Page is loading ...
*Honda OHV engine
*Cast-iron cylinder sleeve
*Low oil sensor
*Receptacles on control panel
*6 gallon plastic fuel tank
*Spark arrester
*Portability Kit
A.120 V, 20 Ampere Duplex Receptacle
This duplex is split so that 20 amps of current may be
drawn from each half of the receptacle. However, total power
drawn must be kept within nameplate ratings. These
receptacles may be used along with the twistlock receptacle
provided the generator is not overloaded.
B.120/240 V, 30 Ampere Twistlock Receptacle
A maximum of 30 amps may be drawn from the 120/240
volt receptacle, provided it is the only receptacle used.
However, current must be limited to the nameplate rating. If the
120/240 volt receptacle is used along with the 120 volt
receptacle, the total load drawn must not exceed the nameplate
ratings.
C.Circuit Breakers
The receptacles are protected by an AC circuit breaker. If
the generator is overloaded or an external short circuit occurs,
the circuit breaker will trip. If this occurs, disconnect all
electrical loads and try to determine the cause of the problem
before attempting to use the generator again. If overloading
causes the circuit breaker to trip, reduce the load. NOTE:
Continuous tripping of the circuit breaker may cause
damage to generator or equipment. The circuit breaker may
be reset by pushing the button of the breaker.
D.Engine On/Off Switch
TOOLS REQUIRED: 7/16”, 1/2” and 9/16" sockets and
ratchets, block(s) of wood (minimum of 6” tall).
Refer to the parts list and drawing on pages 8 and 9.
WHEEL INSTALLATION
1.Block up end of generator opposite the fuel tank cap to
install wheel kit.
2.Insert wheel spacer (item 50) into the center of the wheel
(item 31).
3.Slide 3/8 x 4.25” bolt (item 35) and 3/8 washer (item 51)
through the wheel (item 31), then through the wheel
bracket on the carrier, with the offset side of the wheel hub
against the wheel bracket.
4.Thread 3/8 nyloc nut (item 36) onto the bolt and tighten to
securely clamp the wheel assembly to the carrier.
5.Repeat above instructions for the remaining wheel.
FOOT INSTALLATION
1.Assemble the rubber feet (item 32) to the foot bracket (item
49) using a 1/4-20 x 1.5” bolt (item 48). Thread a 1/4
washer (item 39) and a 1/4 nyloc nut (item 13) to the bolt to
secure the assembly. Caution: Do not over tighten so
that the foot material collapses.
2.Blocking up the alternator side of the generator, place the
foot bracket under the carrier channel. Thread a 5/16-18 x
1” bolt (item 47) with a 5/16 washer (item 34) through the
mounting holes and thread a 5/16 washer (item 34) and a
5/16 nyloc nut (item 16) to the bolt to secure the foot
bracket to the carrier.
LOCKING HANDLE
1.Attach the lanyards (item 33) to the release pins (item 37)
and carrier as shown in the illustration.
2. To lock the handle (item 28) in the extended position, align
the holes in the handle brackets with the holes in the carrier
brackets and insert the release pins (item 37).
3.Insert caps (item 38) into ends of handle (item 28).
2
English
CONTROL PANEL
MAJOR GENERATOR FEATURES
PORTABILITY KIT INSTALLATION
1
2
This product is warranted by Coleman Powermate, Inc. to
the original retail consumer against defects in material and
workmanship for a period of two (2) years from the date of retail
purchase and is not transferable. This two year warranty
applies only to products used in consumer applications. If this
generator is used in a commercial application, then the period
of warranty coverage is limited to one (1) year from the date of
purchase.
Please complete and return the enclosed Customer
Information Card so that we can reach you in the unlikely event
a safety recall is needed. Return of this card is not required to
validate this warranty.
WHAT IS COVERED: Replacement parts and labor.
WHAT IS NOT COVERED: Transportation charges to
Coleman Powermate, Inc. for defective products.
Transportation charges to consumer for repaired products.
Brushes, fuses, rubber feet, and receptacles. Damages
caused by abuse, accident, improper repair, or failure to
perform normal maintenance. Power units or engines which
are covered exclusively by the warranties of their manufacturer.
Sales outside of the United States or Canada. Any other
expense including consequential damages, incidental
damages, or incidental expenses, including damage to
property. Some states do not allow the exclusion or limitation
of incidental or consequential damages, so the above limitation
or exclusion may not apply to you.
IMPLIEDWARRANTIES: Any implied warranties, including
the Implied Warranties of Merchantability and Fitness For A
Particular Purpose, are limited in duration to one (1) year from
the date of retail purchase. Some states do not allow
limitations on how long an implied warranty lasts, so the above
limitation may not apply to you.
