Magma CABO A10-703 Owner's manual

Brand: Magma

Model: CABO A10-703

Type: Owner's manual

Adventurer Series Gas Grill

Model A10-703

OWNER’S MANUAL

For questions regarding performance, assembly,

operation, parts, or returns, contact the experts

at MAGMA by calling (562) 627-0500

7:00 a.m. - 5:00 p.m. Pacific Time Monday thru

Friday or e-mail us at mail@MagmaProducts.com

IMPORTANT, read these instructions carefully before use. Familiarize yourself with the

appliance before connecting it to its gas container. Keep these instructions for future reference.

Cabo

™

Turbo Burner

Lid Lock

Oversized,

Balanced Lid

Grill Grates

“Stay Cool”

Handle

Radiant Plate

Outer Shell

Match Light

Hole

Mount

Support Pad

Valve Chamber

Slide Out

Grease Tray

Single mount through-bolt applications

4 Carriage bolts, washers & lock nuts.

Note: Place washers on carriage bolts as shown.

Control Valve

Regulator

Type 1 Low-

Output Shown

See Magma website for replacement part numbers and valve applications.

www.MagmaProducts.com

Folding Legs

MOUNT HARDWARE

Fasteners are supplied for Single Mount grill mounting options.

See Magma Catalog or Website for mount selection.

Carriage bolt,

washer & lock nut

OPERATING PROCEDURES

OPERATE ONLY ON “LOW” WHEN LID IS CLOSED.

ALWAYS OPERATE WITH GREASE TRAY IN PLACE.

WARNING: Do not overheat grill.

Magma Grills do not require pre-heating. Stainless

Steel loses anti-corrosive characteristics when subjected to extreme heat. Most

grilling is done on low temperature with the lid closed. If medium or high heat is

required, grill with lid open.

LIGHTING INSTRUCTIONS

s/PENLID

s0LACEFLAMEUPTOBURNERTHROUGHTHEMATCHLIGHTHOLE

s$EPRESSVALVEANDTURNCOUNTERCLOCKWISETOTHEh()'(v.

s6ISUALLYCONFIRMIGNITION

TO REDUCE FLARE-UP

s%MPTYANDCLEANGREASETRAYPRIORTOEACHUSE

s4RIMEXCESSFATSFROMMEAT

s5SENONOILBASEDMARINADES

s2EDUCEHEAT

s5SEWATERSPRAYDIRECTLYONFLAREUPS

NOTE:"EFORELIGHTINGLIDLOCKMUSTBEPOSITIONEDNOTTOENGAGE/PENLIDAND

TURNLOCKTOLOCKEDPOSITION

PRACTICAL HINTS:

Before lighting your grill, be sure that …

s

'RILLISSECUREANDPROPERLYMOUNTED

s

)NTERNALCOMPONENTSANDGREASETRAYARECLEANANDCORRECTLYPOSITIONED

s

9OUHAVEPLENTYOFGASINTHECANISTER

s

'ASCANISTERISATTACHEDPROPERLYANDTHEREARENOGASLEAKS

s

,IDLOCKHASBEENSETNOTTOENGAGE

s

9OUHAVEAWATERSPRAYBOTTLEHANDYTOCOOLAHOTGRILLORSTOPANYFLAREUPS

STOWING TIPS

s!LWAYSDISCONNECTTHEFUELCANISTERFROMTHEVALVEPRIORTOSTOWING

s3TOWTHEVALVEINACLEANDRYAREATOPROTECTFROMCORROSIONTOVALVE

s

!LWAYSSTOREPROPANEINASEALEDPROPANESTORAGELOCKERTHATALLOWSLEAKAGETO

vent overboard or use Magma Propane Storage/Locker Tote Bag.

