Lovibond 2438200 Owner's manual

Brand: Lovibond

Model: 2438200

Category: Fridges

Type: Owner's manual

This manual is also suitable for

www.lovibond.com

Lovibond

Water Testing

Tintometer

Group

TC 135 S / TC 175 S / TC 255 S / TC 445 S

Thermostatschränke TC-Serie

Instruction Manual

Page 10 – 17

Thermostatschränke

Vor Inbetriebnahme die Gebrauchsanweisung lesen

Thermostatically controlled incubators

Read the operating instructions before switching on for the ﬁrst time

Etuves réfrigérées

Lire le mode d'emploi avant la mise en service

Armarios termostaticos

Leer las instrucciones de manejo antes de la puesta en servicio

Estufas reguladas por termóstato

Antes da colocação em funcionamento, ler o manual de utilização

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014

Safety instructions and warnings

• Topreventinjuryordamagetotheunit,theapplianceshouldbe

unpackedandsetupbytwopeople.

• Intheeventthattheapplianceisdamagedondelivery,contact

thesupplierimmediatelybeforeconnectingtothemains.

• Toguaranteesafeoperation,ensurethattheapplianceissetup

andconnectedasdescribedintheseoperatinginstructions.

• Disconnecttheappliancefromthemainsifanyfaultoccurs.Pull

outtheplug,switchofforremovethefuse.

• Whendisconnectingtheappliance,pullontheplug,notonthe

cable.

• Anyrepairsandworkontheapplianceshouldonlybecarriedout

bythecustomerservicedepartment,asunauthorisedworkcould

provehighlydangerousfortheuser.Thesameappliestochanging

themainspowercable.

• Donotallownakedflamesorignitionsourcestoentertheappli-

ance.Whentransportingandcleaningtheappliance,ensurethat

therefrigerantcircuitisnotdamaged.Intheeventofdamage,

make sure that there are no ignition sources nearby and keep the

roomwellventilated.

• Donotstandontheplinth,drawersordoorsorusethemtosup-

portanythingelse.

• Thisappliancecanbeusedbychildrenof8yearsoldandover,and

alsobypersonswithrestrictedphysical,sensoryormentalcapacity

orlackofexperienceandknowledge,iftheyaresupervisedor

have been instructed on safe use of the appliance and understand

theresultingrisks.Childrenmustnotbeallowedtoplaywiththe

appliance.Cleaningandusermaintenancemustnotbecarried

outbychildrenwithoutsupervision.

• Avoidprolongedskincontactwithcoldsurfacesorchilled/frozen

food.Thiscouldcausepain,numbnessandfrostbite.Inthecase

ofprolongedskincontact,protectivemeasuresshouldbetaken,

e.g.glovesshouldbeworn.

• Donotstoreexplosivesorspraysusingcombustiblepropellants

suchasbutane,propane,pentane,etc.intheappliance.Electrical

componentsmightcauseleakinggastoignite.Youmayidentify

suchspraysbytheprintedcontentsoraflamesymbol.

• Ifyouhavealockableappliance,donotkeepthekeynearthe

applianceorwithinreachofchildren.

• Theapplianceisdesignedforuseinenclosedareas.Donotoperate

theapplianceoutdoorsorinareaswhereitisexposedtosplash

waterordampconditions.

• Donotplaceitemswithtoohightemperatureintheinterior.

Disposal notes

The appliance contains reusable materials and should be

disposedofproperly-notsimplywithunsortedhousehold

refuse.Applianceswhicharenolongerneededmustbe

disposedofinaprofessionalandappropriateway,in

accordancewiththecurrentlocalregulationsandlaws.

Whendisposingoftheappliance,ensurethattherefrigerantcircuit

is not damaged to prevent uncontrolled escape of the refrigerant

itcontains(dataontypeplate)andoil.

Do not vent R134a into atmosphere.

R134a is a ﬂuorinated greenhouse gas, covered by

Kyoto Protocol, with a Global Warming Potential

(GWP) = 1300.

•Disabletheappliance.

