Ackerman K1 User manual

Brand
Ackerman
Model
K1
Category
Stoves
Type
User manual
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
www.ackerman.pl 9
FREESTANDINGSTOVES
GENERALINFORMATION
Wheninstallingthedevice,observetherequirementsoftheapplicablestandardsandregulationsofthenationaland
local(ifapplicable)law;andinparticularStandardEN13240:2008.
Thestovecanbeconnectedonlytotheindividualchimney.
Intheroomwherethestoveisinstalled,thegravitationalintake‐exhaustmustbeprovided.Thisinstallationcannot
giverisetonegativepressureintheroom.
Airinletgrillesshouldbeconstructedso,asnottoshutthemselfoffandsothatitcannotgetblockedoff.Thesevents
shouldbelocatedso,asnottocausedrafts.Preservingthepurity of the air vents and the bandwidth is the
responsibilityoftheuser.
Incaseofcombustionofsootinthechimneyoneshould:
• callthefiredepartment;
• burnthestovedownbyscrappingof embersandfuel,and thentightlyclosethestove(door,inletsofthe
primaryandsecondaryairanddamper,ifequipped).
Freestandingstovesareheatingdevicesbyperiodicburning.
Stovesshouldbeinstalledonthegroundwithsufficientbearingcapacity.Incaseofinsufficientbearingcapacityone
should take appropriate measures, for example use plates to distribute the load in order to obtain the sufficient
capacity.
SPECIFICATIONS
ACKERMANtiledstovesaredesignedtoheathouses,smallcommercialandservicepavilions,withsolidfuel.Awide
rangeofmodelsallowsflexiblearrangementofanyinteriortocreateanatmosphereofcomfort,aestheticsandheat.
NominalheatoutputcalculationisbasedonthebasisofthePN‐EN13240:2008.Reachingthedesiredpowerdepends
ontheuseoftheproperfuel(withadequatecaloriesandhumidity),thefiringupandaddingoffuel,adjustmentofthe
flowofair,thechimney,aswellastheorganizationofanefficientheattransfer.Forthecalculationoffuelneeded,
one should consider that heating of one cubic meter requires from 25 to 180 watts, depending on the location,
isolation,outdoortemperatureandwind.Itisknownthatintermsofpriceandcalorificvaluecorrelation,themost
economicsolutionisheatingwiththeuseofsolidfuels.
Stoveparameters
Model
Dimensions
(mm)
(width/depth/
height)
Flue
Gasses
Outlet
(mm)
Weight
(kg)
Model
Dimensions
(mm)
(width/depth/
height)
Flue
Gasses
Outlet
(mm)
Weight
(kg)
K1 580/360/910 150 85 K5 760/390/1165 150 115
K2 580/360/1150 150 95 K6 750/500/1200 150 210
K3 750/390/950 150 110 K11 590/360/815 150 65
K4 760/390/980 150 110
www.ackerman.pl 10
Woodparameters
Model
Heating
power
[kW]
Loadingof
wood
[kg/h]
Efficiency
[%]
СОmissionsin
thecombustible
products[%]
FlueGas
temp.
[°C]
Chimneydraft
[Pa]
K1,K2 6 1‐1,5 66 0,43 242 12
K3,K4,K5 7 1‐1,6 66 0,43 242 12
K6 8 1,5‐2 73 0,18 264 12
K11 6 1‐1,5 77 0,30 281 12
INSTALLATION
Thefurnacecanbeliftedonlyformetalparts.Donotpressthetiles.Damagescausedbyimproperhandlingand
installationarenotcoveredunderwarranty.
Furnaceisequippedwithastableandfireproofbaseorlegs.Toprotectthefloor,youputitonastable,heat‐resistant
platethatshouldextendatleast50cmfromthefrontand30cmatthesidesofthestove.Atadistanceof150cm
fromthestove,oneshouldnotstoreanycombustiblematerialsandthosethatcanbedestroyedbyhotair.Thestove
must beinstalled by a suitablyqualifiedperson andin accordance with the law. Connectingelements (rosette and
smoke pipes) should be joined together in a stable and durable way, so that nothing can get inside the furnace.
