Wen 61620 User guide

OPERATOR’S MANUAL

6-Gallon Horizontal Tank

Air Compressor

Item #2276

IMPORTANT:

YournewWEN

®

tooland/orequipmenthasbeenengineeredandmanufacturedtohighstandards

fordependability,easeofoperation,andoperatorsafety.Properlycaredfor,itwillgiveyouyears

ofrugged,trouble-freeperformance.

PaycloseattentiontotheRulesforSafeOperationandWarnings.Ifyouuseyourtooland/or

equipmentproperlyandonlyforwhatitisintended,youwillenjoyyearsofsafe,reliableservice.

09/10

It's not how, it's WEN the project get's done!

 WenProducts.com

800-232-1195M–F 8–5 (CST)

[email protected]

AIR COMPRESSOR IDENTIFICATION

Forinformationandquestionspleasecontactcustomerserviceat1-800-232-1195.Pleasell

outtheinformationbelowandhaveitaccessiblepriortocalling.FortheSerialNumberrefertothe

specicationsstickeronyourAirCompressor.

DATE OF PURCHASE: _____________________________________________________________

PURCHASED FROM: _____________________________________________________________

ITEM #: _____________________________________________________________

SERIAL NUMBER: _____________________________________________________________

#2276OPERATOR’SMANUAL 3

TABLE OF CONTENTS

Specications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

ImportantSafetyInstructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

GeneralSafetyInstructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4–6

AirCompressorSafetyInformation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6–7

ElectricalInstructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .  7–9

Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

AssemblyInstructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11–12

Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12–14

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14–15

Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Service..............................................16

ExplodedView . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

PartsList.............................................18

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

6–Gallon Horizontal Tank Air Compressor

Item#:   2276

Motor:   120V,60Hz,13Amps

PressureRange: 85–125psi

AirFlow:   4.2CFM@40psi

   3.2CFM@90psi

AirOutletSize:  1/4"NPT

TankCapacity:  6-Gallons

Weight:   50lbs.

SPECIFICATIONS

#2276OPERATOR’SMANUAL 4

GENERAL SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS

1. Thepurposeofsafetysymbolsistoattractyourattentiontopossibledangers.Thesafetysymbols,

andtheexplanationswiththem,deserveyourcarefulattentionandunderstanding.Thesafety

warningsdonotbythemselveseliminateanydanger.Theinstructionsorwarningstheygivearenot

substitutesforproperaccidentpreventionmeasures.

WARNING:Thisisthesafetyalertsymbol.Itisusedtoalertyoutopotentialpersonal

injuryhazards.Obeyallsafetymessagesthatfollowthissymboltoavoidpossibleinjuryor

death.

Note: Advisesyouofinformationorinstructionsvitaltotheoperationormaintenanceoftheequipment.

2. Servicingrequiresextremecareandknowledgeandshouldbeperformedonlybyaqualiedser-

vicetechnician.Forservicewesuggestyoureturnthetool/equipmenttoWENPRODUCTSfor

repair.Whenservicing,useonlyidenticalWENreplacementparts.

3. READ ALL INSTRUCTIONS BEFORE USING YOUR AIR COMPRESSOR

4. Failuretofollowallinstructionslistedbelowmayresultinelectricalshock,reand/orseriousper-

sonalinjury.

WARNING: Donotattempttooperatethistool/equipmentuntilyouhavereadthoroughly

andunderstandcompletelyallinstructions,safetyrules,containedinthismanual.Failure

tocomplycanresultinaccidentsinvolvingre,electricshock,orseriouspersonalinjury.

Savethisoperator’smanualandreviewfrequentlyforcontinuingsafeoperationandin-

structingotherswhomayusethistool/equipment.

5. Safeoperationofthistool/equipmentrequiresthatyoureadandunderstandthisOperator’sManual

andalllabelsafxedtothetool/equipment.Safetyisacombinationofcommonsense,stayingalert

andknowinghowyourtool/equipmentworks.