•Pulloutthemainsplug.

•Cutthroughtheconnectioncable.

•Disablesafetylock.

WARNING

Dangerofsuffocationduetopackingmaterialandplasticlm!

Donotallowchildrentoplaywithpackagingmaterial.Takethe

packagingmaterialtoanofcialcollectionpoint.

Range of appliance use

Thethermostat-controlledincubatorsaredesignedtoallowcontinu-

ousregulationoftemperatureforvariousfieldsofapplication,e.g.

• 20°CBOD

measurement

andresearchpurposesat:

• 4°Cstorageofsewagesamples

• 25°Cenzymeactivity(TTC-test)

• 37°Ccolonycount

• Microbiology

• Foodindustry

• Laboratories

Alltemperaturecontrolproblemsintheusualrangeof2°Cto40

°Caresolvedbythefactorysetuniversalplug-incontrollerwhich

ismaintenance-freeandreliable.Thisapplianceisnotsuitablefor

storingflammableliquids,acidsandlyes.

Function

The inner temperature of the fully insulated incubator is controlled

exactlybyanintergratedcorrosion-prooftemperatureprobewhich

connects or switches-off either the cooling unit or the heating

element.

Themeasuredinnertemperatureisdirectlyindicatedbyadisplay.

Thetemperaturerangeof2°Cto40°Ccanbesetinincrements

of0,1°Cwiththeaidoftwotactileresponsekeys.Thekeyboardis

protectedbyaruggedfoil.Aircirculationisprovidedby2axialflow

fanswithadischargewidthof160cm

and an output of 300 m

/h.

Noise emissions from the appliance

Thenoiselevelwhiletheapplianceisoperatingisbelow70dB(A)

(relativenoiselevel1pW).

Climate rating

The climate rating indicates the room tempera-

tureatwhichtheappliancemay b eo pera t e d i n 

ordertoachievefullrefrigerationperformance.

Theclimateratingisindicatedonthetypeplate.

Climate rating Room temperature

4 (SN) +10°C to +32°C

4 (N) +16°C to +32°C

4+ (ST) +16°C to +38°C

4+ (SN-ST) +10°C to +38°C

5 (T) +16°C to +43°C

5 (SN-T) +10°C to +43°C

Do not operate the appliance outside the speci-

ﬁed room temperature range.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014 11

Setting up

•Donotplacetheapplianceindirectsunlightornear

cookers,radiatorsandsimilarsourcesofheat.

•Theflooronwhichtheappliancestandsshouldbe

horizontalandlevel.Compensateforunevenfloors

withtheadjustablefeet.

•Donotcoverventilationopeningsor

grille.

•Always install the appliance directly

againstthewall.

•Wellventilatedrooms

Appliance dimensions

 A B C D E

TC 135 S 850 mm 600 mm 600 mm 648 mm 1153 mm

TC 175 S 1250 mm 600 mm 610 mm 650 mm 1180 mm

TC 255 S 1640 mm 600 mm 610 mm 650 mm 1180 mm

TC 445 S 1640 mm 750 mm 730 mm 850 mm 1410 mm

Installing beneath a worktop TC 135 S

F o rc o nti n uo u swo rk t op s th e re f r ig era t o r ‘ s ta b l e to pc an b ed et a ch e d. 

Therefrigeratorcanthenbepushedundertheexistingworktop.

•Totakeofftabletopremovescrews➊.

• A cross-section of min. 200 cm

 is required in the

worktopforventilationoftherearoftheappliance.

Electrical connection

Onlyoperatetheappliancewithalternating current (AC).

Thepermissiblevoltageandfrequencyareindicatedonthetypeplate.

Thesocketmustbeproperlyearthedandprotectedbyafuse.

Thetrippingcurrentofthefusemustbebetween10Aand16A.

The socket must not be situated behind the appli-

anceandmustbeeasilyaccessible.

Donotconnecttheapplianceusinganexten-

sioncableorextensionsocket.

