GAS GAS K2 QUAD 110 4 Stroke User manual

MANUAL DEL USUARIO

USER MANUAL

MANUEL D’ENTRETIEN

LIBRETTO D´USO

BETRIEBSANLEITUNG

4 STROKE

110

SERVICE MANUAL

110

ENGLISH

4 STROKE

FOREWORD

Thanks for purchasing QUAD 110 - 4 STROKE. This manual ¡ncludes important safety information. It provides

information about special techniques and skills necessary to ride this vehicle. It also includes the details to

opérate and necessary maintenance procedure to perform safely.

IMPORTANT SAFETY MESSAGE:

–PAY ATTENTION TO THE CAUTION AND WARNING LABELS ON THIS QUAD.

–READ THIS MANUAL BEFORE OPERATING THIS QUAD. MAKE SURE YOU UNDERSTAND ALL INS-

TRUCTION. ALSO KEEP ALL INFORMATION IN MIND WHILE OPERATING THIS QUAD.

– ANYONE UNDER AGE 16 SHOULD NEVER BE ALLOWED TO OPÉRATE QUAD 110 - 4 STROKE.

–KEEP THIS MANUAL IN THE WATERPROOF PLACTIC BAG AND STORED IN THE COMPART-

MENT PROVIDED BY YOU QUAD.

–FAILURE TO FOLLOW THE WARNINGS CONTAINED IN THIS MANUAL CAN RESULT IN SERIOUS INJURY

OR DEATH.

–NEVER CARRY A PASSENGER ON THIS QUAD.

-1-

IMPORTANT NOTICE TO PARENTS AND ADULTS:

–THIS QUAD IS NOT A TOY.

–YOU SHOULD UNDERSTAND THE INSTRUCTIONS AND WARNINGS IN THIS MANUAL BEFORE YOU

LET YOUR CHILD RIDE THIS QUAD. THEN BE SURE YOUR CHILD UNDERSTANDS AND WILL FOLLOW

THEM.

–THIS QUAD SHOULD ONLY BE OPERATED UNDER THE DIRECT SUPERVISIÓN OF AN ADULT.

–NEVER EXCEED YOUR RIDING CAPABILITIES.

–

THIS QUAD CAN BE HAZARDOUS TO OPÉRATE, AVOID EXCESSIVE SPEED, ON PAVED SURFACES,

SHARP TURNS, AND UNEVEN TERRAIN.

–ADULTS SHOULD ADJUST THE THROTTLE FOR SLOWER SPEEDS.

–NEVER RIDE THIS QUAD DURING LOW LIGHT CONDITIONS.

–CHILDREN DIFFER IN SKILLS. SOME CHILDREN MAY NOT BE ABLE TO OPÉRATE AN QUAD SAFETY.

PARENTS SHOULD PERMIT CONTINUED USE ONLY IF THEY DETERMINE THAT THE CHILD HAS THE

ABILITY TO OPÉRATE THE QUAD SAFETY.

–IF YOUR CHILD ISINEXPERIENCED IN RIDING QUAD, HE OR SHE SHOULD TAKE A TRAINING COURSE

BEFORE OPERATING THIS QUAD.

-2-

-3-

Whenever you see the symbols shown below, heed their instructions. Always follow safe

operating and maintenance practices.

WARNING

HAZARD

Failure to heed WARNINGS...

WHATCANHAPPEN

WARNINGS ¡dentify special instructions or proce-

dures which, if not correctly followed, could result

in serious injury or death.

HOW TO AVOID THE HAZARD

Read all WARNINGS in this manual carefully and

for your safety be sure to follow their instruc-

tion.

CAUTION

This caution symbol identifies special instruc-

tion Or procedures which, if not strictly observed,

could. Result in damage to or destruction of

equipment.

NOTE

This note symbol indicates points of particu-

lar interest for more efficient and convenient

operation.