WARNING: Readallsafetywarningsandinstructions.Failuretofollowthewarningsand

instructionsmayresultinelectricshock,reand/orseriousinjury.

SAVE ALL WARNINGS AND INSTRUCTIONS FOR FUTURE REFERENCE.

#2276OPERATOR’SMANUAL 5

Work Area Safety

1. Keepworkareacleanandwelllit.Clutteredordarkareasinviteaccidents.

2. DonotoperateyourAirCompressorinexplosiveatmospheres,suchasinthepresenceofam-

mableliquids,gasesordust.AirCompressormotorsproducesparkswhichmayignitethedustor

fumes.

3. KeepchildrenandbystandersawayfromanoperatingAirCompressor.

Electrical Safety

1. AirCompressorplugsmustmatchtheoutlet.Nevermodifythepluginanyway.Donotuseany

adapterplugswithgroundedAirCompressors.Standardplugsandmatchingoutletswillreduce

theriskofelectricshock.

2. DonotexposeyourAirCompressortorainorwetconditions.WaterenteringyourAirCompres-

sorwillincreasetheriskofelectricshock.

3. Donotabusethecord.NeverusethecordforunpluggingyourAirCompressor.Keepthecord

awayfromheat,oil,sharpedgesormovingparts.Damagedorentangledcordsincreasetherisk

ofelectricshock.

Personal Safety

1. Stayalert,watchwhatyouaredoingandusecommonsensewhenoperatingyourAirCompres-

sor.DonotuseyourAirCompressorwhileyouaretiredorundertheinuenceofdrugs,alcohol

ormedication.AmomentofinattentivenesswhileoperatingyourAirCompressormayresultin

seriouspersonalinjury.

2. Useprotectivesafetyequipment.AlwayswearANSI-approvedeyeprotectionduringsetupand

use.

3. Preventunintentionalstarting.EnsuretheswitchisintheOFFpositionbeforeconnectingto

powersourceormovingyourAirCompressor.

Air Compressor Use and Care

1. DonotuseyourAirCompressoriftheswitchdoesnotturnONandOFF.AnAirCompressorthat

cannotbecontrolledwiththeswitchisdangerousandmustberepaired.

2. Disconnecttheplugfromthepowersourcebeforemakinganyadjustments,changingaccessories,

orstoringyourAirCompressor.ThispreventivesafetymeasurereducetheriskofstartingyourAir

Compressoraccidentally.

#2276OPERATOR’SMANUAL 6

3. StoreyourAirCompressoroutofthereachofchildrenanddonotallowpeopleunfamiliarwithyour

AirCompressorortheseinstructionstooperateit.AnAirCompressorisdangerousinthehandsof

untrainedusers.

4. MaintainyourAirCompressor.KeepyourAirCompressorcleanformaximumperformance.Fol-

lowtheinstructionsforlubricatingandchangingaccessories.KeepyourAirCompressordry,clean

andfreefromoilandgrease.Checkformisalignmentorbindingofmovingparts,breakageofparts

andanyotherconditionthatmayaffectyourAirCompressor'soperation.Ifdamaged,haveyourAir

Compressorrepairedprofessionallybeforeuse.Manyaccidentsarecausedbyapoorlymaintained

AirCompressor.

5. UseyourAirCompressorinaccordancewiththeseinstructions,takingintoaccounttheworking

conditionsandtheworktobeperformed.UseofyourAirCompressorforoperationsdifferentfrom

thoseintendedcouldresultinahazardoussituation.

Service

HaveyourAirCompressorservicedbyaqualiedprofessionalrepairpersonusingonlyidentical

replacementparts.ThiswillensurethatthesafetyofyourAirCompressorismaintained.

1. RISKOFFIREOREXPLOSION–Donotsprayammableliquidinaconnedareaortowardsa

hotsurface.Thesprayareamustbewell-ventilated.Donotsmokewhilesprayingorspraywhere

sparkorameispresent.