Donotusestand-aloneinverters(conversionof

directcurrenttoalternatingcurrent/three-phase

current)orenergy-savingplugs.Riskofdamage

totheelectroniccontrolsystem!

Safety lock TC 135 S

Thelockintheappliancedoorisequippedwithasafetymechanism.

Locking the appliance

•Insertthekeyasshown

byarrow1.

•Turnthekey90°.

To unlock the appliance, the

same procedure must be re-

peatedinthesameorder.

Safety lock TC 175 S, TC 255 S, TC 445 S

The lock in the appliance door is

equippedwithasafetymechanism.

Locking the appliance

•Insertthekeyasshownby

arrow1.

•Turnthekey90°.

Tounlocktheappliance,thesame

procedure must be repeated in the

sameorder.

Important

TC 135 S, TC 175 S, TC 255 S

Themaximumloadpergridshelfis45kg.

TC 445 S

Themaximumloadpergridshelfis60kg.

Important

Whenunpackingandsettingupuseprotectivegloves.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014

Adjustment and operation

TheunitisswitchedonandoffviatheOn/Offswitch.

The „Up“ key is used to increase the temperature

The „Down“ key is used to decrease the temperature

Theillustrationshowstheactual

temperatureof20.0°C.

Setting the temperature values

Whentheunitisswitchedon,thedisplaywillinitiallyshowbriey

thetypeofovenand a versionnumber. Itwillthendisplaythe

preset temperature,together with the symbol forthe specied

gure(3horizontallines).After5seconds,thiswillbereplacedby

thecurrent,actualtemperature.

Theunitispresetinthefactorytoaworkingtemperatureof20°C.

Ifthisisrequiredtobe25°C,forexample:

Pressthe„⬆“keyonce.Thedisplaywillshowthespeciedgure

whichhasbeenset, togetherwiththesymbolforthespecied

gure (3 horizontal lines). Now press the „⬆“ key again, or

hold it down until the display shows the new gure required

(25°Cinthisexample).Thenreleasethekey.Thedisplaywillshow

the new setting for 5secondsand willthendisplaythe actual,

currenttemperature.

Ifalowerworkingtemperatureisrequired,thesameprocedure

applies,usingthe„“key.Thetemperaturecanbeadjustedin

stepsof0.1°Cbetween2°Cand40°C.

Ifyouwishtoreadthespeciedtemperaturebutwithoutchanging

it,simplypressthe„⬆“or„“keyonceandreleaseit,sothatthe

displayshowsthespeciedgureinsteadofthecurrenttemperature.

Thespeciedgurecannotbechangedunlessoneofthekeysis

pressedwhilethedisplayisalreadyshowingthespeciedgure.

Thepresettemperaturewillnotbelostifthereisapowerfailure

ofifthe unitisswitchedoff.Thedata arestoredinaninternal

electronicmemoryandarecalledupautomaticallywhenpoweris

restoredortheunitisswitchedon.

Detecting a power failure

Whentheunitisrstswitchedon,thedisplaywillash.Pressing

the„⬆“or„“keywillcauseittostopashingandremainper-

manentlylit.

Ifthereisapowerfailure,thedisplaywillstarttoashagain.Thismay

indicate that the temperature in the oven can no longer be held at

theworkingtemperature,ifthepowerisoffforanextendedperiod.

Thecontrolswillcontinuetooperatenormally,evenifthedisplay

isashing.Theashingmerelyindicatesthattheunithasbeen

switchedoffandthenbackonagain,orthatthepowersupply

failedforatimeandnokeyhasbeenpressedsincethen.

Itisimportanttonotethatthedisplaywillash,evenifthepower

supplyhasfailedforaveryshortperiod.Itdoesnotnecessarily

meanthatthetemperatureintheovenhasdeviatedsignicantly

fromthespeciedlevel.

Temperature control and accuracy

Thethermostaticallycontrolledincubatorsarenotspeciedaccor-

dingASTM E 145(9-point-measurement) orDIN 12880, part 2

(27-point-measurement).

Specicationsarebasedonaone-point-measurement.