HOW TO OBTAIN WARRANTY PERFORMANCE:
Replacement parts and service are available from Coleman
Powermate, Inc. Service Centers. Locate your nearest Service
Center by calling TOLL FREE 1-800-445-1805. In the unlikely
event a Service Center can not be located you may call
Coleman Powermate, Inc. for a return authorization number.
Any unit returned WITHOUT an authorization number will
be refused.
To the extent any provision of this warranty is prohibited by
federal, state, or municipal law, and cannot be preempted, it
shall not be applicable. This warranty gives you specific rights,
and you may also have other rights which vary from state to
state.
3
English
LIMITED WARRANTY
(NOT VALID IN MEXICO)
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
9
REF.PARTDESCRIPTION DESCRIPTION DESCRIPCIÓNQTY
NO.NO.
10062639Carrier, assemblyEnsemble transportTransportador, conjunto1
2Note AEngine Honda OHVMoteurMotor1
30051094IsolatorSectionneurAislador4
40050236.01Adapter, engineAdaptateur pour moteurAdaptador, motor1
50000919.01Bolt whz 3/8-16 x .75BoulonPerno4
60062494Stator 5.5 KW 60 HZ StatorEstator1
6A0056716Connector, statorJeu pr logemt prise, statorConjunto de conectores stator1
6B0062196Connector hsg set panelJeu pr logemt prise,Conjunto de conectores panel 1
70058130Rotor 5.5 KW RotorRotor1
80049004Bolt, hex 5/16-24 x 7.25BoulonPerno1
9Note BWasher, lock 5/16Contre-écrou 5/16Arandela, de cierre 5/163
100062470Endbell Wired Couvre-enroulement, câblage completCaja posterior con cable
tableau1
10A0050439Brush, E-4RBalais, E-4REscobilla, E-4R2
10B0062455Assembly, bridge rectifierEnsemble de planche de redresseur Conjunto de la tabla del rectificador del puente
boardde pont1
10C0062466Connector plugPrise de connecteurTapón del conector1
10D0062264Brush CoverCouvre-balaisCubierta de escobillas1
110056076Bolt, hex hd 1/4-20 x 6.50BoulonPerno4
120008854Lug, groundOeillet de mise à la terreTerminal, tierra1
130040832Nut, nyloc 1/4-20Écrous nyloc 1/4-20 Tuerca, nyloc 1/4-20 7
14Note BBolt, 5/16-18 x 1 1/2BoulonPerno2
15Note BWasher, flat 5/16Rondelles plates 5/16Arandela, plana 5/165
160048736Nut, nyloc 5/16-18Écrous nyloc 5/16-18Tuerca, nyloc 5/16-189
170049224Assembly, ground wireEns. fil de masse tressé a tierraConjunto, cable trenzado 1
18Note BWasher, star external 5/16Rondelles à dents externa 5/16Arandela, estrella 2
19Note BBolt, hex 5/16-18 x 3/4Boulon, tête hex 5/16-18 x 3/4Perno1
20
0057664MufflerSilencieuxSilenciador1
210061392GasketJointEmpaquetadura1
220062311Panel, wiredTableau compl. câbléPanel, cabeado completo1
22A0049072Circuit Breaker 25 ampDisjoncteurs 25 ampCortacircuitos 25 amp2
230062462Screw #6-20 x .38 Type BVisTornillo4
240062307
Shield, heatÉcran de chaleurPantalla para el calor1
25Note CFuel tank assemblyAssemb. complet du réservoirConjunto tanque1
25A0055340Fuel CapCapuchonTapa de combustible1
25B0049114Fuel shut off with filterRobinet de carburantVálvula combustible con filtro1
25C0051102Fuel filterFiltre à carburantFiltro combustible1
26
0058618Screw, #10 x 1VisTornillo4
270062537Bracket, handle lockSupportSoporte2
280062316HandlePoignéeManija1
29Note BBolt, 5/16-18 x 1 3/4BoulonPerno2
300062159Cap, rubberCapuchonTapa1
310057704WheelRoueRueda2
320055894Rubber FootPiedPie2
330062174LanyardLanyardAcollador2
340049352Washer, flat 5/16 WRondelles plates 5/16 largeArandela, plana 5/16 lejos4
35Note BBolt, 3/8-16 x 4.25BoulonPerno2
360057578Nut, nyloc 3/8-16Écrous nyloc 3/8-16Tuerca, nyloc 3/8-162
370059392Pin, releaseEpingle de relâchementAlfileres de la liberación2
380058955Cap, plasticCapuchonTapa2
39Note BWasher, flat 1/4Rondelles plates 1/4Arandela, plana 1/47
400056039Bracket, statorSectionneur statorConjunto de soporte1
410049279Bolt, whz 5/16-18 x 1/2BoulonPerno3
420000901.01Bolt, whz 5/16-24 x 5/8BoulonPerno2
430061393Nut whz 8mmÉcrousTuerca2
440050298Switch, RockerInterrupteurInterruptor1
450052931J ClampCollierPinza vinílica1
46Note BBolt, 1/4-20 x 1 1/4BoulonPerno1
47Note BBolt, 5/16-18 x 1BoulonPerno2
48Note BBolt, 1/4-20 x 1 1/2BoulonPerno2
490062301Bracket, footSupport de piedSoporte del pie1
500062433Wheel spacerBague d’espacement Espaciador de la rueda2
51Note BWasher, flat 3/8Rondelles plates 3/8Arandela, plana 3/82
PARTS LIST / LISTE DES PIÈCES / LISTA DE PIEZAS
10
Note A:
Coleman Powermate, Inc. will not provide engines as replacement parts. Engines are covered through the engine manufacturer's warranty. Consult the accompanying
engine manual or contact our service department for assistance.
