Aker Plastics 141352-R-000-002 Installation guide

Brand: Aker Plastics

Model: 141352-R-000-002

Type: Installation guide

This manual is also suitable for







Alcove-Style (Flanged) Bath Modules



141078-141356

TO-3060 R

TO-3060 L (shown)

TO-3060 AFR R

TO-3060 AFR L

141350-141357

TO-3260 R

TO-3260 L (shown)

141351-141358

TO-3260 AFR R

TO-3260 AFR L

141352-141359

TO-3660 R

TO-3660 L (shown)

141353-141360

TO-3660 AFR R

TO-3660 AFR L

141354-141361

TO-4260 R

TO-4260 L (shown)

141355-141362

TO-4260 AFR R

TO-4260 AFR L

141081

OVA-4260 R

OVA-4260 L (shown)

141080

SBA-3660 R

SBA-3660 L (shown)

141082

GT-4260 R

GT-4260 L (shown)

141079

SBA-3260 R

SBA-3260 L (shown)

    

    

      



    







NOTE:



     



   



ON WHIRLPOOL EQUIPPED MODELS,

A SEPARATE SET OF INSTRUCTIONS

IS PACKED WITH THE UNIT FOR THE

WHIRLPOOL SYSTEM. READ THEM

BEFORE INSTALLING UNIT!

WARNING!

NEVER LIFT OR HANDLE WHIRLPOOL

BY SYSTEM PIPING AT ANY TIME.

LIFTING THE UNIT BY THE PIPING CAN

CAUSE SYSTEM DAMAGE.

Special Notes to Installer

*



   

       



*

    

      

    



*     





*     

  Any critical dimensions

required for installation should be taken

directly from the unit being installed!

*     

      

     

     

    warranties 



Inspection Guidelines

       







DO NOT INSTALL ANY UNIT

WITHOUT FIRST ADDRESSING

QUESTIONS WHICH ARISE DURING

THE INSPECTION!

Basic Module Check

 



 

      



     



Whirlpool and Accessories Check









    











Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

10" 50"

60"

21"

42"

43-1/2"

21"

1-1/2"

17-1/4"

21-1/4"

22-3/4"

Nailing Flange

9-1/2" 50-1/2"

60"

Ø 2" Drain

Ø 2-3/8" Overflow

19-1/4"

40-1/2"

42"

21-1/4"

1-1/2"

14-3/4"

17-3/4"

5-1/2"

24-3/4"

1-1/2"

Nailing Flange

Arm Rest

Lumbar

8-3/8" 51-5/8"

60"

Ø 2" Drain

Ø 2-3/8" Overflow

15-1/4"

32-1/2"

34"

17-1/4"

1-1/2"

18-1/2"

21-1/4"

22-3/4"

1-1/2"

Nailing Flange

Arm Rest

Lumbar

8-3/8" 51-5/8"

60"

Ø 2" Drain

Ø 2-3/8" Overflow

17-1/4"

36-1/2"

38"

19-1/4"

1-1/2"

18-1/2"

21-1/4"

22-3/4"

1-1/2"

141079

SBA-3260 R

SBA-3260 L (Shown)

141080

SBA-3660 R

SBA-3660 L (Shown)

141081

OVA-4260 R

OVA-4260 L (Shown)

141082

GT-4260 R

GT-4260 L (Shown)

Unit Data and Dimensional Guidelines

Unit Sump Bottom Dry Unit Avg. Oper. Max. Sump Floor

Model Surface Dim. (W x L) Weight (1) Volume Capacity Loading

141079 - SBA-3260      

141080 - SBA 3660      

141081 - OVA-4260      

141082 - GT-4260      



Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

13-1/2"

16"

17"

8" 52"

60"

30-1/2"

31-1/2"

17"

13-5/8"

141078-141356

TO-3060 R

TO-3060 L (Shown)

141078-141356

TO-3060 AFR R

TO-3060 AFR L (Shown)

Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

13-1/2"

17-3/4"

8" 52"

60"

30-1/2"

31-1/2"

17"

15-3/8"

18-3/4"

Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

15"

16"

17"

8" 52"

60"

32"

33"

17"

13-5/8"

141350-141357

TO-3260 R

TO-3260 L (Shown)

141351-141358

TO-3260 AFR R

TO-3260 AFR L (Shown)

Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

15"

17-3/4"

8" 52"

60"

32"

33"

17"

15-3/8"

18-3/4"









Unit Data and Dimensional Guidelines

Unit Sump Bottom Dry Unit Avg. Oper. Max. Sump Floor

Model Surface Dim. (W x L) Weight Volume Capacity Loading

141078-141356 - TO-3060 

141350-141357 - TO-3260  

141351-141358 - TO-3260AFR 









Unit Sump Bottom Dry Unit Avg. Oper. Max. Sump Floor

Model Surface Dim. (W x L) Weight Volume Capacity Loading

141352-141359 - TO-3660

141353-141360 - TO3660AFR 

141354-141361 - TO-4260

141355-141362 - TO-4260AFR

Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

17-1/4"

16"

17"

8" 52"

60"

36"

37"

18-3/4"

13-5/8"

141352-141359

TO-3660 R

TO-3660 L (Shown)

141353-141360

TO-3660 AFR R

TO-3660 AFR L (Shown)

Ø 2" Drain

Ø 2-3/8" Overflow

Nailing Flange

17-1/4"

