Verona 879453 Installation guide

THIS RANGE IS FOR RESIDENTIAL USE ONLY

FOR INSTALLER ONLY

GAS RANGE

for residential use only

Models: VEFSGG 304 ..

INSTALLATION INSTRUCTIONS

IMPORTANT - PLEASE READ AND FOLLOW

• Beforebeginning,pleasereadtheseinstructionscompletelyandcarefully.

• Donotremovepermanentlyafxedlabels,warnings,orplatesfromtheproduct.Thismay

voidthewarranty.

• Pleaseobservealllocalandnationalcodesandordinances.

• Pleaseensurethatthisproductisproperlygrounded.

• Theelectricalplugshouldalwaysbeaccessible.

• The installer should leave these instructions with the consumer who should retain

for local inspector’s use and for future reference.

Installationmustconformwithlocalcodesorintheabsenceofcodes,theNationalFuelGas

CodeANSIZ223.1/NFPA54-Iatestedition.Electricalinstallationmustbeinaccordancewith

theNationalElectricalCode,ANSI/NFPA70-latesteditionand/orlocalcodes.

INCANADA:InstallationmustbeinaccordancewiththecurrentCAN/CGA-B149.1National

GasInstallationCodeorCAN/CGA-B149.2,PropaneInstallationCodeand/orlocalcodes.

ElectricalinstallationmustbeinaccordancewiththecurrentCSAC22.1CanadianElectrical

CodesPart1and/orlocalcodes.

INSTALLATIONINMANUFACTURED(MOBILE)HOME:Theinstallationmustconformwith

theManufacturedHomeConstructionandSafetyStandard,Title24CFR,Part3280[formerly

theFederalStandardforMobileHomeConstructionandSafety,Title24,HUD(Part280)]

or,whensuchstandardisnotapplicable,theStandardforManufacturedHomeInstallations,

ANSI/NCSBCSA225.1,orwithlocalcodeswhereapplicable.

INSTALLATIONINRECREATIONALPARKTRAILERS:Theinstallationmustconformwith

stateorothercodesor,intheabsenceofsuchcodes,withtheStandardforRecreationalPark

Trailers,ANSIA119.5.

Installationofanygas-redequipmentshouldbemadebyalicensedplumber.Amanualshut-

offvalvemustbeinstalledinanaccessiblelocationinthegaslineexternaltotheappliance

forthepurposeofturningonorshuttingoffgastotheappliance(InMassachusettssuchshu-

toffdevicesshouldbeapprovedbytheBoardofStateExaminersofPlumbers&GasFitters).

Ifanexternalelectricalsourceisutilized,theappliance,wheninstalled,mustbeelectrically

groundedinaccordancewithlocalcodesor,intheabsenceoflocalcodes,withthenational

ElectricalCode,ANSI/NFPA70.

Some models are supplied with a protective lm on steel and aluminium

parts.Thislmmustberemovedbeforeinstalling/usingtheappliance.

WARNING !

Toreducetheriskoftippingtheappliance,

theappliancemustbesecuredbyproperly

installed anti-tip device packed with the

appliance.

• ALL RANGES CAN TIP

• INJURY TO PERSONS COULD RESULT

• INSTALL ANTI-TIP DEVICE PACKED

WITH RANGE

• SEE INSTALLATION INSTRUCTIONS

– Donotstoreorusegasolineorotherammablevaporsand

liquids in the vicinity of this or any other appliance.

– NEVER use this appliance as a space heater to heat or warm

theroom.Doingsomayresultincarbonmonoxidepoiso-

ningandoverheatingoftheappliance.

– WHAT TO DO IF YOU SMELL GAS:

• Donottrytolightanyappliance.

• Do not touch any electrical switch.

• Donotuseanyphoneinyourbuilding.

• lmmediately call your gas supplier from a neighbor’s

phone.Followthegassupplier’sinstructions.

• lfyoucannotreachyourgassupplier,calltheredepart-

ment.

– Installationandservice must be performed by a qualied

installer,serviceagency,orthegassupplier.

Iftheinformationinthismanualisnotfollowedexactly,



re



explosion



may



result



causing



property



damage,



personal

injury,ordeath.

WARNING !

Thisapplianceisdesignedandmanufacturedsolelyforthecookingofdomestic(household)food

andinnotsuitableforanynonedomesticapplicationandthereforeshouldnotbeusedinacom-

mercialenvironmement.

