Cres Cor Roast-N-Hold Operating instructions

Cres Cor
Brand
Cres Cor
Model
Roast-N-Hold
Category
Ovens
Type
Operating instructions
C
C
O
O
O
O
K
K
B
B
O
O
O
O
K
K
E
E
v
v
e
e
r
r
y
y
t
t
h
h
i
i
n
n
g
g
Y
Y
o
o
u
u
W
W
a
a
n
n
t
t
T
T
o
o
K
K
n
n
o
o
w
w
A
A
b
b
o
o
u
u
t
t
R
R
o
o
a
a
s
s
t
t
i
i
n
n
g
g
a
a
n
n
d
d
R
R
e
e
t
t
h
h
e
e
r
r
m
m
a
a
l
l
i
i
z
z
i
i
n
n
g
g
W
W
i
i
t
t
h
h
Y
Y
o
o
u
u
r
r
C
C
r
r
e
e
s
s
C
C
o
o
r
r
O
O
v
v
e
e
n
n
• Chef-Developed Recipes
• Time/Temperature Charts
• Preparation Tips
Table of Contents
SECTION 1; Introduction and Operating Instructions Page
Introduction.............................................................................................................................1
How to Operate Your CRES COR Roast-N-Hold Oven.........................................................3
Microprocessor with Probe Model Operating Instructions ....................................................3, 4
Advantages of Low-temperature Cooking ..............................................................................5, 6
The All Important Hold Cycle.................................................................................................7
SECTION 2; Preparing Beef Products
Prime Rib.................................................................................................................................9
Outside Round.........................................................................................................................10
Ribeye......................................................................................................................................11
Steamship Round.....................................................................................................................12
Strip Loin, Boneless ................................................................................................................13
Pulled Tenderloin....................................................................................................................14
Short Ribs................................................................................................................................15
Swiss Steak..............................................................................................................................16
Corned Beef Brisket................................................................................................................17
Cooked Sliced Beef w/Gravy..................................................................................................18
Reheating Prime Ribs..............................................................................................................19
Steak Proofing.........................................................................................................................19
SECTION 3; Preparing Pork Products
Fresh Ham B.R.T.....................................................................................................................21
Fresh Ham Bone-in .................................................................................................................22
Pork Loin, Boneless ................................................................................................................23
Pork Chops, 1-pound...............................................................................................................24
B.B.Q. Spare Ribs (to bite)......................................................................................................25
B.B.Q. Spare Ribs (fall from bone).........................................................................................26
Cured Ham (smoked or canned)..............................................................................................27
Bacon.......................................................................................................................................28
Fresh Sausage..........................................................................................................................29
Roast Suckling Pig ..................................................................................................................30
SECTION 4; Preparing Poultry Products
Chicken; Splits, Quarters.........................................................................................................33
Chicken; Breast Boneless........................................................................................................34
Duck Halves............................................................................................................................35
Turkey .....................................................................................................................................36
Turkey Breast, Foil-wrapped...................................................................................................37
(Continued on following page.)
