BIOZONE SCIENTIFIC FCC-30 FreshCare Series Air Purifier User manual

Brand: BIOZONE SCIENTIFIC

Model: FCC-30 FreshCare Series Air Purifier

Category: Air purifiers

Type: User manual

Model: FCC-30

Air Purifier

FreshCare Series

User Ma

cBiozone Scientific Group

nual

Read this user manual before operating

The company reserves the right of final decision on the interpretation of this manual

Read and save this user manual together with sales invoice

The company reserves the right to upgrade or make technical change to this product

without further notice

For product outlook, refer to the actual appearance

Contents

Precautions

Product Components

Usage

Cleaning & Maintenance

Troubleshooting

Technical Specification

Warranty

IOZONE

CIENTIFIC

BIOZONE

SCIENTIFIC

Precautions

This appliance is not intended for use by persons (including children) with

reduced physical,sensory or mental capabilities, or lack of experience and

knowledge, unless they have been given supervision or instruction concern-

ing use of the appliance by a person responsible for their safety.

Children should be supervised to ensure that they do not play with the

appliance.”

Unintended use of the appliance or damage to the housing may result in the

escape of dangerous UVC radiation. UVC radiation may, even in little doses,

cause harm to the eyes and skin.

This appliance contains a PhotoPlasma/ UVC generator.

Appliances that are obviously damaged must not be operated.

Read the maintenance instructions before opening the appliance.

The appliance must be disconnected from the supply before replacing the

PhotoPlasma/ UVC generator.

Any content marked with this sign refers to prohibited

behavior, otherwise it may cause damage to the product

or harzard to the user.

Any content marked with this sign must be strictly

followed, otherwise it may cause damage to the product

or harzard to the user.

Any content marked with this sign must be paid attention to,

otherwise it may cause damage to the product .

Notice

Warning

Do not insert fingers or foreign

objects into the air-inlet or

outlet.

Prohibited

Do not plug the power cord

when your hands are wet.

Note: The following content is related to safety, please read and follow the instructions

for proper usage.

Precaution is related to safety risk and hazardous situations.

1. Do not use any accessories unless it is recommended in this manual; otherwise,

warranty will be void.

2. After unpacking, check the product for any damage and if all accessories are included.

3. Usage of this product by children and people with disabilities should be supervised.

4. If a fault occurs, unplug the power cord immediately . Do not operate the air purifier

if it is defective.

5. The air purifier should be repaired by authorized service centres, as repair by

non-authorized party may cause safety issue.

6. If the power cord is damaged, please contact the authorized service centre and have

qualifed technicians to replace the cord. Do not replace the cord on your own as

it may be dangerous.

Precautions

Do not use the air purifier in

an environment filled with

hydrogen, natural gas, propane

and other flammable gases.

Do not use the air purifier while

spraying pesticides. Do not use the

air purifier near cigarettes, incense,

or other spark-generating items.

Do not use in areas with high

humidity or where the air purifier

may become wet such as in the

bathroom.

Do not block the air inlet / outlet.

Do not operate the air purifier

without installing the filters.

Clear the dust on the power

plug regularly.

Do not wash and reuse the

composite carbon filter mesh.

Please use only the power supply

voltage indicated on the rating

label.

Precautions

Please be careful when cleaning

the air purifier. Strong corrosive

detergents can damage the

surface of the air purifier.

Hold the plug when unplugging

the power cord and do not pull

the cord. Otherwise it may result

in electric shock or fire because of

short circuit.

Please unplug the power cord when

cleaning or not using the air purifier

in case of electric shock or fire

because of short circuit.

Use only soft cloth to clean the

surface of the air purifier,

otherwise it may damage or

scratch the unit itself.

Do not use the air purifier if power

cord or plug is damaged or the

power socket outlet is loose.

If this air purifier causes interference

to radio or television receiver, please

try one or more of the following

measures to correct the interference:

• Re-adjust the antenna direction

on the TV.

• Move the air purifier further away

from the radio / television receiver.

• Connect the air purifier's power

supply and the TV or radio’power

supply to different power outlets.