Theappliancewarrantywillbevoidiftheapplianceisusedwithinanonedomesticenvironmement

i.e.asemicommercial,commercialorcommunalenvironment.

CONVERSIONLABEL

DATAPLATE

TheGovernorofCaliforniaisrequiredtopublishalistofsubstancesknowntothestateofCalifor-

niatocausecancerorreproductiveharmandrequiresbusinessestowarncustomersofpotential

exposurestosuchsubstances.

WARNING!: Gas appliances contain or produce substances which can cause death or serious

illnessandwhichareknowntotheStateofCaliforniatocausecancer,birthdefectsorotherrepro-

ductiveharm.Toreducetheriskfromsubstancesinfuelorfromfuelcombustion,makesurethis

applianceisinstalled,operated,andmaintainedaccordingtothemanufacturer’sinstructions.

The product data plate is

attachedinsidethebottom

pivotingpanel.

INSTALLATION INSTRUCTIONS

WARNING!

THIS APPLIANCE MUST BE INSTALLED BY A QUALIFIED INSTALLER.

Improperinstallation,adjustment,alteration,services,ormaintenancecancauseinjuryorpropertydamage.Consultaquali-

edinstaller,serviceagent,orthegassupplier.

Screwdriver 2 - Wrench

T-handle

wrench

Tape

measurePencil

Adjustable

pliers

Adjustable

wrench

Suitable protective

gloves

Drill

Hammer

TOOLS NEEDED FOR INSTALLATION (NOT SUPPLIED WITH THE APPLIANCE)

IMPORTANT:Theuseofsuitableprotectiveclothing/glovesis

recommendedwhenhandling,installingofthisappliance.

GENERAL INFORMATION

1. Installation mustconform with local codes or, in the absen-

ceoflocal codes, with the National Fuel Gas Code,ANSI

Z223.1/NFPA54

-LatestEdition,CAN/CGA-B149.1orCAN/

CGA-B149.2.

2. Installationinmanufactured(mobile)home:installationmust

conform with the Manufactured Home Construction and

Safety Standard, Title 24 CFR, Part 3280 [formerly the

FederalStandardforMobileHomeConstructionandSa-

fety, Title 24, HUD (Part 280)] or, when such standard is

notapplicable,theStandardforManufactured Home Instal-

lations,ANSI/NCSBCSA225.1, or with local codes where

applicable.

3. Installation in Recreational Park Trailers: installation must

conformwithstateorothercodesor,intheabsenceofsuch

codes, with the Standard for Recreational Park Trailers,

ANSIA119.5.

4. Toeliminateriskofburnsorrebyreachingoverheatedsur-

face units, cabinet storage located above the surface units

shouldbeavoided.

5. Aircurtainorotheroverheadrangehoods,whichoperateby

blowingadownwardairowontoarange,shallnotbeused

inconjunctionwithgasrangesotherthanwhenthehoodand

rangehavebeendesigned,testedandlistedbyanindepen-

denttestlaboratoryforuseincombination.

6. 

WARNING!!

 Thisapplianceshallnotbeusedforspaceheating.This

informationisbasedonsafetyconsiderations.

7. AlIopeningsinthewallbehindtheapplianceandintheoor

undertheapplianceshallbesealed.

8. Keepapplianceareaclearandfreefromcombustiblemate-

rials,gasoline,andotherammablevapors.

9. Donotobstructtheowofcombustionandventilationair.

10. Disconnecttheelectricalsupplytotheappliancebeforeser-

vicing.

11. Whenremovingapplianceforcleaningand/orservice;

A. Shutoffgasatmainsupply.

B. DisconnectACpowersupply.

C. Disconnectgaslinetotheinletpipe.

D. Carefullyremovetherangebypullingoutward.

 CAUTION:Rangeisheavy;usecareinhandling.

12.

Electrical Requirement

Electrical installation should comply with national and local

codes.

13.

Air Supply and Ventilation

Theinstallermustreferstolocal/nationalcodes.

14.

Gas Manifold Pressure

Naturalgas-4.0”W.C.P.

LP/Propane-11.0”W.C.P.

15. Themisuseofovendoor(e.g.stepping,sitting,orleaningon

them)canresultinpotentialhazardsand/orinjuries.



WARNING!!