Diameterofconnectingpipesshouldbethesameasthediameteroftheflueofthefurnace.Stoveshouldbeoperated
withaseparatechimney.Ensureaccessofairtothefurnaceinanamountofatleast10m3/hperkWofpower.If
necessary, you can make intake of air fromthe nextroom or outside.The device can not operate in conditions of
inadequateamountofairasaresultofgravitationalforcesorforced.Thismaycauseweakcombustionorevensmoke
cangetintotheroom.
INSTRUCTIONSFORUSE
Fuel
Useonlyhardwoodorbriquetteswithout.Itisnecessarythatthewoodusedwasdry.Drywoodiswhenitshumidityis
lessthan20%.This condition is achievedwhenthewoodisstoredinadry,airyplaceforatleasttwoyears.Wood
shouldbechoppedupthewaythatitsthicknessisbetween5and15cm.
Whynottousewetwood:
1. Wood moisture lowers the temperature during combustion. Much of the heat energy is consumed in the
processofwaterevaporation,andtherestofenergymaynotbeenoughtoreachenoughlevelofheat.
2. Evaporation of water reduces the burning temperature and contributes to the excessive soot formation,
whichformstheblackcoatingontheburningchamber,ontheglassandinthechimneyconnection.
3. Burningofwetwooddoesnotallowtoreachtheadequateburningtemperature,andthusgasescontaina
biggeramountofharmfulsubstances.
Firingup
The purpose offiring up is to warmthe burning chamberand chimney connectionsto a temperaturethat ensures
adequatedraft,whichwillensurecompleteandstableburning.
1. Cleantheashfromthestovebeforefiringup.
2. Opentheairintakevalvesandexhaustoutlet(ifequipped).
3. Puttwopiecesofwoodintotheburningchamber,paralleltoeachother,onthetwosidesoffurnace.
4. Tear old newspapers and spread them along the front of the burning chamber. Do not use glossy or
impregnatedpaper.
5. Placesmallpiecesofdrywoodonpaper.Makesurethatthewoodwon’tfallduringfiringup.Thenaddlarger
woodpiecesandplacethemonthestack.
6. Ignitethepaper.Whenthenewspaperisburning,closethestovedoor.
7. Leavetheairsupplyvalvefullyopeneduntilthefirespreadstheentirecombustionchamber.
www.ackerman.pl 11
Firingupistoinflamethewoodforthefirsttime.
Howtoburnhardwood:
1. Onthelayerofembersplacetherightamountofwood.
2. Air inlet valve on ash container and flue gas damper (if equipped) should be fully opened for the first 5
minutesofloading.Atthattimethefireshouldspreadtotheentireburningchamber.
3. Whenthefirespreadedtotheentireburningchamber(around5minutesafterloading)completelyclosethe
air intake and flue gas damper (if equipped), and maintain this stateto burn the whole charge (about60
minutes).
4. 60minutesafterloadingandpriortomovementofembersonecanagainloadproperamountofwood‐the
furtherstepsseesections2and3
Howtoburnbriquettes:
1. Applytherightamountoffuelselectedonthelayerofembers.
2. Duringthefirstfiveminutesofloading,airinletvalveandflue gas damper (if equipped) should be fully
opened.Atthattimethefireshouldspreadtotheentireburningchamber.
3. Afterabout5minutesfromloading,whenthefirespreadedtotheentireburningchamber,oneshouldclose
theairinletonashcontainerby50%andclosethefluegasdamper(ifequipped).Maintainthisstatetoburn
outthecharge(about60minutes).
4. Afterabout30minutesfromloading,openfluegasdamper(ifequipped),moveloadonthegridinorderto
improveburningefficiencyandclosefluegasdamper(ifequipped).
5. After60minutesfromloadingandpriortomovementofembers,stovecanbeloadedagainwiththeproper
amountoffuel‐furtherstepsseesections2,3and4
Inordertopreventvolatilizationofexhaustgas,burningchambershouldbeclosed,exceptduringloadingoffuel,
firingupandscrappingofash.Itisforbiddentostoreflammablematerialsintheshelfundertheburningchamber.
