2. Industrial & lab equipment
  3. Electrical equipment & supplies
  4. Power conditioning
  5. Uninterruptible power supplies (UPSs)
  6. Cabac
  7. UPS1500DV3

Cabac UPS1500DV3, UPS600DV3 User manual

  • Hello! I am an AI chatbot trained to assist you with the Cabac UPS1500DV3 User manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
1
Version 1
CABAC UNINTERRUPTIBLE POWER
SUPPLY
USER’S MANUAL
UPS600DV3
UPS1000DV3
UPS1500DV3
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
2
2 of 21
Contents

GeneralSafetyInstructions 3
ConditionsofUse 3
ElectricalSafety 4
SafeOperatingPractices 5
BatteryInformation 7
Introduction 8
Performance 8
InstallationInstructions10
PhysicalAppearance11
FrontPanelOperationalIndicators12
Operation13
Specification14
Maintenance15
SoftwareInstallation16
Loadconfigurereference20
Troubleshooting21

Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
3
3 of 21
General safety instructions

This manual contains important safety instructions that should be followed
duringtheinstallationandmaintenanceoftheUPS.
Pleasereadthismanualthoroughlybeforeattemptingtoinstalloroperatethis
UPS.
DO NOTunder any circumstances attempt to remove the UPS cover. It may
containhazardousvoltagesinternallythatmaycauseelectricshock.Thereare
no userserviceable parts inside. For service, please contact your nominated
serviceagent.
Conditions of Use
This equipment is designed for domestic use only. Themanufacturer neither
recommends nor knowingly sells this product for use in critical life support
applications.
1. Intendedforinstallationinacontrolledenvironment.   
a. Thecontrolledenvironmentshouldbeinaccordancewith
therequirementofthespecification  
b. DonotinstalloroperateyourUPSinornearwater.   
c. DonotplaceUPSonanunstablecart,standortable.  
d. Do not place UPS under direct sunlight or close to heat
emittingsources.
e. DonotplaceUPSpowercordinanyareawhereitmayget
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
4
4 of 21
damagedbyheavyobjects.
2. Placing magnetic storage media on top of the UPS may result in data
corruption.
3. YourUPSprovidesconditionedpowertoconnectedequipment.Maximum
load must not exceed that shown on the UPS rating label. If uncertain,
contactLegend
 