ELECTRICAL GROUNDING INSTRUCTIONS

Therangemustbeelectricallygroundedinaccordancewith

localcodesor,intheabsenceoflocalcodes,withtheNatio-

nalElectricalCode,ANSI/NFPANo.70-latestedition,inCana-

da Canadian Electrical Code.

InstallationshouldbemadebyaIicensedelectrician.

FORPERSONALSAFETY,THISAPPLIANCEMUSTBEPRO-

PERLY GROUNDED.

Ifanexternalelectricalsourceisutilized,theinstallationmustbe

electrically grounded in accordance with local codes or, in the

absenceoflocal codes,withthenationalElectricalCode,ANSI/

NFPA70.

This appliance is equipped with a three-prong grounding plug

(NEMA 5-15P) for your protection against shock hazard and

shouldbepluggeddirectlyintoaproperlygroundedsocket.

Do not under any circumstances cut or remove the third

(ground)prongfromthepowerplug.

REPLACEMENT PARTS

Onlyauthorizedreplacementpartsmaybeusedinperformingser-

viceontherange.Replacementpartsare availablefromfactory

authorizedpartsdistributors.Contactthenearestpartsdistributor

inyourarea.

16. Wheninstallingorremovingtherangeforservice,arollinglift

jackshouldbeused.Donotpushagainstanyoftheedgesof

therangeinanattempttoslideitintooroutoftheinstallation.

Pushingorpullingarange(ratherthanusingaliftjack)also

increases the possibility of bending the leg spindles or the

internalcouplingconnectors.

PROXIMITY TO SIDE CABINETS

1. Thisrangemaybeinstalleddirectlyadjacenttoexisting36”(914mm)

highbasecabinets.

 Rangedimensions:

• width:29”7/8(759mm)

• depth:24”13/64(614.9mm)

• height (without backguard): MIN 35” 21/32 (905.5 mm) - MAX 36”

11/32(923mm)

• backguard(height):3”(76mm)

 Gaslineopening:Wall-37/64”(14.5mm)fromtherightsidetocentre

ofrange;from5”7/16(138mm)to6”1/8(155.5mm)[dependingonfeet

regulation]fromtheoor.

 Grounded outlet:The electric cord with3-prong ground plug (NEMA

5-15P)hasalengthof72”(1830mm).Groundedoutletshouldbeloca-

ted37/64”(14.5mm)fromtheleftsidetocentreofrange;from5”7/16

(138mm)to6”1/8(155.5mm)[dependingonfeetregulation]fromthe

oor.

2. TherangeCANNOTbeinstalleddirectlyadjacenttosidewalls,tallcabi-

nets,tallappliances,orothersideverticalsurfacesabove36”(914mm)

high.

 Theremustbeaminimumof11”13/16(300mm)sideclearancefromthe

rangetosuchcombustiblesurfacesTOTHELEFTorTOTHERIGHT

abovethe36”(914mm)highcountertop.

 IMPORTANT:Oneside(leftorright)abovethe36”(914mm)high

countertopmustalwaysbekeptclear.

 Island installation: Theremustbeaminimumof12”(305mm)clearan-

cefromtherear ofthebackguardto suchcombustiblesurfaceon the

backoftherangeabovethe36”(914mm)highcountertop.

3. Themaximumuppercabinetdepthrecommendedis13”(330mm).Wall

cabinetabovetherangemustbeaminimumof30”(762mm)abovethe

countertopforawidthofminimum30”(762mm):ithastobecentered

withtherange.Sidewallcabinetsabovetherangemustbeaminimum

of18”(457mm)abovethecountertop.

installation

Fig. 1.1

3”

(76mm)

MIN35”21/32(905.5mm)

MAX36”11/32(923mm)

24”

13/64

(614.9

mm)

29”



7/8

(759

mm)

ASSEMBLING THE BACKGUARD

Itismandatorytoinstallthebackguard.

Assemblethebackguardasshowningure1.3:

• Screwthe2screws“A”interposingthespacers.

• Screwthecentralscrew“B”.