.EVERSTOWBELOWDECKS

s)NSPECTBURNERREMOVEANYOBSTRUCTIONS

s#LEANASINDICATEDIN-AINTENANCEPAGE

s4OREASSEMBLEREVERSETHEPROCEDUREABOVE

RADIANT PLATE

1. Release locking

pin & lift up

2. Slide out

TURBO BURNER

3. Release locking pin

TURBO BURNER

4. Lift up

5. Slide out

1.4OREMOVERADIANTPLATEPULLLOCKING

PINTORELEASEANDLIFTPLATEUPFROM

LEFTSIDE

2.3LIDEPLATEASSEMBLYFROMRIGHTTOLEFT

3.4OREMOVEBURNERPULLLOCKINGPIN

4. ,IFTBURNER

5.3LIDEFROMRIGHTTOLEFTTOREMOVEFROM

GRILLBODY

#HECKBURNERFORGREASERESIDUEORSPIDER

WEBSTHATMAYOBSTRUCTGASFLOW

#!54)/.7(%.2%0,!#).'"52.%2#54

3,/43)."52.%2-534&!#%$/7.

DISASSEMBLY & RE-ASSEMBLY

Locking grease tray accessible from either side

1. Slide in

to lock

2. Slip Grease Tray lip

between brackets

2.3LIP'REASE4RAYLIPBETWEENBOTH

MOUNTBRACKETS

1.3LIDE'REASE4RAYINTOEITHERSIDEOF

THEMOUNTINGBRACKETTOLOCK

MAINTENANCE

Stainless steel contrary to popular belief can rust. Most commonly, deposits on surface of the product will trap moisture.

It is this moisture that robs stainless steel of oxygen. Oxygen is the element that reacts with stainless steel to form a

protective layer of chrome oxide. Robbed of oxygen, this reaction does not take place and “crevice corrosion” or “surface

rusting” occurs. To minimize this effect, thoroughly clean your grill with soap and water, rinse with fresh water, and dry.

Avoid using stainless steel polishes on grill exterior as most leave a residue that may discolor when grill is heated.

Additionally, stainless steel that is exposed to high heat will change color and texture over time. The “amber” color of

grill exterior and internal components is not a failure of the stainless steel and will not affect products operation. When this

happens, we recommend using “Magma Magic” Grill Restorer to remove the “amber” color and return grill to its

original luster. However, prolonged exposure to extreme high heat will cause chromium and nickel to “burn out” of stainless

steel. At this point stainless steel will become more susceptible to corrosion and will start to deteriorate. We recommended

replacement of internal components as they become seriously deteriorated.

We recommend thoroughly cleaning grill and internal components after each outing. Disassemble interior components

and remove all food residue. Use a “Scotch Brite” pad or similar product and “Easy-Off” oven cleaner for cleaning grills

interior components, followed by thoroughly washing with soap and water, rinse with fresh water & dry. Thoroughly rinse

the area between the interior heat shield and the front surface of the grill. AVOID CONTACT OF OVEN CLEANER WITH

SKIN, CONTROL VALVE, AND BOAT SURFACE. CAUTION: DO NOT USE ANY TYPE OF ABRASIVE PAD ON EXTERIOR MIRROR

FINISH AS IT WILL SCRATCH SURFACE, USE ONLY A SOFT CLOTH. We recommend covering grill between uses. Grill covers

are available at Magma retailers or directly from Magma. See our website, www.magmaproducts.com

Grill Grates - Clean with brass wire brush while grill is warm. Use Oven & Grill cleaner for burnt-on residue. Wash with

soapy water and dry prior to storage.

Control Valve - All valves are set and tested at our factory. Do not attempt to adjust or disassemble the valve in any way.

Call Magma if you suspect it is not adjusted properly. Clean valve with a cloth and remove any debris obstructing the

orifice.

Repair/Replacement Parts - All replacement parts are readily available at your Magma Retailers or directly from Magma.

For a complete list of replacement parts visit our website www.MagmaProducts.com.

USING GRILL WITH ON-BOARD LPG (PROPANE) SYSTEMS

Propane (LPG)

Gas Regulator

A10-225

Hose Kit

To other LPG

appliance

or use cap

Shut off

valve

Cylinder Valve

Gauge

Type 3

Valve

Solenoid

Gas Grill

Typical Marine &

R.V. Application

Align valve stem key

to valve chamber

lock detent and rotate

Gas Grill

Type 3

Valve

s-AGMAONBOARD,0'PROPANE

valves and hose kit allow Magma grills

to be installed to an existing on-board,

PREREGULATEDLOWPRESSURE,0'PROPANE

system.

s5SEONLYMagma Type 3 Low

Pressure LPG (Propane) Control

Valves. Visit our website at www.