2. ARCINGPARTS–KeepyourAirCompressoratleast20feetawayfromexplosivevapors,suchas

whensprayingwithaspraygun.

3. RISKOFBURSTING–Donotadjustregulatorhigherthanmarkedmaximumpressureofattached

pneumatictool/equipment.

4. RISKOFINJURY–Donotdirectairstreamatpeopleoranimals.

5. Donotusetosupplybreathingair.

6. DonotleaveyourAirCompressorunattendedforanextendedperiodwhilepluggedin.Unplug

compressorafteruse.

7. KeepyourAirCompressorwell-ventilatedanddonotcoverduringuse.

8. Draintankdailyorafteruse.Internalrustcausestankfailureandexplosion.

9. YourAirCompressor'scylinderheadandairlinesgethotduringoperation.Donottouchorallow

childrennearbyduringorimmediatelyfollowingoperation.

10.DonotusetheairhosetomoveyourAirCompressor.

AIR COMPRESSOR SAFETY INFORMATION

#2276OPERATOR’SMANUAL 7

11.Releasethepressureinthestoragetankbeforemoving.

12.Theuseofaccessoriesorattachmentsnotrecommendedbythemanufacturermayresultinbodily

injury.

13.Allairlinecomponents,includinghoses,pipe,connectors,andltersmustberatedforaminimum

workingpressureof150%ofthemaximumsystempressure.

14.IndustrialapplicationsmustfollowOSHAguidelines.

15.Thisproductisnotatoy.Keepitoutofreachfromchildren.

16.Peoplewithpacemakersshouldconsulttheirphysician(s)beforeuse.Electromagneticeldsin

closeproximitytoheartpacemakercouldcausepacemakerinterferenceorpacemakerfailure.

WARNING:Thebrasscomponentsofthisproductcontainlead,achemicalknowntothe

StateofCaliforniatocausebirthdefects(orotherreproductiveharm).(CaliforniaHealth&

Safetycode25249.5,etseq.)

17.Thewarnings,precautions,andinstructionsdiscussedinthisOperator'sManualcannotcoverall

thepossibleconditionsandsituationsthatmayoccur.Itmustbeunderstoodbytheoperatorthat

commonsenseandcautionarefactorswhichcannotbebuiltintothisproduct,butmustbesupplied

bytheoperator.

Grounding Instructions

1. INTHEEVENTOFAMALFUNCTIONORBREAKDOWN,groundingprovidesthepathofleast

resistanceforelectriccurrentandreducestheriskofelectricshock.Thistoolisequippedwithan

electriccordthathasanequipmentgroundingconductorandagroundingplug.TheplugMUSTbe

pluggedintoamatchingoutletthatisproperlyinstalledandgroundedinaccordancewithALLlocal

codesandordinances.

2. DONOTMODIFYTHEPLUGPROVIDED.Ifitwillnotttheoutlet,havetheproperoutletinstalled

byanelectrician.

3. IMPROPERCONNECTIONoftheequipmentgroundingconductorcanresultinelectricshock.The

conductorwiththegreeninsulation(withorwithoutyellowstripes)istheequipmentgroundingcon-

ductor.Ifrepairorreplacementoftheelectriccordorplugisnecessary,DONOTconnecttheequip-

mentgroundingconductortoaliveterminal.CHECKwithalicensedelectricianorservicepersonnel

ifyoudonotcompletelyunderstandthegroundinginstructions,orifyouarenotsureifthetoolis

properlygrounded.

ELECTRICAL INSTRUCTIONS

#2276OPERATOR’SMANUAL 8

4. USEONLYTHREEWIREEXTENSIONCORDSthathave3-prongplugsand3-prongoutletsthat

acceptthetool’splug.Repairorreplacedamagedorworncordsimmediately.