Fig. 1.3

GAS AND ELECTRIC CONNECTION

Fig. 1.2

Dottedlineshowingtheposition

oftherangewheninstalled

Areafor

ELECTRICAL

connection

Areafor

GASconnection

Ref. inch mm

A 5”7/16-6”1/8(*) 138-155.5(*)

B 14”3/8 365

C 37/64” 14.5

(*):Dependingonfeetregulation

PROXIMITY TO SIDE CABINETS

STANDARD INSTALLATION

Fig. 1.4b

Fig. 1.4a

OVEN VENT

Ref. inch mm

A 0” 0

B 36” 914

C 11”13/16 300

D 30”minimum 762minimum

E 18”minimum 457minimum

F 13”maximum 330maximum

G 20”minimum 500minimum

OVEN VENT

PROXIMITY TO SIDE CABINETS

ISLAND INSTALLATION

Fig. 1.5b

Fig. 1.5a

OVEN VENT

Ref. inch mm

A 0” 0

B 36” 914

C 11”13/16 300

D 30”minimum 762minimum

E 18”minimum 457minimum

F 13”maximum 330maximum

G 20”minimum 500minimum

H 12”minimum 305minimum

OVEN VENT

YOU MUST USE STABILITY

ANTI TIP BRACKET TO

PREVENT UNIT FROM

TIPPING.

ANTI-TIP STABILITY DEVICE INSTALLATION INSTRUCTIONS

1. Theanti-tipbrackethastobeattachedasshownongurebelow(onlyrearleftside),

ithastobexedontheoorORontherearwallbyno.4(four)suitablescrews(not

supplied).Alternativelytheanti-tipbracketcanalsobexedontheoorANDonthe

rearwallbyno.8(eight)suitablescrews(notsupplied).

2. Afterxingtheanti-tipbracket,sliderangeintoplace.Besuretherearleftfootslides

undertheanti-tipbracketattached.

LEVELLING THE RANGE

Therangeisequippedwith4LEVELLINGFEETandmaybelevelledbyscrewingor

unscrewingthefeet(gs.1.6-1.7).

Itisimportanttoobservethedirectionsofgures1.6,1.8a,1.8b.

Fig. 1.8bFig. 1.8a

Fig. 1.7

Fig. 1.6

Suppliedwiththerange

inaseparatekit

Suppliedwiththerange

inaseparatekit

0”

0mm

+5/16”

+8mm

+5/16”

+8mm

+11/16”

+17.5mm

Fig. 1.9

Dotted line showing the position

oftherangewheninstalled

ANTI-TIPSTABILITY

DEVICEFIXING

Anti-tipstability

device

Rearleft

feetofrange

3”

15/64

(82mm)

INSTALLING THE COOKTOP FRONT GUARD

Toincreasetheclearancebetweenthefrontedgeofthecooktopandtheburnersitispossibletoinstallthecooktopfrontguardsupplied

withtheappliance.

IMPORTANT:Toinstall/removetheguarditisnecessarytoremovethecooktop.

Attemptingtoinstall/removetheguardwithoutdisassemblingthecooktopwillresultinpermanentdamagetotheappliance.

Installthefrontguardasshowningure1.10:

1. Removethebackguard.

2. Removethepansupports,theburnercapsandtheamespreaders.

3. Unscrewcooktopxingscrews(“A”ingurebelow).

4. Removethedualburnerinneramespreader(“B”ingurebelow).

5. Removethecooktop(keepattentionnottodamagethegasketsttedabovetheburnercups-belowthecooktop).

6. Installthefrontguard“C”byinsertingthewireterminalsintotheproperholesabovethecontrolpanel(“D”ingurebelow).

7. Reassemblethecooktopandtheothercomponents(stepsfrom5to1).

 Payspecialattentiontothegasketsttedabovetheburnercups

 (belowthecooktop);iftheyaredamagedtheyshallbereplaced.

Fig. 1.10

gasconnection

2.PressureRegulator:

a. Allheavyduty,commercialtypecookingequipmentmusthaveapressureregulator

ontheincomingservicelineforsafeandefcientoperation,sinceservicepressure

mayuctuatewithlocaldemand.

 Beforeinstallingtheregulatormountthe1/2”NPT(conical)maleconnectortothe

regulator(seepicture2.2).

 Gasketsuppliedhastobeplacedbetween1/2”NPT(conical)connector/extension

pipemalepipetting(seepicture2.3).

 Theregulatorsuppliedwiththisrangemustbeinstalledbeforeanygasconnections

aremade.

 Usesuppliedpressureregulatoronly.

Gas supply line

Shuto valve

“open” position

To range

Explosion Hazard

Use a new CSA or UL approved

gas supply line.

Install a shut-off valve.

Securely tighten all gas connec-

tions.