Test procedure

1. Placeasamplebottlelledwith500mlwaterwithastirring

rodonastirringplaceandplaceitinthemiddleofagrid(5th

insertfromthebottom).

2. Completelyimmersetheprobeofthemeterinthewatersample

(accordingtothespecicationsofthemeter).Theprobeshould

nottouchthebottlewall.

Specicationsofthemeter: Accuracyatleast0.5°C

Resolutionatleast0.1°C

3. Thetemperatureisreadafter4hours.

Trouble shooting

Ifthevericationofthetemperatureaccuracyisnotsuccessfulthe

followingshouldbetakenunderconsideration:

- The ambient temperature of the thermostatically controlled

incubatormustmatchtheclimaterate(typeplate).

- Acertaincirculationofairisnecessaryforthecompressorto

workproperly.

- Theincubatorshouldnotbeopenedtooftenand/orforlonger

periodoftime.

- Checkthefunctionofthetwofansbyvisualinspection.

- Checkthecoolingdevicebysetting10°Candwaitforasigni-

cantchangeofthetemperatureinthesampletowards10°C.

- Checktheheatingdevicebysetting40°Candwaitforasigni-

cantchangeofthetemperatureinthesampletowards40°C.

- Dependingonthesampletemperatureitcantakeupto7hours

fortemperaturestabilityattheset-value.

Important

Theairtemperatureinthecabinetmayuctuatebyseveraldegrees

centigrade. Nevertheless the actual temperature of the sample

uctuatesonlybyamaximumof±0.5°C.

Other operation controls

On the front side of the temperature control unit there are

covered shock-proof sockets for the connection of BOD's

appliances or stirring apparates. The total load on the sockets

must not exceed 4,5 amps.

The thermostatically controlled oven and laboratory sockets are

protectedbyafuse(6.3AT)whichisaccessiblefromthefront

paneloftheunit.

Thecontrolunitisconnectedbymeansofa4-poleplugonthe

bottomoftheincubator.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014 13

Cleaning

Clean the appliance at least twice per year.

Before cleaning always switch off the appliance. Pull out the

mains plug or switch off or unscrew the fuse.

•Clean the inside, equipment and outer walls with

lukewarmwaterandalittledetergent.Donotuse

abrasiveoracidcleanersorchemicalsolvents.

•Ensure that no cleaning water penetrates into the

electricalcomponentsorventilationgrille.

•Thedustshouldberemovedfromtherefrigeration

unitandheatexchanger-metalgridatthebackof

theappliance-onceayear.

•Donotdamageorremovethetypeplateonthein-

sideoftheappliance.Itisveryimportantforservicing

purposes.

•Important! The compressor and other parts may

stillbehotfromoperation.

Do not use steam cleaners because of the risk

of injury and damage.

Defrosting

Whenoperatingataverycoldthermostatsetting,theinteriorrear

wallmayiceup.

Inthiscase,theappliancemustbedefrostedmanually.

•Pull out the mains plug!

•Leavethedooroftheapplianceopenwhiledefrosting.

Defrostedwatercollectsinanevaporatortrayandis

evaporatedautomatically.Attentionmustbepaidthat

thedefrostedwatercandrainofffreelythroughthe

drainageopeninginthebackpaneloftheincubator.

The drainage opening should, when necessary be

cleanedwiththeaidofasuitabledevice(e.g.bottle

brush).Afterdefrostingmopuptheremainingwater

andcleantheappliance.

Do not use any mechanical devices or other

artiﬁcial aids for defrosting other than those

recommended by the manufactur er.

Shutting your appliance down

Ifyourapplianceistobeshutdownforanylengthoftime,switch

itoffanddisconnecttheplugorswitchofforunscrewthefuse.

Cleantheapplianceandleavethedooropeninordertoprevent

unpleasantsmells.

The permissible room temperature for storing the appliance

after decommissioning is between -10°C and +50°C.

Storing the appliance outside this temperature range can

damage the appliance and cause it to malfunction.

Theappliancecomplieswiththerelevantsafetyregulationsand

ECDirectives2004/108/ECand2006/95/EC.

Malfunctions

Ifamalfunctionoccursduringoperation,checkwhetheritisdue

toanoperatingerror.

You may be able to rectify the following faults yourself:

•Appliance does not function:

–Istheapplianceswitchedon?

–Istheplugcorrectlyfittedinthemainssocket?

–Isthefuseintact?Ifnecessary,replacewithanew6.3A(slow).

•Loud running noise:

–Istheappliancesetupfirmlyonthefloor?

–Doestheappliancecausenearbyitemsoffurnitureorobjectsto

vibrate?Pleasenotethatnoisescausedbytherefrigerantcircuit

cannotbeavoided.

•Correct display of inside temperature but no regulation to the

temperature setpoint:

–Isthetemperaturesettingcorrect(see"Settingthetemperature")?

–Istheventilationsystemworkingproperly?

–Istheappliancesetuptooclosetoaheatsource?

Ifnoneoftheabovecausesapplyandyoucannotrectifythefault

yourself.Contactyourdealerorsupplier,ifnecessarysendinthe

controlunitorthermostat-controlledincubatorforrepair(original

packingifpossible!).

Changing over door hinges TC 135 S

•Unscrewhingebracket1.

•Pullthedooroutatthebottomandliftoff.

•Transfercover3 totheoppositeside.

•Transferhingepin2 on hinge bracket 1 to the op-

positeside.

•Transferhingepin4 totheoppositeside.

•Transferdoorhandle5 and plugs 6 totheotherside.

•Mountdooronhingepin4 andclose.

•Inserthingebracket1 inlowerdoormountingand

screwintoplace.

Important

Before undertaking any repair work disconnect plug from

mains! Only trained specialists should work on electrical

devices.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014

Changing over door hinges

TC 175 S, TC 255 S, TC 445 S

Door hinges should only be changed by a trained expert.

Changing the door hinges must be done by two people.

2. Openthedoorapprox.45°

andliftupwards.

Important

As a result of its heavy weight,

the door must be held secure by

one person.

3. Pushthepinupwardsusing

yourfingertip.

4. Pull the door to the front

andremoveitdownwards.

1. Remove screw from

lowerhingebracket.

5. Transfer door handle

and plugs to the other

side.

6. Unscrewthepin.

Usethespannerprovided.

7. Screwinthepinontheoppositeside.

9. Unscrew hinge

bracket.

Transfer locking bracket to

theoppositeside.

10. Remotethecover,turnitthrough

180°andre-fititontheopposite

side.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014 15

11.Screwhingebrack-

etintoplace.

13.Insertthepinintotheleft-handdoormount-

ing.

Useyourindexfingertoholdthepinwhile

youareassemblingthedoor.

14. Locate the door on the upper

pinasshownintheillustration

andguideittothelowerhinge

bracket.

Important

As a result of its heavy weight,

the door must be held secure by

one person.

15.Liftthedoorupwardsandturn

the pin until it fits into the bore

holeofthehingebracket.

Slowlylowerthedoordownwards.

Thelowerpartofthepinmust

be fully engaged in the bore hole

ofthehingebracket.

16.Screwthescrewinto

the pin again and

tighten.

12.

Turnthedoorby180°.

Adjusting the lateral tilt of the door

Ifthedoorisatanangle,adjusttheangle.

17.Remove middle screw from hinge

bracket.

Thisscrewisnolongerneeded.

18. Undo screws and slide

hinge bracket to the right

orleft.

Tightenscrews.

TC 135 S / TC 175 S / TC 255 S / TC 445 S_1 03/2014

Construction fullyinsulatedincubatorwithuniversalplug-intemperature

Control unit operation robust,waterprotectedfoilfrontpanel,2keyswithtactileacknowledgement

Range of adjustment 2°Cto40°C,adjustablein0.1°C-increments

Constancy of temperature

20°C,±1.0°C

Climate class

the climate rating is indicated on the type plate

Display 3digitforactualandtargettemperature,resolution0.1°C

Refrigerating unit compressor-system

Heating unit

heating element

Fan axial,dischargecapacity320m

Power requirement

 220-240V/50Hz

Sockets CEE7/5,typeE,withhingedlid,230V/16A,2p+E,IP44

Coolant R134a

TC 135 S

(4sockets)

Net capacity 135Ltr.

Power consumption 270VA

1.35kWh/24h

(ambienttemperature25°C,targettemperature20°C),variationspossible

Overall dimensions 600Wx600Dx850Hmmwithworktop

600Wx600Dx819Hmmwithoutworktop

Inside dimensions 513Wx441Dx702Hmm(with3retractablegridsand1bottomgrid)

Weight 39.0kg

Order Code 2 43 82 00

TC 175 S(5sockets)

Net capacity 175Ltr.

Power consumption 270VA

1.23kWh/24h

(ambienttemperature25°C,targettemperature20°C),variationspossible

Overall dimensions 600Wx610Dx1250Hxmm

Inside dimensions 470Wx440Dx1062Hmm

(with3retractablegridsand1bottomgrid)

Weight 51.0kg

Order Code 2 43 82 20

TC 255 S

(7sockets)

Net capacity 255Ltr.

Power consumption 270VA

1.54kWh/24h

(ambienttemperature25°C,targettemperature20°C),variationspossible

Overall dimensions 600Wx610Dx1640Hxmm

Inside dimensions 470Wx440Dx1452Hmm(with4retractablegridsand1bottomgrid)

Weight 61.0kg

Order Code 2 43 82 30

TC 445 S(9sockets)

Net capacity 445Ltr.

Power consumption 270VA

1.42kWh/24h

(ambienttemperature25°C,targettemperature20°C),variationspossible

Overall dimensions 750Wx730Dx1640Hxmm

Inside dimensions 600Wx560Dx1452Hmm(with4retractablegridsand1bottomgrid)

Weight 78.5kg

Order Code 2 43 82 40

Technical Data

Technical changes without notice

Printed in Germany 03/14

No.: 00 38 56 86

Lovibond

and Tintometer

are Trademarks of the

Tintometer Group of Companies

Tintometer China

Room1001,ChinaLifeTower

16ChaoyangmenwaiAvenue,

Beijing,100020

Tel.:+861085251111App.330

Fax:+861085251001

China

Tintometer South East Asia

UnitB-3-12,BBTOneBoulevard,

LebuhNilam2,BandarBukitTinggi,

Klang,41200,SelangorD.E

Tel.:+60(0)333252285/6

Fax:+60(0)333252287

lovibond.asia@tintometer.com

www.lovibond.com

Malaysia

Tintometer GmbH

Lovibond

WaterTesting

Schleefstraße8-12

44287Dortmund

Tel.:+49(0)231/94510-0

Fax:+49(0)231/94510-20

sales@tintometer.de

www.lovibond.com

Germany

Tintometer AG

Hauptstraße2

5212HausenAG

Tel.:+41(0)56/4422829

Fax:+41(0)56/4424121

info@tintometer.ch

www.tintometer.ch

Switzerland

The Tintometer Limited

LovibondHouse/SolarWay

SolsticePark/Amesbury,SP47SZ

Tel.:+44(0)1980664800

Fax:+44(0)1980625412

water.sales@tintometer.com

www.

lovibond.com

Tintometer Inc.

(dbaOrbeco-HelligeInc.)

6456ParklandDrive

Sarasota,FL34243

Tel:941.756.6410

Fax:941.727.9654

[email protected]

www.orbeco.com

USA

sales@novatech-usa.com

www.novatech-usa.com

Tel: (866) 433-6682 Fax: (866) 433-6684

Tel: (281) 359-8538 Fax: (281) 359-0084

Lovibond 2438200 Owner's manual

Brand: Lovibond

Model: 2438200

Category: Fridges

Type: Owner's manual

This manual is also suitable for

Download PDF

report

Lovibond 2438200 Owner's manual

This manual is also suitable for

Lovibond 2438200 Owner's manual

Related papers

Other documents