2. White Mountain Hearth
  3. DVP72LKR Liner Kit for DVLL72BP Direct-Vent Boulevard 72

White Mountain Hearth DVP72LKR Liner Kit for DVLL72BP Direct-Vent Boulevard 72 Owner's manual

  • Hello! I am an AI chatbot trained to assist you with the White Mountain Hearth DVP72LKR Liner Kit for DVLL72BP Direct-Vent Boulevard 72 Owner's manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
38219-0-1017 Page 1
Installation
CAUTION
Sharp edges! To avoid injury, wear safety gloves and
glasses to install liner.
1. Refertothereplaceinstallationmanualforremoval
oftheBarrierandGlassDoorassembliespriorto
installationoftheporcelainlinerkit.
2. RemovedecorativemediafromHearthandburner
cover.
3. Carefullyunpacktheblackglassliners,verifythat
allcomponentsareincluded,andinspectforhidden
damage,priortoinstallation.
4. Removethefrontglassretainer(HearthLedge)by
liftingitupandout,thensetitaside.
DVP72LKR-1 BLACK GLASS LINER KIT
FOR USE ON: DVLL72BP SERIES FIREPLACES ONLY
LEAVE INSTRUCTIONS WITH THE APPLIANCE FOR FUTURE REFERENCE.
INSTALLATION INSTRUCTIONS
Carton Contents:
• RearPanel-BlackGlass
• SidePanel-BlackGlass
(Qty.2)
• Bracket,Rear
GlassPanel(2)
• ScrewPackage
• SideGlassPanel
Bracket(Qty.2)
• Insulation
14-1/2”x22-1/2”(Qty.2)
Tools Needed:
• Gloves
• EyeProtection
• 5/16”HexDriver
5. InstallthetwoSideGlassPanelBracketsatthefront
leftandrightsideopeningsofthereboxwithtwo
5/16x1/2-inchscrewseach.Thesebracketsmustbe
installedsothe“u”shapebreaksarefacingforward.
See Figures 1 and 2.
SIDE GLASS
PANEL BRACKET
Figure 1
REAR GLASS
PANEL BRACKET
Figure 2
6.
PlaceoneofthelongRearGlassPanelBracketsat
thebackofthereboxandontopofthestainlesssteel
burnercoverscreen,thencenteritlefttoright.Placethe
bracketagainsttherearwallwiththelongange(with
holes)extendingdownbehindtheburnercoverscreen.
NOTICE:Thetwohandbendtabslocatedateachend
shouldbepointingupward@about90degrees.
38219-0-1017Page 2
7. Placeonepieceofinsulationagainsttherightside
oftherebox.Foldthe14-1/2inchhighpieceof
insulationoveronitselfsothecutedgesaretoward
thefrontofthereplace.Whenoverlapped,leave
approximatelya5to6inchdifferencebetweenthe
frontedges.Proptheinsulationagainstthesidewall
sothefrontedgeis2to3inchesfromthefrontfaceof
therebox.See Figure 3.
Figure 3
8.
InstalloneoftheSideGlassPanelsagainsttheside
insulationwiththeglossysidefacingyou.Raisethe
bottomedgeabovetheRearGlassPanelBracketand
insertthefrontedgeoftheglassintotherightside
bracket(installedinstep5).Gentlypivotthebackedge
oftheSideGlassPaneloutwarduntilitcontactsthe
endtabontheRearGlassPanelBracket,thenlower
theglasspaneltoretaintheglasspanel.See Figure 4.
Figure 4
9. Repeatsteps7and8toinstalltheleftinsulationand
leftglasspanel.
10. ToinstalltheRearGlassPanel,placethebottomedge
ofthepanelintotheRearGlassPanelBracket,and
betweenthesideglasspanels.Thebottomedgeofthe
glasswillnestbetweenthefrontedgeoftheretainer
andtwosmalltabsabout9inchesfromeachendof
theretainer.
11. SlowlypivottheRearGlassPanelupwardand
betweentheRightandLeftSideGlassPanels.Some
shiftinglefttorightmaybeneededtocenterallthree
glasspanelswiththerearretainer.
12. OncetheRearGlassPanelisvertical,installtheother
RearBracketoverthetopoftheRearGlassPanel.
TheRearBracketwillbeinstalledsothelongange
(withholes)arevisibleabovetheglasspanelandline
upwiththepilotholesintherearoftherebox.See
Figures 5 and 6.
REAR GLASS
PANEL BRACKET
REAR GLASS PANEL
Figure 5
REAR GLASS
PANEL BRACKET
REAR GLASS PANEL
5/16 X ½”
HEX SCREW
Figure 6
13. Install(4)#10x1/2-inchScrewstosecuretheTop
RearGlassBracket.Refertothepartsillustrationon
page4toidentifytheorientationoftheindividualparts.
14. Checktoseethatallexposedinsulationistucked
behindthesidepanels.Ifnecessary,trimawaythe
excessinsulationaway,usingautilityknife.
15. ReplacetheGlassRetainerremovedinStep#4.
16. Cleantheglasslinerswithasoftclothtoremovedirtor
ngerprints.Donotuseabrasivecleanersonglass.
17. Adddecorativecrushedglassmediaasrequired.
18. ReplacetheGlassDoorandBarrierScreen
assemblies.
38219-0-1017 Page 3
1
2
2
4
4
3
3
INDEX
NUMBER
PART NUMBER DESCRIPTION
QUANTITY
SUPPLIED
1 R12472 RearLiner,BlackGlass 1
2 R12473 SideLiner,BlackGlass 2
3 38216 Bracket,RearGlassPanel 2
4 38215 Bracket,SideGlassPanel 2
N/S R2737 Screw,#10x1/2inch 8
N/S R11285 Insulation-SidePanel 2
N/S-NotShown
38219-0-1017Page 4
www.empirecomfort.com
Empire Comfort Systems Inc.
Belleville, IL
Ifyouhaveageneralquestion
aboutourproducts,pleasee-mail
usat[email protected].
Ifyouhaveaserviceorrepair
question,pleasecontactyourdealer.
/