If connected to LP, have a quali-

fied person make sure gas pres-

sure does not exceed 14" water

column.

Examples of a qualified person

include licensed heating per-

sonnel, authorized gas compa-

ny personnel, and authorized

service personnel.

Failure to do so can result in

death, explosion, or fire.

Fig. 2.1

Allgasconnectionsmustbemadeaccordingtonationalandlocalcodes.Thisgassupply

(service)linemustbethesamesizeorgreaterthantheinletlineoftheappliance.Sea-

lantonallpipejointsmustberesistanttotheactionofLP/Propanegas.

TherangeisequippedfortheusewithNATURALgas.Itisdesign-certiedbyCSAInter-

nationalforNATURALandL.P.gaseswithappropriateconversion.

Themodel/serialratingplate,locatedinsidethebottompivotingpanel,hasinformation

onthetypeofgasthatcanbeused.Ifthisinformationdoesnotagreewiththetypeof

gasavailable, check withthe localgas supplier.See page from16 to21 for L.P.gas

conversioninstructions.

1.ManualShut-offValve(g:2.1):

Amanualshut-offvalvemustbeinstalledinanaccessiblelocationinthegaslineexternal

totheapplianceforthepurposeofturningonorshuttingoffgastotheappliance(InMas-

sachusettssuchshutoffdevicesshouldbeapprovedbytheBoardofStateExaminersof

Plumbers&GasFitters).

Thisvalveshouldbelocatedinthesameroomastherangeandshouldbeinalocation

thatallowseaseofopeningandclosing(inapositionwhereitcanbereachedquicklyin

theeventofanemergency).

Donotblockaccesstotheshutoffvalve.Thevalveisforturningonorshuttingoffgas

totheappliance.

LOCK

Arrow

PRESSURE REGULATOR INSTALLATION

STEP1

Mountthe1/2”NPT(conical)maleconnectortothepressureregulatorand

tightenbyusingawrench.

Donotovertightentheconnector.

Overtighteningmaycrackregulator.

STEP2

Assemblethe1/2”NPTconnector+pressureregulatorgrouptotheextensionpipeinterposingthegasketsupplied.

Theregulatorcovermustbeorientedtowardthefrontsideoftherange.

IMPORTANT:usetwowrenchestotightentheconnection.

Fig. 2.3

Fig. 2.2

Regulatorcover

Gasket

Fig. 2.4

GAS CONNECTION SPEFICICATION

Range

manifold

Manifoldmalepipetting

1/2”Gcylindrical

(ISO228-1)male

1/2”Gcylindrical

(ISO228-1)female

Gasket

Extension

pipe female

pipetting

Torange

1/2”Gcylindrical

(ISO228-1)female

Extension

pipe

1/2”Gcylindrical

(ISO228-1)male

Extension

pipe male

pipetting

Gasket

Connector

1/2”NPT(conical)

male

1/2”NPT

female

Pressure

regulator

1/2”NPT

female

To mains

connection

Arrow

WARNING: Check the right positioning of the gas

regulator.

Thearrowonthebackofthegasregulatormustbe

oriented toward the connector.

b. Anyconversionrequiredmustbeperformedbyyourdealeroraqualiedlicen-

sedtechnicianorgasservicecompany.Pleaseprovidetheservicepersonwith

thismanualbeforeworkisstartedontherange.(Gasconversionsarethere-

sponsibilityofthedealerorenduser.)

c. ThisrangecanbeusedwithNATURALorLP/PROPANEgas.Itisshippedfrom

thefactoryadjustedforusewithNATURALgas.

d. Manifold pressureshould be checked with a manometerandby operating as

belowdetailed:

• Removetheinjectorfromtherearleft(orrearright)burnerandmountthe

proper test point adapter which is available from theAfter-Sales Service

(seesidegureandthe“OPERATIONSTOBEPERFORMEDWHENSUB-

STITUTINGTHEINJECTORSOFTHECOOKTOPBURNERS”chapter).

• Turntherearleft(orrearright)burnercontrolknobtothemaximumposi-

tion.

• Presstheknobandkeepingitpressedcheckthemanifoldpressurewitha

manometer;NATURALgasrequires4.0”W.C.P.andLP/PROPANErequires

11.0”W.C.P.

• Incominglinepressureupstreamfromtheregulatormustbe1”W.C.P.hi-

gherthanthemanifoldpressureinordertochecktheregulator.

