Huffy Youth Basketball System User manual
- Type
- User manual
1
12/04 P/N 21473501
A Company
Toll-Free Customer Service Number for U.S.: 1-800-558-5234
http://www.huffysports.com
© COPYRIGHT 2004 by HUFFY SPORTS
Youth Basketball System
Owner's Manual
READ AND UNDERSTAND
OPERATOR'S MANUAL
BEFORE USING THIS UNIT.
FAILURE TO FOLLOW
OPERATING
INSTRUCTIONS COULD
RESULT IN INJURY OR
DAMAGE TO PROPERTY.
WARNING!
Write Model Number
From Box Here:
REQUIRED TOOLS
AND MATERIALS:
• (2 each) Wrenches and/or
Socket Wrenches and
Sockets.
1/2" 9/16"
1/2" 9/16"
AND/OR
2
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
IMPORTANT!
Remove all contents from boxes.
Be sure to check inside pole sections;
hardware and additional parts are packed inside.
NOTICE TO ASSEMBLERS
ALL Huffy Sports basketball Systems, including those used for DISPLAYS, MUST be assembled and
ballasted with sand or water according to instructions. Failure to follow instructions could result in
SERIOUS INJURY. It is NOT acceptable to devise a makeshift weight system.
SAFETY INSTRUCTIONS
FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN SERIOUS INJURY
AND/OR PROPERTY DAMAGE AND WILL VOID WARRANTY.
Owner must ensure that all players know and follow these rules for safe operation of the system.
To ensure safety, do not attempt to assemble this system without following the instructions carefully. Proper
and complete assembly, use, and supervision is essential for proper operation and to reduce the risk of
accident or injury. A high probability of serious injury exists if this system is not installed, maintained, and
operated properly.
• Check base regularly for leakage. Slow leaks could cause the system to tip over
unexpectedly
• Seat the pole sections properly (if applicable). Failure to do so could allow the pole
sections to separate during play and/or during transport of the system.
• Climate, corrosion or misuse could result in system failure.
• If technical assistance is required, contact Huffy Sports.
Most injuries are caused by misuse and/or not following instructions.
Use caution when using this unit.
12/04 P/N 21473501
3
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
PARTS LIST
Item Qty. Part No. Description
1 1 20664903 Tank (Black)
2 1 908130 Top Pole Section
3 1 908133 Middle Pole Section with Label
4 1 908132 Bottom Pole Section
5 1 203220 Nut, Ny-Lock, 5/16-18
6 1 Net
7 1 20378701 Cap
8 3 203223 Bolt, Carriage, 5/16-18 x 1" Long
9 1 203617 Tank Cap
10 1 203740 Bolt, Hex, 5/16-18 x 2.63" Long
11 2 201344 Knob, Plastic, 3-sided
12 1 Rim
13 12* 201219 Smart Clip, Net Holder
14 1 908134 Backboard Mounting Bracket
15 1 908129 Rim Bracket
16 2 203739 Bolt, Carriage 5/16-18 x 3.25" Long
17 4 203218 Washer, Flat, 5/16
18 1 203309 Washer, Flat, 1.0" O.D.
19 1 203679 Bolt, Hex, 3/8-16 x 2" Long
20 3 203100 Nut, Flange, 5/16-18
21 1 900454 Strut, Left
22 1 900255 Strut, Right
* YOU MAY HAVE EXTRA PARTS WITH THIS MODEL.
4
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
WARNING
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT
IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow
these rules for safe operation of the system.
• DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
• During play, especially when performing dunk type
activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.
• Do not slide, climb, shake or play on base and/or pole.
• After assembly is complete, fill system completely with
water or sand. Never leave system
in an upright position
without filling base with weight, as
system may tip over
causing injuries.
• When adjusting height or moving system, keep hands and
fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,
etc.). Objects may entangle in net.
• Surface beneath the base must be smooth and free of
gravel or other sharp objects. Punctures cause leakage and
could cause system to tip over.
• Keep organic material away from pole base. Grass, litter,
etc. could cause corrosion and/or deterioration.
• Check pole system for signs of corrosion (rust, pitting,
chipping) and repaint with exterior enamel paint. If rust has
penetrated through the steel anywhere, replace pole
immediately.
• Check system before each use for proper ballast, loose
hardware, excessive wear and signs of corrosion and
repair
before use.
