EcoSmart Smart POOL 18 User manual

EcoSmart
Brand
EcoSmart
Model
Smart POOL 18
Type
User manual

This manual is also suitable for

PLEASEREADTHESEINSTRUCTIONSTHOROUGHLYANDCOMPLETELYPRIORTOINSTALLATION&USE.
FAILURETODOSOCOULDCAUSEPROPERTYDAMAGEORSERIOUSINJURYORDEATH&VOIDYOUR
WARRANTY.
ECOSPA&POOLOWNERSMANUAL&INSTALLATIONGUIDE
MODELS:ECOSPA5.5-11/ECOPOOL18-27
IMPORTANTSAFETYINSTRUCTIONS,INSTALLATIONINSTRUCTIONS,USERINSTRUCTIONS
Aswheninstallingorusinganyhighvoltageelectricalappliance,basicsafetyprecautionsshouldalwaysbe
followed.Undernocircumstancesshouldyouattempttoclean,install,inspect,repair,disassembleorother-
wiseservicethiswaterheaterwithoutfirstshuttingoffallpowertotheunitdirectlyatthebreakerbox.
SERIOUSBODILYINJURYORDEATHCOULDOCCURIFYOUIGNORETHISWARNING.
THISPRODUCTMUSTBEINSTALLEDBYAQUALIFIEDELECTRICIAN&PLUMBERINACCORDANCEWITH-
Article680oftheNationalElectricalCode,NFPA70andwiththerequirementsoftheauthorityhavingjurisdiction
andallapplicablenational,state,provincial,andlocalelectricalcodes.
READANDFOLLOWALLINSTRUCTIONSANDSAVETHESEINSTRUCTIONS.
IMPORTANTSAFETYINSTRUCTIONS
By installing this product, you acknowledge the terms of the manufacturer's warranty and your
Authorized Dealer's return policies. Spa/Pool heaters that have been installed cannot be returned. If
youhaveanyquestionsregardingthewarrantyorproductreturnpolicies,pleaseconsultyourAuthor-
CongratulationsonthepurchaseofyourSpa/PoolHeater!Youhavepurchasedthemosttechno-
logically-advancedSpa/Poolheaterinthemarkettoday.YourECOSMARTSpa/PoolHeateris
backedbytheindustry'smostcomprehensivewarranty.
To get the best performance and energy savings from your Spa/Pool heater, it is important that it be
installedinaccordance withourinstructionsandtheelectricalandplumbingcodesapplicabletoyour
area, and that you read this manual thoroughly for important operating instructions and tips.
Atanytime,ifyouhaveanyquestions,pleasecontactyourAuthorizedDealer,orcontactusdirectlyat:
ECOSMARTUS,L.L.C.
3315NW167THSTREET,MIAMIGARDENS,FLORIDA33056
TollFree:1-877-474-6473
1. Spa/Pool heater.
2. Installation Location.
3. Water Connections / Plumbing Diagram.
4. Electrical Connections/ElectricalDiagram
5. How to operate your Spa/Pool heater.
6. Digital Control Temperature Setting
7. Important Safety Information
8. Warranty Information
9. Warranty Registration Card
PLEASE READ THESE INSTRUCTIONS THOROUGHLY AND COMPLETELY BEFORE INSTALLATION
ANDBEFOREUSE.FAILURETODOSOCOULDCAUSEPROPERTYDAMAGEORSERIOUSPERSONAL
INJURY OR DEATH & VOID YOUR WARRANTY.
izedDealerpriortoinstallation.
OpentheboxandcarefullyunpacktheSpa/Poolheater.Inspectallcomponents.
2.INSTALLATIONLOCATION
Ecosmartheatersaredesignedforeitherindoororoutdooruse.Unitsmustbemountedonalevel
baseparalleltotheground.Allow6 clearanceatsidesandatleast18 clearanceattopandfrontfor
anymaintenanceorrepairs.Securetheunittothebaseviascrews(notprovided)
RecommendedClearances:
Top18inches CAUTION:Combustiblematerialsshouldbekeptatleast24inches
Sides:6inches awayfromyourheaterandtheoutputhotwaterpipe.