• Theregulatorusedonthisrangecanwithstandamaximuminputpressure

of1/2PSI(14.0”W.C.P).Ifthelinepressureisinexcessofthatamount,a

stepdownregulatorwillberequired.

e. Theappliance,itsindividualshut-offvalve,andpressureregulatormustbedi-

sconnectedfrom thegas supplypiping system duringany pressuretesting of

thatsystematpressuresinexcessof1/2PSI(3.5kPa).

f. Theappliancemustbeisolatedfromthegassupplypipingsystembyclosingits

individualmanualshut-offvalveduringanypressuretestingof thegassupply

pipingsystemattestpressureequaltoorlessthan1/2PSI(3.5kPa).

3.FlexibleConnections:

Iflocalcodespermit,CSAorULdesign-certied,exiblemetalapplianceconnector

isrecommendedforconnectingthisrangetothegassupplyline.DoNotkinkorda-

magetheexibleconnectorwhenmovingtherange.Thepressureregulatorhas1/2”

NPTfemalepipethreads.Youwillneedtodeterminethettingsrequired,depending

onthesizeofyourgassupplyline,exiblemetalconnectorandshutoffvalve.

4.RigidPipeConnections:

Ifrigidpipeisusedasagassupplyline,acombinationofpipettingsmustbeusedto

obtainanin-lineconnectiontotherange.Allstrainsmustberemovedfromthesupply

andfuellinessorangewillbelevelandinline.

• Usejointcompoundsandgasketsthatareresistanttoactionofnaturalorpropa-

negasonallmalepipethreads.

• Donotovertightengasttingwhenattachingtopressureregulator.Overtighte-

ningmaycrackregulator.

5.LeakTesting:

IMPORTANT:Leaktestingoftheapplianceshallbeconductedasfollows:

• Afternalgasconnectionismade,turnonmanualgasvalveandtestallcon-

nectionsin gassupplypiping andappliance forgas leakswitha soapywater

solution.Duringthistestallappliancegasvalveshavetobeclosed.

• Inordertoavoidpropertydamageorseriouspersonalinjury,neveruseaIighted

match.Ifaleakispresent,tightenjointorunscrew,applymorejointcompound,

tightenagainandretestconnectionforleak.

Fig. 2.5

TESTPOINTADAPTER

The Test Point adapter is available from the

After-SalesService.

Pressure

regulator

NATURAL GAS

REGULATION

LP/PROPANE

REGULATION

REGULATOR COVER

CONVERSION TOLP/PROPANE GAS (OR CONVERSION BACK TOTHE

ORIGINAL GAS - NATURAL GAS)

Everyrangeisprovidedwithasetofinjectorsforthevarioustypesofgas.

Selecttheinjectorstobereplacedaccordingtothe“INJECTORSTABLE”.

Thenozzlediameters,expressedinhundredthsofamillimetre,aremarkedonthebodyofeachinjector.

CAUTION:Savetheoricesremovedfromtheapplianceforfutureuse.

SETTING THE PRESSURE REGULATOR

Thepressure regulatorisaccessible byopening the pivotingpanel (g.2.6); the pressureregulator is

positionedontherearrightsideoftherange(g.2.7).

Tosetthepressureregulator(g.2.7):

1. Unscrewtheregulatorcover.

2. Unscrewthe“A”component,reverseandscrewitaccordingtotheLP/PROPANE(orNATURALGAS)

regulation.

Fig. 2.6

Fig. 2.7

OPERATIONS TO BE PERFORMED WHEN SUBSTITUTING THE

INJECTORS OF THE COOKTOP BURNERS

• Removethepansupports,theburnercapsandtheamespreaders.

• Dualburneronly(g.2.9):Unscrewtheno.3xingscrews“A”andremovetheinner

crownamespreader“B”;thenunscrewtheno.2xingscrews“C”andremovethe

coverplate“D”.

• Usingawrenchsubstitutethenozzleinjectors“J

”,“J

”and“J

”(gs.2.8,2.9)with

thosemostsuitableforthekindofgasforwhichitistobeused.

• Dualburneronly(g.2.9):

Ret

thecoverplate“D”andscrewtheno.2xingscrews

“C”;thenrettheinnercrownamespreader“B”andscrewtheno.3xingscrews“A”

• Rettheamespreaders,theburnercapsandthepansupports.