Electrical Safety
DO NOTunder any circumstances attempt to remove the UPS cover. It may
containhazardousvoltagesinternallythatmaycauseelectricshock.Thereare
no userserviceable parts inside. For service, please contact your nominated
serviceagent.
1. TheCabacUPSwillprovidea220~240VAC1φ（singlephase）ratepower
source.PleaseverifythatthismodelmatchesyourACmains/loadvoltage
requirements.
2. TheCabacUPSmustbeearthedatalltimesduringoperation.Thiscanbe
achieved by only connectingthe input power chord to a mains supply
socketoutletwithanintegralearthterminal.Ameansofdisconnectingthe
mainssupplyshouldbewithin2metersoftheUPS.
3. OutputsocketsontheUPSareelectricallyliveiftheUPSisswitchedON,
eveniftheUPSisnot plugged intomainssupply.TheOn/Off buttonon
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
5
5 of 21
theUPSdoesnotelectricallyisolatetheinternalparts.ToisolatetheUPS,
switchtheUPSOFFfirst,thenunplugitfromthemains.
4. Toreducetheriskoffire,usefuseswiththecorrectratingwhenreplacing
fuses.
5. TheUPSreliesonyourbuildingwiringovercurrentprotection,whichmust
beratedbetween1016amperes.
6. When using the communication features on the UPS, ensure the cabling
connectedtotheUSBcommunicationportarekeptseparatedbyatleast
25mmfromthepowercordstoandfromtheUPSinputandoutput.
Safe Operating Practices
ThispluggabletypeAequipmenthasfactoryinstalledbatteries,andhencemay
beoperatedbyanyonethathasreadandunderstoodthismanual.
Duringtheinstallationofthisequipment,itshouldbeassuredthatthesumof
the leakage currents of the UPS and the connected loads does not exceed
3.5mA.
1. Themains socketoutletthat suppliesthe UPS shallbe installednearthe
UPSandshallbeeasilyaccessible.
2. When replacing batteries, replace with the same type and number of
batteries.
3. TurnoffandunplugyourUPSbeforecleaning.Donotuseliquidoraerosol
cleaners.Adryclothisrecommendedtoremovedustfromthesurfaceof
yourUPS.
4. Do not handle any metallic connector before the power has been
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
6
6 of 21
disconnected.
5. TurnoffandunplugyourUPSfromtheoutletandcontactyournominated
serviceagentif:
o Thepowercordorplugdamaged.  
o LiquidhasbeenspilledontheUPS.  
o Thefuseblowsfrequently.  
o The UPS does not operate even when user follows the
operatinginstructions.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
7
7 of 21
Battery Information
1. CAUTION:Donotdisposeofbatteriesinafire,thebatterymayexplode.
2. CAUTION: Do not open or damage the battery or batteries,asreleased
electrolyteisharmfultotheskinandeyes.
3. Abatterycanpresentariskofelectricshockandhighshortcircuitcurrent.
Thefollowingprecautionshouldbeobservedwhenworkingonbatteries:
Remove watches, rings or other metal objects. Use tools with insulated
handles.
4. NOTE. The batteries used in your CabacUPS aremaintenance free. This
meansthatyouDONOTneedtocheckthebatteryfluidlevels.Tryingtodo
so may cause injury to yourself, or may cause a fault with the battery/
UPS.
5. The battery backup runtime is affected by the state of charge of the
batteries,theageofthebatteriesandgeneralconditionofthebatteries.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
8
8 of 21
Introduction  
The CabacUPScan instantly switch your computer to emergency battery
backup power and allows you to work through mains power outages without
datalossordowntime.Itcontinuouslyconditionsthepower comingintoyour
computerandprovidesapowersourcewithvirtuallyzerointerruption.
This UPSis specially designed for PC users and also suitable for computer
peripheralsorPOS.Amicrocontrollerisusedasthemaincontrollerthatrenders
theproductanintelligentUPS,capableofselfprotectionandfaultdiagnosis.A
builtinAVRfunctionautomaticallyadjustsitselftomaintainapowersupplyof
stable voltage when the utility power is of high or low voltage.
Highperformance surge suppression protects your computer from electrical
noiseanddamagingpowersurges.
Performance
YourCabacUPSprovidesthefollowinghighperformancefeatures:
• UninterruptiblePower
Protectsyourdatabysupplyingbatterybackupwhenpowerfails.
• MicrocontrollerControl
Bymeans ofinnovativesoftware control programs,the complicated hardware
circuitry is inlaidin the powerful microcontroller. Apart from reduced size, it
alsolowerstherateofUPSfailure.
• LEDIndicators
Operationalstatusisindicatedbyaseriesof3easytoreadLED’s.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
9
9 of 21
• AudibleAlarms
Activelyletsyouknowiftheunitisinbatterymode,ifthebatteryislow,orif
thereisanoverloadcondition.
• Highqualitybattery
The selection of high quality sealed leadacid maintenance free batteries
maximisesthelifespanofthebatteryforprolongedperformanceandenhanced
economicbenefits.
• AutomaticDetection
When the UPS is turnedON, it immediately performs an inspection of the
batterycapacity.
• AutomaticVoltageRegulation
Correctsoverandundervoltages,withoutdrainingthebattery.Thispreserves
batteryresourcesandensuresyourUPSwillprovidetheoptimumruntimeand
optimumvoltagesourceduringapowerblackout.
• SurgeProtection
Protectshardwarefromdamageduetounexpectedpowersurges.
• AutomaticCharge
TheUPSchargesitsbatterywheneveritisconnectedtoutilitypower.TheUPS
canbeineithertheONorOFFmode.
• AutoRestart(ColdStart)
If the UPS has shutdown during a battery backup session due to discharged
batteries, the UPS will automatically restart once mains power has been
restoredtosupplymainspowerandrechargethebatteries.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
10
10 of 21
Installation Instructions
1. Inspection
Inspectthe UPSuponreceipt.Thepackagingisrecyclable.Save it for reuse or
disposeofitproperly.EnsuretheUPSisphysicallyundamagedduetotransit.
2. Placement
InstalltheUPSinaprotectedareawithadequateairflow,andawayfromdirect
sunlightandexcessivedust.DonotoperatetheUPSwherethetemperatureand
humidityisoutsidethespecifiedlimitsintheSpecificationsTable.
3. ConnecttoMainsPower
ConnecttheACinputpowercordtoasocketoutlettopoweruptheUPS.
ThebatteryintheUPSwilllosesomechargeduringshippingandstorage.Itwill
rechargecompletely after approximately 8 hours of normal operation. Do not
expectfullbatteryruntimeduringthisinitialrechargeperiod.
4. Connecttheloads
PlugtheloadsintotheoutputsocketsontherearoftheUPS.EnsuretheUPSis
sizedcorrectlysothattheUPSisnotrunatfullloadconstantly.
Caution: NDO NOT connect a laser printer or plotter to the UPS with other
computerequipment.A laser printer or plotter periodicallydraws significantly
morepowerthanwhenidle,andmayoverloadtheUPS.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
11
11 of 21
Physical Appearance
FrontPanel