3-WATERCONNECTIONS/PLUMBINGDIAGRAM
Pleasefollowallplumbinginstructionscarefully.Thisproductmustbeinstalledbya
licensedandqualifiedplumberinaccordancewithall applicablenational,state,pro-
vincial,andlocalplumbingcodes.
IMPORTANTNOTES:
WH E N PRE P A R I N G TH E CO N N E C T I O N S GO I N G TO UN I T , MA K E SU R E YO U DO NOT USE
G L U E O R P U D D Y . A N Y G L U E O R P U D D Y G O I N G I N T O U N I T W I L L D A M A G E T H E F L O W
SENSOR PERMANENTLY. PRIOR TO THE FINAL HOOK UP TO UNIT FLUSH ALL THE LINES TO CLEAR
ANY DEBRIS IN LINE. NOTE: When using two speed pumps, do not install gate valve on inlet. No
shut-offvalvesaretobeinstalledinthepipingbetweenthespaheateroutletandthespa.Ifusinganin-
line chlorinator a check valve must be used. Any chlorinators valves that can cause return line block-
age will VOID the warranty.
SPA/POOL HEATER MUST BE INSTALLED AFTER FILTER-Spa models are supplied with 11/2 NPT and
Poolmodelswith2 NPTinletandoutlet plumbingconnections.Allmodelsarerated240Vsinglephase.
Units are Flow activated. No Hartford loop is required.
F
I
T
E
R
L
PoolInstallationDiagram
Spa/Poolreturn InlettoSpa/Pool
-
SHUTOFFVALVEMUSTBEINSTALLEDATINLETOFUNIT.ELECTRICALANDPLUMBING
CONNECTIONSMUSTBEFOLLOWEDTOMEETALLLOCALCODESANDREQUIREMENTS.
After tightening both fittings at the water heater, RUN our pump to allow water to run through
the Spa/Pool heater for at least 5-10 minutes. This process purges all the air from the water lines
andMUSTbeperformedpriortoturningonthepowerattheunit.
FAILURETOFOLLOWTHISSTEP
CAN CAUSE PERMANENT DAMAGE TO THE HEATING ELEMENTS.
WaterFlow-YourSpa/Poolheatermusthaveanadequateflowofwaterflowforproperoperation.
Adequatewaterflowremovestheheatproducedbythe heaterandtransferstheheattotheSpa/
Poolandpreventsoverheating.Lowwaterflowusuallyresultsfromdirtyfilterorimproperlyad-
justed manualby-pass.Manualby-passvalvesshouldbesetsothattheoutlettemperaturecom-
ingfromtheheateris6-8degreesF.abovetheSpa/Poolwaterafterfive(5)minutesofheaterop-
eration.Thiscanbemeasuredusingathermometer.
WhenanymaintenanceisperformedontheSpa/Poolthatmayintroduceairintotheplumbing
pipes,itisimportanttoturnthepowerofftotheSpa/Poolheaterandpurgetheairoutofthe
linesbeforeallowingtheunittopowerup.
DRY-FIRINGofELEMENTS: causedbywatervoidswhenpowerison.ALLairmustbepurgedfrom
systembeforeanyheatstart-up.ItisIMPORTANTtopurgeallairaftercleaningorchangingacar-
tridgefilter.Thefiltercasingactsasanairreservoirduringthisprocedure,thecirculationsystem
mustbeonforatleast2minutesbeforeyouturnpoweron.
ECO SPA 5 5. ECO SPA 11
GRND
L1 L1
60 60
DOUBLE POLE BREAKER
GRND
L1 L1
30 30
DOUBLE POLE BREAKER
4.ELECTRICALCONNECTIONS/ELECTRICALDIAGRAM
PLEASEREADTHESEINSTRUCTIONSTHOROUGHLYANDCOMPLETELYBEFOREINSTALLATION
AND BEFORE USE. FAILURE TO DO SO COULD CAUSE PROPERTY DAMAGE OR SERIOUS
PERSONAL INJURY, DEATH AND VOID YOUR WARRANTY.
This product must be installed by a licensed and qualified electrician in accordance with Article 680 of
the National Electrical Code, NFPA 70 and with the requirements of the authority having jurisdiction
and all applicable national, state, provincial, and local electrical codes. As with all electrical appli-
ances, under no circumstances should you attempt to install, repair or disassembled this water
heaterwithoutfirstshuttingoffallpowertotheunitdirectlyatthefuseorbreakerbox. SERIOUSBOD-
ILYINJURYORDEATHCOULDOCCURIFYOUIGNORETHISWARNING
All wiring (wiregauge) and circuit protection (breakers) must comply with the U.S. National Electrical
Code(NEC)intheU.S.A.,ortheCanadianElectricalCode(CEC)inCanada.Failuretodosocouldresult
in property damage and / or personal injury, and void your warranty. Note: the Canadian Electrical
Code generally requires that all supply wires and corresponding circuit protection (breakers) used for
hot water heating and hydronic heating applications be sized to a minimum of 125% of the maximum
Currentratingoftheheater(seemodelspecificationsbelowfordetails).
Beforeinstallingthisproduct,ensurethatthehomehassufficientelectricalpoweravailabletohandle
the maximum amperage load of the applicable model. ALL UNITS HAVE A 3 MINUTE TIME DELAY
ONSTART.
Electricalspecificationsbymodel
Wireconnectiontobreaker/ModelEcoSpa5.5Wireconnectiontobreaker/ModelEcoSpa11
GRND
L3 L3
L2
L1
L2
L1
GRND
L2 L2
L1 L1
50 50
DOUBLE POLE BREAKER
ECO POOL18 ECO POOL27
50 50
DOUBLE POLE BREAKER
50 5050 50
DOUBLE POLE BREAKER DOUBLE POLE BREAKER
50 50
DOUBLE POLE BREAKER
Wireconnectiontobreaker/ModelEcoPool18Wireconnectiontobreaker/ModelEcoPool27
Wire&Breakersspecificationbasedonthemodelbeinginstalled
Aseparategroundconductorforeachincomingcircuitisrequired.
DOUBLECHECK theelectricalconnectionstomakesuretheyarecorrectandthatallwireconnec-
tionsaretightandsecure.Alsoconfirmthatthecorrectbreakersizeandwiregaugehasbeenused
andconfirmthattheunithasbeenconnectedtoagroundinaccordancewithapplicablecodes.
5.HOWTOOPERATEYOURSPA/POOLHEATER
OnceyourSpa/Poolheaterhasbeeninstalledandyouarereadytobeginenjoyingityearround.
You MUST make sure your pump timer is disengaged to allow it to run until desired temperature
Settingisreached.
Your heater will ONLY heat your Spa/Pool when there is water running through it and ONLY when
yourSpa/Poolpumpisworking,ifyourSpa/PoolpumpisnotrunningyourSpa/Poolheaterwillnot
turnon.
Yourpoolheaterhasa3minutebuildinTIMEDELAYtoprotectitfromairinthelinesandelements
burn out, when the unit senses water flow it will automatically activate (GREEN LED will turn on).
When you initially start to heat your pool, you must run your pool pump without the timer. In order
to reach your initial desire pool temperature you will need to run the pool heater for the required
time.
6.DIGITALCONTROLTEMPERATURESETTING
TURNCONTROLKNOBTOSETYOURDESIREDSPA/POOLTEMPERATURE.WHENTHESETTEMPERA-
TUREISREACHEDTHEHEATERWILLRUNIDLEANDCONSUMENOENERGY.
Digital Control Temperature Setting: All Ecosmart models come with a digital control temperature setting
located in the front panel that can be easily set from 80 -104 (26 - 40 ) in 1 degree intervals by a simple
turnoftheknob.Theheatercanalsobeturned OFFbypushingthecontrolknobonceandconvertedtoCelsius
by holding the knob in for 3 seconds.
° °F ° °C
YoujustSETITandFORGETIT
Whenusingthiselectricalequipment,basicsafetyprecautionsshouldalways
befollowed,includingthefollowing:
Poolwatertemperaturestypicallyrangefrom78 to82 .TheAmericanRed
Crossrecommendsatemperatureof78 forcompetitiveswimming.However,
thismaybetoocoolforyoungchildrenandtheelderly,whomayrequireate-
mperatureof80 orhigher.
°F °F
°F
°F
7.IMPORTANTSAFETYINFORMATION
READANDFOLLOWALLINSTRUCTIONS.1.
The water in a spa or pool should never exceed 104°F (40°C). A water temperature
in excess of 104°F is considered unsafe for all persons. Lower water temperatures
arerecommendedforextendeduse(exceeding10-15minutes)andforyoungchildren.
2.
3. Excessivewatertemperatureshaveahighpotentialforcausingfetaldamage
duringtheearlymonthsofpregnancy.Pregnantorpossiblypregnantwomen
shouldlimitspaorpoolwatertemperaturesto100(38 ).°C
4. Beforeenteringaspaorpooltheusedshouldmeasurethewatertemperature
atseverallocationsusinganaccuratethermometersincethetoleranceofwater
temperature-regulatingdevicesmayvaryasmuchasmuchas+/-5F(3 )°C
5. Alcohol,drugsormedicationshouldnotbeusedbeforeorduringspaorpooluse
sincetheirusemayleadtounconsciousnesswiththepossibilityofdrowning.
6. Personssufferingfromobesiityorwithamedicalhistoryofheatdisease,loworhighbloodpressure,
circulatorysystemproblems,ordiabetes shouldconsultaphysicianbeforeusingaspaorpool.
7. Persons using medication should consult a physician before using a spa or pool since some medication
may induce drowsiness while other medication may affect heart rate, blood pressure and circulation.
Prolonged immersion in hot water may induce hyperthermia. Hyperthermia occurs when the internal
temperature of the body reaches a level several degrees above normal body temperature of 98.6 F.
The symptons include dizziness, fainting, drowsiness, lethargy and an increase in the internal
temperature of the body. The effects of hyperthermia include: Unawareness of impending hazard,
failure to perceive heat , failure to recognize the need to exit spa or pool, physical inability to exit
spaorpool,fetaldamageinpregnantwomenandUnconsciousnessresultinginadangerofdrowning.
8. SAVETHESEINSTRUCTIONS
WATERTREATMENT:
Fortheprotectionofyourspaandpoolequip-
mentandhealth,itisimportantthatyour
waterbechemicallybalanced
CAUTION:CorrosivewaterVOIDSall
warranties.* MUSTNOTFreeChlorine
EXCEED5ppm.
Occasionalchemicalshockdosingofyourspa
andpoolshouldnotdamagetheheateraslong
asthewaterisbalanced.
AutomaticChlorinatorsandChemicalFeed-
ers: Allchemicalsmustbecompletelydiluted
intospaorpoolwaterbeforebeingcirculated
throughtheheater.Chlorinetabletsorbro-
minesticksshouldnotbeplacedinskimmer.
Highchemicalconcentrationswillresult
whenthepumpisnotrunning.
Chlorinatorsmustbefeeddownstreamof
theheaterandhaveanti-siphoningdeviceto
preventchemicalbackupintotheheater
whenthepumpisshutoff.
CAUTION: Highchemicalconcentratesfrom
feedersandchlorinatorsthatareoutofad-
justmentwillcauserapidcorrosionto
heater.Thistypedamageisnotcovered
underthewarranty.
Foradditionalinformationorquestionspleasecall877-474-6473 Do
notreturnyourheatertoyourAuthorizedDealer.Pleasecallourcustomerservicedept.
E-mail: info@ecosmartus.com
Areyouhavingproblemswithyourwaterheater?CallTOLLFREE
YoumayalsocontactyourAuthorizedDealerforassistance
E-mail:info@ecosmartus.com
877-474-6473
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

EcoSmart Smart POOL 18 User manual

EcoSmart
Brand
EcoSmart
Model
Smart POOL 18
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents