Zanussi ZF4A-SIL User manual

Category
Freezers
Type
User manual
INDEX
READ CAREFULLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PÁG. 2
WARNINGS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PÁG. 3
INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . PÁG. 4- 5
REGULATION AND CONTROL . . . . . . . . . . . . . . . . . . . . . . PÁG. 6
HOW TO USE YOUR REFRIGERATOR-FREEZER . . . . . . PÁG. 7 - 8
MAINTENANCE OF YOUR REFRIGERATOR-FREEZER . PÁG. 9 - 10
SOMETHING NOT WORKING . . . . . . . . . . . . . . . . . . . . . . PÁG. 11 - 12
NORMAL NOISES WHEN FUNCTIONING . . . . . . . . . . . . . PÁG. 13
TECHNICAL FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . PÁG. 14
2
READ CAREFULLY
Together with the appliance you should receive an instruction booklet as
well as:
A Guarantee Card «Certificado de Garantía», with the conditions of the
Guarantee.
List «Centros de Recepción de Garantías y Servicio Técnico».
This documentation should always be kept at hand for consulting.
Should this appliance be sold or transferred to another user,make sure that
this documentation stays with the appliance so that the new owner can get
acquainted with the functioning of the appliance and relevant warnings.
3
WARNINGS
Warning for your safety. Carefully read these
instructions before installing and using the
machine.
 This text affects appliances with gas R600a only.
The refrigeration circuit contains isobutane (R600a), which is a natural gas
noted for its excellent ecological properties. In the event of a mechanical
rupture causing a leak, this gas could ignite if naked flames or sparks are
present. For this reason do not use electrical appliances inside the
refrigerator, and do not place heating equipment or other sources of heat
using naked flames inside or close to the refrigerator. The refrigerant is
heavier than air and for this reason would be concentrated at the bottom
of the appliance. In the event of a gas leak air the room thoroughly.
This freezer is designed to be operated by adults. Children should not be
allowed to temper with the controls or play with the product.
Any electrical work required to install the appliance should be carried out
by a qualified electrician or competent person.
 This appliance is heavy. Care should be taken when moving it.
Make sure that the cable is not trapped underneath the appliance, nor
touches the motor
Repairs carried out by inexperienced persons may cause injuries or
serious malfunctioning. Refer to the nearest Network Centre.
 Make sure the rear part of the appliance stands against a wall as there are
working parts which heat up and should not be of easy access.
Make sure that there is a continous and adequate ventilation as a failor to
do so will result in component failure and possible food loss.
The appliance should be left for at least 4 hours after installation before it
is turned on in order to allow the refrigerant to settle.
This product must be serviced by an authorized NETWORK SERVICE
CENTRE, and only genuine SPARE PARTS
must be employed.
Before cleaning or reparing the appliance,
make sure to switch off and unplug.
It is dangerous to alter the specifications or
modify this product in any way.
These domestic refrigerators are designed to
be used specifically for the storage and conservation of food.
DO NOT USE SHARP INSTRUMENTS to scrap off frost or ice. Frost may
be removed by using a plastic scraper. (See defrost instructions).
 Frozen food must not be re-frozen once it has been thawed out.
 Manufacturers storage recommendations should be strictly complied with.
The lollies can cause frost burns if consumed right away from the freezer.
Do not place carbonate or frizzy drinks in the freezer as these may
explode.
 Whenever there is a need of discarding an old freezer make sure to:
Take off the doors in order to prevent children getting trapped inside.
Have the gas of the cooling system recovered before making it to
scrap iron.
4
Positioning
Place the refrigerator away from direct sunlight and heat sources.
Maintain recommended ventilation - see figure 2
Make sure the refrigerator is accurately levelled turning the adjustable
feet in order to avoid vibrations and noises J FIG. - 1
This is a built in design to be aligned with other furniture
The climate classification can be found on the serial plate, which is
located at the left on the inside of the appliance.
The following table shows which ambient temperature is correct for each
climate classification:
Climate classification for an ambient temperature of
SN + 10 to + 32°C
N + 16 to + 32°C
ST + 18 to + 38°C
T + 18 to + 43°C
INSTALLATION
5
INSTALLATION
Cleaning the interior
 Do not use alcohol or any cleaning product containing alcohol because it
can damage the cabinet.
Before using the appliance for the first time wash the interior with luke
warm water and some neutral soap so as to remove the typical smell of a
brand - new product and then dry thoroughly.
Do not use detergents or abrasive powders as these will damage the
finish.
Remove security used for transportation.
Cleaning of outside of appliance
Steel surface
For cleaning of the steel surface you can use cleaning agent for steel usual
in the trade.
Thouse cleaning agents create a protection against fingerprints as well.
m Warning: When using this product, it is necessary to avoid the contact
with plastic material because of degradation.
