Bosch HUI54452UC Installation guide

Page is loading ...

3

Table of Contents

Installation instructions

Safety Definitions .......................................................... 4

IMPORTANT SAFETY INSTRUCTIONS ........................ 5

General notes ........................................................................ 5

Fire Safety .............................................................................. 5

Burn Prevention .................................................................... 6

Child Safety ........................................................................... 6

Cleaning Safety ..................................................................... 7

Safe use ................................................................................. 7

Proper Installation and Maintenance ................................ 7

Proposition 65Warning: ..................................................... 8

Causes for damages ..................................................... 9

Protecting the environment ........................................ 10

General Notes .............................................................. 10

Exhaust air mode .............................................................. 10

Ventilation line .................................................................... 10

Electrical connection ........................................................ 10

Before you begin ......................................................... 11

Tools and parts needed ................................................... 11

Parts included .................................................................... 11

Appliance dimensions ...................................................... 11

Safety clearances .............................................................. 11

Preparing the units ...................................................... 12

Installing the appliance ............................................... 13

Removing the appliance .................................................. 13

Installing the appliance with wall-unit holders ......... 14

Connecting the appliance ........................................... 16

Recirculating Kit (Optional) ........................................ 17

Installation through the soffit / cabinet .......................... 17

Charcoal Filter Replacement (optional) ........................ 17

Customer service ........................................................ 18

Pr odukt i nf o.

Additional information on products, accessories,

replacement parts and services can be found at

www.bosch-home.com and in the online shop

www.bosch-home.com/us/store

4

9 Safety Definitions

Safety Defi nitions

9 WARNING

This indicates that death or serious injuries may

occur as a result of non-observance of this warning.

9 CAUTION

This indicates that minor or moderate injuries may

occur as a result of non-observance of this warning.

NOTICE: This indicates that damage to the appliance or

property may occur as a result of non-compliance with

this advisory.

Note: This alerts you to important information and/or

tips.

5

9 IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE INSTRUCTIONS

IMPORTANT SAFET Y I NS T RUCT I ONS READ AND SAVE THESE INSTRUCTIONS

WARNING

When properly cared for, your new appliance has been

designed to be safe and reliable. Read all instructions

carefully before use. These precautions will reduce the

risk of burns, electric shock, fire, and injury to persons.

When using kitchen appliances, basic safety precautions

must be followed, including those in the following pages.

General notes

Examine the appliance after unpacking it. In the event of

transport damage, do not plug it in.

WARNING

TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR

INJURY TO PERSONS, OBSERVE THE FOLLOWING:

▯ Use this unit only in the manner intended by the

manufacturer. If you have questions, contact the

manufacturer.

▯ Before servicing or cleaning unit, switch power off at

service panel and lock the service disconnecting

means to prevent power from being switched on

accidentally.

When the service disconnecting means cannot be

locked, securely fasten a prominent warning device,

such as a tag, to the service panel.

WARNING

WARNING – TO REDUCE THE RISK OF FIRE, ELECTRIC

SHOCK, OR INJURY TO PERSONS, OBSERVE THE

FOLLOWING:

▯ Installation work and electrical wiring must be done by

qualified person(s) in accordance with all applicable

codes and standards, including fire-rated construction.

▯ Sufficient air is needed for proper combustion and

exhausting of gases through the flue (chimney) of fuel

burning equipment to prevent back drafting. Follow the

heating equipment manufacturer’s guideline and safety

standards such as those published by the National Fire

Protection Association (NFPA), and the American

Society for Heating, Refrigeration and Air Conditioning

Engineers (ASHRAE), and the local code authorities.

▯ When cutting or drilling into wall or ceiling, do not

damage electrical wiring and other hidden utilities.

▯ Ducted fans must always be vented to the outdoors.

This appliance is not intended for operation with an

external clock timer or a remote control.

Have an appropriate fire extinguisher available, nearby,

highly visible and easily accessible near the appliance.

Fire Safety

WARNING

To reduce risk of fire and to properly exhaust air, be sure

to duct air outside. Do not vent exhaust air into spaces

within walls, ceilings, attics, crawl spaces or garages.

WARNING

To reduce the risk of fire, use only metal ductwork.

Always have a working smoke detector near the kitchen.

WARNING

TO REDUCE THE RISK OF A RANGE TOP GREASE

FIRE:

a.

