2. Binks
  3. Pressure Tanks

Binks Pressure Tanks User manual

  • Hello! I am an AI chatbot trained to assist you with the Binks Pressure Tanks User manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
KK-5041 1/2” SHAFT SEAL KIT
KK-5042 5/8” SHAFT SEAL KIT
INSTALLATION INSTRUCTIONS
Direct Drive Models
1. ApplyalightlmofgunlubeorwatertotheO-ringonthesealtoaid
ininstallation.
2. Orienttheshaftsealintheadapterasshown.
3. UsingtheatsideofasocketwithanO.D.slightlysmallerthanthe
shaftseal,pushshaftsealintoadaptercompletelyagainsttheupper
surface.
4. Carefullyinsertairmotorshaftthroughshaftseal,beingcarefulnotto
dislodgesealfromadapter.
5. Tighten(2)setscrewswhichretainairmotorinadapter.Attachadapter
couplingtoairmotorshaftandagitatorshaft.UseLoctite242(blue)
onallsetscrews.Tightenallsetscrews.
Hand Crank/Gear Reduced Models
1. Applyalightlmofgunlubeorwatertotheo-ringonthesealtoaid
ininstallation.
2. Orienttheshaftsealintheadapterasshown.
3. UsingtheatsideofasocketwithanO.D.slightlysmallerthanthe
shaftseal,pushshaftsealintoadaptercompletelyagainsttheupper
surface.
4. Carefullyslideagitatorshaftupthroughseal,beingcarefulnottonick
ordamagetheseal.
5. Slidethrustwasherandthrustcollaroverendofagitatorshaft.Ap-
plyLoctite242(blue)tosetscrewinthrustcollar.Tightensetscrew.
Screwretainingnutontobearingassemblyandtighten.
Vacuum Tank Operation
Ifthepressuretankisusedforvacuumoperation,theinternalretaining
ringsuppliedinthiskitmustbeusedtoretaintheshaftseal.Ifthetank
isusedforpressurefeedonly,discardtheretainer–notrequired.
Toinstalltheinternalretainingring:
1. Installshaftsealrstaspreviouslyshown.
2. The retaining ring has prongs that slope in one direction. Orient the
retainerwiththeprongsfacing awayfromtheshaftseal.
3.Using the samesocketasused to installthe shaft seal,press the
retainer(byhand)downintotheadapteruntilitseatsevenlyagainst
thefaceoftheshaftseal.Donotuseexcessiveforceasyoumay
damagetheshaftseal.
InternalRetainingRing
(usedforVacuum Tank Operation–
seeinstructionsbelow.)
SI-21-05-19-J (6/2017) 1 / 2 www.carlisleft.com
EN
SERVICE MANUAL
IMPORTANT! DO NOT DESTROY
ItistheCustomer'sresponsibilitytohavealloperatorsandservicepersonnelreadandunderstandthismanual.
ContactyourlocalDeVilbissrepresentativeforadditionalcopiesofthismanual.
READ ALL INSTRUCTIONS BEFORE OPERATING THIS DEVILBISS PRODUCT.
EN
SI-21-05-19-J (6/2017)2 / 2www.carlisleft.com
WARRANTY POLICY
DeVilbissproductsarecoveredbyCarlisleFluidTechnologiesoneyearmaterialsandworkmanship
limitedwarranty.Theuseofanypartsoraccessories,fromasourceotherthan
CarlisleFluidTechnologies,willvoidallwarranties.Forspecicwarrantyinformationpleasecontact
theclosestCarlisleFluidTechnologieslocationlistedbelow.
DeVilbissispartofCarlisleFluidTechnologies,agloballeaderininnovativenishingtechnologies.
Fortechnicalassistanceortolocateanauthorizeddistributor,contactoneofourinternationalsales
andcustomersupportlocations.
USA/Canada
[email protected]
Tel: 1-888-992-4657
Fax: 1-888-246-5732
United Kingdom
[email protected]
Tel: +44(0)1202571111
Fax: +44(0)1202573488
China
[email protected]
Tel: +8621-33730108
Fax: +8621-33730308
Mexico
[email protected]
Tel: +525553212300
Fax: +525553104790
Japan
[email protected]
Tel: +81457856421
Fax: +81457856517
Brazil
[email protected]
Tel: +551156412776
Fax: +551156411256
Germany
[email protected]
Tel: +49(0)60744031
Fax: +49(0)6074403281
Australia
[email protected]
Tel: +61(0)285257555
Fax: +61(0)285257575
CarlisleFluidTechnologiesreservestherighttomodifyequipmentspecicationswithoutpriornotice.
DeVilbiss
®
,Ransburg
®
,MS
®
,BGK
®
,andBinks
®
areregisteredtrademarksofCarlisleFluidTechnologies,Inc.
©2017CarlisleFluidTechnologies,Inc.
Allrightsreserved.
USA/Canada
www.autorenishdevilbiss.com
[email protected]
TollFreeTel: 1-800-445-3988
TollFreeFax:1-800-445-6643
Mexico
www.autorenishdevilbiss.com.mx
TollFreeTel: 1-888-835-6232USA
DeVilbissAutomotiveRenishingispartofCarlisleFluidTechnologies,
agloballeaderininnovativenishingtechnologies.Fortechnicalassistance
ortolocateanauthorizeddistributor,contactoneofourinternationalsales
andcustomersupportlocations.
Forthelatestinformationaboutourproducts,visitwww.carlisleft.com.
/