•
Check system before each use for instability.
• Do not use system during windy and/or severe weather
conditions; system may tip over. Place system in the
storage position and/or in an area protected from the wind
and free from personal property and/or overhead wires.
• Never play on damaged equipment.
• See instruction manual for proper installation and
maintenance.
• When moving system, use caution to keep mechanism from
shifting.
• Keep pole top covered with cap at all times.
• Do not allow water in tank to freeze. During sub-freezing
weather add non-toxic antifreeze, sand or empty tank
completely and store. (Do not use salt.)
• Use extreme caution if placing system on sloped surface.
System may tip over more easily.
203782 07/04
In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339
For Europe: 00 055 85234 (Sweden: 009 555 85234).
For Australia: 1-800-632 792
204178 05/04
HEIGHT ADJUSTMENT
A
WARNING
Backboard
may rotate during
height adjustment.
B
WARNING
Do not adjust height of system
in upright position. System must
be in down position to adjust
Rest unit on support table. Remove adjustment knobs (A)
and carriage bolts (B) to extend or retract backboard and rim.
Height adjustment from 4-1/2' - 6-1/2'.
12/04 P/N 21473501
5
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
PARTS IDENTIFIER- Hardware is actual size
PARTS IDENTIFIER- Not actual size
Item # 8 - Qty (3)
Item # 13 - Qty (12) *
Item #10 - Qty (1)
Item #16 - Qty (2)
Item # 5 - Qty (1)
Item # 17 - Qty (4)
Item # 18 - Qty (1)
Item #15 - Qty (1)
Item #7 - Qty (1)
Item # 20 - Qty (3)
Item #19 - Qty (1)
Item #9 - Qty (1)
Item #14 - Qty (1)
#11 - Qty [2]
Item #21 - Qty (1)
Item #22 - Qty (1)
6
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
Get to know the basic parts of your basketball system.....
FRONT
TOP POLE
BACK
MIDDLE POLE
RIM
BOTTOM POLE
STRUTS
ELEVATOR
ASSEMBLY
BACKBOARD
BASE
12/04 P/N 21473501
7
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
1.
Correctly identify each pole section. Poles have an identification sticker
that will be used as a reference point in the next step.
3
2
4
TOP MIDDLE BOTTOM
Reference Stickers
8
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
2.
IMPORTANT!
ONCE POLE SECTIONS ARE POUNDED TOGETHER- THEY CANNOT BE TAKEN APART
3
2
4
TOP
MIDDLE
BOTTOM
alignment mark
alignment mark
Align poles using alignment marks. First, pound top and
middle poles together by bouncing them on a scrap piece of
wood on the ground as shown in FIG B. until they no longer
move toward pole identification stickers. THEN add bottom
pole section and pound together in the same way.
middle pole
IDENTIFICATION
STICKER
middle pole
IDENTIFICATION
STICKER
3-3/4"
1-1/4"
THE IDENTIFICATION STICKER IS
LOCATED 3-3/4" FROM THE END OF
THE POLE. WHEN PROPERLY
POUNDED TOGETHER, THE POLE
SECTIONS SHOULD HAVE A 2-1/2"
MINIMUM OVERLAP, LEAVING 1-1/4"
BETWEEN THE OVERLAPPING POLE
AND THE IDENTIFICATION STICKER.
CAUTION!
FIG B.
scrap wood
(Not Supplied)
12/04 P/N 21473501
9
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
Attach pole assembly to tank as shown. Secure pole assembly to tank by turning
the pole assembly clockwise as shown.
3.
FIG B
18
19
4
CAREFULLY TIPPING THE
SYSTEM FORWARD WILL
ALLOW EASIER ACCESS
TO UNDERSIDE OF BASE
NOTE:
TWO PEOPLE REQUIRED
FOR THIS PROCEDURE.
FAILURE TO FOLLOW THIS
WARNING COULD RESULT IN
SERIOUS INJURY AND/OR
PROPERTY DAMAGE.
WARNING!
IMPORTANT!:
NOTE ORIENTATION
10
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
5.
Rotate struts down and bend struts outward to line up with holes on base as shown.
Secure free ends of tank struts to tank with carriage bolt (8), and nut (20) as shown.
Repeat for other side.
17
22
1
17
21
5
10
Secure tank struts (21 & 22) to pole.