17-3/4"

8" 52"

60"

36"

37"

18-3/4"

15-3/8"

18-3/4"

141354-141361

TO-4260 R

TO-4260 L (Shown)

141355-141362

TO-4260 AFR R

TO-4260 AFR L (Shown)

Ø 2" Drain

Ø 2-3/8" Overflow

16"

17"

42"

Nailing Flange

60"

13"

51-1/2"

8-1/2"

41"

20-1/2"

Ø 2" Drain

Ø 2-3/8" Overflow

17-3/4"

18-3/4"

42"

Nailing Flange

60"

14-3/4"

51-1/2"

8-1/2"

41"

20-1/2"

Unit Data and Dimensional Guidelines









Framing Requirements

     

     

    

   

      









     



 

    





NOTE:    



NOTE:



       





NOTE: A pump access is MANDATORY

on all whirlpool equipped models.

     



Installation Procedure







 



 

 



 

 

 

       



ON WHIRLPOOL EQUIPPED UNIT

     

    

      



     



      



If the unit is a whirlpool with an alternate

pump mounting, refer to the special

alternate pump location supplement at

this time.

Drain Cut-Out

21" W x 16" H

Pump Access

Mandatory

on All Whirlpool

Equiped Units

Fixture

Blocks

Finished Unit Depth

Minimum Alcove Depth

Unit Rough-In Depth

Drain Center

Drain

Center

Alcove Lenght / Unit Lenght

Drain Cut-Out

Drain

Cut-Out

NOTE: Left End Drain

Installation Illustrated

Figure 1 - Alcove Framing Guidelines

MODEL

141078-141356 / TO-3060

141079 / SBA-3260

141080 / SBA-3660

141082 / GT-4260

60"

31-1/2"

43-1/2"

34"

42"

30-1/2"

42"

32-1/2"

40-1/2"

13-1/2"

21"

15-1/4"

19-1/4"

10"

8-3/8"

9-1/2"

11"

13"

11-3/8"

12-1/2"

141350-141357 / TO-3260

141351-141358 / TO-3260 AFR

60"

33"

32"

15"

11"

60"

37"

36"

17-1/4"

11"

60"

42"

41"

20-1/2"

8-1/2"

12"

141081 / OVA-4260

141352-141359 / TO-3660

141353-141360 / TO-3660 AFR

141354-141361 / TO-4260

141355-141362 / TO-4260 AFR

38"

36-1/2"

17-1/4"

8-3/8"

11-3/8"













     





      

       





     

       

      

      

     

    





WARNING!

THE UNIT BOTTOM SHOULD BE

CLEAR OF ALL POTENTIALLY

DAMAGING DEBRIS AND THE

SURFACE PROTECTED BEFORE

STEPPING INSIDE.

CAUTION: It is advisable to protect

the unit surface with a thin plywood or

cardboard shield while fastening the

flange to the framing.

Water Supply and Drain Connections

      

    

Carefully

check all fittings and connections for

leaks.

Wall

Framing

Fastening

Flange

gure

a -

ecur

Drill 1/8 inch hole

through flange at each

framing member

Wall

Framing

Fastening

Flange

Figure 3b - Securing Unit

Secure unit

to framing with

1-1/4" screws

CAUTION: Protect unit surface

with a shield when fastening

Wall

Framing

Fastening

Flange

gure

Furring Strip

or Shim

Material

Waterproof

Sealant

Water Resistant

Underlayment

Confirm the tub is level

along the sides and

across each end.

Confirm unit is square

in framed area.

Figure 2b - Unit

Installation

Procedure

Wall

Framing

Fastening

Flange

2. Level Tub

in Framed Area

Wall Framing

Confirm unit apron is

resting flush on floor.

Confirm Drain Alignment

Figure 2a - Unit

Installation

Procedure

Wall

Framing

Fastening

Flange

1. Position Tub

in Framed Area

Wall Framing









Finishing Guidelines

      

      





    







    

      



  



Unit Surface Care

WARNING!

NEVER USE ABRASIVE MATERIALS

NOR ABRASIVE CLEANERS ON THE

UNIT SURFACE!

EXTREME CAUTION is urged regarding

the use of any cleaner, acid or solvent

on the unit surface.

READ, AND FOLLOW ALL PACKAGE

LABELS AND INSTRUCTIONS!

  

  

     





      







    

     

    

     

      



WARNING!

AVOID APPLYING WAX TO THE UNIT

BOTTOM!

    



   



     





    

    



      



      







     

     



    

    





 

      

    





      



WARNING!

BATH MATS OR OTHER ITEMS WHICH

ARE HELD IN PLACE USING SUCTION

AGAINST THE UNIT SURFACE MUST

BE REMOVED FROM THE FLOOR OF

THE UNIT AFTER EACH USE.

OVER A PROLONGED PERIOD,

FAILURE TO REMOVE THESE TYPES

OF ITEMS FROM THE BOTTOM OF

THE UNIT CAN RESULT IN SURFACE

DAMAGE.









2012-12-07 10023031

After Sales Service





800-962-2537



www.akerbymaax.com

.



acrylic units



fiberglass units

















Limitations

                 





























          



EXCEPT AS OTHERWISE PROVIDED ABOVE, MAAX MAKES NO WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF

MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE OR COMPLIANCE WITH ANY CODE.



Commercial Limitations











Warranty service