Never leave surface units unattended at high settings.

Boilovers cause smoking and greasy spillovers that

may ignite. Heat oils slowly on low or medium settings.

b.

Always turn hood ON when cooking at high heat.

c.

Clean ventilating fans frequently. Grease should not be

allowed to accumulate on fan or filter.

d.

Use proper pan size. Always use cookware

appropriate for the size of the surface element.

Do not flambé under the extractor hood or work with a

naked flame. When switched on, the extractor hood

draws flames into the filter. There is a risk of fire due to

deposits on the grease filter!

CAUTION

For general ventilating use only. Do not use to exhaust

hazardous or explosive materials and vapors.

Do not operate any fan with a damaged cord or plug.

Discard fan or contact an authorized service facility for

examination and/or repair.

Do not run cord under carpeting. Do not cover cord with

throw rugs, runners, or similar coverings. Do not route

cord under furniture or appliances. Arrange cord away

from traffic area and where it will not be tripped over.

In the event that personal clothing or hair catches fire,

drop and roll immediately to extinguish flames.

Smother flames from food fires other than grease fires

with baking soda. Never use water on cooking fires.

9 IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE INSTRUCTIONS

6

WARNING

TO REDUCE THE RISK OF INJURY TO PERSONS IN

THE EVENT OF A RANGE TOP GREASE FIRE,

OBSERVE THE FOLLOWING:

▯ SMOTHER FLAMES with a close-fitting lid, cookie

sheet, or metal tray, then turn off the burner. BE

CAREFUL TO PREVENT BURNS. If the flames do not

go out immediately, EVACUATE AND CALL THE FIRE

DEPARTMENT.

▯ NEVER PICK UP A FLAMING PAN – You may be

burned.

▯ DO NOT USE WATER, including wet dishcloths or

towels – a violent steam explosion will result.

▯ Use an extinguisher ONLY if:

- You know you have a Class ABC extinguisher, and

you already know how to operate it.

- The fire is small and contained in the area where it

started.

- The fire department is being called.

- You can fight the fire with your back to an exit.

Whenever possible, do not operate the ventilation system

during a cooktop fire. However, do not reach through fire

to turn it off.

WARNING

RISK OF FIRE

When gas burners are in operation without any cookware

placed on them, they can build up a lot of heat. A

ventilation appliance installed above the cooker may

become damaged or catch fire. Only operate the gas

burners with cookware on them.

WARNING

RISK OF FIRE

During simultaneous use of multiple gas burners, a great

deal of heat is created. A ventilation device located

above it can become damaged or catch fire. Never use

two gas burners together at maximum heat for longer

than 15 minutes. One large burner with over

17,000BTU/hr (5kW) (wok) is equal to the wattage of

two gas burners.

WARNING

RISK OF FIRE

Hot oil and fat catch fire fast. Never leave hot oil and fat

unsupervised. Never extinguish a fire with water. Switch

off the cooking position. Suffocate flames carefully with a

lid, a fire blanket or similar.

WARNING

RISK OF FIRE

Grease deposits in the grease filter can ignite.

Clean the grease filter at least every two months.

Never operate the appliance without the grease filter.

WARNING

RISK OF FIRE

Grease deposits in the grease filter can catch fire. Never

work with a naked flame near the appliance (e.g.

flambéing). Install the unit near a heat-producing

appliance for solid fuels (e.g. wood or coal) only if there

is a closed, non-detachable cover. There must be no

flying sparks.

Burn Prevention

WARNING

RISK OF BURNS

The accessible parts get hot during operation. Never

touch hot parts. Keep children away.

Child Safety

When children become old enough to use the appliance,

it is the responsibility of the parents or legal guardians to

ensure that they are instructed in safe practices by

qualified persons.

Remove all tape and packaging before using the

appliance. Destroy the packaging after unpacking the

appliance. Never allow children to play with packaging

material.

Do not allow anyone to climb, stand, lean, sit, or hang on

any part of an appliance, especially a door, warming

drawer, or storage drawer. This can damage the

appliance, and the unit may tip over, potentially causing

severe injury.

Do not allow children to use this appliance unless closely

supervised by an adult. Children and pets should not be

left alone or unattended in the area where the appliance

is in use. They should never be allowed to play in its

vicinity, whether or not the appliance is in use.