FAILURE TO FOLLOW THE WARNINGS CONTAINED IN THIS MANUAL CAN RESULT IN

SERIOUS INJURY OR DEATH.

-4-

IMPORTANT NOTICE

Off-road vehicle riding is a wonderful sport, and we hope you will enjoy it to the fullest.

This vehicle is designed and manufactured for off-road use only. It is illegal and unsafe to operate this vehicle

on any public road, street and highway.

This vehicle complies with all applicable off-road noise and spark arrester laws and regu-lations in effect at the

time of manufacture. Please check your local riding laws and regulations before operating this vehicle.

Read this manual carefully and completely before starting your new quad.

It contains important safety information. Never operate this quad without proper instruction. Beginner should

take a training course before operating this vehicle.

Never allow a child under the age 16 to operate this quad. Use of this quad by children under 16 years of age

can lead to severe injury of death of the child. Even youths starting at age 16 may not have the skills, abilities,

or judgment needed to operate this quad safety. Therefore youths starting at age 16 should have adult supervision

even after they attend a training course. To protect your safety, make sure you use your vehicle legally, show

concern for the environment, and respect the rights of other people.

-5-

WARNING

Indicate a potential hazard that could result in personal injury or death.

FORWORD......................................................1

IMPORTANT NOTICE.....................................4

SAFETY INFORMATION ............................... 6

LOCATION OF THE WARNING AND

SPECIFICATION LABELS.............................. 11

VEHICLE IDENTIFICATION ..........................15

CONTROL FUNCTIONS.................................16

PRE-OPERATION INSPECTION ..................25

OPERATION....................................................30

RIDING YOUR QUAD.....................................33

PERIODIC MAINTENANCE AND

ADJUSTENT..................................................... 39

CLEAN AND STORAGE ................................45

SPECIFICATIONS...........................................47

WARRANTY TERMS AND CONDITIONS ........... 49

TABLE OF CONTENTS

-6-

SAFETY INFORMATION

AN QUAD IS NOT A TOY AND CAN BE HAZAR-

DOUS TO OPERATE. An quad handles differ-ently

from other vehicles including motorcycle and cars.

A collision or rollover can occur quickly, even during

routine maneuvers such as turning and driving on

hills or over obstacles, if you fail to take proper

precautions. SEVERE INJURY OR DEATH

can result if you do not follow these instruc-

tions:

–Read this manual and all labels carefully and

follow the operating procedures described.

–Never operate an quad without proper instruc-

tion. Take a training course. Beginners should receive

training from a certified instructor.

– Always follow the age recommendation:

• A child under 6 years old should never operate an

quad with engine size greater than 50 c.c.

• A child under 12 years old should never operate

an quad with engine size greater than 70 c.c.

• A child under 16 years old should never operate

an quad with engine size greater than 90 c.c.

–Never allow a child under age 16 to operate quad

without adult supervision, and never allow continued

use of an quad by a child if he or she does not have

the abilities to operate it safely.

– Never carry a passenger on an quad.

–Never operate an quad on any public road, street

or highway, even a dirt or gravel one. Never consume

alcohol or drugs before or while operating this quad.

–Never operate an quad without wearing an appro-

ved motorcycle helmet that fits properly. You should

also wear eye protection (face shield or goggles),

gloves, bots, long-sleeved shirt or jacket, and long

pants.

–Always avoid operating an quad on any paved

surfaces, including driveways, sidewalks, streets

and parking lots.

–Always go slowly and be extra careful when ope-

rating on unfamiliar terrain. Always be alert to chan-

ging terrain conditions when operating the quad.

–Always follow proper procedures for turning as

described in this manual. Practice turning at low

speeds before attempting to turn at faster speeds.

–Do not turn at excessive speed. Never operate

on excessively rough, slippery or loose terrain until

you have learned and practiced the skill necessary

to control the quad on such terrain. Always be es-

pecially cautious on these kinds of terrain. Always

-7-

keep both hands on the handlebars and both feet

on the footrests of the quad during operation.