Table of Contents, continued
SECTION 5; Preparing Lamb Products Page
Leg of Lamb, Boneless............................................................................................................39
Hotel Rack of Lamb ................................................................................................................40
Lamb Shanks...........................................................................................................................41
SECTION 6; Preparing Baked Goods
Demi-loaves.............................................................................................................................43
Sheet Pizza ..............................................................................................................................44
Bread Pudding.........................................................................................................................45
Croissants ................................................................................................................................46
New York-Style Cheescake.....................................................................................................47
Turnovers, Fruit-filled, Frozen................................................................................................48
Fruit Pies, Frozen ....................................................................................................................49
Cookies....................................................................................................................................50
SECTION 7; Preparing Miscellaneous Products
Lobster Tails............................................................................................................................53
Salmon, Poached.....................................................................................................................54
Fillets; Scrod and Snapper.......................................................................................................55
Bread Dressing........................................................................................................................56
Stuffed Cabbage Rolls.............................................................................................................57
Lasagna....................................................................................................................................58
Vegetables, Canned.................................................................................................................59
Vegetables, Frozen..................................................................................................................60
Baked Potatoes........................................................................................................................61
Oven-Roasted Garlic...............................................................................................................62
SECTION 8; Rethermalizing
Rethermalizing ........................................................................................................................65
School Foodservice .................................................................................................................65
Health Care / Elder Care..........................................................................................................65
Correctional / Penal Institutions..............................................................................................65
SECTION 9; General Information and Reference Sheets
Cleaning your CRES COR Oven ............................................................................................67
Helpful Information.................................................................................................................68
Determining Meat Shrinkage ..................................................................................................69
Meat Shrinkage Work Sheet....................................................................................................70
SECTION 1
INTRODUCTION and
OPERATING INSTRUCTIONS
for
ROAST-N-HOLD™ and
RETHERM OVENS
Section 1 Page
Introduction................................................................................................................ 1
How to Operate Your CRES COR Roast-N-Hold Oven.......................................... 2
Microprocessor w/ Probe Model Operating Instructions........................................... 3, 4
Advantages of Low-temperature Cooking................................................................. 5
Low Temperature Cooking........................................................................................ 6
Adding Water to Sheet Pans...................................................................................... 7
The All Important Hold Cycle................................................................................... 7
1
INTRODUCTION
TO YOUR
ROAST-N-HOLD™ and
RETHERM OVENS
This cooking guide for CRES COR Roast-N-Hold/
ReTherm Convection Ovens was developed for you
as a useful reference when using your new unit.
The enclosed information will help you become
familiar with your new piece of equipment and should
answer many of your questions.
Experiment with your own house specialties and
you’ll see that the CRES COR slow-roasting oven can
do much more than produce an excellent roast with
minimum shrinkage.
For additional assistance, please contact your
Customer Care Department.
TOLL FREE 1-877-CRESCOR (1-877-273-7267)
FAX-1-800-822-0393 www.crescor.com
2
HOW TO OPERATE YOUR
ROAST-N-HOLD™ and
RETHERM OVEN
FRONT PANEL OF HOT TOP UNIT
HOW TO START UNIT
(for first time operation only):
A new oven needs to “burn off” factory oils
before it is used for the first time.
DO NOT load food into oven until this is
done!
1. Push ON/OFF switch to “ON”. Yellow
hold light will light.
2. Set ROASTING thermostat to
350° F/177° C.
3. Set HOLDING thermostat to
150° F/66° C.
4. Set timer to one (1) hour. (See timer
instructions in To Set Cooking Time
under Manual Operations.)
5. Close oven vents. (Ref. pg. 7)
6. Allow oven to run automatically for one
hour of ROAST cycle and 30 minutes of
HOLD cycle.
COOKING PROCEDURE
1. Turn Power Switch to On.
Pilot light will go on.
2. Set ROASTING thermostat to desired
temperature.
3. Set HOLDING thermostat to desired
temperature (140°F/60°C).
4. Set TIMER for desired number of hours.
This will activate ROASTING
thermostat.
5. After preheat period:
a) Load oven with food product
b) Close doors, making sure that oven
vents are closed when roasting meats
(Ref. pg. 7).
c) Check TIMER for proper cooking
time.
NOTES:
1. Be sure to allow for a minimum holding
time of 2-3 hours for roasted meats.
2. Do not load oven with frozen meat
products. If, in an emergency, this
situation does occur, increase roasting
time by 50 percent to allow for thawing
period.
3. When TIMER is not engaged, the oven
will remain in the HOLDING mode at
whatever temperature is set.
3
MICROPROCESSOR WITH PROBE
MODEL OPERATING INSTRUCTIONS
PROBE MODEL CONTROL PANEL
HOW TO START UNIT
(for first time operation only):
A new oven needs to “burn off” factory oils
before it is used for the first time.
DO NOT load food into oven until this is
done!
1. Push ON/OFF switch to “ON”. Yellow
hold light will light.
2. Set ROASTING thermostat to
350° F/177° C.
3. Set HOLDING thermostat to
150° F/66° C.
4. Set timer to one (1) hour (see timer
instructions in To Set Cooking Time
under Manual Operation).