CAUTION

Items of interest to children should not be stored in an

appliance, in cabinets above an appliance or on the

backsplash. Children climbing on an appliance to reach

items could be seriously injured.

7

9 IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE INSTRUCTIONS

Cleaning Safety

WARNING

Be sure the entire appliance (including the grease filters

and light bulbs, if applicable) has cooled and grease has

solified before attempting to clean any part of the

appliance.

Do not use steam cleaners to clean the appliance.

Safe use

WARNING

Do not repair, replace or remove any part of the

appliance unless specifically recommended in the

manuals. Improper installation, service or maintenance

can cause injury or property damage. Refer to this

manual for guidance. All other servicing should be done

by an authorized servicer.

WARNING

RISK OF INJURY

Items placed on the appliance may fall down. Do not

place any objects on the appliance.

Proper Installation and Maintenance

Have the installer show you the location of the circuit

breaker or fuse. Mark it for easy reference.

This appliance must be properly installed and grounded

by a qualified technician. Connect only to properly

grounded outlet. Refer to Installation Instructions for

details.

This appliance is intended for normal family household

use only. It is not approved for outdoor use. See the

Statement of Limited Product Warranty. If you have any

questions, contact the manufacturer.

Do not store or use corrosive chemicals, vapors,

flammables or nonfood products in or near this

appliance. It is specifically designed for use when

heating or cooking food. The use of corrosive chemicals

in heating or cleaning will damage the appliance and

could result in injury.

Do not operate this appliance if it is not working properly,

or if it has been damaged. Contact an authorized

servicer.

Do not repair or replace any part of the appliance unless

specifically recommended in this manual. Refer all

servicing to a factory authorized service center.

CAUTION

Grease left on filters can remelt and move into the vent.

CAUTION

Turn power off at breaker before removing a damaged

bulb. Do not touch the bulbs immediately after use. The

bulbs will remain hot for several minutes.

WARNING

Make sure the appliance and lights are cool and power

to the appliance has been turned off before replacing the

light bulb(s). Failure to do so could result in electrical

shock or burns.The lenses (if equipped) must be in place

when using the appliance.The lenses (if equipped) serve

to protect the light bulb from breaking.The lenses (if

equipped) are made of glass. Handle carefully to avoid

breaking. Broken glass can cause an injury.

WARNING

When the hood is operated in exhaust-air mode

simultaneously with a different burner which also makes

use of the same chimney (such as gas, oil or coal-fired

heaters, continuous-flow heaters, hot-water boilers) care

must be taken to ensure that there is an adequate supply

of fresh air which will be needed by the burner for

combustion.

Safe operation is possible provided that the under

pressure in the room where the burner is installed does

not exceed 4 Pa (0.04mbar).

This can be achieved if combustion air can flow through

non-lockable openings, e.g. in doors, windows and via

the air-intake/exhaust-air wall box or by other technical

measures, such as reciprocal interlocking, etc.

WARNING

Avoid carbon monoxide poisoning – Provide adequate

air intake so combustion gases are not drawn back into

the room.

An air-intake/exhaust-air wall box by itself is no

guarantee that the limiting value will not be exceeded.

Note: When assessing the overall requirement, the

combined ventilation system for the entire household

must be taken into consideration. This rule does not

apply to the use of cooking appliances, such as

cooktops and ovens.

Hidden surfaces may have sharp edges.

Use caution when reaching behind or

under appliance.

9 IMPORTANT SAFETY INSTRUCTIONS

READ AND SAVE THESE INSTRUCTIONS

8

Proposition 65Warning:

This product may contain a chemical known to the State

of California, which can cause cancer or reproductive

harm. Therefore, the packaging of your product may

bear the following label as required by California:



&DQFHUDQG5HSURGXFWLYH+DUPZZZ3:DUQLQJVFDJRY

67$7(2)&$/,)251,$352326,7,21:$51,1*

:$51,1*

9

Causes for damages

9 CAUTION

Risk of damage due to corrosion. Always turn

appliance on when cooking to avoid condensation

buildup. Condensation can lead to corrosion

damage.

9 CAUTION

Always replace blown bulbs immediately to avoid an

overload of the remaining bulbs.

9 CAUTION

Risk of damage due to ingress of humidity into the

electronic circuitry. Never clean operator controls

with a wet cloth.