–Always inspect your quad each time you use it to

make sure it is in safe operating condition.

Always follow the inspection and maintenance pro-

cedures and schedules described in this

manual.

–Never attempt wheelies, jumps, or other stunts.

–Never operate at speeds too fast for your skills

or the conditions. Always go at a speed that

is proper for the terrain, visibility and operating

conditions, and your experience.

–Never exceed the stated load capacity for an

quad. Cargo should be properly distributed

and securely attached. Reduce speed and follow

instructions in this manual for carrying cargo or

pulling a trailer. Allow greater distance for braking.

–Never modify an quad through improper installa-

tion or use of accessories.

–Never operate the quad on hills too steep

for the quad or for your abilities. Practice on

smaller hills before attempting larger hills.

–Always follow proper procedures for climbing hills

as described in this manual. Check the terrain care-

fully before you start up any hill. Never climb hills

with excessively slippery or loose surfaces. Shift

your weight forward. Never open the throttle suddenly

or make sudden gear changes. Never go over the

top of a hill at high speed.

–Always use the size and type tires specified in

this manual. Always maintain proper tire pressure

as described in this manual.

–Never attempt to operate over large obstacles,

such as large rocks or fallen trees. Always follow

proper procedures when operating over obstacles

as described in this manual. Always use proper

procedures if you stall or roll backwards when clim-

bing a hill. To avoid stalling, use proper gear and

maintain a steady speed when climbing a hill. If you

stall or roll backwards, follow the special procedure

for braking described in this manual. Dismount on

the uphill side or to a side if pointed straight uphill.

Turn the quad around and remount, follow the pro-

cedure described in this manual.

–Always be careful when skidding or sliding. Learn

to safety control skidding or sliding by practicing at

low speeds and on level, smooth terrain. On extre-

mely slippery surface, such as ice, go slowly and

be very cautious in order to reduce the chance of

skidding or sliding out of control.

-8-

–Never operate an quad in fast flowing water or in

water deeper than the recommended in this manual.

Remember that wet brakes may have reduced sto-

pping ability. Test your brakes after leaving water.

If necessary, apply them several times to let friction

dry out the linings. Always follow proper procedures

for going down hills and for braking on hills as

described in this manual. Check the terrain carefully

before you start down any hill. Shift your weight

backward. Never go down a hill at high speed. Avoid

going down a hill at an angle that will cause the

quad to lean sharply to one side. Go straight down

the hill where possible.

–Always follow proper procedures for crossing the

side of a hill as described in this manual. Avoid hills

with excessively slippery or loose surface. Shift your

weight to the uphill side of the quad. Never attempt

to turn the quad around on any hill until you have

mastered the turning technique described in this

manual on level ground. Avoid crossing the side of

a steep hill if possible. Always check for obstacles

before operating in a new area.

-9-

WARNING

When transporting the QUAD in another vehicle,

make sure it is placed upright and its fuel cock is

in the "OFF" position. Otherwise, gasoline may

leak out from the fuel tank or carburetor.

WHAT CAN HAPPEN

Gasoline is poisonous and can cause injuries.

HOW TO AVOID THE HAZARD

If you swallow some gasoline or breathe a lot of

gasoline vapor, or get some gasoline into your

eyes, see your doctor right away. If gasoline spills

on your skin, wash with water and soap immedia-

tely. If gasoline spills on your clothes, change

your clothes immediately.

POTENTIAL HAZARD

Improper handling of gasoline.

WHAT CAN HAPPEN

Gasoline can catch and you could be burned.

HOW TO AVOID THE HAZARD

Always shut down the engine while refueling. Do

not refuel immediately after the engine has been

running and is still very hot. Do not spill gasoline

on the exhaust muffler/pipe or engine when refue-

ling. Never refuel while smoking, or while in the

vicinity of sparks, open flames, or other sources

of ignition such as the pilot lights of clothes dryers

or water heaters.