MagmaProducts.com to view valve

application guide.

s.ORTH!MERICAUSEMagma A10-225

LPG Hose Kit in conjunction with Type

3 Valve. Outside North America see your

local dealer for proper hose and fittings.

s0RIMARYSHUTOFFVALVE(supplied with

A10-225 hose kit) must be used at

point of connection to allow shutoff of

gas supply leading to grill.

Install valve as shown in diagram above. Even

though valve may seem loose or not snug-fitting

it will function properly and is safe for use.

TROUBLE SHOOTING GUIDE

Problem

Burner will not

light with match

Flare-up

Yellow sooty flame

Blow-out

Hot Spots

Possible Cause

No gas flow

Obstructed gas flow

Excessive cooking temperature

Grease and/or residue build-up

Excessive fat in meats

Excessive oils in marinades

Obstructed gas flow

Flame too low

Wind directly on burner

Obstructed gas flow

Grill not level

Grease or residue build-up

Excessive fat in meats

Excessive oil in marinades

Possible Solution

Check fuel level, replace canister or

refill cylinder

Clean burner and valve orifice.

Remove debris/spider webs

Operate only on low when lid is closed

Reduce flame level

Leave lid open

Use water spray to cool

Clean components

Trim fat from cuts of meat before

grilling

Use non-oil based marinades

Clean burner and valve orifice.

Remove debris/spider webs

Increase flame

Block wind when opening lid

Clean burner and valve orifice.

Remove debris/spider webs

Level Grill

Clean components

Trim fat from cuts of meat before grilling

Use non-oil based marinades

USING GRILL WITH ON-BOARD CNG (NATURAL GAS) SYSTEMS

s-AGMAONBOARD#.'NATURALGASVALVESALLOW-AGMAGRILLSTOBEINSTALLEDTOANEXISTINGONBOARD

PREREGULATEDLOWPRESSURE#.'NATURALGASSYSTEM

s5SEONLY-AGMA4YPE,OW0RESSURE#.'NATURALGASCONTROLVALVES6ISITOUTWEBSITEATwww.

MagmaProducts.comTOVIEWVALVEAPPLICATIONGUIDE3EEYOURLOCALDEALERFORPROPERHOSEANDFITTINGS

LIMITED WARRANTY

83-703 0613

Magma Products, Inc.

3940 Pixie Avenue, Lakewood, CA 907A$"

-32*A*1&.01&.0&,1& 63)9(87(31

;;;&,1& 63)9(87(31

&2)8-*&,1&03,3&6*6*,.78*6*)86&)*1&6/73+&,1& 63)9(872(

&'3.7&86&)*1&6/3+&,1& 63)9(872(

&8*284*2).2,

! ! "#65 – %!– #-*'962.2,3+,&7(33/.2,+9*0,*2*6&8*7731*'=463)9(87;-.(-&6*on 8-*0.783+79'78&2(*7

;-.(- &6* known by 8-*"8&8* 3+ &0.+362.& 83 (&97* (&2(*6 36 6*463)9(8.:* -&61 &0.+362.& 0&;6*59.6*7 '97.2*77*7 83 ;&62 (97831*67 3+

438*28.&0 *<43796* 83 79(- 79'78&2(*7 #3 1.2.1.>* *<43796* 83 8-*7* 79'78&2(*7&0;&=7 34*6&8* 8-.7 92.8 &((36).2, 83 8-*97* and (&6*

1&29&0*2796.2,=39463:.)*,33):*28.0&8.32;-*2(33/.2,;.8-,&7

&,1& 63)9(872(,9&6&28**78-.7463)9(883'*+6**+631)*+*(87.21&8*6.&0736;36/1&27-.4838-*36.,.2&0(32791*6#-.7,9&6&28**.7+368-*

4*6.3)7-*6*.274*(.+.*);-*297*)92)*62361&0&2)6*&732&'0*(32).8.32732*0=*&6+6318-*)&8*3+36.,.2&0496(-&7*#-.7;&66&28=)3*7238.2(09)*8-*

(3783+4634*68=)&1&,*36&2=.2(32:*2.*2(*)9*838-*+&.096*3+8-*463)9(836)3*7.8(3:*6)&1&,*)9*831.797*&'97*&((.)*2836)&1&,*6*7908.2,