Note B:
These are standard parts available at your local hardware store.
Note C:
Contact your nearest Coleman® Powermate® Service Center for replacement fuel tanks.
WARNING: To avoid possible personal injury or equipment damage, a registered electrician or an authorized service representative should
perform installation and all service. Under no circumstances should an unqualified person attempt to wire into a utility circuit.
Electrical: For models approved for the City of Los Angeles, the ampacity of the phase conductors from the generator terminals to the first over current device shall not
be less than 115 percent of the nameplate rating of the generator.
Remarque A:
Coleman Powermate, Inc. ne fournit pas de moteurs dans ses pièces détachées. Les moteurs sont couverts par la garantie du fabricant de moteurs. Consulter le
manuel du moteur inclus ou contacter notre département de service après-vente pour toute assistance.
Remarque B:
Ces pièces sont des pièces standard disponibles en quincaillerie.
Remarque C:
Pour commander un réservoir de rechange, contacter Centre de service Coleman® Powermate® le plus proche.
AVERTISSEMENT: Pour éviter toute blessure personnelle ou dommage à l’équipement, l’installation et tout entretien devralent être effectués par un
électricien qualifié ou un préposé au service autorisé. En aucun cas, une personne non-qualifiée ne devrait essayer de faire le raccord au circuit principal.
Électricité: Pour les modèles a approuvé pour la ville de Los Angeles: La charge limite en ampères des fils de phase allant des bornes du groupe électrogène au
premier appareil en surcharge ne doit pas être inférieure à 115% de la puissance nominale indiquée sur la plaque des caractéristiques du groupe électrogène.
Nota A:
Coleman Powermate, Inc. no proporcionará los motores como repuestos. Los motores están cubiertos por medio de la garantía del fabricante del motor. Consulte el
manual adjunto del motor o comuníquese con nuestro departamento de servicio para recibir ayuda al respecto.
Nota B:
Estas son piezas estándar disponibles en su ferretería local.
Nota C:
Para hacer pedidos de tanques, localice el Centro de Servicio de Coleman® Powermate® más cercano.
ADVERTENCIA: Para evitar posibles lesiones físcas o daños materiales, es necesario que la instalación y todo el servicio sea realizado por un electricista
matriculado o representatnte de servicio autorizado. Bajo ninguna circunstancia debe permitirse que una persona que no está capacitad trate de
manipular cables dentro del circuito de servicio eléctrico.
Eléctricos:
El amperaje de los conductores de fase desde los terminales del generador al primer dispositivo de sobrecorriente no podrâ ser menor que 115 porciento del valor
nominal que aparece en la placa de identificación del generador en los modelos aprobados para la ciudad de Los Angeles.
Page is loading ...
4970 Airport Road
P. O. Box 6001
Kearney, NE 68848
1-800-445-1805
1-308-237-2181
Fax 1-308-234-4187
© 2004 Coleman Powermate, Inc. All rights reserved.
are registered trademarks of The Coleman Company, Inc. used under license.
Powermate ® is a registered trademark of Coleman Powermate, Inc.
© 2004 Coleman Powermate, Inc. Tous droits réservés.
sont des marques déposées de The Coleman Company, Inc. utilisées sous licence.
Powermate® est une marque déposée de Coleman Powermate, Inc.
© 2004 Coleman Powermate, Inc. Reservados todos los derechos.
son marcas comerciales registradas de The Coleman Company, Inc. utilizadas bajo licencia.
Powermate ® es una marca comercial registrada de Coleman Powermate, Inc.
Coleman® and
Coleman® et
Coleman® y
/