5. CAUTION:Inallcases,makecertaintheoutletisproperlygrounded.Ifyouarenotsureifitis,have

alicensedelectricianchecktheoutlet.

WARNING:Thistoolisforindooruseonly.Donotexposetorainoruseindamplocations.

1. Toolswiththreewiregroundingplugs(Fig.1,A)areintendedforuseonacircuitthathasanoutlet

thatlooksliketheoneillustrated(Fig.1,B).

2. Atemporaryadapter(Fig.1,B&C)maybeusedtoconnectthisplugtoa2-polereceptacle(Fig.1,

B)ifaproperlygroundedoutletisnotavailable.

3. Thetemporaryadaptershouldbeusedonlyuntilaproperlygroundedoutletcanbeinstalledbya

qualiedelectrician.

4. Thegreencoloredrigidear,lug,etc.extendingfromtheadaptermustbeconnectedtoapermanent

groundsuchasaproperlygroundedoutletbox(Fig.1,D).



Fig.1

#2276OPERATOR’SMANUAL 9

Extension Cord Guidelines

Makesureyourextensioncordisingoodcondition.Whenusinganextensioncord,besuretouseone

heavyenoughtocarrythecurrentyourproductwilldraw.Anundersizedcordwillcauseadropinline

voltageresultinginlossofpowerandoverheating.Thetablebelowshowsthecorrectsizetobeused

accordingtocordlengthandnameplateampererating.Ifindoubt,usethenextheaviergauge.The

smallerthegaugenumber,theheavierthecord.

1. Besureyourextensioncordisproperlywiredandingoodcondition.Alwaysreplaceadamaged

extensioncordorhaveitrepairedbyaqualiedpersonbeforeusingit.

2. Protectyourextensioncordsfromsharpobjects,excessiveheatanddamporwetareas.

3. Useaseparateelectricalcircuitforyourtools.Thiscircuitmustnotbelessthana#12wireand

shouldbeprotectedwitha20Amptimedelayedfuse.

4. Beforeconnectingthemotortothepowerline,makesuretheswitchisintheOFFpositionandthe

electriccurrentisratedthesameasthecurrentstampedonthemotornameplate.Runningata

lowervoltagewilldamagethemotor.

WARNING: Thistoolmustbegroundedwhileinusetoprotecttheoperatorfromelectrical

shock.

Minimum gauge for Extension Cords (AWG)

(When using 120V only)

AmpereRating TotalLengthofCordinfeet

MoreThan

NotMore

Than

25 50 100 150

0 6 18 16 16 14

6 10 18 16 14 12

10 12 16 16 14 12

12 16 14 12 NotRecommended

#2276OPERATOR’SMANUAL 10

COMPONENTS

1–AirRegulatorGauge 6–ON/OFFSwitch

2–DrainValve 7–AirFilter

3–TankPressureGauge 8–HeatDispensationFins

4–Regulator 9–AirFlowValve

5–CarryingHandle

Fig.2

9

#2276OPERATOR’SMANUAL 11

Unpacking

1. Whenunpacking,makesurethatthemachineisintactandundamaged.

2. PleasecheckthatthefollowingitemsareincludedwithyourAirCompressor.

 –OilBottle –AirFilter –WheelKit

 –RubberFeet –OilBreatherCap

3. Ifanypartsaremissingorbroken,pleasecallour

customerservicesat1-800-232-1195.

4. YourAirCompressorrequiresminimumassembly.

Removethepartsfromthecarton.Includedaretwo

wheels,arubberfootwithboltandnut,andanair

lter.

Wheel Installation (Fig. 3 & 4)

Insertaxleboltthroughthewheel.Placethelarge

washerontheaxelboltandinserttheboltthrough

thewheelportonthetank.Securethewheelwitha

lockwasherandnut(Fig.3).Theninstalltherubber

foot(Fig.4).

Air Filter Installation (Fig. 5)

ThisAirCompressorisshippedwithaplasticplugintheair

lterhole.Beforeoperatingthisunit,removetheplugand

connecttheairlter(Fig5).