5. Close oven vents (Ref. pg. 7).
6. Allow oven to run automatically for one
hour of ROAST cycle and 30 minutes of
HOLD cycle.
FOR MANUAL (Timer) OPERATON:
1. Push TIMER/PROBE switch to
TIMER.
2. Push ON/OFF switch to “ON”. Yellow
hold light will light and POWER
LIGHT will come on.
3. Set the ROAST thermostat and the
HOLD thermostat to desired
temperatures.
4. TO SET COOKING TIME:
a) Press the UP Arrow-button (on the
TIMER) to increase the time. The
longer the button is held down, the
faster the time will increase.
Pressing the DOWN Arrow-button
(using the same method) will cause
the time to decrease.
b) Press START/STOP button on
TIMER to begin cooking cycle.
Red roast light will light up.
TIMER will count down to 0.00.
The timing light on the TIMER will
flash.
c) Cooking time can be changed while
oven is in ROAST mode.
1) Press START/STOP button.
2) Adjust time by using UP and
DOWN Arrow-buttons.
3) Press START/STOP button to
restart oven.
5. Preheat oven for 30 minutes before
loading food.
6. Place food into preheated oven.
Close doors and double-check
cooking time and the ROAST and
HOLD thermostats. Make sure oven
is in ROAST mode with red light on.
7. Oven will automatically switch to
HOLD at end of cooking time. The
timer will “beep” and the yellow
HOLD light will light up. The timer
display will be 00.00.
4
MICROPROCESSOR WITH PROBE MODEL
OPERATING INSTRUCTIONS (cont’d.)
FOR AUTOMATIC (Probe)
OPERATION:
1. Push ON/OFF switch to ON. Yellow
hold light will light up.
2. Push TIMER/PROBE switch to PROBE.
3. Preheat oven for 30 minutes on hold
thermostat.
4. Insert probe jack into receptacle located
inside the oven top, near fans. The probe
temperature display will show the digital
temperature of probe.
5. Set the roast, hold and probe thermostats
to desired temperatures.
6. Put sanitized probe into the center of the
food product. Make sure the food is in
the center of the pan, in the center of the
oven.
7. Push PROBE START button. Oven will
switch to roast mode and red roast light
will light up. The probe temperature
display will show internal temperature of
food being cooked.
8. Oven will automatically switch to hold
when the food reached the temperature
you set on the probe thermostat. The
yellow hold light will light up. The
probe display will continue to show the
internal temperature of the food.
NOTE: Always set the probe thermostat
below the desired final internal temperature
to allow for cooking “carryover” or “setup”
of food. The internal temperature will rise as
food absorbs heat from the oven during cool
down to the hold temperature.
FOR HOLDING OPERATION ONLY:
1. Push TIMER/PROBE switch to TIMER.
2. Push ON/OFF switch to ON. Yellow
hold light will light up.
3. Set hold thermostat to desired
temperature.
4. Allow for preheat. Do not set timer.
TO SHUT DOWN UNIT:
Push ON/OFF switch to OFF.
NOTE: Ventilating fans will continue to run
until cabinet is cool. Do not disconnect the
power supply to the cabinet while the
ventilating fans are still operating.
Do not change the mode of TIMER/
PROBE switch while oven is operating in
Roasting Cycle.
Oven must be OFF, or in the Hold Cycle,
to change the timer or probe operation.
5
ADVANTAGES OF SLOW,
LOW-TEMPERATURE COOKING IN
ROAST-N-HOLD™ OVENS
5 Reduces meat shrinkage and food costs.
5 Enhances flavor development.
5 Retains natural meat juices within the product.
5 Allows maximum enzyme action on meat products.
5 Uniformly coked meat from center to exterior.
5 Requires less total energy consumption.
5 Easy clean-up due to less spattering inside walls.
5 Exhaust hoods and vents* unnecessary.
5 Achieves proper browning and carmelization.
5 Safely conforms with all health standards.
5 Cooks and holds in one unit, “Set it and forget it.”
5 Saves labor when roasting overnight.
5 Mobile unit; may be located wherever needed.
*Local codes may vary.
6
LOW TEMPERATURE COOKING
When was the last time you received an invoice
where all the prices were less than the week before?