TIGHTEN BOLT (10) IN
LOCK NUT (5) UNTIL
FLUSH (EVEN) WITH LOCK
NUT’S OUTER EDGE.
FAILURE TO FOLLOW
THIS WARNING COULD
RESULT IN SERIOUS
INJURY AND/OR
PROPERTY DAMAGE.
WARNING!
4.
8
20
17
12/04 P/N 21473501
11
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
Pole bracket will need to be lightly pressed into backboard ribbing. Be sure to press
completely into place. Attach rim to backboard and pole bracket (14) with nut (20),
reinforcement bracket (15), and carriage bolt (8) as shown. Tighten nut completely.
PRESS BRACKET
(14) INTO PLACE
HERE
SAWHORSE OR SUPPORT TABLE
8
15
14
6.
Carefully tip unit forward and slide backboard
assembly onto pole as shown.
BOARD STYLE
MAY VARY
NOTE:
12
20
12
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
7
9
7.
8.
Attach board assembly to pole with carriage
bolts (16) and knobs (11) as shown. Install pole
cap (7) as shown.
Place assembled unit in desired location. Fill tank completely with water (14 gallons/53
liters) or sand (approx. 170 lb./77 kg) and snap tank cap (9) in place.
ADD ONE GALLONS (3.78
LITERS) OF NON-TOXIC
ANTIFREEZE IN SUB-
FREEZING CLIMATES.
CAUTION!
16
11
16
11
12/04 P/N 21473501
13
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
Attach net clips to rim as shown.
CLIP “ARM”
CLIP “BODY”
Insert one “arm” of clip into ram as shown. Twist “body” of clip slightly so
that second “arm” slides over the top of the first “arm” as shown.
Push in direction indicated by arrows.
Push second “arm” back and into ram as shown.
Twist “body” of clip slightly again to spread “arms” of clip.
Clip “arms” must be flat and touching edge to edge as shown, not
overlapping.
AA
BB
CC
13
13
9.
USE OF THIS PRODUCT
WITHOUT PROPER
INSTALLATION OF SMART
CLIPS
®
, OR WHEN ALL SMART
CLIPS
®
ARE NOT PRESENT
COULD RESULT IN BODILY
HARM. BE SURE TO FOLLOW
DIRECTIONS CAREFULLY.
WARNING!
14
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
Install net.
Insert net into bottom of clip as shown.
SIDE VIEW
Twist net until it snaps into position.
Net must be centered through clip.
NET
NETCLIP
SIDE VIEW
NET
NETCLIP
10.
6
12/04 P/N 21473501
15
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
11.
Maximum rim height is 6.5 feet.
6.5 feet
(1.98 m)
204178 05/04
HEIGHT ADJUSTMENT
A
WARNING
Backboard
may rotate during
height adjustment.
B
WARNING
Do not adjust height of system
in upright position. System must
be in down position to adjust
Rest unit on support table. Remove adjustment knobs (A)
and carriage bolts (B) to extend or retract backboard and rim.
Height adjustment from 4-1/2' - 6-1/2'.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT
IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow
these rules for safe operation of the system.
• DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
• During play, especially when performing dunk type
activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.
• Do not slide, climb, shake or play on base and/or pole.
• After assembly is complete, fill system completely with
water or sand. Never leave system
in an upright position
without filling base with weight, as
system may tip over
causing injuries.
• When adjusting height or moving system, keep hands and
fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,
etc.). Objects may entangle in net.
• Surface beneath the base must be smooth and free of
gravel or other sharp objects. Punctures cause leakage and
could cause system to tip over.
• Keep organic material away from pole base. Grass, litter,
etc. could cause corrosion and/or deterioration.
• Check pole system for signs of corrosion (rust, pitting,
chipping) and repaint with exterior enamel paint. If rust has
penetrated through the steel anywhere, replace pole
immediately.
• Check system before each use for proper ballast, loose
hardware, excessive wear and signs corrosion and repair
before use.
•
Check system before each use for instability.
• Do not use system during windy and/or severe weather
conditions; system may tip over. Place system in the
storage position and/or in an area protected from the wind
and free from personal property and/or overhead wires.
• Never play on damaged equipment.
• See instruction manual for proper installation and
maintenance.
• When moving system, use caution to keep mechanism from
shifting.
• Keep pole top covered with cap at all times.