+63186&274368&8.323+8-*463)9(836)3*7.8.2(09)*)&1&,*6*7908.2,+6318-*(311*6(.&097*3+8-.7463)9(836)3*7.8i2(09)*3278&.20*7778**0

463)9(87"96+&(*!978?<(*77.:*36637.32)9*83*<43796*837&08;&8*636.7(3036&8.323636637.32(&97*)'=*<43796e 83*<(*77.:*-*&836+&.096*83

4634*60=(0*&2&2)(&6*+368-*78&.20*7778**0796+&(*7+8-*463)9(8+&.078334*6&8*)9*83&)*+*(8.21&8*6.&0736;36/1&27-.4)96.2,8-*;&66&28=4*6.3)

8-*)*+*(8.:*4&68;.00'*6*4&.6*)366*40&(*)&8&,1&?7348.32+=39;.7-833'8&.24*6+361&2(*92)*68-.70.1.8*);&66&28y,=397-390)(328&(8&,1&?7

97831*6"*6:.(**4&681*28:.&8*0*4-32*&836:.&*1&.0&81&.0&,1& 63)9(87(3136:.&$" 378&0"*6:.(*1&.0&8&,1& 63)9(87

2(88*28.3297831*6"*6:.(* .<.*:*&/*;33)#-*)*+*(8.:*4&68&032,;.8-4633+3+496(-&7*1978'*6*8962*)4378&,*46*4&.)83

&,1& 63)9(872(We79,,*788-&8=39/**4=396496(-&7*6*(*.48&7;*1&=6*59.6*6*&732&'0*4633+3+496(-&7*

28-*78&8*3+&0.+362.&320=.+6*+.2.7-.2,366*40&(*1*283+8-*463)9(8.7238(311*6(.&00=46&(8.(&'0*8-*6*8&.0*67*00.2,8-*463)9(836&,1&

63)9(872(;.006*+92)8-*496(-&7*46.(*4&.)+368-*463)9(80*778-*&13928).6*(80=&886.'98&'0*8397*'=8-*36.,.2&0(32791*646.36838-*).7(3:*6=3+

8-*232(32+361.8=2&)).8.32.28-*78&8*3+&0.+362.&320==391&=8&/*8-*463)9(8838-*6*8&.0*78&'0.7-1*28+631;-.(-.8;&7496(-&7*)3683&2=6*8&.0

*78&'0.7-1*287*00.2,8-.7463)9(8.236)*6833'8&.24*6+361&2(*92)*68-.7;&66&28=00.140.*);&66&28.*7.2(09).2,8-*.140.*);&66&28.*73+1*6(-&28&'.0.8=

&2)+.82*77+36&4&68.(90&6496437*&6*0.1.8*).2)96&8.32838-**<46*77;&66&28=4*6.3)774*(.+.*)-*6*.2+368-*4&687)*7(6.'*)-*6*.2"31*78&8*7)3238

&003;0.1.8&8.32732-3;032,&2.140.*);&66&28=0&787738-*&'3:*0.1.8&8.321&=238&440=83=39*.8-*6&,1&)*&0*67n368-*6*8&.0*78&'0.7-1*28

7*00.2,8-.7463)9(8-&7&2=&98-36.8=831&/*&2=;&66&28.*736834631.7*6*1*).*7.2&)).8.328336.2(327.78*28;.8-8-37*78&8*)&'3:*&,1&?71&<.191

0.&'.0.8=7-&00238*<(**)8-*496(-&7*46.(*3+8-*463)9(84&.)'=8-*36.,.2&0(32791*6"31*78&8*7)3238&003;8-**<(097.32360.1.8&8.323+.2(.)*28&036

(327*59*28.&0)&1&,*7738-*&'3:*0.1.8&8.3236*<(097.3271&=238&440=83=39#-*;&66&28=,.:*7=3974*(.+.(0*,&06.,-87&2)=391&=&073-&:*38-*6

6.,-87;-.(-:&6=+63178&8*8378&8*

x 4 x 4 x 4

Pack of (4) 1/4”-20 x 5/8” carriage bolts, washers

and lock nuts for single mount applications.

CONTENTS

• Orifice size for model A10-703NZ-3 is 0.84 mm.