We constantly see our costs increasing and are forced
to raise menu prices. The customer in turn looks for
the quality and/or quantity that he or she expects for
the price that is paid.
To provide our clientele with a satisfying
product is the main task we all face day in and day
out. That is why the Roast-N-Hold Convection Oven
has been developed. Our CRES COR Oven will
make your job more enjoyable when you can depend
on a consistently well-prepared product.
In addition, these ovens provide labor and
energy savings that further increase the profitability of
serving high cost items, such as red meats and fowl.
When cooking a 20 lb. Roast at 350° F. in a
standard convection oven, the meat shrinkage will
average 25%. In most cases the loss will be higher.
This means a loss in the number of portions served and
in actual dollars.
This shrinkage is not simply a loss from
rendering fats but an actual loss in meat fluids and a
reduction in size. The meat is composed of
approximately 70% water and at higher temperatures
this moisture is cooked off and lost in the atmosphere.
With the CRES COR Roast-N-Hold Oven you
will prepare your roasts at lower temperatures which
will prevent the loss. The average shrinkage will be 7
to 10% and the additional portions served will reduce
the food cost on that product.
The CRES COR Roast-N-Hold is a convection
oven with a gentle air flow which removes the thermal
blanket of insulating cold air surrounding the meat. There
is no strong blast of hot air to force the product to cook,
but a continuous circulation around the product which
results in an evenly cooked roast with excellent browning
and appearance.
This is the reason for placing the food up on
raised wire grids.
Being a convection oven, the flavor of the
meat produced is truly that of a roasted meat; not
steamed or simmered. The hold cycle of the CRES
COR Oven produces a tender, flavorful roast with
the convenience of holding the meat without
additional cooking or increased doneness. The
natural enzymes within the meat are allowed to
tenderize by breaking down connective tissues. The
suggested minimum holding time on beef products is
two to three hours to allow for this enzyme action.
During this period the meat also has a chance to
develop its own flavor within the roast. This flavor
development is similar to the time allowed for
simmering a stew on the stove. As time is allowed
for the roast to hold, the meat takes on a better
flavor. Seasoning a roast becomes unnecessary – an
important advantage when dealing with low-sodium
diets.
The elimination of waste also helps to
reduce the food cost. The oven will hold the meat at
the same degree of doneness for a lunch period and
then for the dinner hour. Leftover meat will be
tender and tasty for the next serving period. Also,
by using a proper handling technique for reheating,
unserved roasts are not lost to the stock pot or soup,
but sold for their original mark-up.
Once programmed, the roast placed in the
oven in the evening will be perfectly prepared for
service the following day. The chef does not need to
check the meat, thus saving valuable time.
Any meat cooked overnight may also be
placed in a separate holding cabinet in the morning,
thus freeing the oven to prepare additional items
such as demi-loaves, pies, custards and braised
items. With a temperature range to 350°F. you’ll
find the CRES COR Roast-N-Hold Oven is a
versatile piece of equipment in any operation.
7
ADDING WATER TO SHEET PANS
With some less dense products like
spare-ribs you will find that we achieve
better results by adding a little warm water to
the sheet pans directly beneath the raised
wire grids holding the food item.
When roasting and holding one or
two roasts in a full-size oven overnight,
placing water in the sheet pans is also
recommended.
THE ALL IMPORTANT HOLD CYCLE
When inspecting your next delivery
of beef from your purveyor, pay close
attention to the amount of marbling and the
color of the fat covering. As we continue to
purchase and serve vast amounts of beef in
our operations, the suppliers are providing a
different product today ten that of ten years
ago. The grazing time has been increased
and the grain feed lot time reduced. This
results in less marbling and a yellow tint to
fat coverings. To counteract the resulting
less tender product, many operations inject
the live cattle with enzyme solutions such as
papain.
Enzymes and co-enzymes (or
activators) are naturally present in some meat
products, but by increasing their
concentration we increase the tenderizing
action. Enzymes are characteristically heat
liable or subject to inactivation by high
temperatures. They are most active in
temperature ranges of approximately 100-
130° F / 38-54° C. Once a temperature
above 160° F / 71° C is attained, they
become inactive.