RearPanel
ItemDescription
1 On/OffPowerSwitch
2 LED1GREENACNormalStatusLED
3 LED2YELLOWBatteryChargingLED
4 LED3RED–BatteryStateofchargeLED
5 ACPowersocketoutlets
6 Phone/FaxlineSurgeSuppressor
7 USBCommunicationsPort
8 InputACFuse
9 InputPowerSocketwithSpareFuse
1
2
3
4
5
6
7
8
9
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
12
12 of 21
Front Panel Operational Indicators
FrontPanelIndicator
BuzzerStatus
Operational
Description
LED1
Green
LED2
Yellow
LED3
Red
OFFONOFFOFF
UPSOFF.
MainsNormal.
BatteriesCharging.
ONONOFF
2secondInterval 
Beeping
UPSON.
MainsMode
OFFOFFBLINK
Beepingevery5
seconds
Mainsnotpresent.
BatteryBackupmode
OFFOFFON
2beepsper
second
i.LowbatteryVoltage
4beepsevery2
seconds
ii.Overload
Continuousiii.Shortcircuit
OFFOFFOFFOFF
BatteriesDischarged.
SleepMode.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
13
13 of 21
Operation
• SwitchOnWiththeUPSpluggedin,pressthepowerswitchintoswitch
theUPSon.TheUPSwillperformaselftesteachtimeitisswitched
onandthebuzzerwillbeep2times.
• Switch Off  By depressing the powerswitch. UPS will keep charging
batteries.
• Backup (Beeping 1 time every 5 seconds)  When in Backup mode, the
battery illuminates and the UPS emits abeeping soundevery four
seconds. Press the power switchto stop the beeping. The alarm
stopswhentheUPSreturnstonormalutilitymodeofoperation
• Low Battery (Beeping 2 times every1 second)  In Backup mode, when
the battery energy runs low, the UPS beeps rapidly until the UPS
shutsdownduetocompletebatterydischarge.
• Overload(Beeping4timesevery2seconds)WhentheUPSisoverloaded
all three LED’s turn on and the buzzer beeps every 1 second.
PromptlydisconnectnonessentialloadequipmentfromtheUPSto
eliminate the overload, otherwise,the UPS will shut off output
power. The time for shutdown is determined by the size of the
overload
• NOTE:  If the UPS is working in battery mode, DO NOTturn on any
additionalloadssuchasacomputerormonitororreturnanyloads
fromsleepmode, otherwise,theUPSmay operateitsoverloador
shortcircuitprotection.
•
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
14
14 of 21
Specification
ModelUPS600DV3UPS1000DV3UPS1500DV3
RatedOutput
power
600VA/360W1000VA/600W1500VA/750W
InputCharacteristics
RatedInputVoltage230/240V
InputVoltageRange165–275V
RatedInputFrequency50Hz±10%
OutputCharacteristics
RatedOutputVoltage230V±10%
OutputFrequency50Hz±10%
OutputWaveformModifiedSquareWave
PowerFactor0.6
ChangeOverTime
Typ.0.4ms
Max.10ms
BatteryInformation(at25°C)
Rating1x12Vdc,7Ah2x12Vdc,9Ah2x12Vdc,9Ah
TypeSealedLeadAcid,MaintenanceFree
ServiceLife 23yearsdependinguponuse
BatteryRechargetimefor
90%capacity
8hours
Runtimeinminutesatfull
load
≥3mins
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
15
15 of 21
General
AudibleNoise<45dBA
NetMass6.3kg12.8kg13.0kg
Dimensions225mmx124mmx382mm
OperatingTemperature 10°Cto+40°C
MaximumOperating
RelativeHumidity
95%Relative
Maintenance
1. With normal use, a UPS battery will last 2to3years depending on the
numberofdischargesandoperating/ambienttemperatures.
2.ChargetheUPS'sbatteryevery3monthsduringextendedstorage.
3. Disconnect the power during extended storage to avoid overcharge of the
battery.
4.AvoidoverloadorshortcircuiteventhoughtheUPShasbuildinoverloadand
shortcircuitprotectfunction.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
16
16 of 21
Software Installation
InordertoutilisetheUPStoitsfullpotential,themonitoringsoftwaremustfirst
be installed. Please install the software according to the following steps.For
informationonhowtooperatethesoftware,refertotheOnCDmanual
Whenthesoftware
CDisinserted,The
Autorunscreenwill
comeup.
ClickInstall.
ClickNEXT
 