Theburnersareconceivedinsuchawaysoasnottorequiretheregulationofthe

primary air.

SECOND ORIFICE

DEUXIEME ORIFICE

Fig. 2.9

Fig. 2.8

SEMI-RAPID BURNER

DUAL BURNER

INJECTORS TABLE

NOMINAL

POWER

REDUCED

POWER

LP/PROPANE

11”W.C.P.

NATURAL GAS

4”W.C.P.

BURNERS BTU/hr BTU/hr

Øinjector

[1/100mm]

Øinjector

[1/100mm]

Semirapid(SR) 8000 1500 85 139

Dual(D)

Innercrown 2100 1000

42(*)

115(**)

70(*)

200(**)

Inner&outercrown 17000 6500

Ovenburner 14000 2400 109 190

Broilburner 11000 - 100 170

(*) innercrown(“J

”ingure2.9)

(**) outercrown(“J

”ingure2.9)

Fig. 2.10

 Regulationscrew(Semirapidburner)

 Regulationscrew(Innercrownofdualburner)

 Regulationscrew(Outercrownofdualburner)

SETTING THE BURNER MINIMUM OF THE COOKTOP BURNERS

Whenswitchingfromonetypeofgastoanother,theminimumowratemustalsobecor-

rect:theameshouldnotgooutevenwhenpassingsuddenlyfrommaximumtominimum

ame.

Toregulatetheame(g.2.10)followtheinstructionsbelow:

Semirapidburner

• Lighttheburner.

• Setthegasvalveto“

LO”position(minimumrate).

• Removetheknob.

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

InsidecrownofDUALburner

• LighttheDUALburner.

• Setthegasvalveto“

”position(minimumrateofinnercrown).

• Removetheknob

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

OutsidecrownofDUALburner

• LighttheDUALburner.

• Setthegasvalveto“

”position(minimumrateofinnerandoutercrowns).

• Removetheknob.

• Withathinscrewdriver,turntheregulationscrew“R

”untiladjustmentiscorrect.

ForLP/PROPANEgas,tightentheadjustmentscrewscompletely.

OPERATIONS TO BE EXECUTED FOR THE REPLACEMENT OF

THE INJECTOR OF THE OVEN BURNER

• Liftandremovethelowerpanelinsidetheoven.

• Gentlyunlock,fromtheburner,thesafetyvalveprobe“V”andtheignitionelectrode

“E”(as indicateding. 2.11).Take carenot todamage the probeand the ignition

electrode.

• Unscrewandremovetheburnersecuringscrews“A”(g.2.11).

• Withdrawtheburnerasshowningure2.12.

• Usinga7mmboxspanner,unscrewtheinjector(indicatedbythearrowing.2.12)

andreplaceitwithanewoneselectedinaccordancewiththe“Injectorstable”.

• Then replace the burner and the other components repeating the above steps in

reverseorder.

 IMPORTANT:Payspecialattentiontoreplacecorrectlythesafetyvalveprobe

“V”andtheignitionelectrode“E”aspergure2.11.Checkthecorrectopera-

tionofthesafetyvalveandtheignitionelectrode.

Fig. 2.11

Fig. 2.12

Anchorage

clip

Anchorage

clip

OPERATIONS TO BE EXECUTED FOR THE REPLACEMENT OF

THE INJECTOR OF THE BROIL BURNER

• Gentlyunlock,fromtheburner,thesafetyvalveprobe“V”andtheignitionelectrode

“E”(as indicatedin g.2.13).Take carenottodamagethe probeand theignition

electrode.

• Unscrewandremovetheburnersecuringscrew“A”(g.2.13).

• Withdrawtheburnerasshowningure2.14.

• Usinga7mmboxspanner,unscrewtheinjector(indicatedbythearrowing.2.14)

andreplaceitwithanewoneselectedinaccordancewiththe“Injectorstable”.

• Then replace the burner and the other components repeating the above steps in

reverseorder.

 IMPORTANT:Payspecialattentiontoreplacecorrectlythesafetyvalveprobe

“V”andtheignitionelectrode“E”aspergure2.13.Checkthecorrectopera-

tionofthesafetyvalveandtheignitionelectrode.

Anchorage

clip

Anchorage

clip

Fig. 2.13

Fig. 2.14

Page is loading ...

Verona 879453, VEFSGG304NSS , VEFSGG304NSS Installation guide

Related papers

Other documents