ASSEMBLY INSTRUCTIONS



Fig.3

Fig.4

Fig.5

#2276OPERATOR’SMANUAL 12

Fig.7

Proper

OilLevel

Minimum

OilLevel

Fig.6

Add Oil and Install Oil Breather Cap (Fig. 6 & 7)

1. YourAirCompressorshipswithoutoilintheCrankcase.

Note: BEFORESTARTINGYOUAIRCOMPRESSORYOU

MUSTADDOILTOTHECRANKCASEASDESCRIBED

BELOW.

2. PlaceyourAirCompressoronlevelground.

3. RemovetheOilShippingPlugfromtheOilFillHole

locatedonthetopoftheCrankcasecoverattherear

oftheAirCompressor(Fig.6).

4. SlowlypourtheoilintotheOilFillHoleuntiltheoil

levelrisestothecenterofthereddotontheOil

SightGlass(Fig.7).

5. InstalltheOilBreatherCapintotheOilFillHole.

BEFORE OPERATING YOUR NEW AIR COMPRESSOR completethefollowingsteps.

1. Checkthatallnutsandboltsaresecure.

2. MakesuretheoilhasbeenproperlyaddedtoyourAirCompressor.

3. PlaceyourAirCompressoronarm,levelsurfaceinaclean,dry,wellventilatedarea.

4. YourAirCompressorshouldbelocated12to18inchesfromwallsoranyotherobstructionwhich

wouldinterferewithairow.YourAirCompressorshouldbelocatedinatemperaturecontrolledarea

between32°and95°F.

5. YourAirCompressorisdesignedwithheatdissipationnswhichallowforpropercooling.Keep

thensandallotherpartscleanfromdustordirt.AcleanAirCompressorrunscoolerandprovides

longerservice.

6. Donotplacerags,containersorothermaterialontopofyourAirCompressor.

OilBreather

Cap

OPERATION

#2276OPERATOR’SMANUAL 13

Power Source Connection

YourAirCompressorisdesignedtooperateonaproperlygrounded120volt,60HZ,singlephase,

alternatingcurrent(AC)powersourcewithafused20Amptimedelayedfuseorcircuitbreaker.Itis

recommendedthataqualiedelectricianverifytheACTUALVOLTAGEatthereceptacleintowhich

theunitwillbepluggedandconrmthatthereceptacleisproperlyfusedandgrounded.Theuseofthe

propercircuitsizecaneliminatenuisancecircuitbreakertrippingwhileoperatingyourAirCompressor.

Forelectricaldetailsseepages7–9.

Initial Start-Up Procedures

1. OpentheAirTankDrainValvetopermitairtoescape,preventingairpressurebuildupintheAir

Tank.

2. Runthecompressorforaminimumof20minutesinthis“no-load”positiontolubricatethepiston.

3. CloseAirTankDrainValve.Yourcompressorisreadyforuse.

4. SeepneumatictoolinstructionsforinstructionsonhowtoconnectatooltoyourAirCompressor.

DependingontheCFMdrawofthetoolsbeingoperated,yournewAirCompressorcanbeusedforop-

eratingpaintsprayers,airtools,greaseguns,airbrushes,caulkingguns,abrasiveblasters,tire&plastic

toyination,sprayingweedkillerandinsecticides,etc.ProperadjustmentoftheAirPressureRegulator

isnecessaryforalloftheseoperations.Refertotheairpressurespecicationsprovidedwiththetool

youareusing.

General Overview

1. Tocompressair,thepistonmovesupanddowninthecylinder.Onthedownstrokeairisdrawn

inthroughthevalveinlet.Thedischargevalveremainsclosed.Ontheupstrokeofthepistonairis

compressed.

2. Theinletvalveclosesandairisforcedoutthroughthedischargevalve,throughtheCheckValve,

andintotheAirTank.