The automatic hold cycle on the
Roast-N-Hold ovens allows the enzymes the
opportunity to break down (hydrolyze) tough
connective tissue. Once the internal
temperature of the meat is above 160° F / 71°
C, no further tenderization takes place. We
suggest a minimum holding time of three
hours. When planning your roasting time,
allow for the additional holding time before
the meat is needed for service.
By roasting overnight you will have
helped tenderize you meat as well as allowed
time for flavor development. The flavor
development is similar to the change in taste
of a pot of stew simmering on the stove. To
test the flavor of a stew now, then again after
simmering for an hour or two, there is a
noticeable difference without any ingredients
being added; it is a natural process.
Convenience is also an added asset
of automatic hold cycles on the Roast-N-
Hold, especially, if the service of a banquet is
delayed through no fault of your own. In
testing we
have held for 24 hours, without
any further cooking or doneness of meat
and without any bacterial growth or
souring. FDA’s recommended holding
time for beef with an internal doneness of
130° F / 54° C is 121 minutes for
properly destroying harmful organisms.
Once destroyed, they are not reactivated
but can be introduced later by improper
handling.
NOTE: Recipes in this manual include
Manufacturer’s suggested holding times
and temperatures.
ALWAYS comply with your local Health
Code’s regulations.
8
SECTION 2
PREPARING
BEEF PRODUCTS
in
ROAST-N-HOLD™ OVENS
SECTION 2 Page
Prime Rib......................................................................................................................9
Outside Round............................................................................................................10
Ribeye.........................................................................................................................11
Steamship Round........................................................................................................12
Strip Loin, Boneless...................................................................................................13
Pulled Tenderloin .......................................................................................................14
Short Ribs...................................................................................................................15
Swiss Steak.................................................................................................................16
Corned Beef Brisket...................................................................................................17
Cooked Sliced Beef w/ Gravy....................................................................................18
Reheating Prime Ribs.................................................................................................19
Steak Proofing............................................................................................................19
9
PRIME RIB – NAMP #109
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Seasoning at personal discretion.
PIECES PER TRAY................................
.
Two, 20-22 lb. each.
TRAYS PER OVEN LOAD ...................
.
Seven 18”x26” pans w/ wire grid, maximum
TOTAL WEIGHT ...................................
.
310 lb./140.6 kg.
COOKING TEMPERATURE.................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
8 hours.
HOLDING TEMPERATURE.................
.
140° F/60° C.
HOLDING TIME....................................
.
3-4 hours minimum.
DEGREE OF DONENESS .....................
.
Medium rare.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. Reheat at 250° F/121° C, to desired
internal temperature.
2. For roasting fewer pieces, see chart
below.
3. When roasting and holding 1 or 2 roasts
overnight, use of warm water placed in the
sheet pans is highly recommended.
(ref. Sec. 1, page 7.)
4. There will be NO pan drippings for
“scratch” au jus
5. For extended holding (over 6 hours), use
150° F/66° C holding temperature.
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 1-3 4-6 7-9 10-12 13-14
Total Weight (lbs.) 22-66 88-132 154-198 220-264 286-310
Cook Time (hrs.) 3.5 4.5 6 7 8
Chef’s Added Notes:
10
OUTSIDE ROUND WHOLE TOP ROUND – NAMP
#168
Roast-N-Hold™ Oven
INITIAL PREPARATION ...................... Seasoning at personal discretion.
PIECES PER TRAY................................ Two, 18-20 lb. each.
TRAYS PER OVEN LOAD.................... Seven 18”x26” pans w/ wire grid, maximum
TOTAL WEIGHT.................................... 280 lb./127 kg.
COOKING TEMPERATURE................. Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME....... 8 hours.
HOLDING TEMPERATURE................. 140° F/60° C.
HOLDING TIME..................................... 3-4 hours minimum.
DEGREE OF DONENESS...................... Medium rare.
OVEN VENT........................................... Closed.
HELPFUL HINTS................................... 1. Reheat at 250° F/121° C, to desired
internal temperature.