• For assistance, please contact your

nearest dealer or an experienced

radio / TV technician.

Precautions

Do not place air purifier near any

heat sources (wall mounted heater

or area near flammable gases).

While moving the air purifier, hold

the handle on the back of the main

body. If you hold the front cover

while moving, it may fall off from

the main body and cause injury.

Do not use alcohol or organic

solvents to wipe and clean the air

purifier as it may damage the air

purifier or trigger electrical shock,

causing damage, fire etc..

This device should not be operated

by people with disabilities or

children without supervision.

Green

Yellow

Remarks: Air Quality Indicator is displayed according to PM2.5 Index.

Product Components

Blue

Red

A. Front Cover B. Pre-Filter C. Composite Carbon Filter Meshs

J. Air Quality Indicator K. PhotoPlasma/ UVC Generator

G. Airduct H. Sensor Cover I. Power Socket

D. LED Display E. Control Panel F. Switch to open the front cover

Excellent PM2.5 Index ≤50

Good 50＜PM2.5 Index ≤100

Fair 100＜PM2.5 Index ≤150

Poor 1 50＜PM2.5 Index

IOZONE

CIENTIFIC

1. Power ON/OFF: Touch ” “ button to turn on/ off

2. Purify: Touch “ ”to activate/ shut down PhotoPlasma/ UVC

purifying function. When turned on, PhotoPlasma/ UVC purification

function will be set according to the last shutdown setting

3. Fan Speed: Touch“ ”button to adjust fan speed in the following

sequence: Level 1-2-3-4-5 . The fan will go back to Level 4 after 60

minutes operation at the speed of Level 5

4. Timer: Press “ ” button to select the time required in the

following sequence : 1H>2H>3H>4H>5H>6H>7H>8H>9H>10H>

11H>12H>0H

5. Auto: Touch “ ” button to start/ end the AUTO mode

6. Sleep: Touch“ ”button to start/ end the SLEEP mode

7. Child Lock: Hold “ ”button for 5 seconds to lock the buttons

and avoid misoperation by children

Product Components

Control Panel

Control Panel Overview

Operating Instructions

PM Index, Timer, Fan Speed Display

2. Remove the pre-filter by pulling it out. (Fig. 2)

Usage

Before Use

Unpack the filters and install them properly into the air purifier before use.

Filter Removal

Fig. 1 Fig. 2

3. Remove the composite carbon filter meshs by pulling them out holding

the handles. (Fig.2)

1. Remove the filters from plastic bag before use and open the front

cover. (Fig.1)

While using the air purifier, place at least 2 meters away from other electronic

appliances that emit electromagnetic waves (such as, TV, radio, clock) to prevent

interference.

Do not place the air purifier near curtains and other objects that may interfere with

the air inlet or outlet, otherwise it may cause malfunction.

Do not place the air purifier where temperature may change vastly. Its operating

temperature is 0–35℃.

Place the air purifier in a secured and well ventilated area. If the air purifier is placed

on a thick carpet, it may vibrate slightly.

Do not place the air purifier where cookng fume may generate (such as kitchen).

Ensure there is enough space around the air purifier.

Place the air purifier where air can flow naturally. This allows PhotoPlasma/ UVC and

negative ions to spread evenly.

IOZONE

CIENTIFIC

2.Install pre-filter: place the pre-filter in the air purifier where 6 fittings click into

place. (Fig. 3)

1.Install the composite carbon filter meshs: remove the plastic bag, place the filter

inside with the handles facing out. (Fig. 3)

Notice:

Please remove

the plastic bag

of composite

carbon filter mesh

Usage

Filter Installation

Connect the provided power cord to AC supply voltage indicated on the rating label

and press“ ”to turn on/ off.

3.Install the front cover: insert the bottom tabs into the slots at the lower part and

close the front cover until the magnets pull the cover closed. (Fig.4)

Operation

Pre-filter

Composite carbon filter meshs

Fig.3 Fig.4

Press " " button to adjust the fan speed manually for Level 1-2-3-4-5,

Level 5 fan speed will automatically switch back to Level 4 after running for

60 minutes.