3. WorkingairisnotavailableuntiltheAirCompressorhasraisedthetankpressureabovethatre-

quiredattheairserviceconnection.

4. Theairinletlteropeningsmustbekeptclearofobstructions,whichcouldreduceairdeliveryofthe

compressor.

Air Pressure Adjustment

1. YourAirCompressorissuppliedwithanAirPressureRegulator.ThisRegulatoradjuststheairpres-

sure.

2. Toincreaseairpressure,turntheAirRegulatorclockwise.

#2276OPERATOR’SMANUAL 14

3. Todecreaseairpressure,turntheAirRegulatorcounterclockwise.

4. TheAirRegulatorgaugewillshowthecurrentpressureselected.

Daily (or before each use)

1. Checkoillevel.

2. Checkforanyunusualnoiseorvibration.

3. Besureallnutsandboltsaretight.

Weekly

1. CleanbreatherholeonOilBreatherCap.

2. DrainwaterfromtheAirTankthroughtheDrainValve.

3. KeepAirFiltercleanatalltimes.DonotoperatetheAirCompressorwiththeairlterremoved.

4. AdirtyAirFilterwillnotallowyourAirCompressortooperateatfullcapacity.Beforeyouuseyour

AirCompressor,checktheAirFiltertobesureitisclean.Ifitisdirtyreplacethelterelement.

Monthly

Inspecttheairsystemforleaksbyapplyingsoapywatertoalljoints.Tightenthesejointsifleaksare

discovered.

6 Months (or after 250 hours of operation - whichever comes rst)

ChangeAirCompressorOil.

Note: ChangetheoilmoreoftenifyourAirCompressorisusednearpaintsprayingoperationsor

industyenvironments.

Checking the Air Compressor Oil

1. PlaceyourAirCompressoronalevelsurface.TheoillevelshouldbeatthereddotontheOilSight

Glass.

2. Ifoillevelislow,removeOilBreatherCapandaddenoughoiltobringtheoilleveltothereddoton

theOilSightGlass.

MAINTENANCE

#2276OPERATOR’SMANUAL 15

Changing the Air Compressor Oil

Note: ThiscompressorusesonlySAE5W-30motoroil.

1. RemovetheOilSightGlassbyturningcounterclockwisewithwrench.

Note: OilwillbegintodrainastheOilSightGlassisloosened.Makesureafunnelandoilpanare

inplaceBEFORElooseningtheOilSightGlass.

2. OncetheOilSightGlassisremoved,tiltyourAirCompressorforwardstoallowalltheoilto

drainoutoftheCrankcase.

3. Oncetheoilisdrained,replacetheOilSightGlassandsecurelytighteninplacewithawrench.

BecarefulnottoovertightentheOilSightGlass,asthiscoulddamagetherubberseal.

4. PlaceyourAirCompressoronlevelsurface.

5. RemovetheOilBreatherCap.

6. Slowlypourtheoilintotheoilllhole,untiltheoillevelrisestothecenterofthereddotonthe

OilSightGlass.

7. InstalltheOilBreatherCapintotheoilllhole.

8. AlwaysinspectAirCompressorbeforeuse,andmakesureitisingoodworkingcondition.Use

compressedairtocleanthemachinewherepossible.

9. Checkthepowercabletomakesureitisintactandfreefromcracks,barewiresetc.

10.Avoidusingsolventswhencleaningplasticparts,mostplasticsaresusceptibletodamagefrom

thevarioustypesofcommercialsolvents.

#2276OPERATOR’SMANUAL 16

Problem Cause Solution

AirCompressor

willnotstart

ThermalOverload Allowtocoolandpushtheresetbutton

locatedintheCrankcaseclosetotheAir

Filter.

Blownfuseorcircuitbreakertripped. Replaceorresetfuse/circuitbreaker.