Electrical connection
Before plugging the appliance into a socket make sure that the voltage
and frequency shown on the rating plate correspond to your home supply.
It is essential that the appliance be connected to an efficient earth tap.
For this purpose the supply cable plug incorporates a special earth
contact. If the sockets of your domestic wiring system are not grounded,
have the appliance connected to a separate ground wire in accordance
with existing safety regulations.
«THE MANUFACTURER DECLINES TO ACCEPT ANY LIABILITY IF
THIS SAFETY RULE IS NOT OBSERVED».
Starting-Up
Plug the appliance into the wall socket.
Make sure the inner light H (Fig. 1) illuminates when opening the door.
Turn the «temperature knob» A (Fig. 1) to intermediate position.
6
REGULATION AND CONTROL
Temperature regulation:
A FIG.- 1
Allows temperature regulation according to room temperature and usage.
 Pos. 1 = minimum cold.
 Pos. 6 = maximum cold.
 Pos. 0 = Disconnection of motor.
Interior light:
H FIG.- 1
Lightens when opening the door of the refrigerator compartment and shuts
off when closing the door. It also shuts off turning the temperature
regukator to 0 position.
When changing the light bulb (see point A-1 «IF SOMETHING DOES NOT
WORK»), release the protection X, by removing the screw Y and pushing it
as showns in the figure.
7
HOW TO USE YOUR
REFRIGERATOR-FREEZER
Freezer Compartment:
This freezer, marked , is suitable for freezing food
and permits long term
storage of frozen food.
The appliance must be connected for at least 3 hours before
introducing food.
Freezing of food:
1) Place food on the upper grill I (figure 1).
2) Maintain food for at least 24 hours in that position.
3) The maximum quantity to be frozen within 24 hours is shown on the
«Rating Plate».
4) The shelf situated in the freezer door is not destined to freeze fresh food
but to preserve prefrozen food, storage ice cream or frost cocktail
glasses; the volume is 7 l.
Conservation of frozen food:
For a safe storage of food the temperature inside should never rise above
- 18° C.
An adjustable thermostat is regulating this temperature automatically.
Make sure the «Temperature Regulator» is on a medium setting.
However, it may sometimes be necessary (due to poor ventilation, high
room temperature, frequent opening of the door) to graduate the setting
of the «Temperature Regulator».
In case of an accidental stop of the appliance or a power cut proceed as
follows:
Keep the doors closed at all events.
Try to find out for how long the failure will continue.
Once reestablished to normality:
A) If the freezer is fully loaded and the power failure is less than the time
indicated on the «Rating Plate» no damage has been done to the
food stored.
B) If the freezer is fairly loaded the «rising of the temperature» is reduced.
If thawing has not yet started proceed as said in previous point.
C) If thawing has started, consume the food immediately, or cook it and
the freezing it again.
Refrigerator Compartment:
This compartment is meant for keeping drinks and fresh food.
The inner temperature is quite equalized. Avoid food touching inner
walls, as the cold is being produced in there and the food could partly get
frozen. On the other hand this would avoid a perfect circulation of the cold
air. This appliance is provided with an automatic defrosting device. You
therefore might find sometimes a fine layer of ice or water drops.
8
HOW TO USE YOUR
REFRIGERATOR-FREEZER
Dynamic refrigeration (DAC):
The DAC system gives an extra performance to the fridge compartment,
shown as:
 Faster cooling.
More uniform temperature.
DAC (Dynamic Air Cooling system) has been mainly designed for hot
weather, and also when the refrigerator is plenty of food.
To operate, push the button on the fan switch and the green pilot light will
come on.
When DAC is switched on, the cold production is higher, thus you should
turn the temperature regulator to an adequate position to avoid excesive
cold.
Useful Hints
Do not introduce any new food during a freezing period.
Do not put any newly introduced food for freezing near to already frozen
food.
Wrap the food up properly or place it in hermethic recipies before
introducing it into the freezer.
Do not introduce any hot food into the freezer
Food and drinks of a strong flavour may pass this on to others and affect
the flavour. Wrap them up adequately or put them into tight closing bags.
Follow the instructions given in the cook books, freezing books and
wrapping utensiles for better conservation of food.
In some models, on the freezer inner door there is usually an schematic
drawing showing the conservation time (in months) for the different types
of food. It will also depend on the food quality in the moment of freezing
and on the specific instructions on packages.
9
MAINTENANCE OF YOUR
REFRIGERATOR-FREEZER
Prior to undertaking any maintenance operation, be
sure to unplug the aplliance
Defrosting of the freezer
The inner walls of the freezer become gradually covered with a layer of frost
keeping in mind not to open the door frequently and keeping the food
wrapped up in closed bags.
Whenever the thickness of ice reaches 5 mm. the frost should be removed.
Here to proceed as follows:
 Remove all food staff and place it in the coolest possible place.