9 CAUTION

Surface damage due to incorrect cleaning. Clean

stainless steel surfaces in the grind direction only.

Do not use any stainless steel cleaners for operator

controls.

9 CAUTION

Surface damage due to strong or abrasive cleaning

agents. Never use strong and abrasive cleaning

agents.

9 CAUTION

Risk of damage from condensation back flow. Install

exhaust vent at a slight downward slope away from

the appliance (1° slope).

10

Protecting the environment

Unpack the appliance and dispose of the packaging in

an environmentally friendly manner.

General Notes

Exhaust air mode

Note: Ventilation may not exit through an already

operational smoke or exhaust chimney, nor a duct used

for ventilating furnace installation areas.

▯ If the ventilation is intended to pass through a smoke

or exhaust chimney that is not in operation, the

responsible area heating inspector must give

approval.

▯ If the ventilation passes through an external wall, use a

telescopic wall sleeve.

Ventilation line

Note: The appliance manufacturer is not responsible for

and does not warant for complaints attributable to the

pipe section.

▯ The appliance achieves its optimum performance by

means of a short, straight exhaust air pipe and as

large a pipe diameter as possible.

▯ As a result of long rough exhaust air pipes, many pipe

bends or pipe diameters that are smaller than 6”

(150 mm), the optimum extraction performance is not

achieved and fan noise is increased.

▯ The pipes or hoses for laying the exhaust air line must

consist of non-combustible material.

Round pipes

An inner diameter of 6” (150 mm), but at least 4 _”

(120 mm), is recommended.

Flat ducts

The inner cross-section must correspond to the diameter

of the round pipes.

dia. 6” (150 mm) approx. 27^ sq in (177 cm

2

)

dia. 4 _” (120 mm) approx. 26_ sq in (113 cm

2

)

▯ Flat ducts should have no sharp deflections.

▯ Use sealing strip for deviating pipe diameters.

Electrical connection

9 WARNING

RISK OF ELECTRIC SHOCK

Parts inside the appliance can have sharp edges.

The connection cable can be damaged. Do not

bend or pinch connection cables during installation.

Check your domestic installation before installing the

appliance. Pay attention to suitable fusing of your

domestic installation. The voltage and frequency of the

appliance must agree with the electrical installation (see

rating plate).

The appliance complies with protective class I and may

only be operated with a PE conductor connection.

The installation must contain a disconnector with a

contact opening of at least X” (3mm) that isolates all

poles from the mains. It must still be accessible after

installation.

Only an electrical specialist may lay or replace the

connecting lead, paying attention to the applicable

regulations.

If the mains connecting lead of this appliance is

damaged, it must be replaced with a special connecting

lead, which is obtainable from the manufacturer or the

manufacturer's after-sales service.

11

Before you begin

Tools and parts needed

▯ Measuring tape

▯ Pencil

▯ Phillips screwdriver (Posidrive) #2

▯ Drill with the following bits:

3

/

16

" (5mm)

▯ Spirit level

▯ Aluminum tape (DO NOT use insulating tape)

▯ Exhaust air duct (configuration depends on the

installation situation)

▯ Additional sheet metal screws (if necessary for

installation of the exhaust air duct)

▯ Jigsaw

Parts included

Appliance dimensions

Safety clearances

The clearance between the shelf on the cooktop and the

bottom of the extractor hood may not be less than 24"

(610 mm) in the case of electric cooktops and 29

1

/

2

"

(750 mm) in case of gas or combined ranges.

If the installation instructions for the gas cooking

appliance specify a larger distance, this must be taken

into account.

PP[PP

[

[

PP[PP

[

[ [

èç¼ʀɿ

PP

ë

PP

èç¼ɾʃ

PP

ɻ¼ɾʃ

PP

èç¼ɾʃ

PP



PP

PP

ê



12

Preparing the units

Fitted units must be heat-resistant up to 194° F (90 °C).

The stability of the fitted unit must also be assured after

the cut-out work.

Make the cut-out according to the installation sketch.

After the cutting out work is complete, remove the

shavings.

Notes

▯ Be aware of the clearance between the partition floor

and the lower edge of the fitted unit; see drawing.

▯ Use the included template to make the holes and the

cut-outs.

1.

Attach the template to the lower side of the partition

floor. Drill holes.

2.