Thefluegasdamper(ifequipped)reachesahightemperatureanditshouldbehandledwithprotectiveglove.
Thesignsofproperburning:
• Burningmustbeconductedinthepresenceofflamesuntilthewoodturnsintoheat.Theaimistoprevent
smolderingand smoke comingout. Smoke shouldnot appear whileburning ofwood and isa symptomof
improperburning.
• Ifinsidethefurnacearerefractorybricks,theyshouldkeeptheirnaturalyellow‐browncolour.
• Ifoneusesdrywoodandkeepssufficientairflow,duringeach adds the wood should immediately start
burning.
• glassoffurnaceshouldbecleanduringburning
• gasesescapingfromthechimneyshouldbetransparentorwhite.Greysmokemeansthatthereisaproblem
withburning.
Chimney
The chimney releases the gases produced in the burning process into the atmosphere.Draft in the chimneyis the
resultofcombinationoftheheightandthetemperaturedifferencebetweenthegasesinsideandoutside.Columnof
hotgasesinthechimneyislighterthanacomparablepolecoldairintheatmosphere,sothepressureatthebottom
ofthestackislessthanatmosphericpressure.Thisrelatively smallpressure differencecausesthe draft. Poordraft
causesproblemswithfiringup
andsmokegetsbackintothefurnace.Thiscanbeeliminatedduringfiringup,byusing
large quantities ofpaper anddry,quicklyburningsmallpieces of wood. Afterheating of burning chamber andthe
wallsofthechimney,thedraftisimproving.Foreconomicreasonsandformoreefficientheating,thechimneydraft
shouldbereducedtoabout5‐10Pa,afterfiringup.Keepinmindthatthesmokeshouldnotgobacktothefurnace.In
case of insufficientchimney draft,the firingup ofthe deviceshould be abandoned. In case of a problem with the
chimneydraftitisprohibitedtoclosetheairregulator.Airregulatoranddamper(ifequipped)mustbesetsothatthe
fuelwasburninginvisibleway.
Thechimneyandthestovemustberegularlyinspectedbyaqualifiedprofessional.
Themaincausesofinsufficientchimneydraft:
• Thesootonthewallsofthechimney,reducingitsdiameterandslowingdownthereleaseofsmoke;
• Crackedchimneywallsorlooserosette;
• Connecting pipes connected too loose or pushed too far into the chimney, reducing the diameter of the
exhaustoutletorblockingit;
www.ackerman.pl 12
• Useofthechimneythatistoosmallindiameter;
• Problemswiththedraftcanoccurifthetemperatureoutsidehasrecentlysignificantlyincreased.Thenfumes
cannotescapefromacoldchimney.Inthiscase,itisnecessarytofireupaparticularlylargeamountofpaper
andsmallpiecesofwood;
• Whentheroofisdraughty,orthereareopenwindowsontheupperfloor,theremaybe"astaircaseeffect",
resultinginreverseoverthechimney;
• Whenthechimneyisintheareaofhypertensioncausedbythewind.
Thefurnacedoesnot emitsmokeintotheroom,ifthereisacorrectconnection,servicingand maintenance.Ifthis
situationoccurs,ventilateimmediately,thenfindandremovethecauseofthesmoke.
Donotburntrash!
Trashburningleadstounpredictableconsequences,ascontrary todrywood,trashcontaindifferentchemicalsthat
react with each other during combustion. Each waste incinerationdoesnotcausetheirdestruction,and
transformationintheirchemicalcompositionproduceslargeamountoftoxicchemicals.Oneoftheproductsofpaper
andplasticcombustionistheformationofdioxin‐ahighlypoisonouschemicalthatdoesnotbreakdownandgets
into the tissues of animals and humans. All manufactured stoves are designed for the use of dry wood without
additives,adhesivesandpaints,aswellascoalwithlowsulphurcontent.Itisallowedtousetheusualnewspapers,
butonlytostartafire.
Donotburn:garbage,varnishedorpaintedwood,plywoodorthesurfaceofthewood,chipboardorcoal!