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
17
3.Enterdetailsas
requestedonthis
screen.Yourproduct
serialnumberwillbe
ontheCDenvelope.
ClickNEXT
4.Choosethe
installation
directory.
ClickNext.
 
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
18
18 of 21
5.Selectlanguage.
EnglishisDefault.
ClickNEXT.
6.SoftwarewillNow
Install.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
19
19 of 21
7.Installationisnow
complete.
ClickFINISH
8.Theprogramis
nowrunning.
Forinformationon
howtooperatethe
software,referto
theOnCDmanual.
Customer Care Australia P: 133 122 F: 1300 303 310 E: [email protected] W: cabac.com.au
A: 8 Distribuon Pl, Seven Hills NSW 2147
Customer Care New Zealand P: 8 0077 6969 F: 8 0088 6969 E: [email protected]o.nz W: cabac.co.nz
20
20 of 21
Load configuration reference
UPS(VA)=PCpowerATX(Watt)/0.6+Monitor(VA)
Monitorpower(reference)
15”CRT15”LCD17”CRT17”LCD19”CRT19”LCD
80VA40VA130VA60VA180VA80VA
21 of 21
Troubleshooting
ProblemPossibleCauseActionToTake
UPSnoton&
NoLED’son
i.BatteryDischarged.Sleep
Mode.
PressthePOWERbuttonON
ii.PCBfailureContactServiceAgent
UPSalwaysatbattery
mode
PowercordloseReplugthepowercord
Linevoltagetoohigh,too
loworblackout
Normalcondition
PCBfailureContactServiceAgent
sBuzzercontinuously
sounding
i.ShortCircuit.Removethenoncriticalloads
ii.UPSFaultyContactServiceAgent
UPSdoesnotprovide
expectedruntime.Low
batterywarningis
soundedprematurely.
Batteryisweakduetowear
orsuccessivemains
outages.
AllowUPStorechargebattery
foraminimumof8hours.IfUPS
soundslowbatterywarning
prematurely,whenretested,
batteryshouldbereplaced.
/