Remove de ice from the walls with a plastic scraper. Never use any sharp
metal tools, electric ovens or similar as these may cause serious damage
to the appliance.
 Once the ice is eliminated clean and dry the appliance
 Connect the appliance.
10
MAINTENANCE OF YOUR
REFRIGERATOR-FREEZER
Defrosting of the refrigerator
Frost is automatically eliminated in the refrigerator.
Clean regularly the water drain opening «G» (figure 1).
Cleaning
Do not use alcohol or any cleanig product containing alcohol because it
can damage the cabinet.
Use lukewarm water and neutral soap or bicarbonate of soda for cleaning
the interior and the exterior of the appliance. Never use detergents nor
abrasive powders.
Clean the black grill on the rear of the appliance (condenser), motor and
the upper and downer ventilation slots with a brush or vacuum cleaner.
This way the performance of the appliance will improve and energy
consumption reduced.
 Clean the water container above the motor.
Idle periods
During periods when the appliance is not in use take the following
precautions:
 Unplug the appliance.
 Remove all food.
 Defrost and clean the interior and all accesories.
Leave the door ajar to permit the air to circulate in the interior and thus
avoid unpleasant smells.
11
SOMETHING NOT WORKING
Some functioning
problems may be due
to causes which can easily be
solved before calling the
Network Service.
Follow these instructions.
PROBLEM CAUSE SOLUTION
A) SPYLAMP
1. Inner light refrigerator Plug not connected. Plug it.
compartment does No power in the wall Check the automatic
not lighten socket. domestic control.
( H Fig. 1) Bulb not fit in properly Fix or substitute it for
or fused. another one of same
features.
 The temperature Change to another
regulator is on 0 position.
position
B) PERFORMANCE
1. The appliance does The temperature Change to another
not cool. regulator is on position.
pos. «
0».
2. The appliance does Door not properly Close the door.
not cool enough. closed.
The door has been Avoid frequent opening.
opened frequently.
Temperature regulation Change position to a
inadequate pos. cooler one.
Food has been The appliance will get
introduced recently to normal, wait.
in great quantities.
3. Food gets frozen in Temperature regulator Change position to less
the refrigerator comp. on inadequate position. cold.
Food touches the back Keep more space.
walls.
12
SOMETHING NOT WORKING
PROBLEM CAUSE SOLUTION
4. The motor does not Temperature regulator Change position to
stop running. on inadequate position. less cold.
Door not properly closed. Close the door correctly.
Opened frequently. Avoid frequent opening.
Food has been loaded Wait for the appliance
recently. to normalize.
C) WATER / ICE
1. Makes too much ice. Temperature regulator Change position to
on inadequate position. less cold.
Door opened frequently. Avoid frequent opening.
2. Water in the lower Draining tube blocked. Clean tube «G» (fig. 1).
part of the refrigerator.
3. Water in the Wet vegetables have This is normal.
vegetable box. been introduced.
4. The outside of the High humidity level in This is normal. It does
cabinet gets humid. the room. not affect the
performance of the
appliance.
D)DOORS
1. Door does not close. The appliance is not Level properly.
properly levelled.
Door has been banged Never bang the door.
too hard.
Load is surpassing the Place food properly.
storage limit.
E) NOISES
Appliance not properly Level properly.
levelled.
One of the tubes is Separate the rubbing
rubbing against the wall tube.
or others.
Any fixing screw may be Fix the screw.
lose.
Anything placed inside Place it correctly.
may be vibrating.
Others. See next page.
13
NORMAL NOISES
WHEN FUNCTIONING
1. Temperature regulator
May cause cracking sounds when
the system connects or disconnects.
2. Refrigerating system
The injected cooling gas may
produce a burbling sound while
running through the tubes.
3. Compressor
May cause zumbing noises
and/or slight bumping.
4. Insulation
The material used has a tendency to
increase noises, but it does insulate
perfectly and is of low energy
consumption.
14
TECHNICAL FEATURES
This appliance complies with the following CEE Directives:
73/23 CEE of 19/02/73 (low voltage directive) and subsequent
modifications.
 89/336 CEE of 03/05/89 (electromagnetic compatibility directive) and
subsequent modifications.
Data in agreement with «UNE» requirements.
GROSS CAPACITY 393 l.
NET CAPACITY FRIDGE 297 l.
NET CAPACITY FREEZER 74 l.
FREEZING CAPACITY 4 Kg./24 h.
REFRIGERANT R 600 a. 0,065 Kg.
TEMPERATURE RISING TIME 25 h.
CLASS N, ST
SISTEM A K
220230 V ~ 50 Hz 140 W 0,8 A
DIMENSIONS WITH DIMENSIONS WITH
DOORS CLOSED DOORS OPEN
1 / 1

Zanussi ZF4A-SIL User manual

Category
Freezers
Type
User manual

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Ask the document