Looseelectricalconnections Checkwiringconnections

Lowpressure

RestrictedAirFilter ReplaceAirFilter

DefectiveCheckValve ReplaceCheckValve

AirleakinSafetyValve Checkvalvebypullingonring.Ifcondition

persists,replacevalve

Safetyvalve

releasing

DefectivePressureSwitch Replacepressureswitch

Oildischargein

AirCompressor

ToomuchoilinCrankcase DrainCrankcaseandrelltoproperlevelon

OilSightGlass

Compressoroverheated Reduceairpressureregulation.

RestrictedOilBreatherCap CleanorreplaceOilBreatherCap.

If trouble persists please call our customer service

1-800-232-1195, M–F 8–5 (CST)

1. Mechanicaland/orelectricaltoolserviceistobeperformedonlybyprofessionalqualiedrepair

personnel.Serviceperformedbyunqualiedpersonnelmayresultinariskofinjury.

2. Whenservicingatool,useonlyidenticalreplacementparts.Useofunauthorizedpartsorfailureto

followmaintenanceinstructionsmaycreateariskofelectricalshockorinjury.

NOTE: Ifanypartsaredamagedormissing,donotattempttopluginthepowercordandturnthe

switchonuntilthedamagedormissingpartsareobtainedandareinstalledcorrectly.

TROUBLESHOOTING

SERVICE

#2276OPERATOR’SMANUAL 17

EXPLODED VIEW

#2276OPERATOR’SMANUAL 18

PARTS LIST

Part # Stock # Description Part # Stock # Description

1 2274-001 Crankcase

37 2274-037 Fan

2 2274-002 CrankShaft

38 2274-038 MotorBackCover

3 2274-003 Gasket

39 2274-039 Stator

4 2274-004 CrankcaseCover

40 2274-040 Bearing

5 2274-005 Bolt

41 2274-041 Rotor

6 2274-006 O-ring

42 2274-042 Bearing

7 2274-007 OilSightGlass

43 2274-043 OilSealing

8 2274-008 Bolt

44 2276-044 AirTank

9 2274-009 Washer

45 2276-045 Nut

10 2274-010 OilBreatherCap

46 2276-046 Washer

11 2274-011 Bolt

47 2276-047 Wheel

12 2274-012 ConnectingRod

48 2276-048 Washer

13 2274-013 CircleClip

49 2276-049 Bolt

14 2274-014 PistonPin

50 2274-050 DrainValve

15 2274-015 Piston

51 2276-051 Bolt

16 2274-016 PistonOilRing

52 2276-052 Washer

17 2274-017 PistonRing

53 2276-053 RubberFoot

18 2274-018 Gasket

54 2276-054 Washer

19 2274-019 Cylinder

55 2276-055 Bolt

20 2274-020 Washer

56 2276-056 HandleGrip

21 2274-021 Bolt

57 2274-049 SafetyValve

22 2274-022 ValveGasket

58 2276-058 PressureSwitch

23 2274-023 Valve

59 2274-064 TankPressureGauge

24 2274-024 ValvePlate

60 2276-060 Connector

25 2274-025 Gasket

61 2274-062 Regulator

26 2274-026 HeadGasket

62 2276-062 AirFlowValve

27 2274-027 ElbowConnector

63 2274-061 AirRegulatorGauge

28 2274-028 CylinderHead

64 2276-064 UnloadingNut

29 2274-029 Washer

65 2276-065 UploadingPipe

30 2274-030 Bolt

66 2276-066 Exhaust

31 2274-031 AirFilter

67 2274-057 CheckValve

32 2274-032 Capacitor

68 2276-068 ExhaustNut

33 2274-033 Washer

69 2276-069 ExhaustPipe

34 2274-034 Bolt

70 2276-070 PowerCord

35 2274-035 MotorCover

71 2276-071 WireCable

36 2274-036 Bolt

72 2274-069 OverloadReset

#2276OPERATOR’SMANUAL 19

WEN

iscommittedtobuildingtoolsthataredependableforyears.Ourwarrantiesareconsistentwith

ourcommitmentanddedicationtoquality.