Press " " button to start/ exit SLEEP mode.

Press " " to start/ exit AUTO mode .

Press " " button for 5 seconds to start/ exit child LOCK mode to avoid any

hazard to children.

Press " " button to select the time : 0H to 12H. When the air purifier is on, the

selected time is set to auto shut down. When the air purifier is off, the selected time

is set to auto turn on.

Filter Reset: After filter replacement, reset the filter's lifetime counter by

pressing“ ” and “ ”simultaneously for 3 seconds.

PhotoPlasma

/ UVCGenerator

Press " " to activate PhotoPlasma/ UVC Purifying Function. Press " " again

to shut down the function.

IOZONE

CIENTIFIC

Pre-filter Not required Do not damage it when cleaning

3) Pre-filter can be rinsed with water and reused after drying completely.

3. Cleaning and Replacing of PhotoPlasma/ UVC Lamp

(Please refer to the Appendix for the correct procedure)

1) If stains are found on PhotoPlasma/ UVC Lamp, remove the lamp from the machine first

and clean it with soft cloth soaked with detergent water. After cleaning, reinstall the lamp.

2) For optimal performance, it's suggested to replace PhotoPlasma/ UVC Generator once

a year.

3) If replacement of PhotoPlasma/ UVC Lamp is needed, please make sure that the lamp is

installed properly.

Precaution: When cleaning or replacing the PhotoPlasma/ UVC Lamp, please handle

the lamp by the white ceramic side on the ends. Do not touch the glass part

of PhotoPlasma/ UVC Lamp with bare hands.

Cleaning & Maintenance

Turn off and unplug the power cable before cleaning / replacing filters.

1. Cleaning Care

1) Wipe the product body with a soft cloth.

2) For tougher stains, clean it with a soft cloth soaked with detergent water.

2. Filter Care

1) Both “AUTO” and “TIMER” buttons flashing indicates it is time for filter

replacement. However, the frequency of filter replacement varies depending

on environment. It is suggested to clean the filters every month. If the filters

are soiled or have a bad odour, please replace the filters immediately.

2) For optimal performance, composite carbon filter mesh can be cleaned with a

vacuum to extend its lifetime. (Suggest to clean it every month)

When to replace Condition

Last up to 6 months

Upper Composite

Carbon Filter Mesh No more than 6 cigarettes daily

Please dispose the used filters as non-combustible item.

The lifetime of the filters will be possibly shortened if the

environment is heavily polluted or more smokers are involved.

Lower Composite

Carbon Filter Mesh Last up to 12 months No more than 6 cigarettes daily

Do not damage it when cleaningPhotoPlasma/ UVC Lamp Last up to 12 months

Symptom Possible Causes and Solutions

Air purifier does

not turn on

1. Check if the power cord is well plugged in.

2. Check if the front cover is installed properly.

Air purifier does not

improve indoor air

quality significantly

Abnormal smell comes

out of the air outlet

Airflow from outlet

is weakened

Notice: If the problem persists after checking the above troubleshooting,

please contact your local service centre. Do not disassemble the unit yourself.

Troubleshooting

1. The plastic bag for filters has not been removed; remove the

plastic bag and reinstall the filters.

2. Other items block the inlet/ outlet; clear the items.

3. Clean or replace the filters.

1. Filters are not installed; install the filters.

2. Doors or windows are opened frequently so that it takes more

time than expected for device to purify the indoor air.

3. Air purifier is placed in a small place or with obstacles nearby

which affects the purifying result.

4. Clean or replace the filters.

1. Heavy indoor air pollution because of a lot of smokers, dust

or odours; It's recommended to enhance air exchange.

2. Clean or replace the filters.

PhotoPlasma

/ UVC

Lamp

does not light up

1. Check if the PhotoPlasma

/ UVC

Purifying Function has been

activated.

2. PhotoPlasma

/ UVC

Lamp is out of order. Please replace the

PhotoPlasma

/ UVC

Lamp.

Technical Specification

100W

FCC-30

50Hz or 60Hz120V~ or 220V~

350m³/h

High Efficiency

130m /h

420x240x690mm

10kg

12.2kg

Net Weight

Gross Weight

Dimension

Product Name FreshCare Series Model

Rated Voltage *1 Rated Frequency

Noise Level ≤64dB(A)

Rated Power Input

Cumulate Clean Mass (PM)

Clean Air Delivery Rate (PM)

Cleaning Energy Efficiency (HCHO)

Qualified

Cleaning Energy Efficiency (PM)

Effective Room Size

PM 2.5 Sensor

Sensor

Clean Air Delivery Rate (HCHO)

27㎡-46㎡

Specifications are subject to change without notice.

*1 : Please use only the power supply voltage indicated on the

product label.

Generators Equipped Negative Ion, PhotoPlasma

/ UVC

Replaceable Filters and PhotoPlasma/ UVC Lamp (For Sale)

FCC-30-FA2/FCC-30-FA2H13

Upper Composite carbon

filter mesh H11/H13

FCC-30-PFPre-filter

Power Cord User Manual

Appendix

Warranty Card Air Purifier

Type Model Number

Packing List

Item Quantity Item Quantity

Technical Specification

PhotoPlasma/ UVC Lamp

FCC-30-FB2/FCC-30-FB2H13

Lower Composite carbon

filter mesh H11/H13

10-08100/10-08000

Lamp Cover

*Please contact the authorized service centre for ordering in details .

FCC-30-LC3

FCC-30-FA2/

FCC-30-FA2H13

Product Warranty

What is covered: All parts defective in material and workmanship.

For how long: One year from the purchase date.

What we will do: Repair or replace any defective parts.

What you must do:

1. Contact your sales representative or dealer or call BIOZONE at +44 (0) 1392 860 862

( Headquarters/ EMEA) for specific return and shipping instructions.

2. Pack the product in its original carton and in the same manner you received

(or identical as possible).

3. Return the product with proof of purchase.

4. Label and ship the unit, freight prepaid, to the address provided.

5. Place any necessary return authorization number prominent on the outside of the

carton.

Other Terms and Conditions:

The provisions of this warranty are in lieu of any other written warranty, whether

expressed or implied, written or oral, including any warranty of merchantability or

fitness for a particular purpose. The manufacturer's maximum liability shall not exceed

the actual purchase price paid by you for the product. In no event shall the manufacturer

be liable for specific, incidental, consequential or indirect damages. This warranty does

not cover a defect resulted from improper or unreasonable use or maintenance,

accident, improper packing, or unauthorized tampering, alteration or modification as

determined solely by us. This warranty is void if the label bearing the serial number

has been removed or defaced.

Warranty

Warranty Conditions

Version: 2021 V1

Asia/Pacific

Email: [email protected]

Website: www.biozonescientific.hk

BioZone Scientific International,Ltd.

Unit 1101,11th Floor, Tins Enterprises Ctr.

777 Lai Chi Kok Road

Kowloon, Hong kong

Tel:+(852) 2372 0218

EPA Producer

Establishment No.

98681-CHN-1

USA

BioZone Scientific America LLC

7616 Southland Boulevard

Orlando, Florida 32809

United States of America

Tel: 1+407.876.2000

Email: [email protected]

Website: www.biozonescientific.com

Email: [email protected]

Website: www.biozonescientific.com

Tel: +44 (0) 1392 860 862

United Kingdom

EX1 2JY

Exeter

72 Paris Street

1st Floor, The Mount

BioZone Scientific Group Limited

Headquarters/Europe/Middle East/Africa

BIOZONE

SCIENTIFIC

BIOZONE SCIENTIFIC FCC-30 FreshCare Series Air Purifier User manual

Brand: BIOZONE SCIENTIFIC

Model: FCC-30 FreshCare Series Air Purifier

Category: Air purifiers

Type: User manual

Download PDF

report

BIOZONE SCIENTIFIC FCC-30 FreshCare Series Air Purifier User manual

BIOZONE SCIENTIFIC FCC-30 FreshCare Series Air Purifier User manual

Other documents