Cleaning,Careandmaintenance
Afterthepurchase,thefurnacemustbehandledwithcareandbeprotectedfrommechanicaldamages.Whenfiring
upforthefirstfewtimesthedeviceshouldoperateonslowruntoallowproperpartdilation.Thisprocessisintended
toeliminatethehighstresswhichcouldcausedeformationandthermalcracking.Thefurnaceispaintedwithaheat‐
resistantmaterialwhichsintersduringthefirsttwofiringupsandbecomesmechanicallystable.Whenthissubstance
sinters,theroommustbeadequatelyventilated.Whileopeningthefurnacedoorstoaddfuel,becautiousanddon’t
let the burning elements to come out fromthe burningchamber. The power of the furnace can be controlled by
adjustmentoftheairsupplyvalveandtheflueoutlet(ifequipped)Donottouchthestovewithbarehandswhileitis
hot.Ashpanshouldbecleanedregularly.Donotdisposeoftheashtoplasticpackaging.Regularlycleanthesmoke
ductsandtubesinthefurnaceconnection.Thesurfaceof thestovecanbecleaneddrygentlyandwithsoft brush.
Ceramicsurfacescanbecleanedwithadampclothwithsmallamountofdetergent.Itisforbiddentowetcleanthe
steelelementsofstove,becausethepaintisnotresistanttorust.Itisnotasignificantproblem,ifduetooverheating
of paint, its colour changes to grey, rust stains appear or part of the surface gets damaged. Losses can be
supplementedwithspraypaint.Theglassshouldbecleanedwithadampclothand,ifnecessary,bymeansofspecial
measures. Glass should be cleanedwhen it iscold. While using a charcoal, particularattentionshould be givento
regularandthoroughcleaningofallpartsofthestove.Topreventcondensationandpossiblecorrosionduringlong
periodsofnon‐use(f.eg.insummer),thestoveshouldbecleanedfromtheashesandtherestoffuel.Leavethedoor
ajar,andthevalvesopen‐forbetteraircirculationaroundandthroughthefurnace.
Donotmakeanyunauthorizedmodificationstothedesignandappearanceofthestove!Duringrepairs,useonly
originalmanufacturer`sspareparts!
Under sanction of losing guarantees it is not permitted to make any changes to the construction of the device.
Unlesstheeventisthefaultofthemanufacturer,themanufacturerdoesnotacceptanyliabilityforeventsoccurring
asaresultofunauthorizedchangesinthedesignoftheequipment,inparticularchangesthatarenon‐compliant
withtechnicalstandards.
Theeventslistedbelowarenotsubjecttoclaimsagainstthemanufacturerandarenotcoveredbythewarranty:
• theformationofcondensation;
• changeinthecolourofthepaintthatcoversthestove;
• breakageofglassorrefractorybricks;
• cracktiles;
• backexhaust;
• sealsareconsideredascomponentssubjecttowearandtear;
• meltingordeformationofthegridduetooverheatingofthedevice;
• non‐compliancewiththerequirementsregardinginstallationandoperation,specifiedinthismanual;
www.ackerman.pl 13
• defectsthatappearedduetotransport.
WARRANTY
Guaranteeofthesmoothoperationofthefurnace,confirmedbythecompany’sorretailerstampandsignedbythe
seller,shallbegrantedforaperiod of 12months from thedateof purchase. In the eventofdamageordefects in
materialthatapperedduringthewarrantyperiod,themanufacturerprovidesfreerepair.Duetothemanufacturing
processthetileshavecharacteristicsofcurrentproductionbatch.Thereforetherecanbeslightcolordifferencesin
hue between each productionbatches. Described feature is notadefectoftheproductanddonotgivebasistoa
claim.Anydamagecausedbyimproperstorage,improperoperation and poor maintenance,inconsistent with the
conditions specified in the instruction manual, and as a result of other causes that are not the fault of the
manufacturer,willvoidthewarranty.Warrantyandrightofwithdrawaldoesnotapplywhentheproductisaffected
bymechanicaldamages of externalorigin.Warrantydoesnot cover productsused(from demonstrationarea). The
manufacturerreservestherighttomakeimprovementsorchangestothedevicesandoperatinginstructionsatany
timewithoutpriornotice.