• Do not allow water in tank to freeze. During sub-freezing
weather add non-toxic antifreeze, sand or empty tank
completely and store. (Do not use salt.)
• Use extreme caution if placing system on sloped surface.
System may tip over more easily.
203782 05/04
In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339
WARNING
READ AND UNDERSTAND
FAILURE TO FOLLOW
OPERATING
INSTRUCTIONS COULD
RESULT IN INJURY OR
DAMAGE TO PROPERTY.
WARNING!
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
12/04 P/N 21473501
23
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
IMPORTANT!
UNE FOIS LES SECTIONS DE POTEAU ENTRECHOQUÉES ENSEMBLE, ELLES NE PEUVENT PLUS ÊTRE DÉMONTÉES.
WICHTIG! NACH DEM ZUSAMMENSTAUCHEN DER STANGENTEILE KÖNNEN DIESE NICHT MEHR VONEINANDER GETRENNT WERDEN.
¡IMPORTANTE!
UNA VEZ QUE LAS SECCIONES DEL POSTE SE HAN EMBRAGADO ENTRE SÍ, YA NO SE PODRÁN SEPARAR
3
2
Section supérieure
Oben
Parte superior
Section centrale
Mitte
Parte media
Section inférieure
Unten
Parte inferior
Repère d'alignement.
Ausrichtungsmarkierung
Marca de alineación.
Repère d'alignement.
Ausrichtungsmarkierung
Marca de alineación.
Alignez les sections de poteau en vous basant sur les repères d'alignement. Tout d'abord,
emboîtez les sections de poteau supérieure et centrale en les entrechoquant sur un bout
de bois posé par terre, comme illustré à la figure B, jusqu'à ce qu'elles ne bougent plus
vers les étiquettes d'identification des sections. ENSUITE, ajoutez la section de poteau
inférieure et entrechoquez de la même façon.
Die Stangen mithilfe der Markierungen korrekt ausrichten. Zuerst das obere und mittlere
Stangenteil auf einem Holzstück auf dem Boden zusammenstauchen (siehe Abb. B), bis
sie sich nicht mehr auf die Markierungsaufkleber zubewegen. DANN das untere
Stangenteil auf gleiche Weise - also durch Zusammenstauchen - anbringen.
Alinee los postes usando las marcas de alineación. Primero embrague las secciones
superior y media del poste golpeándolas entre sí sobre un trozo de madera colocado en el
piso como se muestra en la FIG. B hasta que ya no se muevan hacia las calcomanías de
identificación del poste. LUEGO añada la sección inferior del poste y golpee las secciones
entre sí de la misma manera.
figure B
siehe Abb. B
FIG. B
Bout de bois
(non fourni)
Holzstück
(nicht im Lieferumfang
enthalten)
Trozo de madera
(No se suministra)
middle pole
ÉTIQUETTE D'IDENTIFICATION
MARKIERUNGSAUFKLEBER
CALCOMANÍAS DE
IDENTIFICACIÓN
middle pole
ÉTIQUETTE
D'IDENTIFICATION
MARKIERUNGSAUFKLEBER
CALCOMANÍAS DE
IDENTIFICACIÓN
3,18 cm
(1-1/4")
2.
Repère d'alignement
Ausrichtungsmarkierung
Marca de alineación.
4
Trou.
Loch
Orificio.
L'ÉTIQUETTE D'IDENTIFICATION SE SITUE À 9,53 (3-
3/4") CM DE L'EXTRÉMITÉ DU POTEAU.
LORSQU'ELLES SONT CORRECTEMENT EMBOÎTÉES
LES UNES DANS LES AUTRES, LES SECTIONS DE
POTEAU DOIVENT SE CHEVAUCHER DE 6,35 CM (2-
1/2") MINIMUM, EN LAISSANT 3,18 CM (1-1/4") ENTRE
LA SECTION QUI CHEVAUCHE ET L'ETIQUETTE
D'IDENTIFICATION.
DER MARKIERUNGSAUFKLEBER BEFINDET SICH
CA. 9,53 CM (3-3/4") VOM STANGENENDE. WENN DIE
STANGENTEILE RICHTIG ZUSAMMENGESTAUCHT
WURDEN, SOLLTEN SIE UM MINDESTENS 6,35 CM
(2-1/2") ÜBERLAPPEN. DER ABSTAND ZWISCHEN
DEM ÜBERLAPPENDEN STANGENTEIL UND DEM
MARKIERUNGSAUFKLEBER SOLLTE ALSO 3,18 CM
(1-1/4") BETRAGEN.