-10-

WARNING

POTENTIAL HAZARD

Starting or running the engine in a closed area.

WHAT CAN HAPPEN

Exhaust smokes are poisonous and may

cause people unconsciousness and death

within a short time.

HOW TO AVOID THE HAZARD

Always start and operate your quad in an area

with adequate ventilation.

-11-

Read and understand all of the labels on this quad.

They contain important information for safe and

proper operation of your quad.

Never remove any labels from your vehicle. If any

label becomes difficult to read or comes off, a repla-

cement label is available from your dealer.

LOCATION OF THE WARNING AND SPECIFICATION LABELS

a

c

e

f

h

b

d

g

i

-12-

!WARNING

Operation of this ATV by children under the age

of 16 increases the risk of severe injury of death.

NEVER permit children under age 16 to operate

this ATV.

THIS VEHICLE IS AN ALL-TERRAIN VEHICLE AND IS NOT

INTENDED FOR USE ON PUBLIC HIGHWAYS.

-13-

!!

!

WARNING

Improper QUAD use can result in SEVERE INJURY or DEATH.

ALWAYS USE NEVER USE NEVER CARRY NEVER USE

AN APPROVED ON PUBLIC PASSENGERS WITH DRUGS

HELMET AND ROADS OR

PROTECTIVE ALCOHOL

GEAR

NEVER operate:

• without proper training or instruction.

• at speeds too fast for your skills or the condictions.

• on public roads-a collision can occurwith another vehicle.

• with a passenger-passengers affect balance and steering and

increase risk of losing control.

ALWAYS:

• use proper riding techniques to avoid vehicle overturns on

hills and rough terrain and in turns.

• avoid paved surfaces-pavement may seriously affect handling

and control.

LOCATE AND READ OWNERiS MANUAL. FOLLOW ALL INS-

TRUCTIONS AND WARNINGS.

WARNING

IMPROPER TIRE PRESSURE OR OVERLOADING CAN

CAUSE LOSS OF CONTROL.

LOSS OF CONTROL CAN RESULT IN SEVERE INJURY OR

DEATH.

OPERATING TIRE PRESSURE:Set with tires cold

• Recommended: FRONT: 20 kPa, {0,20 kgf/cm3} 2,9 psi

REAR: 20 kPa, {0,20 kgf/cm3}, 2,9 psi

• Minimum: FRONT: 17 kPa, {0,17 kgf/cm3}, 2,5 psi

REAR: 17 kPa, {0,17 kgf/cm3}, 2,5 psi

• Never set tire pressure below minimum.

It could cause the tire to dislodge from the rim.

LOADING

• Maximum Vehicle load:95kg,(209lbs).

Includes weight of operator, cargo and accessories.

WARNING

NEVER ride as a

passenger

Passengers can cause a loss of

control, resulting in SEVERE INJURY

or DEATH.

-15-

VEHICLE IDENTIFICATION

Identification number records

Record the vehicle identification number and engine

number in the follow spaces provided for assistance

when ordering spare parts from your dealer or for

reference in case the quad is stolen.

1. Vehicle Identification Number:

2. Engine Number:

Vehicle identification number

The vehicle identification number is stamped into

the frame. This vehicle identification num-ber is used

to identify your quad.

-16-

CONTROL FUNCTIONS

WARNING

Indicates a potential hazard that could re-sult in

serious injury or death. Main switch.

Functions of the respective switch positions are as

follows: ON

The engine can be started only at this position:

OFF

All electrical circuits are switched off. The key can be

removed in this position.

Indicator lights

Neutral indicator light "N"

This indicator light comes on when the trans-mission

is in neutral.

Page is loading ...

GAS GAS K2 QUAD 110 4 Stroke, K2 QUAD 110 User manual

Other documents