Make cut-out for the exhaust air pipe:

Exhaust air opening above the fitted unit:

Exhaust air opening behind the fitted unit:

èç¼ʀɿ

PP

[



çɾʃ

PP













13

Installing the appliance

1.

Screw appliance tightly to the fitted unit.

2.

Pull out the filter pull-out until it is flush with the front

edge of the fitted unit.

3.

Take metal mesh grease filter out. Push stop forward

until it lies against the filter pull-out. Screw stop tight in

this position.

Removing the appliance

1.

Disconnect the appliance from the power supply.

2.

Loosen the exhaust air lines.

3.

Loosen the screw connections with the unit.

4.

Remove the appliance.

[

PP[PP

[

PP[PP

14

Installing the appliance with wall-unit holders

1.

Screw the cabinet brackets tightly into the cabinet.

2.

Open the lock and fold down the metal grease filter.

While doing this, place your other hand under the

metal grease filter.

Take the metal mesh grease filter out of the holder.

3.

Screw the appliance brackets tightly onto the

appliance.

 [

[











[[

15

4.

Insert the appliance into the cabinet.

5.

Align the appliance.

16

6.

Screw the appliance into place.

Connecting the appliance

Notes

▯ With ducted operation, a back-pressure flap should be

installed. If no back-pressure flap is included with the

appliance, it can be ordered from a specialist retailer.

▯ If the exhaust air is conveyed through the outer wall, a

telescopic wall box should be used.

Connecting the air extractor

Note: If an aluminum pipe is used, smooth the

connection area beforehand.

1.

Attach the exhaust air pipe directly to the air pipe

connector.

2.

Connect it to the air extractor opening.

3.

Seal the joints appropriately.

Connecting the power supply

1.

Plug the mains plug into the grounded socket.

2.

If a fixed connection is required, please follow the

instructions in the Electrical Connection section.

[[

17

Recirculating Kit (Optional)

When used in recirculation mode, to reduce the risk of

Fire and Shock, use only conversion kit Model

HVREC5UC.

If it is not possible to vent cooking fumes and vapors to

the outside, the hood can be used in the non-vented

(recirculating) mode, using the recirculating kit. Fumes

and vapors are recycled through the round grid.

Installation through the soffit / cabinet

1.

Depending on your recirculating installation, take into

consideration the next diagram:

▯ A. Ceiling

▯ B. Recirculating grid

▯ C. Soffit

▯ D. 6” (15.2cm) vent

▯ E. Range hood

▯ F. Cabinet

▯ G. Wall

▯ H. 14” (35.5cm) min. cabinet height

▯ I. Top of the cabinetry

2.

Measure and mark the centerline of the cabinet to the

soffit above.

3.

Measure from the bottom of the cabinet to the

centerline of the where the vent will come through the

soffit. Mark the location and use a saber saw or

keyhole saw to cut a 5¾" (14.6 cm) hole for the

recirculating grid.

4.

Install the recirculating grid with the 2provided

screws.

▯ A. Recirculating grid

▯ B. Centerline

Charcoal Filter Replacement (optional)

Notes

▯ The charcoal filter cannot be cleaned. It must be

replaced every 4-6months (depending on hood

usage).

▯ Do not rinse, or put charcoal filter in an automatic

dishwasher.

Charcoal filter installation

(

$

%

*

'

)

+

$

%

*

)

&

'

(

,

$

%

18

Customer service

Our customer service department is there for you if your

appliance requires repair.

When calling, please give the Product Number (P-No.)

and the Serial Number (S-No.) to help facilitate your

repair. The identification plate listing the numbers can be

found inside of the appliance (remove metal grease filter

to find it).

So that you don't have to search for these numbers when

you need them, you can enter your appliance information

and the customer service number here.

Please note that a service visit to instruct the customer

on the proper use of the appliance is not covered by the

warranty. Please see the Statement of Limited Warranty.

Please find the contact data of all countries in the

enclosed customer service list.

To book a service visit and product advice

P-No. S-No.

Customer service

O

US 8009442904

toll-free

Page is loading ...

1901 Main Street, Suite 600 • Irvine, CA 92614 • 800-944-2904

990507

*9001416436*

9001416436

Bosch HUI54452UC Installation guide

This manual is also suitable for

Bosch HUI54452UC Installation guide

in other languages

Related papers

Other documents