LA CALCOMANÍA DE IDENTIFICACIÓN ESTÁ
COLOCADA A 9,53 CM (3-3/4") DEL EXTREMO DEL
POSTE. CUANDO ESTÁN ADECUADAMENTE
EMBRAGADAS, LAS SECCIONES DEL POSTE DEBEN
TENER UN TRASLAPE MÍNIMO DE 6,35 CM (2-1/2"),
DEJANDO 3,18 CM (1-1/4") ENTRE EL POSTE
TRASLAPADO Y LA CALCOMANÍA DE
IDENTIFICACIÓN.
ATTENTION !
VORSICHT!
¡PRECAUCIÓN!
9,53 cm
(3-1/2")
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
30
P/N 21473501 12/04
Toll-Free Customer Service Number for U.S. : 1-800-558-5234
http://www.huffysports.com
6.5 pieds
1,98 m
6.5 Fuß
(1,98 m)
6.5 pies
(1.98 m)
11.
La hauteur réglementaire du cerceau est de 1,98 m (6,5
pieds).
Der Korbrand wird den offiziellen Regeln gemäß in einer
Höhe von 1,98 m (6,5 Fuß) angebracht.
La altura reglamentaria del borde es de 1,98 m (6.5
pies).
204178 05/04
HEIGHT ADJUSTMENT
A
WARNING
Backboard
may rotate during
height adjustment.
B
WARNING
Do not adjust height of system
in upright position. System must
be in down position to adjust
Rest unit on support table. Remove adjustment knobs (A)
and carriage bolts (B) to extend or retract backboard and rim.
Height adjustment from 4-1/2' - 6-1/2'.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT
IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow
these rules for safe operation of the system.
• DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
• During play, especially when performing dunk type
activities, keep player's face away from the backboard, rim
and net. Serious injury could occur if teeth/face come in
contact with backboard, rim or net.
• Do not slide, climb, shake or play on base and/or pole.
• After assembly is complete, fill system completely with
water or sand. Never leave system
in an upright position
without filling base with weight, as
system may tip over
causing injuries.
• When adjusting height or moving system, keep hands and
fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces,
etc.). Objects may entangle in net.
• Surface beneath the base must be smooth and free of
gravel or other sharp objects. Punctures cause leakage and
could cause system to tip over.
• Keep organic material away from pole base. Grass, litter,
etc. could cause corrosion and/or deterioration.
• Check pole system for signs of corrosion (rust, pitting,
chipping) and repaint with exterior enamel paint. If rust has
penetrated through the steel anywhere, replace pole
immediately.
• Check system before each use for proper ballast, loose
hardware, excessive wear and signs corrosion and repair
before use.
•
Check system before each use for instability.
• Do not use system during windy and/or severe weather
conditions; system may tip over. Place system in the
storage position and/or in an area protected from the wind
and free from personal property and/or overhead wires.
• Never play on damaged equipment.
• See instruction manual for proper installation and
maintenance.
• When moving system, use caution to keep mechanism from
shifting.
• Keep pole top covered with cap at all times.
• Do not allow water in tank to freeze. During sub-freezing
weather add non-toxic antifreeze, sand or empty tank
completely and store. (Do not use salt.)
• Use extreme caution if placing system on sloped surface.
System may tip over more easily.
203782 05/04
In the U.S.:1-800-558-5234 and Canada: 1-800-284-8339
WARNING
Lisez le mode d'emploi
sous peine d'encourir des blessures ou des
dégâts matériels.
vor Gebrauch dieses Produkts sorgfältig
durchlesen.
Ein Missachten dieser Betriebsanleitung
kann Verletzungen oder Sachschäden zur
Folge haben.
Lea y entienda
Si no se siguen las
instrucciones de operación se podría
ocasionar una lesión o daños a la
propiedad.or damage to property.
AVERTISSEMENT !
WARNUNG!
¡ADVERTENCIA!
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
Huffy Youth Basketball System User manual
- Type
- User manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
in other languages
Related papers
Other documents
-
Spalding 214994B User manual
-
-
-
-
-
Porter BIG SHOT PRO PACKAGE Operating instructions
-
-
-
-