• The nominal gas consumption for models A10-703NZ-3 burners is 10.6 MJ/H.

ADDENDUM FOR GAS GRILL MODEL

A10-703NZ-3

SOLD IN NEW ZEALAND

83-703NZ 0613

Over

Front

Back

CAUTION: Accessible parts may be very hot. Keep young children away. ONLY USE IN WELL-VENTILATED

AREAS. • CARBON MONOXIDE HAZARD-THIS APPLIANCE CAN PRODUCE CARBON MONOXIDE

WHICH HAS NO ODOUR. DO NOT USE IN ENCLOSED AREAS, (FOR EXAMPLE: CAR, TENT, CARAVAN,

MOBILE HOME) MAY CAUSE DEATH. This appliance shall only be used in an above ground, open air

situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are

rapidly dispersed by wind and natural convection.

Any enclosure in which the appliance is used shall comply with one of the following:

(A) An enclosure with walls on all sides, but with no overhead cover.

(B) Within a partial enclosure that includes an overhead cover and no more than two walls.

apply:

(1) At least 25% of the total wall area is completely open.

(2) 30% or more in total of the remaining wall side, backand front wall areas is open and unrestricted.

(3) In the case ob balconies, 20% or more of the total wall area shall remain open and unrestricted.

• Use appliance only in horizontal position. • This appliance must only be serviced by an authorized person.

• Do not use this appliance if it has damaged or worn seals. • Do not move this appliance during operation.

FUEL CONTAINERS: Change gas containers in well-ventilated areas, preferably outside, away from people &

sources of ignition; such as naked flames, pilot flames, electric heaters/equipment. Do not use appliance if it is

leaking, damaged, or not working properly. Check that burners are extinguished before removing gas

container. To check if gas cylinder is empty, remove regulator/valve and shake listening for liquid in cylinder; if

no liquid sounds are heard, cylinder is empty.

GAS LEAKS: NEVER CHECK FOR GAS LEAKS WITH A FLAME! Check for gas leaks by applying a soapy

solution to connections. If bubbles appear, turn off appliance and repair leaks as necessary.

HOW TO ISOLATE GAS SUPPLY IN THE EVENT OF A LEAK (smell of gas):

Cartridges: If there is a leak on your appliance (smell of gas) and you cannot stop the gas flow, remove the

appliance to a well ventilated location away from any ignition source.

Cylinders: If there is a leak on your appliance (smell of gas), immediately attempt to turn off cylinder valve.

Turn off appliance control valve. Remove appliance to a well-ventilated location away from any ignition source.

STORAGE: NEVER LEAVE GAS CYLINDERS CONNECTED WHEN NOT IN USE!

Cylinders: When you have finished using this appliance, turn gas cylinder off; wait for the flame to go out and

turn the appliance control valve off. Remove appliance control valve from appliance and store control valve in

a dry, non-corrosive environment. • Store fuel containers outdoors, in a well ventilated area, out of reach of

children, never below decks on boats. (Any indoor storage shall comply with Section 2 Minor storage and

usage of AS/NZS 1596).

HOSES: Use only AGA approved regulator and hose supplied by your distributor. DO NOT USE ADAPTORS.

(RECA #719 AGA 3735 Regulator) Connections must be spanner tight per AGA requirements. Make sure gas

hose is in good condition and avoid twisting or kinking.

PACKING MATERIALS: BEFORE INSTALLATION OR USE!

• Open package containing grill and components, remove all contents.

Package contents:

• Grill body

• Grill cooking grate

• Components package

• Remove grill from plastic bag.

• Open end cap that supports grill in box and remove small components package.

Component package contents:

• Control valve / regulator

• Mounting Fasteners

• Remove all components from paper bags.

• All necessary assembly instructions are detailed in the provided owner’s manual.

• These appliances shall only be used with ULPG cylinders certified to standard AS2030.

• It may be hazardous to attempt to fit other types of gas containers.

• Read complete instructions before operating

Align valve stem key

to valve chamber

lock detent and rotate

Gas Grill

Hose

supplied

by your

dealer

Magma CABO A10-703 Owner's manual

Magma CABO A10-703 Owner's manual

Magma CABO A10-703 Owner's manual

Related papers

Other documents