2. For roasting fewer pieces, see chart
below.
3. When roasting and holding 1 or 2 roasts
overnight, use of warm water placed in the
sheet pans is highly recommended.
(ref. Sec. 1, page 7.)
4. For extended holding (over 6 hours), use
150° F/66° C holding temperature.
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 1-3 4-6 7-9 10-12 13-14
Total Weight (lbs.) 20-60 80-120 140-180 200-240 260-280
Cook Time (hrs.) 3.5 4.5 6 7 8
Chef’s Added Notes:
11
RIB EYE, LIP ON – NAMP #112A
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Seasoning at personal discretion.
PIECES PER TRAY................................
.
Three, 12-14 lb. each.
TRAYS PER OVEN LOAD ...................
.
Eight 18”x26” pans w/ wire grid, maximum
TOTAL WEIGHT ...................................
.
288 lb./130.6 kg.
COOKING TEMPERATURE.................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
7 hours.
HOLDING TEMPERATURE.................
.
140° F/60° C.
HOLDING TIME....................................
.
3-4 hours minimum.
DEGREE OF DONENESS .....................
.
Medium rare.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. Reheat at 250° F/121° C, to desired
internal temperature.
2. For roasting fewer pieces, see chart
below.
3. When roasting and holding 1 or 2 roasts
overnight, use of warm water placed in the
sheet pans is highly recommended.
(ref. Sec. 1, page 7.)
4. For extended holding (over 6 hours), use
150° F/66° C holding temperature.
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 1-3 4-8 9-12 13-18 19-24
Total Weight (lbs.) 14-42 56-112 126-168 182-252 266-336
Cook Time (hrs.) 3.5 4.25 5 6 7
Chef’s Added Notes:
12
STEAMSHIP ROUND w/ HANDLE; RUMP
And SHANK OFF – NAMP #160
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Seasoning at personal discretion.
PIECES PER TRAY................................
.
One per each 18” x 26” pan (50 to 60 lbs.)
TRAYS PER OVEN LOAD ...................
.
Three pans, maximum.
TOTAL WEIGHT ...................................
.
180 lb./81.6 kg.
COOKING TEMPERATURE.................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
14 hours.
HOLDING TEMPERATURE.................
.
150° F/66° C.
HOLDING TIME....................................
.
3-4 hours minimum.
DEGREE OF DONENESS .....................
.
Medium rare – 140°F/60°C internal temp.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. Cooking time for one roast; 9 hours.
Cooking time for two roasts; 12 hours.
Cooking time for three roasts; 14 hours.
2. When roasting a single piece, place
toward center of oven.
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 1 2 3
Total Weight (lbs.) 60 120 180
Cook Time (hrs.) 9 12 14
Chef’s Added Notes:
13
STRIP LOIN BONELESS – NAMP #180
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Seasoning at personal discretion.
PIECES PER TRAY................................
.
Three, 10-12 lb. each.
TRAYS PER OVEN LOAD ...................
.
Eight 18”x26” pans w/ wire grid, maximum
TOTAL WEIGHT ...................................
.
288 lb./130.6 kg.
COOKING TEMPERATURE.................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
6 hours.
HOLDING TEMPERATURE.................
.
140° F/60° C.
HOLDING TIME....................................
.
3-4 hours minimum.
DEGREE OF DONENESS .....................
.
Medium rare.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. For roasting fewer pieces, see chart
below.
2. Do not overcrowd pans or allow roasts to
rest against each other. Restriction of air-
flow will produce uneven cooking.
3. Try marinating in a red wine-and-herb
brine prior to roasting.
4. When roasting and holding 1 or 2 roasts
overnight, use of warm water placed in the
sheet pans is highly recommended.
(ref. Sec. 1, page 7.)
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 1-3 4-8 9-12 13-18 19-24
Total Weight (lbs.) 12-36 48-96 108-144 156-216 228-288
Cook Time (hrs.) 3 3.50 4.25 5 6
Chef’s Added Notes:
14
PULLED TENDERLOIN – NAMP #189
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Season or bard as desired. Coating with oil
is recommended
PIECES PER TRAY................................
.
Five, 5-7 lb. each.