ONE(1)YEARLIMITEDWARRANTYOFWENPRODUCTSFORHOMEUSE.

GREATLAKESTECHNOLOGIES,LLC(“Seller")warrantstotheoriginalpurchaseronly,thatallWEN

consumerpowertoolswillbefreefromdefectsinmaterialorworkmanshipforaperiodofone(1)year

fromdateofpurchase.Ninety(90)daysforallWENProducts,ifthetoolisusedforprofessionalor

commercialuse.

SELLER’SSOLEOBLIGATIONANDYOUREXCLUSIVEREMEDYunderthisOne(1)YearLimited

Warrantyand,totheextentpermittedbylaw,anywarrantyorconditionimpliedbylaw,shallbethere-

pairorreplacementofparts,withoutcharge,whicharedefectiveinmaterialorworkmanshipandwhich

havenotbeenmisused,carelesslyhandled,ormisrepairedbypersonsotherthanSellerorAuthorized

ServiceCenter.TomakeaclaimunderthisLimitedWarranty,youmustreturntheentirepowertool

product;transportationprepaid,toGreatLakesTechnologies,LLC,501DavisRoad,Elgin,IL60123.

Includealegiblecopyoftheoriginalreceipt,whichliststhedateofpurchase(monthandyear)andthe

nameofthecompanypurchasedfrom.

THISLIMITEDWARRANTYDOESNOTAPPLYTOANYACCESSORYITEMSINCLUDEDWITHTHE

TOOLSUCHASCIRCULARSAWBLADES,DRILLBITS,ROUTERBITS,JIGSAWBLADES,SAND-

INGBELTS,GRINDINGWHEELSANDOTHERRELATEDITEMSORTOANYREPLACEMENT

PARTSLISTEDUNDERMAINTENANCE.

ANYIMPLIEDWARRANTIESSHALLBELIMITEDINDURATIONTOONE(1)YEARFROMDATEOF

PURCHASE.SOMESTATESINTHEU.S.ANDSOMECANADIANPROVINCESDONOTALLOW

LIMITATIONSONHOWLONGANIMPLIEDWARRANTYLASTS,SOTHEABOVELIMITATIONMAY

NOTAPPLYTOYOU.

INNOEVENTSHALLSELLERBELIABLEFORANYINCIDENTALORCONSEQUENTIALDAMAG-

ES(INCLUDINGBUTNOTLIMITEDTOLIABILITYFORLOSSOFPROFITS)ARISINGFROMTHE

SALEORUSEOFTHISPRODUCT.SOMESTATESINTHEU.S.ANDSOMECANADIANPROV-

INCESDONOTALLOWTHEEXCLUSIONORLIMITATIONOFINCIDENTALORCONSEQUENTIAL

DAMAGES,SOTHEABOVELIMITATIONOREXCLUSIONMAYNOTAPPLYTOYOU.

THISLIMITEDWARRANTYGIVESYOUSPECIFICLEGALRIGHTS,ANDYOUMAYALSOHAVE

OTHERRIGHTSWHICHVARYFROMSTATETOSTATEINTHEU.S.,PROVINCETOPROVINCE

INCANADAANDFROMCOUNTRYTOCOUNTRY.

THISLIMITEDWARRANTYAPPLIESONLYTOPORTABLEELECTRICTOOLS,BENCHPOWER

TOOLS,OUTDOORPOWEREQUIPMENTANDPNEUMATICTOOLSSOLDWITHINTHEUNITED

STATESOFAMERICA,CANADAANDTHECOMMONWEALTHOFPUERTORICO.FORWARRAN-

TYCOVERAGEWITHINOTHERCOUNTRIES,CONTACTWENCUSTOMERSUPPORT.

ONE (1) YEAR LIMITED WARRANTY

Wen 61620, 2276 User guide

Related papers

Other documents