During the warranty period, any repairs performed by persons not authorized by the manufacturer will void the
purchaserclaimsunderwarranty.Buyercanclaimtheguaranteeonlyifthemanufacturerordealerdoesnotperform
its obligations under the guarantee. The manufacturer should accept the exchange of the furnace, based on the
judgementofauthorizedexpertindicatingthatitisimpossibletoperformtheauthorizedrepair.Thewarrantycardis
theonlybasisforabuyertoafreewarrantyrepairs.Warrantyisvoidwithoutdates,stamps,signaturesofauthorized
persons,aswellaswithanymodificationsmadebynonauthorisedpersons.Ifyoulosethewarrantycardduplicates
willnotbeissued.Inthecaseofunjustifiedcomplaintsbuyercoversthecostoftransport,repair,packing,dismantling
andmaintenance.

www.ackerman.pl 14
WARRANTYCARD
Donotmakeanyunauthorizedmodificationstothedesignandappearanceofthestove!
Duringrepairs,useonlyoriginalsparepartsfromthemanufacturer!
Customers reporting a claim within the warranty shall sign a declaration that they did not use forbidden and
prohibited fuel to burn. The device will be given to the experts for the investigation of presence of prohibited
substances, in case it is suspected that forbidden and prohibited fuels were used. If the use of prohibited fuels is
determinedcustomerlosesanyrighttoguaranteeandisobligedtocoverthecostsoftheserviceandtheexpertise.
Themanufacturerconsidersallclaims,exceptinthefollowingcases:
̶ Theformationofcondensation;
̶ Wearofsealingelements;
̶ Mechanicaldamage,eg.impact,scratches;
̶ Ruptureofglassorrefractorybricks;
̶ Damageoftiles;
̶ Backexhaust;
̶ Whenthegrateismelted,thereareexcessivedeformations,orthepaintcolourhaschangeddueto
overheating;
̶ Requirementsfortheinstallationandoperationspecifiedinthismanualhaven’tbeenfulfilled;
̶ Defectswerecausedduetotransport;
̶ DefectsresultingfromthefaultorignoranceoftheBuyerarenotcoveredbywarranty.Clientshouldconduct
aninspectionofequipmentpurchasedinthepresenceofthedealerorcarrier.
̶ intheeventofunjustifiedrequestsyouwillbeobligedtoreimbursethecostoftheservicecallandtocover
thecostofrepairifdefectsareofusersfault..
MODEL:
Year:
SerialNumber:
Qualitycontrol:
Theproductwasdeliveredintacttothecustomer:
(Fullnameoftheseller)
Address:
Nameofcompany:
Town:
Numberofinvoice:
date:
 (Dateofsell)
BUYER
 SELLER
(Sign) (Signandstamp)
www.ackerman.pl 15
Dateofthedevicelaunch:
I,theundersigned
, confirm that I have read installation requirments
specifiedbythemanufacturerandIhaveobservedtechnicalstandardsinforceintheEuropeanUnion.Ialsocertify
thattheequipmentisinstalledinaccordancewithcurrenttechnicalknowledgeandwithduediligenceandthatitisfit
forsafeoperationundertheconditionthatitishandledinaccordancewiththespecificationincludedinthismanual.
Warrantyrepairs:
Anychangesmadetotheguaranteebyanunauthorizedpersonwillvoidthewarranty.
Donotmakeanyunauthorizedmodificationstothedesignandappearanceofthestove!
Duringrepairs,useonlyoriginalsparepartsfromthemanufacturer!
INSIDEPACKAGE:
Thestoveiscompleteandincludesthefollowingpartsandcomponents:
̶ Stove,
̶ Doorwithglass(ifequipped),
̶ Drawer‐ashcontainer,
̶ Castirongrate,
̶ Asetofhandleswithhookandairregulator,
̶ Technicaldescription.
www.ackerman.pl 16
ACKERMANSA
ul.Lektykarska54
01‐687Warszawa
tel.:+48224909900
fax:+48224909901
+48500465931,+48505920197
[email protected]
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Ackerman K1 User manual

Brand
Ackerman
Model
K1
Category
Stoves
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Other documents