TRAYS PER OVEN LOAD ...................
.
Eight 18”x26” pans w/ wire grids.
TOTAL WEIGHT ...................................
.
200 lb./90.72 kg.
COOKING TEMPERATURE.................
.
Preheat oven to 350° F/177° C.
APPROXIMATE COOKING TIME ......
.
2.5 hours.
HOLDING TEMPERATURE.................
.
140° F/60° C.
HOLDING TIME....................................
.
For convenience only (see Helpful Hint #4).
DEGREE OF DONENESS .....................
.
Medium rare.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. With quality tenderloin, holding time for
allowing meat to set up is unnecessary.
2. For roasting fewer pieces, see chart
below.
3. Room tempering not included in cooking
time consideration.
4. If holding for service, open doors,
allowing 350°F/177°C air to escape as
quickly as possible. Hold at 140°F/60°C.
NOTE: Cooking times may vary with individual circumstances.
Total pieces per load 10 20 30 40
Total Weight (lbs.) 28-70 140 210 280
Cook Time (hrs.) 1 1.5 2 2.5
Chef’s Added Notes:
15
SHORT RIBS – NAMP #123
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
.
Pre-brown and lay out in 12” x 20” hotel
pan w/ brown sauce; cover with foil or
plastic film.
TRAYS PER OVEN LOAD ...................
.
Eight pans (in CO-151-F-1818B); thirty to
Forty 8 to 10-oz. Portions per 12” x 20” x 4”
Pan (16 pans in CO-151-FUA12B).
COOKING TEMPERATURE.................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
4.5 hours.
HOLDING TEMPERATURE.................
.
170° F/77° C.
HOLDING TIME....................................
.
3-4 hours; may be held overnight
DEGREE OF DONENESS .....................
.
Well.
OVEN VENT ..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. When braising with this method you will
not experience burning around sided or top
of pan.
2. May be cooked ahead and reheated for
service.
NOTE: Cooking times may vary with individual circumstances.
Oven Model CO-151-F-1818B CO-151-FUA12B
Total pans per load 8 16
Total portions 240-320 320-640
Cook Time (hrs.) 3.25 4.5
Chef’s Added Notes:
16
SWISS STEAK
Roast-N-Hold™ Oven
INITIAL PREPARATION......................
Season, flour, pre-brown. Shingle in
12” x 20” x 4” hotel pan, cover in brown
sauce; cover pan with foil or plastic film.
PIECES PER TRAY ...............................
.
30-40 portions of 6-8 oz. per 12” x 20” x 4”
pan.
TRAYS PER OVEN LOAD ...................
.
8 in CO-151-F-1818B; 16 in CO-151-FUA12B
COOKING TEMPERATURE ................
.
Preheat oven to 250° F/121° C.
APPROXIMATE COOKING TIME ......
.
4 hours.
HOLDING TEMPERATURE.................
.
170° F/77° C.
HOLDING TIME....................................
.
3-4 hours; may be held overnight
DEGREE OF DONENESS.....................
.
Well.
OVEN VENT..........................................
.
Closed.
HELPFUL HINTS...................................
.
1. May be served or precooked and reheated.
2. Jardinere of vegetables may be prepared
separately and used at plating.
NOTE: Cooking times may vary with individual circumstances.
Oven Model CO-151-F-1818B CO-151-FUA12B
Total pans per load 8 16
Total portions 240-320 320-640
Cook Time (hrs.) 3 4
Chef’s Added Notes:
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55
  • Page 56 56
  • Page 57 57
  • Page 58 58
  • Page 59 59
  • Page 60 60
  • Page 61 61
  • Page 62 62
  • Page 63 63
  • Page 64 64
  • Page 65 65
  • Page 66 66
  • Page 67 67
  • Page 68 68
  • Page 69 69
  • Page 70 70
  • Page 71 71
  • Page 72 72
  • Page 73 73
  • Page 74 74
  • Page 75 75

Cres Cor Roast-N-Hold Operating instructions

Cres Cor
Brand
Cres Cor
Model
Roast-N-Hold
Category
Ovens
Type
Operating instructions
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents