SpaDealers TopSpa User guide

TopSpaX



User’sGuide

Installationofelectrics:TopSpaXSrequiresa230V,1x16Aconnectionwitha2.5mm2wirecrosssectionviaa

mainbreakerswitch.Aresidualcurrentdevicemustbeengaged.Itisalsorecommendedthatatimer(clock)

withanon/offswitchbeinstalledtoensurethatthefiltrationsystemsrunsabout4‐6hoursperday.E.g.2x2

hours,or2x3hours,dependingonwhatismostappropriatefortheuser.Meanwhile,theelectricalheater

alsoturnsonifthetemperaturedropsbelowthesetvalue.NOTE!Timermaynotbeinstalledontheincoming

phaseaheadofthesafetyswitch.Seewiringdiagramforthecorrectsetup.It’simportantthataqualified

professionalcheckthateverythingworksbeforethebathisused.Itisthereforepracticaltofillthebathas

shownonpage6,andthatthestartupisdoneaccordingtotheinstructionsonpage7.Seepage11forsuitable

foundations.

WARNING!

A. Makesurethattheproductisnotdamagedintransitduringunpacking.

B. Theelectricalinstallationshouldonlybedonebyqualifiedpersons.

C. Readinstructionscarefullybeforeinstallationbegins.

D. Wearenotresponsibleforproductmalfunctionordamageiftheinstructionsarenotfollowedduring

installation.

E. Donotconnectpowerbeforetheinstallationiscomplete.

F. NOTE!Ifthehottubisbuiltintoaterraceorsimilar,theconstructionshallbebuiltinsuchawaythat

allsidesarefreelyaccessibleforservicing.Outerpanelingandeventualinsulationmustbeeasily

removable

G. Readthetechnicalinstructionsbeforeinstallingthebath

H. Readtheusersinstructionsbeforeusingthebath

I. Donotleavechildreninthebathwithoutsupervision

J. Donotsitwithyourbackorheadagainsttheskimmer

K. Ifautomaticdispensers(floating,etc.)areused,carefuladjustmentshouldbemadetoavoidincorrect

dosage.Followtherecommendationsinourinstructions.

L. Thecirculationpumpalsogeneratesheatandifitisrunningalongtimeitcanraisethetemperatureby

severaldegreesinonedaywhenthetubiswellinsulated.

M. Checkthequalityofthewater,aswellastemperatureandfunction,regularly,don'tleavethespa

unmonitoredforlongtimeperiods.

N. Ifthewater'sdrainedandthebathisn'tinuseduringcoldweather,thenallscrewconnectionsareto

beleftopensothatanywatercandrainout.Drainthebubblesystemusingtheblower.

O. Whenfillingwaterandthetemperatureisbelowfreezing,thepumpsandpipesarealsocold.Takethis

intoaccountandfillwithwarmwaterfirst,orwarmupthespacewithanappropriatefanheater

beforefillingwithwater.

P. Afrostguardcanbeplacedinthetechnicalareatoprotectagainstdamagefromfreezingincold

weatheriftheequipmentfails.

2017-01-23

HEATING

Expectaheatingrateof2degreesperhour.Ifthetemperatureofthewaterisaround6degreeswhen

starting,itwillbearound37degreesafter15hours.Afterthatthewatertemperatureiskeptaccordingto

thethermostat.Filtrationandwaterhygieneproductswillkeepthewaterclean.

Note!Evenifthethermostatissethigherthanthecurrentwatertemperature,itwillonlyturnonwhen

thewatercirculationisactive.Theheaterhasabuilt‐inflowsensorincl.microswitchthatrelyonacertain

flowofwatertobeactivatedandprovidepowertotheheater.Ifthereisnotenoughcirculation(e.g.filter

isnotcleaned,thewaterlevelistoolow),thentheheaterwon’tstart.Itcanalsoleadtotheoverheating

protection(coveredbyablackplasticnut)activatingandtheheaterstopsworking.Resettingisdoneby

looseningthenutanddepressingtheredpin.

CIRCULATIONPUMP

Werecommendthatthecirculationpumpbecontrolledviathetimerasdescribedonthefirstpage.Itis

alsopossibletocontrolitmanuallyviathebuttonsonthesidesofthe"controlbox".Thispresupposesthat

thetimer(ifused)isactivated.Ondeliveryhoseintendedforcirculationpumpislabeled"Pump".NOTE!If

youturnoffthepumpmanuallywiththebuttonitwillnotstartagainevenwiththetimerset!Thebutton

mustbeinthe"on"positionforthetimertofunctioncorrectly.

BLOWERFORBUBBLESYSTEM

Thisisalsocontrolledviaoneofthebuttonsonthesideofthe"controlbox"(locatedabovetheboxwith

pumps).Whichbuttoncontrolswhatfunctionisdeterminedbyhowthebuttonsareconnectedtothe

pumpandblower(viapneumatictubes).Ondeliverythehoseintendedforblowerislabeled"Blower".

Whenthewaterisdrained,thewaterinthehoseisremovedbystartingtheblowerforafewseconds.

NOTE!Whenairpassestheblowerthisandtheairwillbeheatedup.Inordernottoblowerandplastic

partswilloverheattherecommendedmaximumrunningtimeis20minutes/sessionwithatleasta30

minutebreakuntilthenextuse.Ifthetemperatureintheblowerrisestoohighitwillstopautomatically

whentheautomaticthermalfusesaretripped.

GOODTOKNOW!

Thebottomofthebathhasasmallbend

upwardswhichwillbeflatandlieagainstthe

supportplateontheframeinthebathwhen

filledwithwater.Whendraingingthebottom

risesupagainandthatmakesallthewaterflow

outtotheedgeandthenoutthroughthedrain

valve.



 Readthewarningtextonthefirstpage.Itisimportanttoknowandfollowtheinformationtherein.

 Notethatabathwhenfilledwithwaterandbeingusedby6people,weighsapprox1800kg.Take

thisintoaccountwheninstallingthebathinaterraceorsimilarandmakesurethestructureis

strongenough.

 The"push‐up"drainvalveisprimarilyusedtoflushoutthelastofthewater.Mostofthewateris

drainedinthewaydescribedonpage8underDraining/replacingwater.

 Whenthecirculationpumpisrunning,thewaterisbeingfiltered.Ifthetemperatureofthewateris

lowerthanwhatissetonthethermostat,thewaterwillbeheatedaswell.Ifthepumpisrunning

allthetime(notcontrolledbyatimer)thatleadstothewatertemperatureisraisedregardlessof

whatthethermostatfortheelectricalheaterissetat.

Installationoffiltration‐/heatingunit

 



 



 

Applypolyurethanefoamontheinsideoftheboxwhereitmeetsthesidesofthehottub(sidesandabove)



Summeruse

Removetheinsulationunderthelidtothe

”technicalbox”whenoutsidetemperaturesexceed

5degreesCelsius.



Winter use

Duringcoldweather,below5degreesCelsius,the

insulationshouldbeinstalled.

Polyurethane

30mm

20mm

Shutoffvalveprocedure

Closing:Thevalveshafthastwo”pins”thatfitintogroovesinthelock,pressdownfirmlyandlockby

twistingthehandleclockwise.Itisimportantthepinsarefirstfirmlyseatedintothegrooves,orthelock

canbreak.

Opening:Twistthehandlecounter‐clockwiseandpullthehandleupwards.Toensurethevalveremainsin

openpositionyoucanuseacliptopreventitclosing.



Pressthehandledownintothegrooves



Twistthehandle(clockwise)toclosethevalve

completely





Openposition



A“lockingclip”canbeaddedtoholdthevalvein

openposition.



1 2

3 4



Schematic

230V/16A

1. Safetyswitch

2. Pressureswitch#1

3. Pressureswitch#2

4. Lighting(accessory)

5. Valve(suctionside)

6. Valve(pressureside)

7. Thermostat

8. Indicatorlamp

9. Overheatingprotection



Notethatthebubblehosehas

bothcheckvalveanddrainvalve,

inordertopreventwaterfrom

enteringtheblower.

23

1789

Fillingofwater

RECOMMENDED WATER LEVEL



Waterconsumptionandenergy!

Fillingisgenerallydonewithagardenhoseconnectedtothewatermains.Ifanotherwatersourceisused,

takespecialconsiderationregardingthepotentialforbacteria.Readtheinstructionsonwaterhygieneand

theuseofchemicals.



Rememberthatthewaterlevelwillrisebyapprox.5cmwhenanaverage‐sizedpersonsitsintheHotTub.

Thisisequivalentto80litersofwater.Thewaterlevelshouldbe20cmbelowtheedgewhenempty.The

totalamountofwatertoheatupissubsequentlyreducedbyca.320liters.Ifthespaiscompletelyfilled,

thisamountofwaterwillfloodovertheedgeswhentheuserssitdown.



Duringfillingofwateragardenhoseorsimilarcanbeused.Filltothelevelthatthepicturesshow.

NOTE!Duringthefilling,valves5&6havetobeclosed,page5.Seepage4tohowtheyaremaneuvered.

SUCTION IS ADJUSTED BY MOVING THE REGULATOR UP OR DOWN. MOVE DOWNWARDS TO DECREASE SUCTION.

Filter/Startup

Limitationofusage:



IMPORTANT!Alwaysshutdownthepumpwhenchangingpositionsonthe4‐wayvalve!

1.Filtration



Normalfunction.

Thewatercirculatesthroughthefilterandreturnsclean.



2.Backwash

Thewaterpassesthroughthefiltrationmediaintheopposite

directionanddirtrunsoutthroughthebackwashpipe.Runthis

modewhenrequired,orwhenthepressuredialgoesover0,7bars.

Usea20‐25literbuckettodrainthedirtywaterinto,drainuntil

filled.

3.Rinse

Thisfunctionhelpstoavoiddirtbeingcarriedbackinthewater.The

dirtyoverflowwaterisbackwashedfromthebackwashingpipe.



Runforabout5seconds.Runaftereverybackwash.

4.WintertimeIfthefilterisnotinuseduringwintertime,removethefilterandbringittoaplace

wheretheambienttemperatureisabovefreezing.

NOTE!Removethefilterballswhenthespaisdrainedforalongtime.Otherwise,moldmaygrowinthem.



5.Filtrationmedia(FilterBalls)

1. Fillupthefilterballstothelevelthatisshowninthepicture.

2. Installthevalvebody.

3. Followtheinstructionsonstartupbelow.

NOTE!Points1‐2havealreadybeencompletedupondelivery.



Startup

1. PlacevalveinpositionBackwash.

2. Openvalves5and6,seepage5.

3. Setthe4‐wayvalveinnormalmodeFILTRATIONwhenthe

startstocomeoutandstartthecirculatingpump.



 Maxwatertemperature:40°C.

 Maxwaterflow:20000l/t.

 Typeofsand:0,4–0,8mm.

 Min.watertemperatuer:4°C.

 Maxdistancefrompool/spa10meter.

YourTopSpaXSisdeliveredwiththefiltrationsystemcontaining

FilterBallsasfiltrationmedia.Readtheinstructions,seeparagraph5!

Draining/replacingwater

Openthecoverwherefilterandpump(s)are.Fordrainingthewater,avalveisinstallednearthefilter

container.Seepicture(V).Removethebackwalloftheboxandconnectcoupling(6)whoseouter

diameteris32mm.Openthevalve(VandB)anddrainthewater.Whenthewaterisdrainedthecoupling

partandthebackwallisputback.



Whenthespaisdrainedfromwaterforalongerperiod,orifthereisariskoffreezing,shouldalsothe

circulatingpumpandmassagepump(ifincluded)bedrained.Theblowershouldalsobestartedupfora

fewseconds,todrainhosesandvalves.



 



NOTE!Ifthefilterisnotinuseduringwintertime,removethefilterandbringittoaplacewherethe

ambienttemperatureisabovefreezing.Removethefilterballswhenthespaisdrainedforalongtime.

Otherwise,moldmaygrowinthem.



V 56

V6

B

CleaningofFilterBalls

Closethevalves(redarrows),unscrew(greenarrows)andremovethefiltercanisteranddrainthewater.

Removethefilterballsandrinse.

Squeezethefilterballstogetoutthedirtywater.UseforexampleFilterCleanertodissolvethedirt.

Letthefilterballssoakforacoupleofhoursthensqueezeoutthedirtywater.Replacethewaterand

repeat.Returnthefilterballstothecontainer.

NOTE!Removethefilterballswhenthespaisdrainedforalongtime.Otherwise,itcanstartforming

mold.

Waterhygieneisimportant!

Becarefulwiththewaterhygiene‐Abathingwaterwillneverbecleanerandsaferthanwhatonemakes

it.Personalhygieneandeffectivedisinfectionaretwothingsthatareimportantforcleanbathingwater.

Thewateryouuseshouldalsobetakenintoaccount.Bacteriathriveinwarmbathwaterandthesafestis

toaddbactericidalagentsbeforetakingabath.Iteffectivelypreventsthegrowthofbacteria.

Ifbacteriahadtimetodevelopitrequiresignificantlygreateramounttoincapacitatethem.Thereare

manydifferentbrands,butwhatisimportantistousebactericidalagentsforthe"right"temperature.

Agentsforswimmingpoolsarenotsuitableforwarmerwaterandviceversa.



Goodpersonalhygienebeforetakingabath‐Keepinmindthatapersonwhohasnotwashedhim/herself

beforewillpollutethewater200timesmorethansomebodywhohastakenashower.Sunlotion,skincare

products,soapshouldnotgetintothewaterandthat’swhywesuggesttotakeaquickshowerbefore

enjoyingabath.



Effectivedisinfection‐Filtrationhastheadvantagethatwatercanbeusedlonger.Stillitisimportantto

addsomebactericidalagents.Filtrationpreventstheaccumulationofimpuritiesbutnotthegrowingof

bacteria.Everyonewhoistakingabathisaddingmicroorganismstothewaterwhichareablendof

differentkindofbacteria.



Important!Whenbathing,largequantitiesofmicroorganisms,whichisamixtureofdifferentbacteria,is

addedtothewater.Bacteriacanhaveadversehealtheffectsandthereforeyouneedtoworkwithe.g.

chlorineaswell.IfthechlorinelevelsaretoohighthenthepH‐valuewillbeincreasedandthewaterwill

haveastrongsmell.Thechlorinelevelsshouldnotexceed1.5ppmandpH7.0‐7.6.Forbrominethelevel

shouldnotexceed2.0ppmandthepHshouldbe7,0‐7.8.Ifautomaticdispensers(floating,etc.)areused,

carefuladjustmentshouldbemadetoavoidincorrectdosage.Followtherecommendationsofthe

manufacturerofthespayouareusing.



5easyadviceformaintaininggoodwaterhygieneifyouhavegotatuboraspawithfiltrationsystem.

1. Takeashowerbeforeyougetintothehottub.

2. Addsomebactericidalagentsbeforeandaftertakingabath.

3. CheckthepH‐valueandbalanceitifnecessary.

4. Addactiveoxygen,about30ml,everyweek

5. Cleanthefiltermediafrequentlyandusesufficientfiltrationtime.About4‐6hoursperday.



Maintenanceinstructions

ThankyouforchoosingaproductfromSpaDealers.Wetrytodoourutmostto

ensurethatyouwillbesatisfiedwithourproducts.Ifyouhaveanyqueries,

pleasecontactusat+358‐(0)10‐2395600or[email protected]



Foundationandplacementoptions

  



Itisalsogoodtorememberthatabathfilledwithwaterand6usersweighsapprox1800kg.When

installedonaterraceorthelike,thismustbetakenintoaccountforthestrengthcalculation.



Maintenance

Thewoodontheoutsidemustbetreatedwithwoodoilatleastonceayeartomaintainthecolor.Theoil

mustbesuitableforhardwoodorheattreatedwood(hardwood)andwithUVprotection.Aslightnuance

(brown)alsoprovidesabetterUVprotection.

UntreatedOiled Untreated>3years



CleaningthehottubThehottubisrinsedoutwithcleanfreshwater.Ifthewaterhasbeeninitfora

longtime,itshouldalsobescrubbedwithsoap.



Managedcorrectly,youwillbatheinaSpaDealershottuborspaformanyyears.

Wewishyoumanywonderfulbathingdays.

Nurmi

Gräs

Grass

Nicht auf Rasen!

Pelouse

Трава

Puualusta

Trästomme

Wooden frame

Auf Holzrahmen

Structure bois

Деревянная конструкция

Kivi- tai valulaatta

Sten- eller gjuten platta

Stone or concrete plate

Stein- oder Betonfundament

Pierre ou ciment

Камень или бетон

Tiivistetty sorapeti

Stampat grus

Gravel foundation

Dichter Schotter

Fondation en gravier

Гравий

PlacetheHotTub

orspaonastable

baseandnot

directlyonthe

ground.

SpaDealers TopSpa User guide

Related papers

Other documents