dualburneronly(g.2.9):

Ret

thecoverplate“D”andscrewtheno.2xingscrews

“C”;thenrettheinnercrownamespreader“B”andscrewtheno.3xingscrews“A”

• Rettheamespreaders,theburnercapsandthepansupports.

Theburnersareconceivedinsuchawaysoasnottorequiretheregulationofthe

primary air.

SECOND ORIFICE

DEUXIEME ORIFICE

Fig. 2.9

Fig. 2.8

SEMI-RAPID BURNER

DUAL BURNER

INJECTORS TABLE

NOMINAL

POWER

REDUCED

POWER

LP/PROPANE

11”W.C.P.

NATURAL GAS

4”W.C.P.

BURNERS BTU/hr BTU/hr

Øinjector

[1/100mm]

Øinjector

[1/100mm]

Semirapid(SR) 8000 1500 85 139

Dual(D)

Innercrown 2100 1000

42(*)

115(**)

70(*)

200(**)

Inner&outercrown 17000 6500

Ovenburner 14000 2400 109 190

Broilburner 11000 - 100 170

(*) innercrown(“J

”ingure2.9)

(**) outercrown(“J

”ingure2.9)

Fig. 2.10

 Regulationscrew(Semirapidburner)

 Regulationscrew(Innercrownofdualburner)

 Regulationscrew(Outercrownofdualburner)

SETTING THE BURNER MINIMUM OF THE COOKTOP BURNERS

Whenswitchingfromonetypeofgastoanother,theminimumowratemustalsobecor-

rect:theameshouldnotgooutevenwhenpassingsuddenlyfrommaximumtominimum

ame.

Toregulatetheame(g.2.10)followtheinstructionsbelow:

Semirapidburner

• Lighttheburner.

• Setthegasvalveto“

LO”position(minimumrate).

• Removetheknob.

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

InsidecrownofDUALburner

• LighttheDUALburner.

• Setthegasvalveto“

”position(minimumrateofinnercrown).

• Removetheknob

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

OutsidecrownofDUALburner

• LighttheDUALburner.

• Setthegasvalveto“

”position(minimumrateofinnerandoutercrowns).

• Removetheknob.

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

ForLP/PROPANEgas,tightentheadjustmentscrewscompletely.

OPERATIONS TO BE EXECUTED FOR THE REPLACEMENT OF

THE INJECTOR OF THE OVEN BURNER

• Liftandremovethelowerpanelinsidetheoven.

• Gentlyunlock,fromtheburner,thesafetyvalveprobe“V”andtheignitionelectrode

“E”(as indicateding. 2.11).Take carenot todamage the probeand the ignition

electrode.

• Unscrewandremovetheburnersecuringscrews“A”(g.2.11).

• Withdrawtheburnerasshowningure2.12.

• Usinga7mmboxspanner,unscrewtheinjector(indicatedbythearrowing.2.12)

andreplaceitwithanewoneselectedinaccordancewiththe“Injectorstable”.

• Then replace the burner and the other components repeating the above steps in

reverseorder.

 IMPORTANT:Payspecialattentiontoreplacecorrectlythesafetyvalveprobe

“V”andtheignitionelectrode“E”aspergure2.11.Checkthecorrectopera-

tionofthesafetyvalveandtheignitionelectrode.

Fig. 2.11

Fig. 2.12

Anchorage

clip

Anchorage

clip

OPERATIONS TO BE EXECUTED FOR THE REPLACEMENT OF

THE INJECTOR OF THE BROIL BURNER

• Gentlyunlock,fromtheburner,thesafetyvalveprobe“V”andtheignitionelectrode

“E”(as indicatedin g.2.13).Take carenottodamagethe probeand theignition

electrode.

• Unscrewandremovetheburnersecuringscrew“A”(g.2.13).

• Withdrawtheburnerasshowningure2.14.

• Usinga7mmboxspanner,unscrewtheinjector(indicatedbythearrowing.2.14)

andreplaceitwithanewoneselectedinaccordancewiththe“Injectorstable”.

• Then replace the burner and the other components repeating the above steps in

reverseorder.

 IMPORTANT:Payspecialattentiontoreplacecorrectlythesafetyvalveprobe

“V”andtheignitionelectrode“E”aspergure2.13.Checkthecorrectopera-

tionofthesafetyvalveandtheignitionelectrode.

Anchorage

clip

Anchorage

clip

Fig. 2.13

Fig. 2.14

Page is loading ...

Verona VEFSGG304NSS Installation guide

Brand: Verona

Model: VEFSGG304NSS

Category: Cookers

Type: Installation guide

This manual is also suitable for

Download PDF

report

Verona VEFSGG304NSS Installation guide

This manual is also suitable for

Verona VEFSGG304NSS Installation guide

Related papers

Other documents